Lanier 480-0081 User Manual

A

Lanier Worldwide, Inc.
2300 Parklake Drive, NE

tlanta, GA USA 30345-2979

MATERIAL SAFETY DATA SHEET

Emergency Telephone: [phone]

Section 1: Chemical Product and Company Information

Identity:

Black Toner Type 110

Product ID: 480-0081 Issued: 11/09/2004
Synonyms

& Common
Names:

Uses:
Chemical

Formula:

Black Toner Cassette
Type 110 for Lanier LP036c

Lanier LP036c

Mixture

MSDS No.

Supersedes:

Date:

Prepared by:

Approved by:

European

Contact:

CP- 400
06/15/2004

11/09/2004
EH&S Department 770-496-9500

Larry Choskey, Manager, CEH&S
Walter Fricke, Manager, Safety &
Environment,
Lanier Worldwide, Inc.
Im Taubental D-41468 Neuss,
Germany [phone]

Section 2: Composition / Information on Ingredients

Component Percent CAS No. Exposure Limits Source

Polyester resin >80 Confidential Not listed N/a
Acrylic resin <10 Confidential Not listed N/a
Carbon black <15 1333-86-4 3.5 mg/m

3.5 mg/m

3
3

Silicon compound <10 7631-86-9 Not listed N/a

*PEL as the product: 15mg/m
*TLV as the product: 10mg/m

3

(total dust), 5mg/m3 (respirable dust)

3

(total dust), 5mg/m3 (respirable dust)

OSHA PEL

ACGIH TWA

Section 3: Hazards Identification

HMIS Rating:

FLAMMABILITY = 1 HEALTH = 1
REACTIVITY = 0 SPECIAL = none

Health Hazards (Acute, Chronic, Immediate and Potential): Minimum irritation to respiratory tract may occur as with exposure
to any non-toxic dust. May cause gasping if inhaled. Inhalation should be avoided. May cause temporary eye discomfort.
Health Hazards of Long Term exposure (Chronic): Prolonged inhalation of excessive dust may cause lung damage. It is
attributed to “lung overloading”, a generic response to excessive amounts of any dust retained in the lungs for a prolonged interval.
Use of this product, as intended, does not result in inhalation of excessive dust.
Carcinogenicity: Carbon Black was reclassified as a Group 2B by the IARC in 1996 based upon the result of only the inhalation
study in rats. However, there was not observed the incidence of tumors on the test results on dermal or oral studies. Also, 2-years
inhalation study using a typical toner containing carbon black showed no association between toner exposure and animal tumors.

Section 4: First Aid Measures

Inhalation:
Skin Contact:

Gargle with water. Remove to fresh air if effects
occur. Get medical attention if needed.

Wash with soap and water.

Eye Contact:
Ingestion:

In case of contact, immediately flush eyes
with water for 15 minutes. Get medical
attention if needed.
Dilute stomach contents with several
glasses of water. Get medical attention.

Section 5: Fire Fighting Measures

Suitable extinguishing media: CO2, dry chemical, foam or water.

Special protective equipment for fire fighters: none
UEL: n/a LEL: n/a

Burning rate: 0.223

Extinguishing media which may not be used for safety
reasons: none

your document management partner

MATERIAL SAFETY DATA SHEET

Page 2 of CP-400

Section 6: Accidental Release Measures

Spill / leak Procedures: If spilled, sweep up using an approved toner vacuum with a 0.5 micron filter or smaller, such as the Atrix
AAA Toner Vacuum or 3M Toner Vacuum. Use of a vacuum cleaner not rated for toner particles, could result in a fire or personal
injury. Remove residue with soap and cold water.
Miscellaneous: Keep product out of sewers and watercourses.
Personal protection: Avoid inhalation of dust.

Section 7: Handling and Storage

Special Handling: Cleanse skin after contact before breaks or meals, and end of workday.

Special Storage: Avoid direct sunlight. Keep out of reach of children. Store in a cool, dry place. Below 35C (95F)

Do not handle in areas where the wind blows.
Minimize the breathing of dust.

Section 8: Exposure Control and Personal Protection Information:

Respiratory Protection: none required under normal use. Hand Protection: none required under normal use.
Eye Protection: none required under normal use. Skin Protection: none required under normal use.

Section 9: Physical and Chemical Properties

CHARACTERISTICS:
Appearance: Black Melting point: N/a
Form: Powder Vapor pressure: N/a
Odor: Slight plastic odor Vapor density: N/a
Solubility in Water: Insoluble Evaporation rate: N/a
Boiling point: N/a

Section 10: Stability and Reactivity

Conditions to avoid: none Materials to avoid: none Stability: Stable
Hazardous decomposition products: Will not occur

Section 11: Toxicological Information:

Ames test: negative Acute skin irritation: n/a
Acute oral toxicity: 5000mg/kg (rat) Acute allergenic effects: n/a
Special effects: Carcinogenicity: In 1996 the IARC reclassified Carbon Black as a Group 2B carcinogen (possible human

carcinogen). This evaluation is given to carbon black for which there is inadequate human evidence, but sufficient animal
evidence. The latter is based upon the development of lung tumors in rats receiving chronic inhalation exposures to free carbon
black at levels that induce particle overload of the lung. Studies performed in animal models other than rats have not
demonstrated an association between carbon black and lung tumors. Moreover, 2-years cancer bioassay using a typical toner
preparation containing carbon black did not demonstrate an association between toner exposure and tumor development in rats.

Section 12: Environmental / Ecological Information

Acute toxicity to fish: N.A. Bioaccumulation: Not known in bioaccumulation
Persistence/Degradability: Not known Acute toxicity to daphnia: Not available
Algae inhibition test: Not available

Section 13: Disposal Consideration

Used Toner should be disposed of under conditions that meet all federal, state and local environmental regulations. Disposal
regulations vary from locality to locality; therefore consult your local Lanier office or the EPA to determine the proper method for
disposal. Do not incinerate loose or spilled Toner.

Section 14: Transportation Information

International regulations:
RID/ADR Not applicable ICAO-TI/ATA-DGR Not applicable
DOT 49 CFR Not applicable UN Classification Number Not applicable
ADNR Not applicable IMDG Code Not applicable

Specific precautionary transport measures: Avoid direct sunlight. Do not keep over 35°C (95°F).
Specific material to avoid: None in normal use.

Information on this data sheet represents our current data and best opinion as to the proper use in handling of this product under
normal conditions.

usual precautionary measures for dealing with chemicals.

On the basis of the data available to us, this product is not a dangerous substance. One should, however, observe the