Page 1
Lemair
RefrigeratorRefrigerator
RQ-80H
INSTRUCTION MANUAL
Page 2
1.Name of parts1.Name of parts
1
PARTS AND FEATURESPARTS AND FEATURES
9
5
2
3
4
8
6
7
10
Cabinet
Evaporator
Thermostat Knob
Shelf
Hinge Cover
Door
Gasket
77
88
Adjustable Legs
99
Small Door
10
Door Bar
1
Page 3
2.Correctly positioning 2.Correctly positioning
Well Ventilating
There is need of good ventilation around the refrigerator for easy
dissipation of heat, high efficiency of refrigeration and low power
consumption. For this purpose, sufficient clear space should be
need around the refrigerator. Its back is at least 100mm away from
the wall, its sides at least have a space of 100mm separately and
the height from over its top is not less than 200mm. A clear space
should be left to open its doors to 160
Power Supply
The refrigerator is only applied with power supply of single phase
alternating current of (220-240)V~/50Hz; If fluctuation
of voltage in the district user is of so large that the voltage
exceeds the above scope, for safety sake, be sure to apply a.c.
automatic voltage regulator to the refrigerator. The refrigerator
must employ a special power socket instead of common one with
other electric appliances. Its plug must match the socket with
ground wire.
(+220-240)V~(+220-240)V~
__
++
10%10%
50Hz50Hz
¡À¡À
¡À¡À
Power Line Cord
The cord should be neither lengthened nor folded into
coil during operation. Moreover, it is forbidden that cord
is kept close onto the compressor at the back of the
refrigerator, the surface temperature of which is quite
high when operating. Touching with it would deactivate
the insulation or cause leakage for electricity.
Protection from Moisture
Avoiding placing the refrigerator in a place where heavy
moisture is present so as to minimize possibility of rusty
for its metal parts. Still more, the refrigerator is forbidden to
be directly sprayed by water, otherwise, poor insulation and
current leakage would occur.
NN
Page 4
2.Correctly Positioning2.Correctly Positioning
Protection from Heat
The refrigerator should be far away from any heat
source or direct sunshine.
Fixing Stable
Floor on which refrigerator will be placed must be flat
and solid. It should not be laid on any soft material such as
foam plastic, etc. If the refrigerator is not on the same level,
adjust the screws suitably. The refrigerator should not be
placed near anything which may echo.
Keep Away from Danger
It is inadvisable that the refrigerator is placed near
any volatilizable or combustible such as gas, petrol,
alcohol, lacquer and banana oil, etc. The above-mentioned
objects can not be stored in the refrigerator.
Moving
When fixed or moved, the refrigerator can not be
set horizontally or declined to more than 45 or
upside-down.
Page 5
3.Cautions3.Cautions
It must be checked that the used should be the same as the rated voltage
before the refrigerator is used.
Water contained in food or getting into air inside the refrigerator by opening doors
may form a layer of frost inside, It will weaken the refrigerator when the frost is thick,
Therefore you should defrost manually when the ice is thick. When defrosting, a pan
is needed to put under the evaporator for taking the defrost water.
If the supply cord of this appliance is damaged, it must only be replaced by a repair
shop appointed by the manufacturer, because special purpose tools are required.
It is dangerous to alter the specifications or attempt to modify this products
in any way
voltage
When the refrigerator is not in use for long periods, disconnect it from the
electricity supply.
Wait for 5 minutes before restart the unit after the power supply blackout..
44
Page 6
4.Changing the reversible door4.Changing the reversible door
This refrigerator has the capability of either opening the door from the left
or right side. The unit is delivered to you with the door opening from the
left side. Should you desire to reverse the opening direction, please
follow these instructions.
NOTE:
Before Reversing the door ,the power must be shut off.
All parts removed must be saved to do the reinstallation of the door.
This refrigerator has been built with the door hinges on the right. If you wish
to change the opening direction, follow the instructions below:
1. Remove the upper hinge cover(6) first
2. Remove the two screws (1) that hold the upper hinge (5) (right side) to the
frame. Take away the upper hinge (5).
3. Lift the door and place it on a padded surface to prevent scratching it.
4. Remove the two screws(8) that hold the lower hinge(2) and Make sure to
Remove the lower hinge(2).
5. Remove the left front leg (4) and transfer it to the right side.
6. Remove the hole cover plate(7) to the right side.
Before placing this lower hinge(2), remove the bolt-pin (9) and reverse
7.
the direction of the lower hinge(2). Then install the lower hinge (2) onto
the left side of the lower frame with two screws (8).
8. Insert the bolt-pin(9) to the lower hinge (2).
9. Set the door to its place making sure the door seat at the lower hinge(2)
.
10. While holding the door in the closed position secure the upper hinge (5) in the
top frame of left side with two screws (1). Please remember that do not tighten
the two screws(1) until the top of the door is levelled with the counter top.
11. Install the upper hinge cover(6) on the upper hinge..
11
66
77
44
Door opening from left side
55
22
88
99
33
11
55
22
88
33
Door opening from right side
77
66
44
99
55
Page 7
5.Maintenance 5.Maintenance
The refrigerator should be cleaned and maintained once a month.
When performing maintenance, make absolutely sure that the power plug
is first disconnected from the power outlet.
Wipe the inner and outer surface of the refrigerator and its accessories with
wet cloth. If they are too dirty, scrub them with neutral detergent, and then
clean them with water and dry them with clean cloth. After this, a small
quantify of glass wax is recommended to polish the refrigerator surface with
a flannelette.
For cleaning, don't use hot water, diluent, petrol, alcohol, kerosene, washing
powder, cleanser, aikailinous detergent, acid, Chemical cloth, etc. So as not
to damage the lacquer coat and plastics. It is forbidden than the refrigerator
is directly sprayed with water. Otherwise, it would cause rusty or weaken the
insulation.
Be careful to upkeep the sealing rubber bars of the doors. They should always
be cleaned.
If the plastic parts in refrigerator remain contaminated for a long time by oil
(animal or vegetable), they will be easy aged and possibly cracked. The drain
pan gets dirty very easily if it is not cleaned regularly, bad odours will be produced, get into the habit of cleaning this pan regularly.
66
Page 8
6. Troubleshooting
1. When the refrigerator does not work
Check if there is a power failure.
Check if the power plug is plugged into the power outlet.
Check that the fuse has not blown.
2. When the refrigerator is cooling excessively
The temperature control dial may be set too high.
If you place foodstuffs containing a lot of moisture directly under the cool
air outlets, they will freeze easily. This does not indicate a malfunction.
3. When the refrigerator is not cooling sufficiently
The food may be packed too tightly together which will block the flow of cool air.
You may have put something hot or a lot of foodstuffs into the refrigerator .
The door may not have been closed properly.
The door gaskets may be damaged.
The refrigerator may not be ventilated.
There may be insufficient clearance between the refrigerator and the surfaces
The temperature control dial may not be set properly.
4. When condensation form on the outside of the refrigerator.
Condensation may form on the outside when the humidity is high such as during
a wet season. This is the same result as the condensation formed when chilled
water is poured into a glass. It does not, therefore, indicate a failure, wipe dry
with a dry cloth.
5. When you hear a sound like water flowing .
A sound like water flowing is the refrigerant flowing. It does not Indicate a
malfunction.
6. When the cabinet's side panel heats up
The side panel of the cabinet will heat up when the door is opened or closed
frequently, when starting the unit and when the unit operates in summer with
high ambient outside temperature, In such case, do not touch the panel, it
results from the dissipation of the heat from inside the cabinet, and it does
not mean that something is wrong with the refrigerator.
7
Page 9
7.Technical specifications7.Technical specifications
*For the detailed technical specifications, please refer to the nameplate at
the back of the refrigerator.
*Specifications are subject to change without prior notice.
8
Page 10
Warranty
TECMA LEMAIR Pty Limited
Lemair all fridge cyclic defrost refrigerators
1) Purchasers Statutory Rights
The supplementary warranty terms set out below are additional to and in no way limit, vary or exclude
any rights conferred by conditions or warranties imposed and required to be binding by statute. Your
attention is drawn to the provision of the trade practices act, 1974 and state legislation, which confers
certain rights to consumers.
2) Supplementary Warranty
Domestic use (single family)
Tecma Lemair Pty Limited warrants to the original purchaser of the equipment purchased from an
authorised dealer the following warranties:
12 MONTHS WARRANTY
From the original date of purchase covering parts and labour.
24 MONTHS WARRANTY
From the original date of purchase any defect found in the refrigeration system (compressor,
evaporator and condenser) (excluding refrigerant) caused by faulty labour and or faulty materials will
be rectified by Tecma Lemair during normal business hours .
Commercial or Industrial use. (More than single family use. Eg. Motels, offices, lunch rooms
etc.)
One (1) YEAR WARRANTY
From the original date of purchase any defect found in the refrigeration system (compressor,
evaporator and condenser, defrost system, temperature control etc) caused by faulty labour and or
faulty materials will be rectified by Tecma Lemair during normal business hours. Plastic, rubber,
painted surfaces and glass components are not covered under this limited commercial warranty.
The above warranties are subject to the following terms and conditions.
The above warranties are subject to the following terms and conditions.
Terms and conditions
1. The appliance is warranted for domestic and commercial use against faulty parts and
workmanship for the warranty period shown above
2. At no time does LEMAIR have liability for any freight or transportation costs or for damage
during transit or for any consequence of failure arising out of the failure of the product unless
such limitation of liability is prohibited by statute. Tecma Lemair Pty Ltd suggests all food
stuffs be adequately insured in the event of the failure of the refrigeration system or its
controlling equipment.
3. In the event that the product is installed outside the normal service area of the authorised
service provider, or not be accessible by a normal two wheel drive service vehicle, you shall
Page 11
meet the cost of sending the product to the service centre or the service providers travelling
costs to your home.
4. Warranty does not include any defect or failure attributable to accident, misuse, abuse,
negligence, non- observance of operating instructions or local regulations on the part of the
user, insect or vermin infestations, thunderstorm activity, and exposure to abnormally
corrosive conditions or to improper installation or connection to inadequate or faulty power.
5. The warranty is valid to products installed in mainland Australia.
6. Excluded from warranty are plastic or glass components, painted surfaces and light globes.
7. Safe access and suitable no cost parking shall be provided for the servicer to transport
themselves and their equipment to your home
8. Warranty does not apply where:
i. equipment has been serviced by a person not authorised by Lemair to do so, or with
non-approved parts.
ii. if any serial number has been removed or defaced.
iii. if the equipment is used outside mainland Australia.
iv. if the equipment is repossessed under any financing agreement
Tecma Lemair Pty Ltd reserves the right to charge for any service not covered by the Lemair
supplementary warranty.
Should service be required under this warranty, the purchaser should contact an
approved LEMAIR service provider.
Please complete the details below which should be kept for future reference.
Model …………………………… Serial Number……………………………………
Retailer…………………………….Date of Purchase ………………………..............
.
Please retain this warranty card with your purchase receipt for presentation to the Service
Technician in the event of a warranty claim.
Loading...