Lincoln FRESH-O-MATIC Owner’s Manual
INSTALLATION & OPERATING
INSTRUCTIONS
for
FRESH-O-MATIC®
MODEL 4000 SERIES
4000opsman REV: 1/5/07
WARRANTY
Lincoln Foodservice Products, Inc. warrants to the original purchaser for use of each new Wear-Ever® Fresh-OMatic manufactured by Lincoln as follows: any original part which proves to be defective in material or workmanship
within the warranty period will, subject to the terms of this warranty, be repaired, or replaced with a new or
remanufactured part, whichever Lincoln elects, free of charge, provided that in the event of any such defects the
Fresh-O-Matic shall be returned within the warranty period to the nearest authorized service station, transportation
prepaid. If found to contain defective original parts within the limits of this warranty, such parts will be repaired or
replaced as provided in this warranty and the Fresh-O-Matic will be returned, transportation prepaid.
The warranty period shall be a period of one year from the date of original purchase for use or shall be limited to
the fifteen-month period from the date of manufacture.
This warranty applies only to original parts, and only where the Fresh-O-Matic has been subject to normal and
proper use. This warranty does not apply if the Fresh-O-Matic is transported outside of the United States or if the
Fresh-O-Matic or any part thereof is subjected to accident, casualty, alteration, misuse or abuse or if the date of
manufacture is altered or removed.
The obligation of Lincoln is limited to the repair or replacement of defective original parts and except as expressly
stated herein. LINCOLN MAKES NO GUARANTEE OR WARRANTY, EXPRESS OR IMPLIED, INCLUDING
WITHOUT LIMITATION WARRANTIES OF FITNESS OR MERCHANTABILITY with respect to Fresh-O-Matics or
parts thereof and Lincoln has no other liability with respect thereto including without limitation liability for indirect,
special, consequential or resultant damages.
WHAT YOUR FRESH-O-MATIC WILL DO FOR YOU
Enables you to serve pre-cooked convenience foods, baked goods, meats, vegetables, etc. Fresh, hot and
delicious in seconds!
Serves as an auxiliary hot food table during slack periods – quickly heats refrigerated foods to serving
temperature.
Eliminates waste… refrigerated or pre-cooked foods can be proportioned for perfect control and then heated as
needed.
AS EASY AS 1 – 2 – 3 TO OPERATE!
1. Raise cover – place food on tray.
2. Close cover – press lever down.
3. Raise cover – food is ready to serve.
2
4000 Series Operations Manual
FRESH-O-MATIC FEATURES
Number Part Description
1 Cover
2 Perforated Aluminum Food Tray
3 Food Tray Casting
4 “Snap Cap” on water tank
5 Pilot Light
6 On-Off Switch
7 Clear-view Water Gauge
8 Drain for Water Tank
9 Pump Handle
ADDITIONAL FEATURES
Approved By: National Sanitation Foundation
Canadian Standards Association
Underwriters’ Laboratories
This machine is rated at 1500 watts.
Four foil trays are provided for heating certain foods.
COMPLETE DIRECTIONS FOR OPERATION
1. Plug Fresh-O-Matic into electric outlet. Use on 120 Volt A.C. current only.
2. Open cover; lift “snap cap.”
3. Insert funnel in opening; release “snap cap.”
4. Fill water tank with DISTILLED water to “FULL” level shown on front indicator (approximately 5 quarts). Refill as
necessary.
5. Remove funnel; close cover.
6. Turn switch to “ON” position. Pilot Light will come on at the same time.
7. Fresh-O-Matic is ready for use when pilot light goes off first time. Light will go on and off periodically, indicating
operating temperature is being maintained.
8. Lift cover; place food to be served in the Fresh-O-Matic.
9. Close cover; depress pump handle 2 times approximately every 30 seconds. See following pages for complete
instructions.
10. Open cover; food is hot, ready to serve.
NOTE: It is important to keep Fresh-O-Matic cover closed between uses so that proper temperature is maintained
for maximum efficiency.
4000 Series Operations Manual
3
Loading...