LIBRO CB55, CB60, RU60 User Manual

USER MANUAL

FREE STANDING OVEN

50x55 / 50x60 / 60x60

Gas & Electrical Oven

H10-20-180-039 Rev 002

GUIA DEL USUARIO

ES

GB

2

Dear User,

Our objective is to make this product provide you with the best output
which is manufactured in our modern facilities in a careful working envi­ronment, in compliance with total quality concept.

Therefore, we suggest you to read the user manual carefully before us­ing the product and, keep it permanently at your disposal.

Note: This user manual is prepared for more than one model. Some of
the features specied in the Manual may not be available in your appli­ance.

All our appliances are only for domestic use, not for commercial use.

“THIS APPLIANCE SHALL BE INSTALLED IN ACCORDANCE WITH THE
REGULA TIONS FORCE AND ONLY USED IN A WELL VENTILATED SPACE. READ
THE INSTRUCTIONS BEFORE INSTALLING OR USING THIS APPLIANCE”

“Conforms with the EEE Regulations."

GB

3

CONTENTS

Important warnings 4
Introduction of the Appliance 6
Important warnings 7
Chain Lashing Illustration 8
Installation of your oven 9
Technical features of your oven 9
If the appliance does not operate 11
Control panel 12
Using cooker section 12
Using oven section 14

Maintenance and cleaning 15

Installation of the Oven Door 16

Cleaning and maintenance of the

oven’s front door glass 17

Changing the Oven Lamp 17
Accessories 18
Nozzle change operation 19

Reduced ame gas cock adjustment 19

Removal of the Lower and Upper Burner and
Installation of the Injector to the Gas Oven 20

GB

4

IMPORTANT WARNINGS

1.Pay attention to minimum health and safety requirements.

2.The cooker is supplied setup according to the conditions shown on the

rating label which is stuck to the rear of the appliance. From this sticker

you can learn for which gas type (LPG or NG) this appliance is congured

when supplied.

3.Keep the electrical cable of your oven away from the hot areas.

4.If the supply cord is damaged, it must be replaced by the manufactur-

er its services agent or similar qualied persons in order to avoid hazard.

5.Ensure that the appliance is switches off before replacing the lamp to

avoid the possibility of electric shock.

6.In case of power failure, readjust your timer denitely. Otherwise, the

oven will not operate (Digital Timer).

7.Your oven can be having different output pressure according your

countries gas and pressure specications. Be sure that the cooker is con­gured correctly for local requirements (for example, the jets must be

suitable for local gas type and gas pressure).

8.Connect your oven to LPG in shortest way and without any leakage.

Min. 40 cm Max. 125 cm.

9.When making gas leakage check, never use any ame type like those

of lighter, matches, cigarette re or similar ones.

10.Usage of your appliance creates moisture and heath in the room it

is placed, make sure that your kitchen is ventilated well. Maintain the

natural ventilation ducts properly.

11.CAUTION! Do not touch hot parts with bare hands and keep children

well supervised

12.When the oven is hot never touch the oven glass by hand.

13.Before starting to use your appliance, keep curtain, tulle, paper or

inammable things away from your appliance. Do not keep combustible
or inammable things in or on the appliance.

GB

5

14.This appliance is for cooking purposes only. It must not be used for

other purposes, for example room heating. All our appliances are only for

domestic use, not for commercial use.

15.For disconnection from the supply mains having a contact separation

in all poles that provide full disconnection, must be incorporated in xed

wiring in accordance with the wiring rules.

16.Some models are supplied without a plug-an-lead set. In this

case please use a exible cable to suitable for connection to mono
phase: H05 VV-F3G4mm 2 or for 3 phase: H05 VV-F 5G 1.5mm 2

17.This appliance is produced in accordance with the safety regula-

tions. Incorrect use will harm people and appliance.

18.Children should be supervised to ensure that they do not play with

the appliance. Never let them play with the appliance.

19.Unattended cooking on a hob with fat or oil can be dangerous and

may result in re.NEVER try to extinguish a re with water, but switch off
the appliance and then cover ame e.g. with a lid or a re blanket.

20.Danger of re: do not store items on the cooking surfaces

21.This appliance is not intended for use by persons (including chil-

dren) with reduced physical, sensory and mental capabilities or lack of

experience and knowledge, unless they have been given supervision or

instruction concerning the use of the appliance by a person responsible
for their safety.

22.“CAUTION: Accessible parts may be hot when the grill is in use. Young

children should be kept away”

GB

6

1. Hotplate Ø145mm

2. Hotplate Ø185mm

3. Middle Burner

4. Trivet

5. Large Burner

6. Glass Door (Sheet Metal

Door)

7. Cooker Section Led Lamp

8. Oven Section Led Lamp

9. Control Panel

10. Thermostat Setting

11. Oven Setting

12. Digital Timer

13. Cooker Section Control
Switches

14. Push Button Lighter

15. Door

16. Handle

17. Plastic Leg

18. Lower Cabinet
Door

18.1 Drawer

18.2 Flap Door

19. Lamp

20. Grill

21. Standard Tray

22. Deep Tray

19

20
21

22

INTRODUCTION OF THE APPLIANCE

6
7

8
9

10

11

18

17

16

15

14

13

12

3
4

5

2

1

18.2*

18.1*

Figure 18.1 and 18.2 are op­tional for ovens with dimen-

sions 50x60 and 60x60(*)

Figure 18.1 is not available for

oven with dimension 50x55

and 18.2 is optional. (*)

GB

7

IMPORTANT WARNINGS
Electrical Connection and Security

1.Your oven requires 16 or 32 Ampere fuse according to the appliance’s

power. If necessary, installation by a qualied electrician is recommended.

2.Your oven is adjusted in compliance with 230V~50-60Hz. (or-

230V/400V~50-60Hz.) electric supply. If the mains are different from
this specied value, contact your authorized service.

3.Electrical connection of the oven should only be made by the sockets

with earth system installed in compliance with the regulations. If there
is no proper socket with earth system in the place where the oven will be

placed, immediately contact a qualed electrician. Manufacturer shall

never be responsible from the damages that will arise because of the
sockets connected to the appliance with no earth system. If the ends of
the electrical connection cable are open, according to the appliance type,
make a proper switch installed in the mains by which all ends can be

disconnected in case of connecting / disconnecting from / to the mains.

4.If your electric supply cable gets defective, it should denitely be re-

placed by the authorized service or qualed electricians in order to avoid

from the dangers.

5.Electrical cable should not touch the hot parts of the appliance.

6.Please operate your oven in dry atmosphere.
Gas Connection and Security

Please operate your oven in dry atmosphere.

1.Fit the clamp to the hose. Push one of the hose until it goes to the

end of the pipe.

2.For the sealing control; ensure that the buttons in the control panel

are closed, but the gas cylinder is open. Apply some soap bubbles to the­connection. If there is gas leakage, there will be foaming in the soaped
area.

3.The oven should be using a well ventilation place and should be in-

stall on at ground.

4.Re-inspect the gas connection.

5.When placing your oven to its location, ensure that it is at the counter

level. Bring it to the counter level by adjusting the feet if necessary.

6.Do not make gas hose and electrical cable of your oven go through

theheated areas, especially through the rear side of the oven. Do not move
gas connected oven. Since the forcing shall loosen the hose, gas leakage
may occur.

7.Before using the appliance, in order to ensure safe use, be sure to

GB

8

x the appliance to the wall using the chain and hooked screw supplied.

Ensure that the hook is screwed into the wall securely.

8.Please use exible hose for gas connection.

Before using the appliance, in order to
ensure safe use, be sure to x the appli­ance to the wall using thechain and hooked
screw supplied. Ensure that the hook is
screwed into the wall securely.

Chain Lashing Illustration

230V~50-60Hz 230V~50-60Hz

400V 3N~50-60Hz 400V 2N~50-60Hz

Earth
Terre
Erdung

Earth
Terre
Erdung

Earth
Terre
Erdung

Earth
Terre
Erdung

L3

L2

L1

L2

L1

L1

Live
Phase

Neutral
Neutre

Neutral
Neutre

Neutral
Neutre

FUSE SWITCH (25A/40A)

JUNCTION BOX

3x4mm²

3x4mm²

610mm

H05 VV-F 3G 4mm² H05 VV-F 5G 1.5mm² H05 VV-F 4G 1.5mm² H05 VV-F 3G 1.5mm²

CONSUMER UNIT

Neutral
Neutre

GB

9

INSTALLATION OF YOUR OVEN

TECHNICAL FEATURES OF YOUR OVEN

SPECIFICATIONS 50x55 50x60 60x60

Outer width 500mm 500mm 600mm
Outer depth 565mm 630mm 630mm

Outer height 855mm 855mm 855mm
Inner width 341mm 341mm 441mm
Inner depth 443mm 443mm 443mm
Inner height 316mm 316mm 316mm
Inner volume 48lt 48lt 62lt
Lamp power 15W 15W 15W
Bottom heating element 1000W 1000W 1200W
Top heating element 800W 800W 1000W
Turbo heating element ----- 1800W 2200W
Grill heating element 1500W 1500W 2000W

850 mm min.

500 -600 mm min.

20 mm 20 mm

GB

10

Supply Voltage

220V-240V AC,50-60Hz (Or
230V400V AC,50-60 Hz)

Hot Plate 145 mm 1000 W
Hot Plate 180 mm 1500 W
Hot Plate rapid 145 mm 1500 W

Hot Plate rapid 180 mm 2000 W

BURNER INJECTOR VALUES

ACCORDING TO

THE GAS TYPE

LPG

G30/28-30 mbar

NG

G20/20 mbar

NG

G25/25 mbar

Wok

Burner

Injector Ø mm 0,96 1,30 1,40
Power kW 3,60 3,35 3,66

Consuption

Gr/h,m³/h

259,20 0,300 0,365

Rapid

Burner

Injector Ø mm 0,85 1,15 1,15
Power kW 2,75 2,75 2,75

Consuption

Gr/h,m³/h

198 0,263 0,287

Semi

Rapid

Burner

Injector Ø mm 0,65 0,97 0,97
Power kW 1,60 1,70 1,70
Consuption

Gr/h,m³/h

115,20 0,165 0,175

Auxiliary

Burner

Injector Ø mm 0,50 0,72 0,72
Power kW 0,90 0,90 0,90
Consuption

Gr/h,m³/h

64,80 0,086 0,097

Oven

Burner

Injector Ø mm 0,65 0,97 0,97
Power kW 1,80 1,85 1,85
Consuption

Gr/h,m³/h

129,60 0,174 0,192

Grill

Burner

Injector Ø mm 0,60 0,92 0,92
Power kW 1,50 1,55 1,55
Consuption

Gr/h,m³/h

108 0,153 0,164

GB

11

IF THE APPLIANCE DOES NOT OPERATE

1. Please check the plug of power supply cord has a well connection

with wall socket or not.

2. Please check the electric network.

3. Please check the fuse.

4. Please check power supply cord for any damage problems.

5. If you can not solve the problem, get in contact with manufacturer

supplier service agent or similar qualied persons.

DESCRIPTION OF OVEN and CONTROL PANELS

THERMOSTAT KNOB; In order to operate the oven, thermostat must be-

adjusted to desired temperature. Your thermostat has a feature of adjust-

ment to 50 - 280 degree.

MECHANIC TIMER KNOB (Optional); In order to operate the oven,
timerswitch should be adjusted to desired time from 0-90 minute. You
can use cooking time table.

Tumspit Fan

Top + Bottom heating
element

Turbo heating + Fan

Lamp

Bottom + Top heating
elements + Fan

Bottom heating element
+ Fan

Grill heating element+Fan

Grill heating element

Grill burner / Grill heating

element

Grill heating
element+Lamp

Top heating element

Electrical timer

Oven burner / Bottom

heating element

Flame Ignition lighter

GB

12

CONTROL PANELS

USING COOKER SECTION

Using Gas Burners:

WOK Burner 24-28cm
Big Burner 22-26cm
Normal Burner 18-22cm
Small Burner 12-18cm

1. In order to obtain maximum output, be careful that the saucepan

which will be used should be at bottomed, and use the saucepans with

dimensions given herein above.

2. The valves controlling the gas cookers have special security mecha-

nism. In order to light the cooker always press on the switch forward and

bring it to ame symbol by turnin counterclockwise. All of the lighters

shall operate and the cooker you controlled shall light only. Keep the
switch pressed until ignition i performed. Press on the lighter button and

Closed

Fully open

Half open

0

0

Front

electric

hot plate

Rear

electric

hot plate

Rear left

burner

(middle

burner)

Front left

burner (big

burner)

Grill burner

or heating

element

Oven burner
(optional) or

heating

element

Timer

(optional)

Thermostat

(optional)

GB