LIFE@HOME Gpc2619j Owner's Manual

WARNING
Improper installation, adjustment,
alteration, service or maintenance can
cause injury or property damage.
Read the installation, operation and
maintenance instructions thoroughly
before installing or servicing this
equipment.
Failure to follow these instructions could
result in fire or explosion which could
cause property damage, personal injury
or death.

GPC2619J Gas Grill

p

Deluxe LP Gas Grill

DANGER!
DO NOT use gas grill for indoor cooking
or heating. TOXIC fumes can accumulate
and cause asphyxiation. NOT to be used
in or on boats or
recreational vehicles.

WARNING
Chemicals known to the state of
California to cause cancer, birth defects,
or other reproductive harm are created
by the combustion of propane.

WARNING

FOR YOUR SAFETY :

For Outdoor Use Only
(outside any enclosure)

VE THESE INS

SA
REFERENCE. IF YOU ARE ASSEMBLING
THIS UNIT FOR SOMEONE ELSE, GIVE
THIS MANUAL TO HIM OR HER TO SAVE
FOR FUTURE REFERENCE.

TRUCTIONS FO

R FUTURE

GPC2619J owner’s manual

Printed in China

0

GPC2619J Gas Grill

f

Table of Contents

For Your Safety.................................................................................................…2

Parts List & Illustration.......................................................................................4

Assembly Instructions........................................................................................6

Operating Your Grill Connecting gas cylinder....................................13

Check for leaks...................................................14

Lighting your grill...............................................14

Cleaning and care...............................................15

Award- Winning Barbecue Recipes..................................................................16

Gas Grill Troubleshooting..................................................................................17

Warranty Program..............................................................................................19

WARNING

FOR YOUR SAFETY

1. DO NOT store or use gasoline or
other flammable vapors and liquids
within 25 feet (8m) of this or any
other appliance.

2. When cooking with oil/grease, do
not allow the oil/grease to exceed
350° F (177°C). Do not store or use
extra cooking oil in the vicinity o

3. An LP Cylinder not connected for
use shall NOT be stored within 10
feet (3m) of this or any other
appliance.

1. Shut off gas to the appliance.

2. Extinguish any open flame.

3. Open Lid.

4. If odor continues, immediately
call your gas supplier or fire
department.

WARNING

FOR YOUR SAFETY

If you smell gas:

GPC2619J owner’s manual

Rev 1.1

1

GPC2619J Gas Grill

Dear Valued Customer,

Congratulations on your new barbecue grill. You’ve made the right choice! In this manual, you will find assembly instructions,
suggestions for grilling and helpful hints, as well as guidelines for the safe operation, proper care and use of your grill. Our
expert staff strives to provide you with an easy to assemble product. Should you have any questions, problems or missing parts
with this product, please call our customer service department at 1-877-885-8227 6:00am - 5:00pm (PST). Monday through
Friday.

NOTE: The use and installation of this product must confor m to local codes. In absence of local code s, use the National Fuel Gas Code ,
ANSI Z223.1, NFPA54 or CAN/CGA-B149.1. Natural Gas and Propane installation Code.

IMPORTANT NOTICE: READ ALL INSTRUCTIONS PRIOR TO ASSEMBLY AND USE!

Safety First!
Read and understand all warnings and precautions prior to operating your grill.

DANGER

To prevent fire or explosion hazard when testing for a leak:

1. Always perform the “leak test” on page 14 before lighting the grill and each time the cylinder is connected for use.

2. Do not smoke or allow other sources of ignition in the area while conducting a leak test.

3. Conduct the leak test outdoors in a well-ventilated area.

4. Do not use matches, lighters or a flame to check for leaks.

5. Do not use grill until any and all leaks are corrected. If you are unable to stop a leak, disconnect the propane supply. Call a gas appliance
serviceman or your local propane gas supplier.

WARNING

1. This grill is for outside use only, and shall not be used in a building, garage, or any other enclosed area.

2. This grill is for use with propane gas only (propane gas cylinder not included).

3. Never attempt to attach this grill to the self-contained propane system of a camper trailer, motor home, or house.

4. Never use charcoal or lighter fluid.

5. The use of alcohol, or prescription or non-prescription drugs may impair the consumer's ability to properl y assemble or safely operate
the appliance.

6. Do not use gasoline, kerosene, or alcohol for lighting! The LP-gas supply cylinder must be constructed and marked in accordance with
the specifications for propnae gas cylinders of the U.S.

Department of Transportation (DOT) CFR 49. This outdoor cooking appliance is not intended to be installed in or on recreation vehicles

and/ or boats.

7. Always open grill lid carefully and slowly as heat and steam trapped within grill can severely burn you.

8. Always place your grill on a ha rd, level surface far away from com bustibles. An asphalt or blacktop surface ma y not be acceptable for
this purpose.

9. Do not attempt to move the grill while it is lit.

10. Do not leave a lit grill unattended, especially keep children and pets away from grill at all times.

11. This is not a table top grill. Therefore, do not place this grill on any type of tabletop surface.

12. Do not use grill in high winds.

13. Do not use the grill unless it is COMPLETELY assembled and all parts are securely fastened and
tightened.

14. Keep all combustible items and surfaces at least
product under any overhead or near any unprotected combustible constructions.

20‘’ (50.8 cm) away from the grill at all times. DO NOT use this gas grill or any gas

CAUTION

1. Do not touch metal parts of grill until it has completely cooled (about 45 min.) to avoid burns, unless
you are wearing protective gear (pot holders, gloves, BBQ mittens, etc.).

2. Do not use in an explosive atmosphere. Keep grill area clear and free from combustible materials,
gasoline and other flammable vapors and liquids.

3. Do not alter grill in any manner.

4. Clean and inspect the hose before each use of the appliance. If there is evidence of abrasion, wear, cuts, or leaks, the hose must be
replaced prior to the appliance being put into operation. The replacement hose assembly shall be that specified by the manufacturer.

5. Move gas hoses as far away as possible from hot surfaces and dripping hot grease.

6. Never keep a filled container in a hot car or car trunk. Heat will cause the gas pressure to increase, which may open the relief valve and
allow gas to escape.

GPC2619J owner’s manual

2

GPC2619J Gas Grill

CAUTION

Liquid propane (LP) gas is flammable and hazardous if handled improperly. Become aware of the characteristics before using any propane
product.

• Propane Characteristics: Flammable, explosive under pressure, heavier than air, and settles and pools in low areas.

• In its natural state propane has no odor. For your safety, an odorant has been added.

• Contact with propane can cause freeze burns to skin.

• This grill is shipped from the factory for propane gas use only.

• Never use propane cylinder with a damaged body, valve, collar or footing.

• Dented or rusted propane cylinders may be hazardous and should be checked by your propane gas supplier.

• It maybe hazardous to attempt to fit other types of gas cylinder.

CAUTION

It is essential to keep the grill’s valve compartment, burners and circulating air passages clean. Inspect
grill before each use.

GENERAL INFORMATION

1. Propane gas cylinder required for operation.

2. This gas grill is NOT for commercial use!

GPC2619J owner’s manual

3

Parts list & illustration

GPC2619J Gas Grill

1. Grill body……………………..1pc 2. Left side shelf…………………1pc

5. Right cart leg………………….1pc 6. Wheel cap…………………..2pcs 7. Wheel………………………2pcs 8. Wheel axle…………………1pc

9. Back panel……………………1pc 10. Front back rail……………….1pc 11. Bottom panel…………………1pc

13. Bottom tank bracket…………1pc 14. Grease cup support………..1pc 15.Grease cup…………...………1pc

17. Cooking grid-L………………1pc

18. Cooking grid-R………………1pc

3. Right side shelf………………..1pc

19. Door…………………………2pcs

4. Left cart leg……………………1pc

12. Top tank bracket……………1pc

16. Side knob……………………1pc

20. Warming rack………………1pc

21. Heating plate……………….1pc

GPC2619J owner’s manual

4

GPC2619J Gas Grill

Hardware ( A screwdriver is also included for your convenience.)

M 6 x 65mm

A

M 10

C

M 6 X 45mm

4pcs

2pcs

M6 X 16mm

B

Ø 18 X Ø6

D

M 4 X 10mm

13pcs

21pcs

E

W asher

G

S crewdriver

I

4pcs

2pcs

1pc

F

M 6

H

W rench

J

GPC2619J owner’s manual

5

2pcs

8pcs

2pcs