Marshalltown RS14 Operation Manual

WS1694
11-2018/Rev.C

Roller Screed Operations Manual

Part# RS14
EDI# 19435

104 S. 8th Ave.

Marshalltown, IA

Phone [phone]

Fax [phone]

www.

MARSHALLTOWN

.com

1 of 11

INTRODUCTION

CAUTION!

DANGER!

WARNING!

The Marshalltown Roller Screed is a quick and easy tool to use in screeding concrete. Its simplicity allows even the most
inexperienced operators to effectively and accurately place a slab.

Specifications:
Part #: RS14
EDI: 19435
Dimensions:
Live handle length: 48" Lag handle length: 61¾"
Live handle width: 19" Lag handle width: 14½"
Live handle diameter: 1¼" Lag handle diameter: 1"
Live end cap length: 5" Lag end cap length: 4"
Motor enclosure: 4¾ X 4½ X 18”
End cap diameter: 3.98"
Motor: 10 amp, 300 RPM, 120V AC
Roller Tube Diameter: 4½"
Roller Tube Thickness: ¼”

TABLE OF CONTENTS

Safety Precautions ............................................................................................................................................................3

Warranty ....................................................................................................................................................................... 4

Parts Breakdown ...............................................................................................................................................................5

Assembly ....................................................................................................................................................................... 6

Product Operation .............................................................................................................................................................7

Maintenance ...................................................................................................................................................................... 8

Troubleshooting .................................................................................................................................................................8

SIGNAL WORDS

UNDERSTAND SIGNAL WORDS

• A signal word - DANGER, WARNING, or CAUTION is used with the safety-alert symbol. DANGER
identifies the most serious hazards.

• DANGER or WARNING safety signs are located near specific hazards.

• General precautions are listed on CAUTION safety signs.

2 of 11

104 S. 8th Ave. Marshalltown, IA Phone [phone] • Fax [phone] www.

MARSHALLTOWN

.com

WS1694

11-2018/Rev.C

SAFETY PRECAUTIONS

CAUTION!

CAUTION!

CAUTION!

CAUTION!

DANGER!

IMPORTANT—READ THIS MANUAL BEFORE ASSEMBLING OR OPERATING
After referring to the operation manual, if you still require assistance, please contact our customer
service department.

This operator’s manual has been prepared to provide the information you need to correctly operate and
maintain your unit. Read it carefully and keep it for future reference.

The replacement of any part on this product by other than the manufacturer’s authorized replacement part may adversely
affect the performance, durability or safety of this product. Should you ever require repair parts or service, contact your
authorized parts and service dealer.

The manufacturer reserves the right to make changes or add improvements to its product at any time without prior notice.
The manufacturer also reserves the right to decide, upon its discretion at any time, to discontinue a product.

Read and follow all safety precautions and operating instructions in this manual.

Familiarity and proper training are required for the safe operation of this equipment. Equipment operated improperly or by
untrained personnel can damage equipment or cause bodily harm. Read the operating instructions contained in this manual
to familiarize yourself with the location and proper use of all the controls.

• DO NOT operate this machine until you have read the operating and safety instructions. ALWAYS operate the machine
in accordance with the manufacturer’s instructions.

• ALWAYS inspect your roller screed upon arrival for damage or tampering that can rarely occur during shipping. If
damage is found, file a claim with your carrier immediately! Mark corresponding delivery receipt as “damaged
shipment”.

NEVER allow untrained personnel to operate your roller screed. Individuals who operate this screed should have
adequate training in operating procedures.

• NEVER use over-the-counter hardware to replace manufacturers’ hardware. Contact MARSHALLTOWN Customer
Service Department for information regarding replacement parts. 800-888-0127

DO NOT attempt to clean or service screed while machine is running.

DO NOT use gasoline, other fuels, or any flammable solvent to clean parts, especially in enclosed areas. Fumes from
fuels and solvents can cause serious health problems if you are exposed to them over an extended period of time.

• ALWAYS disconnect power to the motor before servicing or cleaning the roller screed to prevent accidental start-up.

ALWAYS wear adequate hearing protection while running your roller screed.

• Refer to the included motor manufacturer’s manual for specific electrical requirements and safety information.

WS1694
11-2018/Rev.C

104 S. 8th Ave. Marshalltown, IA Phone [phone] • Fax [phone] www.

MARSHALLTOWN

.com

3 of 11

ROLLER SCREED WARRANTY

This product is warranted to the original purchaser only, to be free of defects in material and workmanship under normal
use, for one year from purchase date. Marshalltown Company shall without charge for parts and labor, repair or replace
such parts which are found to be defective. All transportation charges for replacement parts must be borne by the purchaser.

For warranty service, the product must be delivered, with proof of purchase date, to the dealer of original purchase, or any
factory authorized service dealer. The delivery of the unit must be made no later than 30 days after the expiration of the
warranty period.

If difficulty is encountered in having warranty work performed, contact the Customer Service Department.

All implied warranties, including those of merchantability and fitness for a particular purpose, are limited to one year from
date of purchase by the original retail customer and to the extent permitted by law any and all implied warranties are
excluded and disclaimed after the expiration of such period.

Some states do not allow limitations on how long an implied warranty lasts, or the exclusion or limitations of incidental or
consequential damages, so the above limitations or exclusions may not apply to you. This warranty gives you specific legal
rights, and you may also have other rights, which vary from state to state.

Exclusion from this warranty:

1. All consequential damages, including pickup and delivery of the unit, communication, mileage charges and/or
rental of a replacement unit during repairs are not covered under this warranty, nor are any loss of income and/or
other loss resulting from the failure of the product to function due to a warranty defect.

2. This warranty will not apply when the product becomes inoperative due to misuse, normal wear, neglect,
improper maintenance, accident or freight damage; has not been operated and maintained in accordance
with the instructions furnished in the Operator’s Manual; or has been altered or modified without approval
from the factory Service Department.

3. No parts or products are to be returned to the factory without prior written approval from the factory.

4 of 11

104 S. 8th Ave. Marshalltown, IA Phone [phone] • Fax [phone] www.

MARSHALLTOWN

.com

WS1694

11-2018/Rev.C