Legacy Heating CDF-WMGB28, WELLFP5010 User Manual

Assembly Instructions

& User’s Manual

Model No ：CDF-WMGB28/WELLFP5010

FOR OUTDOOR USE ONLY.

KEEP THE INSTRUCTIONS FOR FUTURE REFERENCE.

If you have any question or concerns, please contact California Outdoor Design at the below resources:
Toll Free Phone: [phone] Monday-Friday , 8am-4:30pm
Email: Service @legacyheatcalifornia .com

Table of Contents

Warnings ………….……………………………………………….2-5

Hardware and Tools............…………………..……………………6

Parts .........................................................................................7

Assembly Instructions …….………………………………………8-10

Installing Instructions.....……………………………………….......11-12

Operating Instructions ……………………………......................13

Lighting......................................................................................14

Cleaning and Care …………………………………....................15-16

Troubleshooting ….……………………………..........................17-18

Care and Maintenance.................................................................19

Warranty Information....................................................................19

Caution: Do not attempt to operate until you have read &
understand all General Safety Information in this manual and all
assembly is complete & leak checks have been performed.

Note: Before beginning assembly of product, make sure all parts
are present. Compare parts with package content list and
hardware contents. If any part is missing or damaged do not
attempt to assemble the unit. Contact customer service for
replacement parts.

Page 1 of 20

Warnings

WARNING

FOR YOUR SAFETY：

Read these instructions before using this appliance. The appliance must be installed in accordance with the
instructions and local regulations. The use of this appliance in enclosed areas can be dangerous and is
PROHIBITED.
Do the leak test after each changing of cylinder.
Never check for leaks with a match or open flame.
Do not store or use gasonline or other flammable vapors and liquids in the vicinity of this appliance.

IF YOU SMELL GAS

Close the valve of gas cylinder or regulator.
Extinguish all naked flames, do not operate any electrical appliances.
Check for leaks as detailed in these instructions.

WARNING

FOR YOUR SAFETY：

Improper installation, adjustment, alteration, service or maintenance can cause injury or property damage.
Read the installation,operation and maintenance instructions thoroughly before installing or servicing this
eqipment. Failure to follow these instructions could result in fire or explosion, which could cause property
damage, personal injury or death.

CARBON MONOXIDE HAZARD

D DANGER

This appliance can produce carbon
monoxide which has no odor.
Using it in an enclosed space can kill, cause
injury or death.
Never use this appliance in an enclosed
space such as a camper, tent, car or home.

WARNING

FOR YOUR SAFETY：

An LP cylinder not connected for use should not be stored in the vicinity of this or any other appliance.

WARNING
FOR YOUR SAFETY:

FOR OUTDOOR USE ONLY (outside any enclosure)
FILL METAL BASE WITH SAND (12.5 KG/27.5 lbs) BEFORE USE

.

Page 2 of 20

Warnings

DANGER

DANGER indicates an imminently
hazardous situation which, if not
avoided, will result in death or
serious injury.

CAUTION

CAUTION indicates an imminently
hazardous situation which, if not
avoided, may result in minor or
moderate personal injury or property
damage.

WARNING: For Outdoor Use Only

WARNING

Improper installation, adjustment,
alteration, service or maintenance
can cause injury or property
damage. Read the instructions
thoroughly before installing or
servicing this equipment.

WARNING

WARNING indicates an imminently
hazardous situation which, if not
avoided, could result in death or
serious injury.

DANGER

Do not store or use gasoline or
other flammable vapor and liquids
in the vicinity of this or any other
appliance.

FOR YOU SAFETY

Failure to comply with the
precautions and instructions
provided with this heater can result
in death, serious bodily injury and
property loss or damage from
hazards of fire, explosion, burn,
asphyxiation, and/or carbon
monoxide poisoning.
Only persons
and follow the instructions should
use or service this heater.

who can understand

WARNING

This product contains chemicals,
including lead, known to the
State of California to cause birth
defects or other reproductive
harm.

Wash hands after handing.

Page 3 of 20

Warnings

DANGER

Solid fuels shall not be burned in this appliance

DANGER

The maximum inlet gas supply pressure: Max . 250PSI . Min 5PSI

DANGER

“Do not use this appliance if any part has been under water.
Immediately call a qualified service technician to inspect the appliance and to replace
any part of the control system and any gas control that has been under water.”

DANGER

CARBON MONOXIDE HAZARD

For outdoor use only. Never use inside house or other unventilated or enclosed
areas. This heater consumes air (oxygen). Do not use in unventilated or enclosed
areas to avoid endangering your life.

DANGER

EXPLOSION - FIRE HAZARD

Never store propane near high heat, open flames, pilot lights, direct sunlight, other
ignition sources or where temperatures exceed 120 degrees F (49°C). Propane vapors
are heavier than air and can accumulate in low places. If you smell gas, leave the area
immediately.
Never install or remove propane cylinder while heater is lighted, near flame, pilot lights,
other ignition sources or while heater is hot to touch.
This heater is red hot during use and can ignite flammables too close to the burner. Keep
flammables at least 48" (122cm) from sides & 48" (122cm) from top. Keep gasoline and
other flammable liquids and vapors away from heater. The
be stored outdoors in a well ventilated space. Never store propane cylinder in an
enclosed area (house, garage, etc.). If heater is to be stored indoors, disconnect the
propane cylinder for outdoor storage.

propane cylinder must always

Caution: Do not attempt to operate until you have read & understand all General
Safety Information in this manual and all assembly is complete & leak checks have
been performed.

Page 4 of 20

Warnings

You must provide propane gas and propane cylinder. Use a standard 20 lb. propane
cylinder only.

Use this heater only with a propane vapor withdrawal supply system. See Chapter 5 of the
Standard for Storage and Handling of Liquified Petroleum Gas, ANSI/NFPA 58. Your local
library or fire department should have this book.

The minimum permissible gas supply pressure of 10 W.C. is required for purpose of input
adjustment.

The minimum hourly of 48,000 Btu is required input rating for a heater for automatic
operation at ratings less than full input rating.

The pressure regulator and hose assembly supplied with the appliance must be used.

The installation must conform with local codes, or in the absence of local codes, with
National Fuel Gas Code, ANSI Z223.1.

A dented, rusted or damaged propane cylinder may be hazardous and should be checked
by your cylinder supplier.

The cylinder used must inc lud e a collar to protect the
cylinder valve.

Never use a propane cylinder with a damaged valve connection.

Do not store a spare LP Gas cylinder under or near this
appliance.

Never fill the cylinder beyond 80 percent full.

For appliances designed to use a CGA No.791 connection:

Place the dust cap on the cylinder valve outlet whenever the
cylinder is not in use.

Only install the type of dust cap on the cylinder valve that is
provided with the cylinder valve.

Other types of caps or plugs may result in leakage o f
propane.

Note: Gas supply pressure: 25 to 250

Page 5 of 20