Lightolier 302ESAICX User Manual

03-03

3 3/4" (95mm) aperture Lytecaster

Line Voltage 120V ES/ESD16 Recessed Downlight

302ESAICX

IC / Air Seal Frame-In-Kit

Complete fixture consists of Reflector Trim & Frame-in Kit. Select each separately

POWER PACK CUT-OUT

REFLECTOR TRIM

302ESAICX 3 3/4" (95mm) Accepts most 3 3/4" (95mm) 300 serie trims ; see Reflector

Trim specification sheets.

Features Label : Air Seal

Housing: .032" (#20 ga.) aluminum. CSA certified and UL Listed for

direct contact with thermal insulation. Airseal housing minimizes air with WSEC & MEC when installed as instructed.
leakage to less than 2 CFM at 1.57 PSF (or 75pa), which complies with
Model Energy Code (Section 602.3.3) and Washing State Energy Code
(Section 502.4) and reduces heat loss and condensation in ceiling.
Access door fo inspection of junction box. Damp or Wet location rated depending on trim used.
Mounting Frame: .032 (#20 ga.) aluminum. Accommodates

ceilings up to 1" thick. 3/8" deep integral lip. Locks into position along length
of mounting bars with locking screw and bendable slot. Four slots are
positioned 90º apart to simplify alignment.
Mounting Bars: 16 ga. galvanized steel. Extend from 14" (356mm) to 24"
(610mm). "SwiveLock" system permits installation and wiring below the ceiling.
Pre-installed No. 6 auger point screws for installation in wood and steel joists.
Attaches to T-bar ceilings without the need of accessories.
Junction Box: 2"( 51mm) x 4" (102mm) x 3 1/2" (89mm) 22 ga. galvanized
steel. CSA certified and UL listed for maximum of 8 No. 12 ga. Integral cable clamp permit
attachment of non-metallic (#12 or #14 ga.) cable without tools or additional
connector.
Socket : Porcelain body ; Two-pin (GX5.3 base) Pre-wired with 18 ga. Teflon
250º leads to junction box.
Lamp cover : Aluminum heat deflector for 50w MR16 or ES/ESD16
dichroic lamps.
Internal Thermal cut-out: Insures against overheating due to incorrect
lamping.

Tested in accordance with ASTM E283 (max 2 cfm @ 75 pa) and comply

Labels : CSA, UL

WE RESERVE THE RIGHT TO CHANGE DETAILS OF DESIGN, MATERIALS AND FINISH, IN ANY WAY

THAT WILL NOT ALTER INSTALLED APPEARANCE OR REDUCE FUNCTION AND PERFORMANCE.

Lightolier CFI, 3015 Louis Amos Lachine, (Quebec) H8T 1C4