Magnum Venus Plastech PATRIOT FIRST TIME START-UP User Manual

FIRST TIME START-UP CHECK LIST FOR PATRIOT

ACTIVITY

NO.

ACTIVITY

TICK WHEN
COMPLETED

Priority

Put on Respirator as specified for spray painting, Protective
Clothing, Eye Protection, and PVC Gloves

1

Remove the mix chamber from the front of the gun.

2

Lock the Gun trigger in the Open position over an appropriate
container.

3

Close the Ball Valve on the Catalyst Manifold

4

Remove the Pivot Pin from the Catalyst Slave Drive.

5

Manually pump the catalyst pump with the slave arm drive,
observe for catalyst exiting the Gun block.

Leave the pivot pin out.

6

Make sure the ball valve below the surge chamber is closed.

7

Using the regulator on the manifold, slowly turn up the pump air
pressure until the pump moves slowly and evenly.

8

Allow the resin pump to cycle until only resin exits the Gun block.

9

Turn the air to the pump down to zero.

10

Disengage the gun trigger; leave it in the CLOSED position.

11

Flush the Gun block with acetone, wipe the gun block face clean.

12

Adjust the catalyst percentage required with the slide arm Knob.

13

Insert the Distribution Ring into the Mix Chamber locating rim on
the Pro Gun.

14

Insert the Catalyst Injector into the aperture in the Distribution
Ring. The spring will facing out towards you. Make sure the
catalyst injector seal is in place.

15

Place Mix Housing Seal into the Mix Chamber locating rim.

16

Place Mix Chamber and Catalyst Injector onto the front of the Pro
Gun, secure it with 2 screws

17

Flush the Assembled mix chamber with solvent.

Abnormal Condition

 when

corrected

Internal Mix System

ACTIVITIES MUST BE DONE IN THE SEQUENCE SHOWN, AND MUST BE TICKED OFF AS COMPLETED.

USE THIS CHECKLIST IN CONJUNCTION WITH THE OPERATING MANUAL FOR THE PATRIOT UNIT.

THIS SEQUENCE FOLLOWS ON FROM “PRE-START CHECKLIST – INTERNAL MIX”

NOW REFER TO CHECKLIST – “SET UP – INTERNAL MIX”.

ABNORMAL CONDITIONS OBSERVED AND CORRECTED

OPERATORS NAME _______________________________________ DATE: _________________
SIGN OFF WHEN START UP CHECKS ARE COMPLETED: ______________________________

PATRIOT MAGNUM VENUS PRODUCTS