Malloca THETA K1520 User Manual
1
Please Read The User Manual Carefully!
CHIMNEY HOOD
USER’S MANUAL
INSTRUCTIONS FOR INSTALLATION
AND USE
THETA K1520
2
1. TECHNICAL DRAWING 3
2. WARNING AND SAFETY PRECAUTIONS 4
2.1 Life-Threatening Danger, Poisoning Danger 6
6
2.3 Danger of electric shock! 6
2. 4 Danger of physical injury! 6
2.5 Danger of burn, danger of electric shock! 7
7
3. USAGE WITH AND WITHOUT CARBON FILTER 8
3.1 Replacement of Carbon Filter 9
3.2 Replacement of Carbon Filter 9
3.3 AF 500 Carbon Filter 9
4. CLEANING AND PREVENTIVE MAINTENANCE 10
4.1 Washing in Dishwasher 10
4.2 Hand Wash 10
4.3 Removal/Installation of Aluminium Filter 10
5. INSTALLATION OF APPLIANCE 11
5.1 Installation and Unpacking of the Appliance 11
5.2 Installation and Unpacking of the Appliance 11
6. CONTENT OF PACKAGE 13
7. OVERVIEW OF COOKER HOOD 14
8. ASSEMBLY OF PRODUCT 15
8.1 Installation Template 15
8.2 Installation Diagram and Components 16
9. ASSEMBLY OF SHEET METAL FLUES 17
10 USE OF PRODUCT 18
10.1 3 Spd Touch Button 18
11. REPLACING THE LAMPS 19
11.1 Replacement of Halogen Lamp 19
11.2 Replacement of Spark Plug Lamp 19
12. AUTHORIZED SERVICE 20
12.1 Potential Failures and Solutions 21
12.2 Technical Table 21
3
1. TECHNICAL DRAWING
900
Fig. 1: TECHNICAL DRAWING
4
2. WARNING AND SAFETY PRECAUTIONS
■ This appliance can be used by children
aged from 8 years and above and persons with
reduced physical, sensory or mental capabilities or lack of experience and knowledge if they
have been given supervision or instruction concerning use of the appliance in a safe way and
understand the hazards involved.
■ This product is designed for home use.
■ Usage voltage of your product is 220-240
Volt~50 Hz.
■ Power cord of your product is tted with a
grounded plug. This cord must be plugged into
a grounded outlet.
■ The whole electrical wiring must be installed
by a qualied electrician.
■ Installation by unauthorized persons could
lead to poor operation performance, damage to
the product, and accidents.
■ Feeder cable of the appliance mustn't be ex-
posed to jamming or crashing during assembly.
Feeder cable mustn't be placed near the cooker. In such cases, it might melt down and lead
to re.
■ Do not plug in the appliance before the in-
stallation.
■ Make sure that the installation place allows
the user to easily unplug the power cable in
case of any danger.
■ Do not touch your product's lamps when
they work for a long time. Since they would be
hot, they could burn your hand.
■ Kitchen cooker hoods are designed for nor-
mal cooking and home use. For uses other than
specied, there is the risk of failure and the appliance becomes out of warranty.
■ Comply with the regulations of the authori-
ties on the discharge of outlet air.
(This warning does not apply to uses without
ue.)
■ Flammable foods must not be cooked under
the appliance.
■ Turn on the appliance after placing a sauce-
pan, pan, etc. on the cooker. Otherwise, high
temperature might lead to deformation on some
components of your product.
■ Turn off the cooker's burner before taking
the saucepan, pan, etc. off the cooker.
■ Do not leave hot oil on your cooker. Pots
that contain hot oil might lead to inammation.
■ Since oils could catch re when you cook
fried foods in particular, be careful about your
curtains and tablecloths.
■ Ensure timely replacement of the lters. Fil-
ters not replaced in a timely manner pose risk
of re due to accumulated grease deposits on
them.
■ Do not use non-re-resistant ltering materi-
als instead of the lter.
■ Do not operate your product without lter,
and do not remove the lters when the product
is in use.
■ In case of any deagration, de-energize the
cooker hood and cooking appliances. (Plug off
the appliance or turn off the main switch).
■ If your product's periodic cleaning is not
made in a timely manner, it could pose risk of
re.
■ De-energize the appliance before any main-
tenance operations. (Plug off the appliance or
turn off the main switch.)
■ When electric cooker hood and devices
fed with energies other than electricity operate
simultaneously, the negative pressure in the
room must not exceed 4 Pa ( 4 X 10 bar ).
5
■ Gas or fuel oil burning appliances, such as
room heaters, which share the same environment with your product, must be fully insulated
from the exhaust of this product or they must be
hermetical.
■ When you make a ue connection for your
product, use pipes with a diameter of 150mm
or 120 mm.
■ The length of the pipe connection as well as
the number of elbows must be as minimum as
possible.
■ Children must not play with the appliance.
■ For your safety, use ”MAX 6 A” fuse in the
cooker hood system.
■ Since the packing materials could be dan-
gerous, keep them away from children.
■ If the feeder cable is damaged, it must be
replaced by its manufacturer or authorized tech-
nical service or any other personnel qualied at
the same level, in order to avoid any dangerous
situation.
■ In case of any deagration, de-energize the
cooker hood and cooking appliances, and cov-
er the ame. Never use water to extinguish the
re.
■ When cooking appliances are in operation,
their accessible parts could be hot.
■ This appliance is not intended to be used
by people with physical, sensory and mental
disabilities (including children) or those who
have not adequate experience and knowledge
regarding its use, unless they are under the supervision of a person responsible for the safety
of the appliance.
■ After the installation of the cooker hood, the
minimum distance must be 65 cm between the
product and any electric cooker; and 75 cm between it and any gas ranges or cookers burning
other fuels.
■ Output of the cooker hood must not be con-
nected to air ducts, where there exist another
smokes.
■ You must be careful when using the appli-
ance spontaneously with other appliances (e.g.
gas, diesel fuels, coal or wood burning heaters,
shower heaters, etc.)
■ Attention must be paid when using them
simultaneously. Because the cooker hood
could adversely affect the combustion, by
discharging the ambient air.
This warning does not apply to uses without
ue.
■ When electric cooker hood is used simulta-
neously with devices that use gas or other fuels,
there must be sufcient ventilation in the room
(might not apply to devices that discharges the
air back into the room).
■ Simultaneous operation of more than one
gas cooker leads to generation of high heat. A
ventilation appliance placed on the surface of
cookers might therefore get damaged or burn.
Do not operate two gas cookers in high heat for
more than 15 minutes. One large burner with
more than 5kW (Work) power generates power
equal to that of two gas burners.
6
2.1 Life-Threatening Danger, Poisoning Danger
DANGER
There are life-threatening danger and poisoning
danger due to reabsorbed combustion gases.
During the air discharge outlet use, unless sufcient air supply is provided, do not use the appliance simultaneously with devices that discharge
toxic gases through ue such as ventilated, gas,
oil, wood or coal burning heaters, shower heaters, water heaters, etc.
Fig. 2: Poisoning Danger
Ventilated devices (e.g. gas, oil, wood or coal
burning heaters, shower heaters, water heat-
ers) take combustion air from the installation
location, and discharge the waste gas through
a waste gas system (e.g. ue). When the cooker hood is active, it absorbs air from the kitchen
and neighbouring rooms. If adequate air entry is
not provided
vacuum emerges. In such a case, the toxic gas-
es are absorbed from the ue and waste gas
channel, and are taken into to door again. Fig. 2
Therefore, adequate fresh air ingress must always be ensured. Fig. 3
Fig. 3
DANGER
2.2 Risk of re!
Due to sparkling. Installation of appliance over
a heating device that is heated by using solid
fuels (for ex. wood or coal) is only allowed if an
non-detachable cover is present. For the installation process, attention must be paid to current
applicable construction regulations and regulations of local electric and gas companies.
Appliance might lead to re unless it is produced
in accordance with cleaning instructions.
DANGER
2.3 Danger of electric shock!
Do not bend or jam the connection cable during
installation due to danger of damaged connection cable.
DANGER
2. 4 Danger of physical injury!
■ During the installation, there is a danger
of physical injury due to the sharp edges. Use
protective gloves throughout the installation process of the appliance.
■ Due to risk of dropping the appliance, as-
sembly of all safety bolts and covers must be
performed as specied in the user manual.
7
2.5 Danger of burn, danger of electric
shock!
DANGER
■ Allow the appliance to cool before cleaning or
maintenance process. Switch off the fuse or pull
out the mains plug from the socket.
■ There is risk of damage due to ingress of mois-
ture in the electronics. Do not clean the control
components with a wet cloth.
■ The surface could be damaged due to a wrong
cleaning process. Clean stainless steel surfaces only in their brushing direction. Do not use a
stainless steel cleaner for the control elements.
■ The surface could be damaged due to aggres-
sive and abrasive cleaning agents. Never use
aggressive and abrasive cleaning agents.
■ There is risk of damage due to backow of
condensate. Mount the air outlet channel down-
wards from the appliance (slope of 1°).
DANGER
2.6 Dangers of re and physical
injury!
In case of repairing that is not performed according to the rules or as required, turn off the fuse
or unplug the feeder cable of your appliance.
Repairing must be performed only by the authorized technical service or authorized experts.
NOTE
If the appliance is faulty or damages, turn off the
fuse or unplug the feeder cable of your appliance
and call the authorized service.
NOTE
If the feeder cable is damaged, it must be
replaced by its manufacturer or its authorized
technical service or any other personnel
qualied at the same level, in order to avoid any
dangerous situation.
NOTE
If the bulbs of your appliance are faulty, turn
off the fuse or unplug the feeder cable of your
appliance. Replace the bulbs immediately to
avoid overload on other bulbs (wait for the bulbs
to cool down rst)
CAUTION
Accessible components might be heated when
used with cooking devices.
DANGER
Air outlet pipe of this appliance mustn't be con-
nected in the ue used to discharge the fume
generated by devices that use gas or other fuels.
Loading...