LIFE@HOME Gsc3218j Owner's Manual

WARNING
Improper installation, adjustment,
alteration, service or maintenance
can cause injury or property
damage.
Read the installation, operation and
maintenance instructions
thoroughly before installing or
servicing this equipment.
DANGER
Failure to follow these instructions
could result in fire or explosion
which could cause property
damage, personal injury or death.

5-Burner LP Gas Grill

DANGER!
DO NOT use gas grill for indoor
cooking or heating. TOXIC fumes
can accumulate and cause
asphyxiation. NOT to be us ed in or
on boats or recreational vehicles.

PROP 65 WARNING
Chemicals known to the state of
California to cause cancer, birth
defects or other reproductive harm
are created by the combustion of
propane.

WARNING

For Outdoor Use Only.
(outside any enclosure)

FOR YOUR SAFETY :

SAVE THESE INSTRUCTIONS FOR FUTURE REFERENCE.
IF YOU ARE ASSEMBLING THIS UNIT FOR SOMEONE
ELSE, GIVE THIS MANUAL TO HIM OR HER TO SAVE FOR
FUTURE REFERENCE.

FOR CUSTOMER SERVICE, CALL 1-877-885-8227,
6 A.M. – 5 P.M. PST, MONDAY-FRIDAY.

Printed in China

GSC3218J Gas Grill

f

Table of Contents

For Your Safety....................................................................................…............2

Parts List & Illustration.......................................................................................4

Assembly Instructions........................................................................................6

Operating Your Grill Connecting Gas Cylinder....................................13

Check for Leaks...................................................14

Lighting Your Grill...............................................14

Cleaning and Care...............................................15

Award- Winning Barbecue Recipes..................................................................16

Gas Grill Troubleshooting.................................................................................17

Warranty Program..............................................................................................19

1. DO NOT store or use gasoline or
other flammable vapors and liquids
within 25 feet (8m) of this or any
other appliance.

2. When cooking with oil/grease, do
not allow the oil/grease to exceed
350° F (177°C). Do not store or use
extra cooking oil in the vicinity o
this or any other appliance.

3. An LP Cylinder not connected for
use shall NOT be stored within 10
feet (3m) of this or any other
appliance.

WARNING

FOR YOUR SAFETY

WA RNING

If you smell gas:

1. Shut off gas to the appliance.

2. Extinguish any open flame.

3. Open Lid.

4. If odor continues, immediately call

FOR YOUR SAFETY

your gas supplier or fire department.

GSC3218J owner’s manual

1

GSC3218J Gas Grill

For Your Safety

Dear Valued Customer,

Congratulations on your new barbecue grill! You’ve made the right choice. In this manual, you will find assembly instructions, suggestions for

grilling, and helpful hints, as well as guidelines for the safe operation, proper care and use of your grill. Our expert staff strives to provide you

with an easy to assemble product. Should you have any questions, problems or missing parts with this product, please call our customer

service department at 1-877-885-8227 6:00am - 5:00pm (PST). Monday through Friday.

NOTE: The use and installation of this product must conform to local codes. In absence of local codes, use the National Fuel and Gas
Code, ANSI Z223.1, Storage and Handling of Liquefied Petroleum Gases, NFPA / ANSI 58 of CAN/CGA-B149.1, Natural Gas Installation Code
of CAN/CGA-B149.2, Propane installation Code.

IMPORTANT NOTICE:

Safety First!
Read and understand all warnings and precautions prior to operating your grill.

To prevent fire or explosion hazard when testing for a leak:

1. Always perform “leak test” on page 12 before lighting the grill each time the cylinder is connected for use.

2. Do not smoke or allow other sources of ignition in the area while conducting a leak test.

3. Conduct the leak test outdoors in a well-ventilated area.

4. Do not use matches, lighters or a flame to check for leaks.

5. Do not use grill until any and all leaks are corrected. If you are unable to stop a leak, disconnect the propane supply. Call a gas appliance

6. This grill is for use with propane gas only (propane gas cylinder not included).

7. Never attempt to attach this grill to the self-contained propane system of a camper trailer, motor home or house.

8. Never use charcoal or lighter fluid.

9. Do not use gasoline, kerosene or alcohol for lighting! The LP-gas supply cylinder must be constructed and marked in accordance with the

10. Do not attempt to move the grill while it is lit.

11. Do not use the grill unless it is

12. Keep all combustible items and surfaces at least 20 inches (50.8 cm) away from the grill at all times. DO NOT use this gas grill or any gas

13. Do not use in an explosive atmosphere. Keep grill area clear and free from combustible materials, gasoline and other flammable vapors

1. This grill is for outside use only, and shall not be used in a building, garage or any other enclosed area.

2. The use of alcohol or prescription or non-prescription drugs may impair the consumer's ability to properly assemble or safely operate the
appliance.

3. Always open grill lid carefully and slowly as heat and steam trapped within grill can severely burn you.

4. Always place your grill on a hard, level surface far away from combustibles. An asphalt or blacktop surface may not be acceptable for

5. Do not leave a lit grill unattended, especially keep children and pets away from grill at all times.

6. This is not a tabletop grill. Therefore, do not place this grill on any type of tabletop surface.

7. Do not use grill in high winds.

CAUTION

1. Do not touch metal parts of grill until it has completely cooled (about 45 minutes.) to avoid burns, unless

2. Do not alter grill in any manner.

3. Clean and inspect the hose before each use of the appliance. If there is evidence of abrasion, wear, cuts, or leaks, the hose must be

4. Move gas hoses as far away as possible from hot surfaces and dripping hot grease.

5. Never keep a filled container in a hot car or car trunk. Heat will cause the gas pressure to increase, which may open the relief valve and

READ ALL INSTRUCTIONS PRIOR TO ASSEMBLY AND USE!

DANGER

serviceman or your local propane gas supplier.

specifications for propane gas cylinders of the U.S. Department of Transportation (DOT) CFR 49 or the National Standard of Canada,
CAN/CSA-B339, Cylinders, Spheres and Tubes for the Transportation of Dangerous Goods. This outdoor cooking appliance is not
intended to be installed in or on recreation vehicles and/ or boats.

COMPLETELY

product under any overhead or near any unprotected combustible constructions.

and liquids.

assembled and all parts are securely fastened and tightened.

WARNING

this purpose.

you are wearing protective gear (pot holders, gloves, BBQ mittens, etc.).

replaced prior to the appliance being put into operation. The replacement hose assembly shall be that specified by the manufacturer.

allow gas to escape.

GSC3218J owner’s manual

2

GSC3218J Gas Grill

Liquid propane(LP) gas is flammable and hazardous if handled improperly. Become aware of the characteristics before using any propane
product.

• Propane Characteristics: Flammable, explosive under pressure, heavier than air and settles in pools in low areas.

• In its natural state propane has no odor. For your safety, an odorant is added.

• Contact with propane can cause freeze burns to skin.

• This grill is shipped from the factory for propane gas use only.

• Never use propane cylinder with a damaged body, valve, collar or footing.

• Dented or rusted propane cylinders may be hazardous and should be checked by your propane gas supplier.

It is essential to keep the grill’s valve compartment, burners and circulating air passages clean.
Inspect grill before each use.

GENERAL INFORMATION

1. Propane gas cylinder required for operation.

2. This gas grill is NOT for commercial use!

DANGER

CAUTION

GSC3218J owner’s manual

3

GSC3218J Gas Grill

Parts list & illustration

1.Cart assembly................…....1pc

2. Store basket......................1pc

3. Back up rail.............................1pc

4. Cart back board....................1pc

5.Cart doors.............................2pcs

9. Right shelf plate......................1pc

13. Warming grid........................1pc

17. Oil cup support..………….…1pc

6.Drawer assembly...............1pc

10. Side burner frame...........1pc

14. Cylinder support..............1pc

18. Motor support……………1pc

7. Body assembly…...................1pc

11. Heating plate.......................4pcs

15. Cylinder fix wire........…….....1pc

8. Left shelf plate.......................1pc

12. Cooking grids....................3pcs

16. Oil cup……........................1pc

GSC3218J owner’s manual

4

GSC3218J Gas Grill

Hardware ( A screwdriver is also included for your convenience.)

A

B

C

Φ6.5 XΦ9 X1.2mm
Lock washer

D

Φ6.5 XΦ16 X1.0mm
Washer

E

F

M6 X 15mm
Bolt

M6 X 20mm
Bolt

M6 X 50mm
Bolt

M4 X 12mm
Bolt

10pcs

12pcs

4pcs

10pcs

18pcs

4pcs

Φ4.5 XΦ10 X0.8mm washer

G

M4 Nut

H

Side knob

I

J

M6 Nut

k

Screwdriver

L

4pcs

4pcs

1pc

M4 X 8mm
Bolt

2pcs

2pcs

1pc

GSC3218J owner’s manual

5