Landmann USA BBQ 12202 User Manual

12202UK_#387-2005_02/05bt_rk

Assembly Instruction for

flat bed BBQ Art.-No. 12202

1

IMPORTANT:
READ ALL INSTRUCTIONS AND OPERATIONS
BEFORE OPERATING THIS UNIT.
FOLLOW THE CORRECT LIGHTING AND USAGE
PROCEDURES. HANDLE METAL PARTS WITH CARE
TO AVOID INJURIES. FOLLOW ALL STEPS IN
ORDER. NEVER ALLOW CHILDREN TO OPERATE
THIS UNIT.

Contents:

1.: Technical data

2.: Function

3.: Single part list

4.: Fixing elements

5.: Exploring drawing

6.: Mounting steps

7.: Preparation

8.: Installation

9.: Warning and safety points

10.: Safety precautions

11.: Lighting instructions

12.: Storage

13.: Cleaning instructions

14.: Barbecue Safety Hints

Warnings:

2

Ensure to use this appliance outdoors.

Do not attempt to move this appliance during

operation. Never leave fuel cylinder attached to

regulator if disconnected from burner tube.

Attention:

Some parts of this appliance become

very hot, take special care when children or elderly are present

For your safety:

Do not store or use gasoline or methylated fuels

or any other flammable vapours and liquids in the

vicinity of this or any other appliance.

Never light a barbecue with gasoline or

comparable fluids !

1.:Technical Data

Gas: LPG (Propane)
Gas Bottle: Propane Gas Bottle with 27mm Clip valve
Pressure: Propane at 37 Mbar

3+ (28-30/37)

Consumption: 800 g / h
Power: approx. 11 kW
Weight: approx. 26,8 kg
Overall dimensions: approx. W 115 cm, D 58 cm, H 113 cm
Cooking Area: approx. 24 x 49 cm (2x)

3

Burner set: adjustable
Ignition: Piezo Ignitor
Lava rocks: 1 Bag

The capacity of a 13kg Propane Gas Bottle is sufficient for

a heating period of approx. 15 hours with full power.

You have purchased a high quality LANDMANN
Gas Appliance. This appliance has been made with
regard to the European Gas Standard (EN 498)
and bears the certification no.
CE - 0085.
The gas hose assembly that is enclosed with this
appliance conforms to British Standard BS 3212.2.

2.: Function

a) Pilot Gas Control Ignition:

With all gas controls on the Barbecue in the 'OFF' position, turn the gas cylinder valve
to the on position at the regulater. Push in the Barbecue ignition gas control knob and
turn anticlockwise until spring resistance is felt. Hold in this position for 3-5 seconds
to allow gas flow, and then continue to turn anticlockwise to 'HIGH"' position. Keep
the knob pressed in until the burner is seen to be alight. When the burner is alight,
adjacent burners will cross light when their controls are turned to 'HIGH'.

b) Manual Ignition:

With all the gas controls in the 'OFF' position, turn the gas cylinder valve on the regulator
to the on position. Lift out one of the cast iron cooking grilles and holding a lighted
taper or gas match alongside the burner, push in and turn the gas control knob for that
burner to 'HIGH'. The burner will light in seconds. Replace the cast iron cooking grille.
Once the first burner is alight, adjacent burners will cross light when their gas controls
are turned to 'HIGH'.
At 'HIGH' setting the burner flame should be approximately 12-20mm long with a
minimum of yellow tipping. Turn the gas control fully anticlockwise for minimum setting.
Should you have any difficulty lighting your barbecue following the above steps, contact
your dealer for advice.

4

3.: Single part list

5

1. Lid Sheet II 1

2. Lid Sheet I 1

3. Left side panel 1

4. Right side panel 1

5. Hinge Pin 2

6. Top hinge 2

7. Handle bracket 2

8. Lid handle 1

9. Cooking Grill 1

10. Hot Plate 1

11. Cross Lighting tube 1

12. Burner 2

13. R Clip 2

14. Body ASSY 1

15. Left Bottom hinge 1

16. Right Bottom hinge 1

17. Gas Control Bar 1

18. Valve with ignitor 1

19. Valve 1

20. Control Panel 1

21. Control Knob 2

Note: All single parts in BOLD are pre - assembled.

4.: Fixing elements

22. Drip pan 1

23. Drip pan handle 1

24. Screw M5x6 1

25. Hose 1

26. Regulator 1

27. Gas Hose connection 1

28. Hose Clamp 2

29. Bolt M6x12 9

30. Washer M6 5

31. Nut M6 5

32. Spring Washer M5 6

33. Flat Washer M6 6

34. Bolt M5x10 6

35. Screw M5x10 4

36. Nut M5

37. Warming Rack 2

38. Thermometer 1

39. Lava rocks 1 Bag

40. Lava rock grid 1

M5x154xM5x81xM54xM5,2

4x 1x 3x 2x 2x

5.: Exploring drawing

6

39
40

1

36

33

35

34

4

32

2

6

5

38

7

8

3

37

10

9

16

12

11

29

14

29

15

31

30

13

26

25

38

27

24

17

19

18

21

20

22

23