MAHLE RTI PSX-2A User Manual

PSX-2 OPERATION INSTRUCTIONS
CAUTION
The PSX-2 is designed to exchange power steering fluid and approved power steering flush chemicals.
Using the PSX-2 for brake fluid and other liquids may damage the pump seals and void the warranty
EXCHANGE
1. Verify that there is enough fluid in the New Fluid Tank and sufficient space in the Used Fluid Tank for the exchange procedure. The vehicle engine must be off.
SERVICE HOSE
2. Remove the Power Steering Fluid Reservoir Cover and submerge Service Hose into the reservoir.
3. Remove the used fluid from the Reservoir by pressing the rear of the switch on the control wand.
4. Refill the Reservoir by pressing the front of the switch on the control wand.
Suggestion: Fill new fluid level slightly above steering
rack return line.
5. Start the vehicle and turn the steering wheel all the way clockwise and then all the way counter-clockwise (lock to lock).
6. Turn the vehicle engine off.
7. Repeat steps 3 through 6 until the desired level of fluid exchange is achieved.
Caution: Do not allow Used Tank to overfill
REPLACEMENT PARTS
ADD NEW FLUID
TO RESERVOIR
REMOVE USED FLUID
FROM RESERVOIR
Pump 320-80016-00 New Fluid Tank 315-80004-00 Used Fluid Tank 315-80005-00 Hose Cap 028-80250-18 Switch 024-80088-00
Technical Support: 800-468-2321 035-80988-00
RTI Technologies, Inc. - 4075 East Market Street - York - PA 17402 - USA
Page 1 of 2
EC Declaration of Conformity for Machinery
Herewith declares that:
- PSX-2 Power Steering Fluid Exchanger
- is in conformity with the provisions of the Machinery Directive (directive 98/37/EC) and with the national implementing legislation
Directive 98/37/EC
RTI Technologies, Inc.
4075 East Market Street York, Pennsylvania 17402 USA Phone: 717-840-0678
- is in conformity with the provisions of the following other EC directives:
Electromagnetic Compatibility (EMC) Directive 89/336/EEC Electromagnetic Emissions EN 61000-6-4: 2001 Electromagnetic Immunity EN 61000-6-2: 1999
The PSX-2 is certified to the EMC Directive like the ATX-2 tested by:
TÜV America Inc. 1775 Old Highway 8 NW Ste. #104 New Brighton, MN 55112 Phone: 651-638-0262
Thomas L. Crandall
Vice President - Technology
Page 2 of 2
Dated: January 10, 2005
Loading...