Mahindra XUV300 W4, XUV300 W6, XUV300 W8, XUV300 W8(0) Owner's Manual

OOwwnneerr’’ss MMaannuuaall

W4/W6/W8/W8(O)

______________________________________________________________________________________

IIssssuuee DDaattee:: FFeebbrruuaarryy 22001199

NNOOTTEE

Carefully read, understand and follow the instructions provided in this manual, and keep it in a safe place for future reference. If you have any

doubt whatsoever regarding the use or care of your vehicle, please visit your Authorised Mahindra Dealer for assistance or advice.

This Owner's Manual should be considered as an integral part of the vehicle and should remain with the vehicle.

__________________________________________________________________________________

MAHINDRA & MAHINDRA LTD., GATEWAY BUILDING, APOLLO BUNDER, MUMBAI - 400 039

www.mahindra.com

1 INTRODUCTION AND SAFETY PRECAUTIONS ........................ 1-1

Introduction............................................................................. 1-1

Safety Symbols ....................................................................... 1-2

General Safety Information and Instructions ..................1-2

To Owners of a Mahindra Vehicle...................................... 1-4

Audio/Infotainment Manual ..............................................1-6

2 GENERAL ..........................................................................................2-1

Feature Matrix........................................................................ 2-1

Lubricants & Fuel Recommendation Chart - Petrol ...... 2-6

Lubricants & Fuel Recommendation Chart - Diesel ...... 2-7

Dimensions.............................................................................. 2-8

Vehicle Identification Number (VIN)................................... 2-9

Engine Number ..................................................................... 2-9

Bulb Specification ............................................................... 2-10

Fuses & Relays.................................................................... 2-11

Changing a Flat Tyre .......................................................... 2-16

Jack Points........................................................................... 2-20

Technical Specifications .................................................... 2-25

3 OVERVIEW........................................................................................ 3-1

Front Overview........................................................................ 3-1

Rear Overview......................................................................... 3-2

Instrument Panel Overview ................................................ 3-3

4 INSTRUMENT CLUSTER OVERVIEW.......................................... 4-1

Warning Lamps Overview.................................................... 4-2

Warning Lamps ..................................................................... 4-4

5 SEATS AND SEAT BELTS ..............................................................5-1

Front Seats ............................................................................. 5-1

Head Restraint ....................................................................... 5-3

Passenger Seat...................................................................... 5-4

Rear Seat ............................................................................... 5-5

Seat Belts ................................................................................ 5-9

Infant and Child Safety ....................................................... 5-15

6 SUPPLEMENTAL RESTRAINT SYSTEM (SRS) ........................6-1

Airbags.....................................................................................6-1

Front Airbags.......................................................................... 6-3

Seat Side Airbag and Curtain Airbag (if equipped).........6-4

Passenger Airbag ON/OFF Switch ................................... 6-5

Airbag System Malfunction Lamp ..................................... 6-5

Table of Contents

Airbag Inflation/Deployment .............................................. 6-6

Child Restraint and Airbag .................................................. 6-8

Airbag Deployment ............................................................... 6-9

Airbag Non-deployment ........................................................ 6-9

Airbag Replacement .......................................................... 6-12

Self Removing SRS Related Parts.................................. 6-12

Airbag Disposal ................................................................... 6-12

Airbag Repair....................................................................... 6-12

Airbag Maintenance........................................................... 6-12

7 LOCKS AND KEYS .......................................................................... 7-1

Doors........................................................................................ 7-2

Tailgate Safety Release Lever............................................. 7-4

Central Locking System........................................................ 7-5

Remote Keyless Entry (RKE) System (if equipped)......... 7-7

Smart Key System/Passive Keyless Entry (PKE) (if

equipped) .............................................................................. 7-12

If Smart Key is Lost............................................................ 7-22

Battery Replacement for Remote Key/Smart

Key.......................................................................................... 7-23

Theft Detent Warning System......................................... 7-24

Engine Immobiliser System .............................................. 7-24

8 FEATURES AND CONTROL...........................................................8-1

Quadruple Switch................................................................... 8-1

Mirrors..................................................................................... 8-4

Interior Rearview Mirror (IRVM) ........................................ 8-5

Storage Compartments ....................................................... 8-7

Sun Visor .............................................................................. 8-16

Horn....................................................................................... 8-17

Sunroof (if equipped).......................................................... 8-18

Interior Lamps ..................................................................... 8-23

Microphone.......................................................................... 8-25

Power Outlet (12V) ............................................................ 8-25

AUX and USB Ports ........................................................... 8-27

Exterior Lamps .................................................................... 8-27

Windshield Wipers............................................................. 8-36

Engine Stop/Start System (ESS) .................................... 8-40

9 INSTRUMENT CLUSTER FEATURES .......................................... 9-1

Tachometer ............................................................................ 9-2

Table of Contents

Speedometer..........................................................................9-2

Odometer.................................................................................9-3

Trip Meter ............................................................................... 9-3

Engine Coolant Temperature Gauge................................. 9-3

Fuel Level Gauge .................................................................... 9-4

W8/W8(O) Instrument Cluster screen flow.................. 9-5

W4/W6 instrument cluster screen flow........................9-6

Clock Screens (if equipped) .................................................9-7

Outside Ambient Temperature (if equipped)................... 9-7

Drive Information (if equipped)............................................ 9-8

Gear Recommendation ....................................................... 9-9

Fuel Computer........................................................................ 9-9

Digital Speedo Meter (if equipped) ................................. 9-10

Cluster Setting (if equipped) ............................................. 9-11

Mood Lighting (if equipped) .............................................. 9-13

Vehicle Condition Related Warning (W8/W8 (O)

only)........................................................................................ 9-14

Tyre Direction Monitoring System (TDMS)................... 9-17

Steering Mode Control Alerts.......................................... 9-18

Smart Key Alerts ................................................................ 9-19

Steering Lock Alerts (for W8/W8 (O) only) ................ 9-19

Door Open Alerts................................................................ 9-20

Functional Safety Alert ...................................................... 9-21

Warning / Tell-tale Lamps in the Instrument

Cluster................................................................................... 9-22

Warning Lamps in the Instrument Cluster .................. 9-24

10 PARKING ASSIST SYSTEM........................................................ 10-1

Front/Rear Obstacle Detection System (if

equipped) .............................................................................. 10-1

Parking Assistance System (PAS) – RPAS & FPAS (If

equipped) .............................................................................. 10-2

PAS (RPAS & FPAS) Information on Instrument

Cluster Screen .................................................................... 10-3

Operation of PAS ................................................................ 10-4

Pay Attention ....................................................................... 10-5

Limitations of PAS .............................................................. 10-7

Reverse Parking Assistance System (RPAS) – Type 1

(if equipped) .......................................................................... 10-8

Table of Contents

Reverse Parking Assistance System (RPAS) - Type-2

(if equipped) ........................................................................10-10

11 REAR VIEW CAMERA (RVC) (if equipped).............................. 11-1

Feature Description ........................................................... 11-1

Screen View Selection....................................................... 11-8

Entry and Exit Conditions................................................... 11-8

Camera Maintenance........................................................ 11-9

System Limitations ............................................................. 11-9

12 STEERING AND BRAKES............................................................ 12-1

Steering................................................................................. 12-1

Steering Mode Control Switch......................................... 12-3

Steering Controls - Audio (if equipped) .......................... 12-4

Brakes ................................................................................... 12-5

Hazard Activation Upon Crash ........................................ 12-7

Vehicle Breakdown Warning ........................................... 12-7

Anti-Lock Brake System (ABS)......................................... 12-7

Electronic Brake Force Distribution (EBD)(if

equipped) .............................................................................. 12-8

13 HEATING, VENTILATION AND AIR-CONDITIONING SYSTEM

(HVAC)............................................................................................ 13-1

HVAC Overview.................................................................... 13-2

Dual Zone Automatic Heater and A/C (if

equipped) .............................................................................. 13-4

Manual Temperature Control (MTC) ...........................13-12

Defogging/Defrosting .....................................................13-17

Replacing Air Conditioner Filter.....................................13-19

14 STARTING AND DRIVING THE VEHICLE................................. 14-1

Safety Tips - Before Starting Your Vehicle .................... 14-1

Starting the Engine............................................................. 14-2

Stopping the Engine ........................................................... 14-3

Exhaust Gases ..................................................................... 14-4

Driving Your Vehicle........................................................... 14-4

Tips for Better Fuel Economy........................................... 14-8

Ignition Switch (if equipped) .............................................. 14-9

Pedals..................................................................................14-10

Transmission .....................................................................14-11

Electronic Stability Program (ESP) (if equipped) .......14-14

Table of Contents

Engine Idling .......................................................................14-15

Cruise Control (if equipped)............................................14-16

Fuel.......................................................................................14-19

15 WHEELS AND TYRES ................................................................. 15-1

Tyre Information.................................................................. 15-1

Tyre Rating ........................................................................... 15-1

Tyre Label (Vehicle Placard)............................................. 15-3

Tyre Pressure ...................................................................... 15-3

Tyre Rotation Recommendations................................... 15-6

Tiretronics (if equipped) .................................................... 15-8

16 EMERGENCIES.............................................................................. 16-1

Hazard Warning Flashers ................................................ 16-1

Vehicle Does Not Start - Checks..................................... 16-1

Vehicle Overheating............................................................ 16-2

Jumpstarting ....................................................................... 16-3

Limp Home Mode ............................................................... 16-7

Towing ................................................................................... 16-7

17 MAINTENANCE ............................................................................ 17-1

General Owner's Information ........................................... 17-1

Opening and Closing the Hood......................................... 17-4

Engine Compartment......................................................... 17-6

General Maintenance........................................................ 17-8

In the Engine Compartment ............................................. 17-9

Maintenance - Inside the Vehicle ..................................17-13

Maintenance - Outside the Vehicle...............................17-14

Battery.................................................................................17-14

Wiper Blades.....................................................................17-15

Appearance Care and Protection.................................17-16

Air-Conditioning System Maintenance.........................17-20

Vehicle Storage.................................................................17-20

Winter Care .......................................................................17-21

Bulb Replacements ..........................................................17-22

Projector Head Lamp (if equipped)...............................17-24

Service Reminder Alert (if equipped) ...........................17-24

Maintenance Schedule Chart (Petrol) .........................17-25

Maintenance Schedule Chart (Diesel) .........................17-28

Table of Contents

1-1

11 IINNTTRROODDUUCCTTIIOONN AANNDD SSAAFFEETTYY PPRREECCAAUUTTIIOONNSS

11..11 IInnttrroodduuccttiioonn

Dear Customer,

Congratulations on purchasing

MMaahhiinnddrraa XXUUVV330000. Your vehicle has

been designed to provide years of safe and dependable service, as long as it is used and maintained in accordance with the instructions provided in this manual.

All persons who will use and/or maintain this vehicle must read, understand and follow all warnings and instructions provided in this manual. This Owner's Manual should be considered an integral part of the vehicle and should remain with the vehicle. However, nothing in this manual, and none of the safety devices installed in the vehicle, are a substitute for careful operation and common sense. Always make sure that your vehicle is in optimum working order, and take note of the road and weather conditions under which you are using your vehicle.

If you have any questions concerning the proper use or maintenance of your vehicle, please call your Authorised Mahindra Dealer. A list of dealers can be found in the Dealer Directory Supplement.

Alternatively, you can contact Authorised Mahindra Dealer at:

• 1800-209-6006 (Toll free)

• customercare@mahindra.com

We extend our best wishes for safe and pleasurable motoring.

Sincerely,

MAHINDRA & MAHINDRA LTD

SSeerrvviicciinngg aanndd SSuummmmaarryy DDaattaa

• For all issues concerning the vehicle and for any need of spare parts, contact only the Authorised Mahindra Dealer network

• We recommend you always use genuine Mahindra spare parts when performing repairs on the vehicle

• We suggest that you record the vehicle data in the

WWaarrrraannttyy aanndd

IInnffoorrmmaattiioonn GGuuiiddee

for future references

IINNTTRROODDUUCCTTIIOONN AANNDD SSAAFFEETTYY PPRREECCAAUUTTIIOONNSS

1-2

11..22 SSaaffeettyy SSyymmbboollss

Carefully read, understand and follow the safety symbols/ instructions given in this manual.

LLeeggeenndd ooff tthhee SSyymmbboollss

To emphasise information and procedures regarding safety, use, maintenance, etc., the following symbols are used throughout the manual:

DANGER indicates an imminently hazardous situation which, if not avoided, will result in death or serious injury.

WARNING indicates a potentially hazardous situation which, if not avoided, could result in death or serious injury.

CAUTION indicates a potentially hazardous situation which, if not avoided, may result in minor or moderate injury and/or property damage.

NOTICE indicates important information relevant to the vehicle, the vehicle's use or to sections of this manual to which

particular attention must be paid for optimum use of the vehicle.

If you see this symbol, it indicates “no,” “do not,” “do not do this,” or “never”.

11..33 GGeenneerraall SSaaffeettyy IInnffoorrmmaattiioonn aanndd IInnssttrruuccttiioonnss

Failure to follow the warnings and instructions provided in this manual could result in failure of the vehicle, an accident and/or serious personal injury.

1. Carefully read, understand and follow the warnings and

instructions given in this manual. This manual is an essential part of the product. Keep it in the vehicle’s glove box for future reference.

2. Please note that throughout this manual, reference is made

that “an accident” could occur. An accident could cause you or a bystander to sustain personal injury, or result in property damage.

3. Never use a mobile phone or any device with headphone while

driving. This may take your focus off the road and lead to accidents.

IINNTTRROODDUUCCTTIIOONN AANNDD SSAAFFEETTYY PPRREECCAAUUTTIIOONNSS

1-3

Please be advised that many service and repair tasks require specialised knowledge, tools and experience. General mechanical aptitude may not be sufficient to properly service or repair your vehicle. If you have any doubt whatsoever regarding the ability to properly service or repair your vehicle, please contact your Authorised Mahindra Dealer or a qualified technician.

5. Inspect the seat belt system periodically, checking for cuts,

frays or wear in the seat belt webbing, or loose buckles, retractors, anchors or other loose parts. Damaged parts must be replaced immediately.

6. Always start and operate the engine in a well-ventilated area. If

in an enclosed area, vent the exhaust to the outside. Do not modify or tamper with the exhaust system.

7. Examine tyres for excessive tread wear and uneven wear

patterns. Check for stones, nails, glass, or other objects lodged in the tread and check sidewalls for any cuts, cracks, or other signs of wear. Replace as necessary.

8. Always maintain the safety labels affixed to your vehicle in a

good legible condition.

9. All signal lamps, buzzers, shields, guards and other protective

safety devices must always remain in place and in good, proper working condition.

10. The lifespan of Mahindra products depend on many factors.

Improper use, abuse or harsh use in general may compromise the integrity of the vehicle and significantly reduce its lifespan. The vehicle is also subject to wear over a period of time. Please

have your vehicle regularly inspected by an Authorised Mahindra Dealer or a qualified mechanic. If the inspection reveals any damage or excessive wear, immediately replace or have the component serviced.

11. We recommend that you use only genuine parts supplied by

Mahindra. The use of non-Mahindra parts will not be covered by warranty.

12. Never crawl under or be in close proximity to the vehicle when

it is lifted off the ground (by a jack), unless the vehicle is properly supported with jack stands, wheel chocks and other appropriate safety devices.

13. Never attempt any repairs or adjustments to any component

while the vehicle is in motion. Always switch off the engine, and wait for the engine to come to a complete stop before performing any repairs or adjustments.

14. The vehicle identification plates are the only legal identification

reference, hence it is necessary to keep them in good condition. Never modify data on the plates or remove them. The customer is responsible for any possible tampering with the plates, which will immediately void the warranty.

15. Do not attempt sharp turns, abrupt manoeuvres, or other

unsafe driving actions that can cause loss of vehicle control. When the vehicle is fully loaded, drive at a slow speed, especially when turning. Note that the centre of gravity of the vehicle changes when the vehicle is fully loaded, and also if luggage is mounted on the roof carrier.

IINNTTRROODDUUCCTTIIOONN AANNDD SSAAFFEETTYY PPRREECCAAUUTTIIOONNSS

1-4

11..44 TToo OOwwnneerrss ooff aa MMaahhiinnddrraa VVeehhiiccllee

When first driving the vehicle after long periods of non-use, you may experience a temporary drive disturbance. This is a characteristic of the tyres and should be no reason for concern. The condition should correct itself within 5-15 km. of driving. If the disturbance persists, have the tyres checked by an Authorised Mahindra Dealer.

DDrriivviinngg aanndd AAllccoohhooll

Your driving ability can be seriously impaired by alcohol even if the blood alcohol level is far below the legal minimum. Drunken driving is one of the most frequent causes of accidents.

Never drink and drive. Drinking and driving will lead to an accident resulting in serious personal injury.

DDrriivviinngg aanndd DDrruuggss//MMeeddiiccaattiioonn

Your driving ability can be seriously impaired through the use of prescription or non-prescription drugs or medication (even cough syrup). If you are taking any sort of drug or medication, be sure that it will not affect your driving ability.

MMoobbiillee PPhhoonneess WWaarrnniinngg

Use of electronic devices such as mobile phones, computers, portable radios or other by the driver while driving is dangerous. In exceptional condition, if use of a mobile phone is necessary despite

this warning, use a handsfree system to ensure that the hands are free to drive the vehicle. Even handsfree do not ensure that due to distraction an accident will not happen.

Please comply with the legal regulations concerning the use of communication equipment in vehicles in your country.

DDrriivviinngg LLoonngg DDiissttaanncceess

When you are driving over long distances, follow these tips so that you have a safe journey:

• Lack of sleep or fatigue will impact your ability to drive safely

• Exercise your eyes by shifting the focus of your eyes to different parts of the road

• Use stimulating beverages such as coffee or tea

• Relax and stay calm

• Take breaks at regular intervals

PPrrootteeccttiinngg OOuurr EEnnvviirroonnmmeenntt

All of us should play our part in protecting our environment. Judicious vehicle usage and ensuring hazardous waste disposal (including cleaning and lubrication fluids) are important steps towards this initiative.

Mahindra vehicles conform to existing emission norms (standards). Adhering to the periodical maintenance schedule and using

IINNTTRROODDUUCCTTIIOONN AANNDD SSAAFFEETTYY PPRREECCAAUUTTIIOONNSS

1-5

Mahindra genuine parts will help retain emission performance of the vehicle and is a pre-requisite for emissions warranty coverage.

SSeerrvviicciinngg

If you have any questions concerning the proper use or maintenance of your vehicle, please call your Authorised Mahindra Dealer. A list of dealers can be found in the Dealer Directory Supplement or on the Internet.

Alternatively, you can contact us on

11880000--220099--66000066 //

ccuussttoommeerrccaarree@@mmaahhiinnddrraa..ccoomm..

RRuunnnniinngg--iinn

Driving smoothly during first 1,000 km. will help to prevent abnormal and premature system wear. Proper running-in will improve the life of drivetrain and vehicle components.

A new engine may consume more oil during the first 1,000 km. of running. This should be considered as a normal part of break-in and not interpreted as any problem with the engine.

MMaahhiinnddrraa GGeennuuiinnee PPaarrttss

Mahindra uses high quality parts for building the vehicles.

In the event that any part needs replacement, we recommend that you use only Mahindra genuine parts.

Non-Mahindra parts may harm vehicle performance and will not be covered by your Mahindra warranty.

To avoid counterfeit parts and to protect our brand image, Mahindra genuine parts are packed in a branded carton. Look for the “Mahindra Genuine Parts” logo.

Any unauthorised modifications or alterations to this vehicle or failure to use appropriate specification and quality spare parts could seriously affect vehicle roadworthiness and safety leading to an accident, resulting in serious injury.

MMaahhiinnddrraa GGeennuuiinnee AAcccceessssoorriieess

A wide selection of quality accessories are available through your Authorised Mahindra Dealer. These accessories have been specifically engineered to allow you to personalise your vehicle to suit your requirements and complement its style and aerodynamic appearance.

Each accessory is made from high quality materials and meets Mahindra's rigid engineering and safety specifications. Every Mahindra accessory installed according to the Mahindra installation provisions comes with the respective accessory warranty.

Consult your Authorised Mahindra Dealer for detailed information about accessories available for your specific model variant.

IINNTTRROODDUUCCTTIIOONN AANNDD SSAAFFEETTYY PPRREECCAAUUTTIIOONNSS

1-6

For maximum vehicle performance and safety considerations, always keep the following information in mind:

• The company does not take any responsibility for consequential damages / injuries resulting due to fitment of unauthorised aftermarket accessories and / or tapping / cutting wires in the wiring harness

• When adding accessories, equipment, passengers and luggage to your vehicle, do not exceed the total weight capacity of the vehicle or of the front and rear axle. Consult Authorised Mahindra Dealer for specific weight information

• Bull bars and nudge guards are not recommended

• Accessories causing any change in vehicle specifications like wheel rims, bull bars, etc., may affect the performance of safety systems

• Mobile communication systems such as two-way radios, telephones and theft alarms that are equipped with radio transmitters and installed in your vehicle should comply with the local regulations and should be installed only by your Authorised Mahindra Dealer

VVeehhiiccllee SSaaffeettyy

When leaving your vehicle unoccupied:

• Always remove the ignition key when you park the vehicle

• Close all the windows completely and lock all the doors

• Do not leave any valuables in your vehicle. If you must leave something in your vehicle, hide them and securely lock all the doors

11..55 AAuuddiioo//IInnffoottaaiinnmmeenntt MMaannuuaall

Please refer the user e-manual in infotainment for details regarding:

• Audio/Video functions (if equipped)

• Bluetooth functions

• Navigation (if equipped)

• Handsfree usage

• Ecosense (if equipped)

• Android Auto (if equipped)

• Car Play (if equipped)

IINNTTRROODDUUCCTTIIOONN AANNDD SSAAFFEETTYY PPRREECCAAUUTTIIOONNSS

2-1

22 GGEENNEERRAALL

22..11 FFeeaattuurree MMaattrriixx

In view of the policy of continuously improving our products, we reserve the right to alter specifications or designs without prior notice and without liability/obligation. Illustrations do not show

the vehicle in the standard form. Please be aware that this manual may apply to various models/variants. As a result you may find some explanations for equipment not installed on your vehicle. All the information, illustration, and specifications in this manual are based on the latest product information available at the time of publication.

We recommend you to contact the nearest Authorised Mahindra Dealer for latest features applicable to your vehicle.

FFEEAATTUURREE WW44 WW66 WW88

WW88((OO))

TTEECCHHNNOOLLOOGGYY

Micro Hybrid Technology (Engine Stop/Start)

� �

Projector Head Lamps

� �

Day Time Running Lamp (DRL)

� �

18 cm (7”) Colour Touch Screen Infotainment Display with GPS, USB (Audio / Video), Bluetooth with Navigation, GPS Antenna and Inbuilt Compass

� � �

10 cm (4") Monochrome Infotainment Display with USB, Bluetooth with Basic Audio Feature

Only for Diesel

Infotainment System (with Carplay and Android Auto)

� �

Tiretronics

�

Reverse Park Assist System

� �

Rear View Camera

� �

Front Park Assist System

�

Auto Rain & Light Sensing Wipers

� �

GGEENNEERRAALL

2-2

FFEEAATTUURREE WW44 WW66 WW88

WW88((OO))

Intermittent Rear Wipers

� �

Intelligent Light Sensing Head Lamps

� �

Digital Immobiliser

� � � �

Digital Trip and Tachometer

� � � �

SMS Read Out

� �

Voice Recognition System

� �

Tweeter

� �

Ecosense

� � �

Mahindra Bluesense App

� � � �

Electric Sunroof with Anti-Pinch

�

Push-Button Start/Stop

� �

Theft Detent Warning System with Burgler alarm

� �

CCOOMMFFOORRTT

Steering Wheel-Leather

� �

Gear Shift Knob-Leather

� �

Steering Mode Control (Normal, Comfort & Sports)

� � � �

HVAC (Manual) with Electrically operated temperature control

� �

HVAC with Dual zone Automatic temperature control

� �

Premium Fabric Seats

� �

Fabric Seats

�

Rear Seat Split (60/40)

� � �

�

GGEENNEERRAALL

2-3

FFEEAATTUURREE WW44 WW66 WW88

WW88((OO))

Artificial Leather Upholstery

�

Power-Foldable ORVM’s with Intergrated Indicator

� �

Power-Adjustable ORVM’s

� �

IRVM (Day/Night)

� � �

IRVM (Auto Dimming)

�

Adjustable Driver's Seat (with Height Adjuster)

� �

Seat Belts (Pre-Tensioner + Load Limiter)

� � � �

Seat Belts (Anchor Pre-Tensioner)

� �

Height Adjustable Seat Belts (Front Row)

� � � �

Sun Visor with Mirror & Illumination

� �

SSTTYYLLEE

Supervision Cluster with Multi Colour Theme

� �

Alloy Wheels

�

Diamond Cut Alloy Wheels

�

Spare Wheel

R16” (Steel) R16 “(Steel) R17” (Steel) R17” (Steel)

Full Wheel Caps

�

Auto Light Control System

� �

Front Fog Lamps

� �

Rear Fog Lamps

� �

High Mounted Stop Lamp

�

In Spoiler In Spoiler In Spoiler

Dashboard and Door Trims Non Painted Non Painted

Soft feel

Painted

Soft feel

Painted

GGEENNEERRAALL

2-4

FFEEAATTUURREE WW44 WW66 WW88

WW88((OO))

2nd Row Armrest with Cupholder

� �

CCOONNVVEENNIIEENNCCEE

Steering Mounted Cruise Controls

� �

Steering Mounted Phone and Audio Controls

� � �

Power Windows

� � � �

Power Windows with Driver Side Express Up/Down with Anti-Pinch

� �

Power Windows with Driver Side Express Down

� �

Extended Power Window

� � � �

Flip Key (Remote Key Entry)

�

Smart Key

� �

Key Illumination

� �

Tinted Solar-Reflecting Glass

� � � �

12V Accessory Socket

� � � �

USB Port for Charging

� � � �

USB Port for Infotainment connectivity

� �

Rear Wash and Wipe

� �

Rear De-Mister

� �

Follow-Me-Home Head Lamps

� � �

Lead-Me-To-Vehicle Lamps

� � �

Roof Lamps Rear Only Rear Only

Front and Rear Front and Rear

Door Ajar Lamps

� �

Bottle Holder

� � � �

GGEENNEERRAALL

2-5

FFEEAATTUURREE WW44 WW66 WW88

WW88((OO))

Glove Box with Illumination lamp

� �

SSAAFFEETTYY

Airbags (Driver + Passenger)

� � � �

Knee Airbag (Driver)

�

Seat Airbag & Curtain Airbags

�

Seat Belt Reminder for Passenger Seats

Front Seats

Only

Front Seats

Only

Front Seats

Only

Front and Rear

Seats

Speed Sensing Door Lock

� � � �

Impact Sensing Door Unlock

� � � �

Passenger Airbag Off Switch

� � � �

ISOFIX Child Seat Mount

� � � �

ABS with Electronic Brake-Force Distribution (EBD)

� � � �

Electronic Stability Program (ESP) with Hill Hold and Brake Assist

� �

Collapsible Steering and Side Intrusion Beams

� � � �

GGEENNEERRAALL

2-6

22..22 LLuubbrriiccaannttss && FFuueell RReeccoommmmeennddaattiioonn CChhaarrtt -- PPeettrrooll

SSyysstteemm

LLuubbrriiccaanntt

RReeffiilllliinngg

CCaappaacciittyy

SSppeecciiffiiccaattiioonn

RReemmaarrkkss

EEnnggiinnee OOiill

MAHINDRA "MAXIMILE FEO"

NEW GENERATION GENUINE ENGINE OIL

4.0 litres

Special Engine

Fluid

Always use "MAXIMILE FEO" new generation Mahindra genuine engine oil. This is specially developed for your engine’s optimum performance and fuel efficiency. In extreme cases of emergency and non-availability of above oil, we suggest Engine Oil meeting minimum API SL SAE 15W-40 specification can be used and replaced at 5,000 km. This alternate oil or other Brand will not provide equivalent performance of above Genuine oil

EEnnggiinnee CCoooolliinngg

MAHINDRA "MAXIMILE ULTRA

COOL"

(READY-TO–USE COOLANT. NO NEED TO MIX WATER)

~3.0 litres

Brand Specific. Don’t use other coolants/water for top-up. In case of emergency, coolant meeting JIS K-2234 specification should be used (30% concentration diluted with distilled water) and coolant change period to be reduced to 30,000 km

TTrraannssaaxxllee OOiill

MAHINDRA "MAXIMILE SYNTEC F2"

NEW GENERATION GENUINE TRANSMISSION OIL

1.75 litres

Special Manual

Transmission

Fluid

In case of genuine oil non-availability, manual transmission oil meeting API GL-4 SAE 80W-90 specification is suggested. This alternate oil or other brand may not provide equivalent performance of recommended genuine oil. Drain Interval should be reduced to 20000km.

BBrraakkee aanndd CClluuttcchh

MAHINDRA "MAXIMILE DOT 4"

GENUINE BRAKE FLUID

1.5 litres (including bleeding)

If Maximile DOT 4 brake fluid is not available and in emergency conditions, use Brake Fluid Meeting SAE J1703 FMVSS NO.116 DOT 4 OR IS 8654 TYPE-2 Specification. Change it at 30,000 km or 2 years whichever is earlier

RReeccoommmmeennddeedd FFuueell

Petrol fuel conforming to Indian

standard IS 2796; 2017 BS–IV

specification or equivalent

42 litres

—

GGEENNEERRAALL

2-7

22..33 LLuubbrriiccaannttss && FFuueell RReeccoommmmeennddaattiioonn CChhaarrtt -- DDiieesseell

SSyysstteemm

LLuubbrriiccaanntt

RReeffiilllliinngg

CCaappaacciittyy

SSppeecciiffiiccaattiioonn

RReemmaarrkkss

EEnnggiinnee OOiill

MAHINDRA "MAXIMILE FEO"

NEW GENERATION GENUINE ENGINE OIL

6.0 litres

Special Engine

Fluid

Always use "MAXIMILE FEO" new generation Mahindra genuine engine oil. This is specially developed for your engine’s optimum performance and fuel efficiency. In extreme cases of emergency and non-availability of above oil, we suggest Engine Oil meeting minimum API CH-4 SAE 15W-40 specification can be used and replaced at 10,000 km. This alternate oil or other Brand will not provide equivalent performance of above Genuine oil

EEnnggiinnee CCoooolliinngg

MAHINDRA "MAXIMILE ULTRA

COOL"

(READY-TO–USE COOLANT. NO NEED TO MIX WATER)

~3.0 litres

TTrraannssaaxxllee OOiill

MAHINDRA "MAXIMILE SYNTEC F2"

NEW GENERATION GENUINE TRANSMISSION OIL

1.75 litres

Special Manual

Transmission

Fluid

BBrraakkee aanndd CClluuttcchh

MAHINDRA "MAXIMILE DOT 4"

GENUINE BRAKE FLUID

1.5 litres (including bleeding)

RReeccoommmmeennddeedd FFuueell

Diesel fuel conforming to Indian

standard IS 1460; 2017 BS–IV

specification or equivalent

42 litres

—

GGEENNEERRAALL

2-8

22..44 DDiimmeennssiioonnss

DDiimmeennssiioonn && WWeeiigghhttss

mmmm

WWhheeeell BBaassee 2600

OOvveerraallll LLeennggtthh 3995

OOvveerraallll WWiiddtthh 1821

OOvveerraallll HHeeiigghhtt 1627

TTrraacckk WWiiddtthh ((FFrroonntt)) 1550

TTrraacckk WWiiddtthh ((RReeaarr)) 1563

22..44..11 FFrroonntt VViieeww

22..44..22 RReeaarr VViieeww

22..44..33 SSiiddee VViieeww

GGEENNEERRAALL

2-9

22..55 VVeehhiiccllee IIddeennttiiffiiccaattiioonn NNuummbbeerr ((VVIINN))

Vehicle Identification Number (VIN) is the legal identity of your vehicle. The vehicle identification number is stamped on the VIN plate riveted on the floor under the driver seat of the vehicle. Flip the cutout provided in the carpet to view the VIN plate.

22..66 EEnnggiinnee NNuummbbeerr

Diesel Petrol

Engine Number is punched on the engine crank case adjacent to transaxle on the front side.

The engine number is also stamped on the VIN plate.

GGEENNEERRAALL

2-10

22..77 BBuullbb SSppeecciiffiiccaattiioonn

LLaammpp BBuullbb WWaattttaaggee BBuullbb TTyyppee NNoo.. ooff BBuullbbss ppeerr VVeehhiiccllee

Headlamp High version – High beam

H1 55W 12V 55W 2

Headlamp High version – Low beam

H7 55W 12V 55W 2

Headlamp Low version High/Low beam H4 55/60W 12V 55/60W

Front position lamp – High version

LEDs

Front position lamp – Low version

W5W 12V 5W 2

Turn signal lamp – Front

P21W 12V 21W 2

Front Fog lamp

H16 19W 12V 19W 2

Side Turn signal lamp – Low version

WY5W 12V 5W 2

Stop lamp

LEDs

Rear position lamp

LEDs

Turn signal lamp – Rear

WY16W 12V 16W 2

Reverse lamp

W16W 12V 16W 2

Rear Fog lamp

P21W 12V 21W 2

GGEENNEERRAALL

2-11

22..88 FFuusseess && RReellaayyss

A fuse is the most common electric protection device. A fuse is placed in an electrical circuit, so that when current flow exceeds the rating of the fuse, it blows off.

The element in the fuse melts, opening the circuit and preventing other components of the circuit from being damaged by the over current. The size of the metal fuse element determines the rating. Once a fuse blows off, it must be replaced with a new one.

Switch the ignition and all electrical equipment OFF before touching or attempting to change a fuse.

The replacement fuse rating should be the same as the one you are replacing.

You can identify a blown fuse by a break in the filament. All fuses except high current fuses are push fit. A fuse puller should be used to remove the fuse from its position.

FFuussee ppuulllleerr iiss aavvaaiillaabbllee aatt tthhee eennggiinnee ccoommppaarrttmmeenntt ffuussee bbooxx..

GGEENNEERRAALL

2-12

22..88..11 EEnnggiinnee CCoommppaarrttmmeenntt FFuussee BBooxx

Engine compartment fuse box is located adjacent to vehicle battery.

To open the fuse box cover, press the lock and push the cover back and lift it.

Spare fuses are provided in the fuse box for replacement of blown fuses. Ensure the correct rating fuse is replaced with the blown fuse.

FFuussee LLaayyoouutt ::

GGEENNEERRAALL

2-13

FFUUSSEESS

FFUUSSEE NNOO.. CCIIRRCCUUIITT FFUUSSEE RRAATTIINNGG

F1 HORN 15A F2 ENG ECU 15A F3 FUEL PUMP 20A F4

H/LAMP LO 20A

F5 ABS 30A F6 WIPER 20A F7

- -

F8 DRL 10A

F9 & 10

- F11 TCU 15A F12

- F13 HVAC 10A F14 RR DEMISTER 30A F15

H/LAMP HI

F16 TAIL LAMP 15A F17 GNS 15A

F18 to 20

- -

F21

H/LAMP LH H/LAMP LH

F22

H/LAMP RH H/LAMP RH

F23

INJECTOR, FUM&HFM INJECTOR,

FUM&HFM

F24

VVT-IN & OUT, VOP VVT-IN & OUT, VOP F25 IGN COIL IGN COIL F26 ORVM ORVM

FFUUSSEESS

FFUUSSEE NNOO.. CCIIRRCCUUIITT FFUUSSEE RRAATTIINNGG

F27

WP, WGV WP, WGV F28 TAIL LH TAIL LH F29 TAIL RH TAIL RH F30 LFS LFS

RREELLAAYY NNOO.. CCIIRRCCUUIITT

RREELLAAYY TTYYPPEE//RRAATTIINNGG

HEAD LAMP HI 12V 20A

HORN 12V 20A

HVAC 12V 20A

WIPER HI 12V 20A 5P

START 12V 35A

COOLING FAN HI 12V 35A

GNS 12V 20A

HEAD LAMP LO 12V 20A

FUEL PUMP 12V 20A

R10

TAIL LAMP 12V 20A

R11

WIPER LO 12V 20A 5P

R12

BLOWER 12V 35A

R13

COOLING FAN LO 12V 35A

R14

- -

R15

ENGINE MAIN 40A 4P

R16

TAIL LAMP 12V 20A

R17

- -

R18

- -

R19

RR DEMISTER 12V 35A

R20

- -

GGEENNEERRAALL

2-14

22..88..22 IInnssttrruummeenntt PPaanneell FFuussee BBooxx

This fuse box is located below the Instrument panel on the driver side. To access the fuse box, pull out the top panel as shown in the image.

FFuussee LLaayyoouutt ::

GGEENNEERRAALL

2-15

FFUUSSEESS

FFSS NNOO.. CCIIRRCCUUIITT FFUUSSEE RRAATTIINNGG

FS1 START 10A FS2 INSIDE MIRROR 10A FS3

EPS, RVC, BCM, SMART KEY

10A

FS4

A/CON, HTR RLY, AUDIO

10A

FS5

H/LAMP LEVELLING DEVICE

10A

FS6

ABS/ESP

10A FS7 TCU 10A FS8

TCU, HVAC

10A FS9 AUDIO 10A

FS10

OUT SIDE MIRROR, SMART

KEY

10A

FS11 & FS12

- FS13 ENG ECU 10A FS14 BUGLER ALARM HORN 10A FS15

- FS16

BACK UP LAMP, PAS

10A FS17 AIRBAG 10A FS18 START * 15A

FS19

SMART KEY BUTTON,

DIAGNOSIS

10A

FS20

- -

FS21

DEFOGGER, BLOWER COIL

10A FS22 BCM 10A

FS23 & FS24

- -

FFUUSSEESS

FFSS NNOO.. CCIIRRCCUUIITT FFUUSSEE RRAATTIINNGG

FS25

HAZARD,TURN SIGNAL LAMP

15A FS26 DOOR LOCK 15A FS27

- FS28 RR WIPER 10A FS29 WASHER 10A

FS30 to FS32

- FS33 RR FOG 10A FS34 POWER WDW LH 25A FS35 POWER WDW RH 25A FS36 FRT FOG LAMP 10A FS37 DRL 10A FS38

- FS39 SUNROOF 20A

*-SMART KEY OPTION

MMEEMMOORRYY FFUUSSEE

PPFF NNOO.. CCIIRRCCUUIITT

MMEEMMOORRYY FFUUSSEE

RRAATTIINNGG

PF1 AUDIO 15A

PF2

ROOM LAMP, FOLDING, CLUSTER

MIRROR, HVAC, TPMS, MBFM

10A

GGEENNEERRAALL

2-16

22..99 CChhaannggiinngg aa FFllaatt TTyyrree

In case of a flat tyre during driving, reduce your speed gradually, keeping a straight line. Move cautiously off the road to a safe place well away from traffic. Park on a level spot with firm ground. Stop the engine and turn ON your hazard warning flashers.

Firmly apply the parking brake. Have everyone come out of the vehicle on the side away from traffic.

Never stop your vehicle in a traffic lane to change a tyre. Risk of being hit by an oncoming vehicle. Keep driving until you reach a safe location.

Lifting a vehicle to change a tyre or perform maintenance is very dangerous if you do not have the requisite tools, safety equipment and training.

The jack provided along with the vehicle is to be used only for changing a spare tyre. It is never to be used to perform any other maintenance or repair on the vehicle.

Never place any part of your body under any portion of the vehicle when it is supported only by the jack. You could be crushed by the vehicle if it falls off a jack. Keep bystanders away from the vehicle.

Find level, solid ground that is clear of oncoming traffic. If you cannot find a safe place to stop, it is better to drive on a flat tyre and damage the rim than it is to risk being hit by oncoming traffic.

After changing a flat tyre, never store the tyre or other equipment in the passenger compartment of the vehicle.

This loose equipment could strike an occupant in the event of a sudden stop or collision. Store all of these items in the proper place.

GGEENNEERRAALL

+ 278 hidden pages

Mahindra XUV300 W4, XUV300 W6, XUV300 W8, XUV300 W8(0) Owner's Manual

Specifications and Main Features

Frequently Asked Questions

User Manual