La Cornue BFG Installation Guide
Broche Flamberge
Rotisserie
« Centenaire »
B Y L A C ORNUE
Installation, operation
and maintenance
manual
C HÂTEAU S ERIES
La Cornue 1908
La Cornue
2008
1908
ANSI/CGA Standard
Designation
85KJ
LA CORNUE
Installation guide Broche Flamberge Page
1
IMPORTANT SAFETY I NSTRUCTIONS
Read all instructions before using this appliance. Save these instructions for future reference.
— Do not spray aerosols in the vicinity of the range while it is in
use.
— Do not store or use combustible materials, gasoline or other
flammable vapors or liquids in the vicinity of this or any
other appliance.
— WHAT TO DO IF YOU SMELL GAS
• Do not try to light any appliance.
• Do not touch any electrical switch.
• Do not use any phone in your building.
• Immediately call your gas supplier from a neighbor's
phone. Follow the gas supplier's instructions.
• If you cannot reach your gas supplier, call the fire department.
— Installation and service must be performed by a qualified
installer, service agency or the gas supplier.
WARNING: IF THE INFORMATION ON THIS
MANUAL IS NOT FOLLOWED EXACTLY
, AFIREOR
EXPLOSION MAY RESULT CAUSING PROPERTY
DAMAGE
, PERSONAL INJURY OR DEATH.
WARNING: NEVER cover any slots, holes or passages in
the appliance bottom or cover an entire rack with materials such as aluminum foil. Doing so blocks airflow
through the appliance and may cause carbon monoxide
poisoning. Do not use aluminum foil to line surface unit
drip bowls, except as suggested in the manual. Improper
installation of these liners may result in a risk of electric
shock, or fire.
WARNING: NEVER use this appliance as a space heater
to heat or warm the room. Doing so may result in carbon
monoxide poisoning and overheating of the appliance
Page
2
Installation guide Broche Flamberge
LA CORNUE
Read all instructions before using this appliance. Save these instructions for future reference.
IMPORTANT SAFETY I NSTRUCTIONS
In Case of Fire
Do not use water on grease fires. Never pick up a flaming pan. Turn the controls off. Smother a flaming pan on a
cooktop burner by covering the pan completely with a well fitting lid or baking tray. If available use a multipurpose dry chemical or foam-type fire extinguisher.
Open doors and windows or if a hood is fitted turn it on to remove smoke and odor.
To Prevent Fire or Smoke Damage
Before using the appliance make sure all the packing materials
have been removed. Always keep the area around the appliance
free from combustible materials, gasoline, and other flammable
vapors and liquids.
If the appliance is installed near a window, proper precautions
should be taken to prevent curtains from blowing over the burners.
NEVER leave any items on the appliance. The hot air may igni-
te flammable items and may increase pressure in closed containers, which may cause them to burst. Many aerosol-type spray
cans are EXPLOSIVE when exposed to heat and may be highly
flammable. Avoid their use or storage near an appliance.
Many plastics will burn and most are damaged by heat. Keep
plastic items away from parts of the appliance that may become
warm or hot. Do not leave plastic items on the appliance as they
may burn, melt or soften if left too close to a vent or a lighted
burner.
This book contains many important safety messages.
Always read and obey all safety messages.
Installer: Leave these instructions with the appliance
u
Proper Installation - Be sure your appliance is properly installed
and grounded by a qualified technician.
The installation of your La Cornue appliance must conform with
local codes or, in the absence of local codes, in the USA with the
"National Fuel Gas Code", ANSI Z223.1NFPA 54, latest edition, and,
in Canada, with CAN/CGA - B149.1, and CAN CGA - B149.2,
“Installation Code for Gas Burning Appliances”.
The appliance must be electrically installed and grounded in
accordance with local codes or in the absence of such codes with
the latest edition of the “National Electrical Code”, ANSI/NFPA 70
in the USA, and CSA C22.2 “Canadian Electrical Code” - in Canada.
Important - Save the installation instructions for the local
electrical inspector’s use.
uThis appliance is designed for domestic cooking only. Use for any
other purpose could invalidate any warranty or liability claim.
uThe appliance and its individual shutoff valve must be disconnected from
the gas supply piping system during any pressure testing of that system at
test pressures in excess of 1/2 psig (3.5 kPa).
uThe appliance must be isolated from the gas supply piping system by closing
its individual manual shutoff valve during any pressure testing of the gas
supply piping system at test pressures equal to or less than 1/2 psig
(3.5 kPa).
uThe inlet gas supply pressure to the appliance must be within the following
limits
LA CORNUE
Installation guide Broche Flamberge Page
3
Read all instructions before using this appliance. Save these instructions for future reference.
IMPORTANT SAFETY I NSTRUCTIONS
uPurchaser of this appliance must post in a prominent location instructions
to be followed in the event the user smells gas. This information shall be
obtained by consulting your local gas supply company.
uThe use of a gas cooking appliance results in the production of heat and
moisture in the room in which it is installed. It is essential that the kitchen
where your appliance will be installed has excellent ventilation to the
outside for steam and combustion gases removal. Keep natural ventilation
holes open or install a mechanical ventilation device, (mechanical extractor
hood).
uProlonged intensive use of the appliance may call for additional ventilation,
for example opening a window, or more effective ventilation.
uDo not obstruct the flow of combustible and ventilation air
uLeak testing of the appliance shall be conducted according to the
manufacturer’s instructions.
uA manual valve must be installed in an accessible location in the gas line
external to the appliance for the purpose of turning on or shutting off gas
to the appliance.
uElectrical Grounding Instructions
To avoid risk of electrical shock, personal injury, or death, make sure your
appliance has been properly grounded and always disconnect it from main
power supply before servicing.
uPower failure - In the case of prolonged power failure no attempt should
be made to operate the appliance during power failure.
uWear Suitable Clothing - Never wear loose-fitting or hanging clothes
while using the appliance. Be careful when reaching for items stored in
cabinets over the appliance. Flammable material could be ignited if brought
in contact with a burner flame or hot surface and may cause severe burns.
Page
4
Installation guide Broche Flamberge
LA CORNUE
Read all instructions before using this appliance. Save these instructions for future reference.
IMPORTANT SAFETY I NSTRUCTIONS
uUse Only Dry Potholders or Oven Gloves - Moist or damp potholders
on hot surfaces may result in burns from steam. Never let a potholder
touch hot heating elements.
Do not use a towel or other bulky cloth in place of a glove. They might
catch fire if they touch a hot surface.
Use dry oven gloves when applicable - using damp gloves might result in
steam burns when you touch a hot surface. Never operate the appliance
with wet hands.
uDo Not Leave Children Alone - Children should not be left alone or
unattended in area where appliance is in use. They should never be allowed to sit or stand on any part of the appliance.
Do not allow children to climb or play around the appliance.
Teach them not to play with controls or any other part of the appliance.
Destroy the carton and plastic bags after unpacking the appliance. Never
allow children to play with packaging material.
Do not store items of interest to children in cabinets above an appliance or
in appliance - children climbing on the appliance to reach items could be
seriously injured.
uDo not use the appliance for storage - This instruction manual is based
on safety considerations. Flammable materials should not be stored in an
appliance or near the burner. This includes paper, plastic and cloth items,
such as cookbooks, plastic ware and towels, as well as flammable liquids.
Do not store explosives, such as aerosol cans, on or near the appliance.
Flammable materials may explode and result in fire or property damage.
uStorage should not be installed directly above an appliance.
uDo not touch burner, areas near burner or interior surfaces of
appliance - Gas burner may be hot even if they have been off for some
time. Areas near the gas burner and interior surfaces may become hot
enough to cause burns. During and after use, do not touch, or let clothing
touch or other flammable materials contact the burner, areas near the burner or interior surfaces until they have had enough time to cool.
LA CORNUE
Installation guide Broche Flamberge Page
5
Read all instructions before using this appliance. Save these instructions for future reference.
IMPORTANT SAFETY I NSTRUCTIONS
uUser Servicing - Do not repair or replace any part of the appliance unless
specifically recommended in the manual. All other servicing should be
referred to a qualified technician. Never modify or alter the construction of
the appliance by removing levelling legs, panels, wire covers, screws, or
any other part of the product.
uImportant Safety Notice and Warning - The California Safe Drinking
Water and Toxic Enforcement Act of 1986 (Proposition 65) requires the
Governor of California to publish a list of substances known to the State of
California to cause cancer or reproductive harm, and requires businesses to
warn customers of potential exposures to such substances.
This appliance contains or produces a chemical or chemicals which can
cause death or serious illness and which are known to the state of
California to cause cancer, birth defects or other reproductive harm.
Users of this appliance are hereby warned that the burning of gas can
result in low-level exposure to some of the listed substances, including
benzene, formaldehyde and soot, due primarily to the incomplete combustion of natural gas or liquid petroleum (LP) fuels. Properly adjusted burners will minimize incomplete combustion.
Exposure to these substances can also be minimized by properly venting
with an open window or using a ventilation fan or hood.
To reduce the risk from substances in the fuel or from fuel combustion
make sure this appliance is installed, operated, and maintained according
to the instructions in this booklet.
u Quality of Flames - On Natural Gas the burners’ flames should be a
blueish color with, at most, a slight yellowish fringe. On Propane gas the
flames may be “softer”. The burner flames may have a slight yellowish tip.
If the flame burns with a long white tip you should call for service.
MAKE SURE THE FLOW OF COMBUSTION AND VENTILATION AIR TO
THE APPLIANCE IS UNOBSTRUCTED.
Page
6
Installation guide Broche Flamberge
LA CORNUE
Read all instructions before using this appliance. Save these instructions for future reference.
IMPORTANT SAFETY I NSTRUCTIONS
uIMPORTANT: Never keep pet birds in the kitchen or in rooms
where the fumes from the kitchen could reach. Birds have a very
sensitive respiratory system. Fumes released due to overheated
cooking oil, fat, margarine and overheated non-stick cookware
may be harmful.
uAll parts of the appliance become hot with use and will retain heat
even after you have stopped cooking.
Take care when touching appliance, to minimize the possibility of burns,
always be certain that the controls are in the OFF position and that it is cool
before attempting to clean the range.
uClean with caution. If a wet sponge or cloth is used to wipe spills on a
hot surface, be careful to avoid steam burns. Some cleansers can produce
noxious fumes if applied to a hot surface.
In the interests of hygiene and safety the appliance should be kept clean at
all times as a build up in fats and other food stuff could result in a fire.
uAlways keep combustible wall coverings or curtains etc. a safe distance
away from your appliance.
uWhen using an electrical appliance near the rotisserie, be sure that the cord
of the appliance does not come into contact with the rotisserie.
uTake care that no water seeps into the appliance.
uThis appliance is designed for cooking foods only and must not be used for
any other purpose.
uThis appliance is heavy, take care when moving it.
uWhen the appliance is not in use ensure that the control knobs are in the
off position.
LA CORNUE
Installation guide Broche Flamberge Page
7
Read all instructions before using this appliance. Save these instructions for future reference.
IMPORTANT SAFETY I NSTRUCTIONS
Loading...