LawnMaster CLGT4012K Operator's Manual

CLGT2412K

Operators Manual

Read all safety rules and instructions carefully before operating this tool.
Distributed By Cleva North America 601 Regent Park Court Greenville, SC 29607 (866)-384-8432

Shoulder Strap Included

40V-12" Li-Ion Cordless Grass Trimmer CLGT4012K

EN p. 2

Type Cordless, Battery-Powered

Rated No Load Speed 7200 r/ min

Line Diameter 0.080" Round Line

Feed System 12" Fixed Line

Cutting Width 12 inch

Weight 7.4 lbs without battery

2

CONTENTS

PRODUCT SPECIFICATIONS

GENERAL SAFETY RULES

ELECTRICAL INFORMATION

SYMBOLS

KNOW YOUR CORDLESS GRASS TRIMMER

ASSEMBLY

OPERATION

MAINTENANCE

TROUBLESHOOTING

WARRANTY POLICY

EXPLODED VIEW

PARTS LIST

NOTES

2

2

3-4

5

6-7

8-9

10-11

12-14

14-15

16

17

18

19

20

CONTENTS

PRODUCT SPECIFICATIONS

40V LITHIUM-ION CORDLESS GRASS TRIMMER

3

GENERAL SAFETY RULES

WARNING

Read and understand all instructions before using this product. Failure to follow all

• Do not operate power tools in explosive atmospheres，such as in the presence of flammable

liquids, gases, or dust. Power tools create sparks which may ignite the dust or fumes.

• Do not allow children or untrained individuals to use this unit.

• Don’t expose power tools to rain or wet conditions. Water entering a power tool will increase the

risk of electric shock.

• Do not handle plug or tool with wet hands.

• Never allow children to operate the equipment. Never allow adults to operate the equipment

without proper instruction.

• Always wear safety glasses with side shields. Everyday glasses have only impact resistant

lenses. They are NOT safety glasses. Following this rule will reduce the risk of eye injury. Use

face mask if operation is dusty.

• Wear eye protection when operating this product. Secure long hair above shoulder level to

prevent entanglement in moving parts.

• Do not expose to rain, store indoors.

• Keep all parts of your body away from any moving part.

• Keep hair，loose clothing，fingers and all body parts away from opening and moving parts.

• Wear heavy long pants, boots, and gloves. Avoid loose garments or jewelry that could get

caught in moving parts of the machine or its motor.

• Do not force tool. Use the correct tool for your application. The correct tool will do the job

better and safer at the rate for which it is designed.

• Do not operate the equipment while barefoot or when wearing sandals or similar lightweight

footwear. Wear protective footwear that will protect your feet and improve your footing on

slippery surfaces.

• Secure long hair so it is above shoulder level to prevent entanglement in any moving parts.

• Keep firm footing and balance. Do not overreach. Overreaching can result in loss balance.

• Do not allow to be used as a toy. Close attention is necessary when used by or near children.

• Do not use tool if switch does not turn it on or off. Any tool that cannot be controlled with the

switch is dangerous and must be repaired.

• Keep all bystanders, children, and pets at least 50 ft. away.

• Do not operate this unit when you are tired，ill， or under the influence of alcohol，drugs，or

medication.

• Do not operate in poor lighting.

• Do not put any object into openings. Do not use with any opening blocked; keep openings free
Of dust，lint,hair，and anything that may reduce air flow.

• Check the work area before each use. Remove all objects such as rocks, broken glass, nails,

wire, or string which can be thrown or become entangled in the machine.

4

GENERAL SAFETY RULES

• Use only identical manufacturer’s replacement parts and accessories. Use of any other parts

may create a hazard or cause product damage.

• Do not charge battery tool in rain, or damp or wet location. Following this rule will reduce the

risk of electric shock.

• For household use only.

• Battery tools do not have to be plugged into an electrical outlet; therefore, they are always in

operating condition. Be aware of possible hazards when not using your battery tool or when
changing accessories. Following this rule will reduce the risk of electric shock，fire，or serious

personal injury.

• Remove or disconnect battery before servicing, cleaning or removing material from the

gardening appliance.

• Store idle appliances - When not in use, grass trimmer should be stored indoors in a dry, locked

place out reach of children.

• Do not dispose of the batteries in fire. The cell may explode. Check with local codes for possible

special disposal instructions.

• Do not place battery tools or their batteries near fire or heat. This will reduce the risk of explosion

and possibly injury.

• Do not open or mutilate the batteries. Released electrolyte is corrosive and may cause damage

to the eyes or skin. It may be toxic if swallowed.

• Batteries can explode in the presence of a source of ignition, such as a pilot light. To reduce

the risk of serious personal injury, never use any cordless product in the presence of open flame.

An exploded battery can propel debris and chemical. If exposed, flush with water immediately.

• Do not crush, drop or damage battery pack. Do not use a battery pack or charger that has

been dropped or received a sharp blow. A damaged battery is subject to explosion. Properly

dispose of a dropped or damaged battery immediately.

• Exercise care in handling batteries in order not to short the battery with conducting materials

such as rings, bracelets, and keys. The battery or conductor may overheat and cause burns.

Do not open or mutilate the batteries. Released electrolyte is corrosive and may cause damage

to the eyes or skin. It may be toxic if swallowed.

• For best results, your battery tool should be charged in a location where the temperature is

more than 50°F but less than 100°F. To reduce the risk of serious personal injury, do not store

outside or in vehicles.

• Under extreme usage or temperature conditions, battery leakage may occur. If liquid comes in

contact with your skin, wash immediately with soap and water, then neutralize with lemon juice

or vinegar. If liquid gets into your eyes, flush them with water with clean water for at least 10

minutes, then seek immediate medical attention. Following this rule will reduce the risk of serious

personal injury.

•

5

ELECTRICAL INFORMATION

The following signal words and meanings are intended to explain the levels of risk associated

with this product.

• If the power supply cord is damaged, it must be replaced only by the manufacturer or by an

authorized service center to avoid risk.

• Do not point the grass trimmer in the direction of people or pets.

• Never run the unit without the proper equipment attached. Always ensure the sweeper tubes

are installed.

• When not in use, grass trimmer should be stored indoors in a dry, locked up place—out of the

reach of children.

• Maintain tool with care. Keep fan area clean for best and safest performance. Follow instructions

for proper maintenance. Do not attempt to clear clogs from tool without first unplugging it.

• To reduce the risk of electrical shock, do not expose to rain, do not use on wet surfaces. Store

indoors.

• Save these instructions. Refer to them frequently and use them to instruct others who may

use this power tool. If you loan someone this power tool, loan them these instructions also.

WARNING (PROPOSITION 65)

Some dust created by power sanding, sawing, grinding, drilling, and other construction activities

contains chemicals known to cause cancer, birth defects or other reproductive harm. Some

examples of these chemicals are:

• Lead from lead-based paints

• Crystalline silica from bricks and cement and other masonry products, and

• Arsenic and chromium from chemically treated lumber.

Your risk of exposure to these chemicals varies depending on how often you do this type of

work. To reduce your exposure to these chemicals, work in a well-ventilated area, and work with

approved safety equipment, such as dust masks that ate specially designed to filter out

microscopic particles.

CHILD SAFETY

Tragic accidents can occur if the operator is not aware of the presence of children.

• Keep children out of the working area and under the watchful care of a responsible adult.

• Do not allow children under the age of 14 to operate this grass trimmer. Children who are 14

years of age and older must read and understand the operating instructions and safety rules

in this manual and must be trained and supervised by a parent.

• Stay alert, and turn the grass trimmer off if a child or any other person enters the working area.

• Look behind and down for small children before and while cutting backwards.

• Use extreme care when approaching blind corners, doorways, shrubs, trees, or other

objects that may obscure your view of a child who may run into the path of the grass trimmer.

6

SYMBOLS

On the product, the rating label and within these instructions you will find among others he following

symbols and abbreviations. Familiarise yourself with them to reduce hazards like personal injuries

and damage to property.

n

o

NOITANALPXE/NOITANGISED EMAN LOBMYS

V Volts Voltage

A Amperes Current

Hz Hertz Frequency (cycles per second)

W Watts Power

hrs Hours Time

No Load Speed Rational speed, at no load

Class II Construction Double-insulated construction

/min Per Minute Revolutions, strokes, surface speed, orbits etc.,
per minute

Designates that this tool is in compliance with
Lithium-Ion battery recycling program requirements

Lithium-Ion Battery
Recycling

Read the Operator’s Manual

Safety Alert Symbol

To reduce the risk of injury, user must read and
understand operator’s manual before using this product.

Eye and Head Protection

Gloves

Safety Footwear

Kickback DANGER! Beware of kickback.

DANGER! Risk of electrocution!

Failure to keep your hands away from the blade will
result in serious personal injury.

Failure to use in dry conditions and to observe safe
practices can result in electric shock.

Risk of Electrocution

Electric Shock

No Hands Symbol

Keep Bystanders Away

Wear eye and head prote

ction when operating this

equipment.

Wear non-slip, heavy-duty protective gloves when
handling the pole saw and the blade.

Wear non-slip safety footwear when using this
equipment.

Precautions that involve your safety.

Keep all bystanders at least 50' (15 m) away.