Martin Magnum Club Smoke System Installation Manual
Martin Professional A/S,Olof Palmes Allé 18, DK-8200,Aarhus N
Phone: +45 87 40 00 00 Internet: www.martin.dk
Magnum
Club Smoke
System
USER GUIDE AND INSTALLATION
INSTRUCTIONS
VERSION 1.0
NOTE! The warranty on this machine is conditional on the use of
genuine JEM / Martin fluid only. Other fluids may represent a health
hazard when used in this machine, and may damage the internal
components.
Fluids Suitable for this system:
Pro-Smoke
Studio
Pro-Smoke
Super
Pro-Smoke
High Density
MAGNUM CLUB SMOKE SYSTEM
CONNECTIONS
MAGNUM CLUB SMOKE SERVICE MODULE
REMOTE
IN
DMX
IN
DMX
OUT
CH 2
CH 1
FLUID
CH 2
FLUID
CH 1
MAINS
IN
ON
OFF
PIN ALLOCATIONS
CHANNEL1&2
1
1
1
2
2
2
3
3
3
READY
0-10 V
0-10 V
GROUND
GROUND
REMOTE
+16V
DMX IN/OUT
SHIELD
DATA NEGATIVE
DATA POSITIVE
1
1
1
1
1
2
2
2
2
2
3
3
3
3
3
MAGNUM CLUB SMOKE HEAD
ANALOGUE
IN
ANALOGUE
OUT
HEAT
READY
1
2
3
1
2
3
PIN ALLOCATIONS
ANALOGUE IN
ANALOGUE OUT
GROUND
GROUND
READY
READY
0-10V
0-10V
1
2
3
1
2
3
MAGNUM CLUB SMOKE SYSTEM
17
SPECIFICATION
HEAD
1KW heater
Copper vaporizing coil
High pressure fluid delivery
Electronic Temperature control using thermocouple
Analogue remote control system
Solenoid operated flow control valve
Adjustable mounting bracket
Maximum distance to service module 50 m
Maximum height above service module 10m
SERVICE MODULE
Oscillating piston high pressure fluid pumps
Low fluid detection by electronic sensor
DMX512 decoder:
Required Channels = 1
Output is proportional for all levels above 10%
Channels supported=1to512
Valid start codes = 0 (dimmer data only)
Full framing error detection implemented
Analogue control via standard Martin Multifunction Controller.
REMOTE CONTROL
16v power supply from service module
Standard 0 - 10V output signal
Output level control from 0 to 100%
Power On LED
Timer cycle LED
Timer range:
Delay time 2sec - 18 sec (x1) 16 sec - 2 min24sec(x8)
Run time 2sec - 18 sec (x1) 16 sec - 2 min24sec(x8)
MAGNUM CLUB SMOKE SYSTEM
16
System Layout Guidelines
Head Installation
Service Module Installation
DMX Settings
Commissioning The System
Maintenance
System Expansion
Specifications
© Martin Professional A/S, Denmark.2004
All rights reserved. No part of this manual may be reproduced, in any form or
by any means, without permission in writing from Martin Professional A/S,
Denmark.
MAGNUM CLUB SMOKE SYSTEM
USER GUIDE CONTENTS
INSTALLATION INSTRUCTIONS CONTENTS
Introduction
Features
Safety Guidelines
System Components
Remote Control Operation
DMX Operation
System Expansion Options
Fault Finding
1
Loading...