Kuppersbusch ITE 128 Series, IKE 178 Series, IKE 188 Series, IKE 238 Series, IKE 318-4-4T Service Manual
f}}~}yC~}}}
y|~|}D~}}}
~}|~}|}{
Service Manual: H8-74-06
Responsible: Uwe Laarmann KÜPPERSBUSCH HAUSGERÄTE AG
E-mail: uwe.laarmann@kueppersbusch.de
Tel.: (0209) 401-732 Kundendienst
Fax: (0209) 401-743 Postfach 100 132
Date: 25.01.2005 45801 Gelsenkirchen
Service Manual 3
Contents
1. Safety instructions ......................................................................................................... 4
2. Introduction..................................................................................................................... 5
3. New Door on Door installation system......................................................................... 6
4. Accessibility.................................................................................................................... 6
4.1 Refrigerator display ............................................................................................... 6
4.2 3/4 star compartment ............................................................................................ 6
5. Operation......................................................................................................................... 7
5.1 Combination bi-compressor .................................................................................. 7
5.2 3/4 star compartment .......................................................................................... 10
5.3 Refrigerator display ............................................................................................. 11
5.4 Freezer display.................................................................................................... 12
6. NTC sensor failure........................................................................................................ 13
6.1 NTC sensor properties ........................................................................................ 14
For internal use only
4 Service Manual
1. Safety instructions
Danger!
Repairs should only be carried out by a qualified electrician.
Repairs which are not carried out properly may put the user at risk.
In order to avoid electrical shocks it is essential that the following instructions be observed:
• In the event of a fault the casing and the frame may be live. Always disconnect the appliance from
the mains prior to commencing with repairs.
• Touching live parts inside the appliance can result in serious electrical shocks.
• Disconnect the appliance from the mains prior to carrying out repairs.
• A residual current circuit breaker is always to be used when carrying out tests on live parts.
• Always ensure that an earthed conductor is properly connected. Earthed conductor resistance may
not exceed figures stipulated in the standard. It is vital for ensuring the safety of persons and the
functioning of appliances.
• After a repair has been carried out, a test in accordance with VDE 0701 or the respective national
regulations and a functional and leak test are to be carried out.
• Do not touch any of the components in the appliance. The modules are also live!
• Observe instructions on electrostatic hazards.
Note!
It is essential to observe the following instructions:
• Appliances must be cut off from the mains prior to carrying out any repairs. A residual current circuit
breaker must be used when carrying out the required tests on current-carrying appliances.
Sharp edges: protective gloves must be worn.
Electrostatic endangered components:
observe handling instructions!
For internal use only
Service Manual 5
2. Introduction
This manual describes the new models of integrated built-in fridge-freezers, such as ITE 128...,
IKE 188..., IKE 178..., IKE 238... or IKE 318-4-4T. This new series has the following modifications:
• new width of the housing: 556 mm instead of 540 mm for the sliding door model
• new Door on Door installation system
• quieter compressor
• perfect workmanship
• the models are available in electromechanical and electronic versions (with the exception of 1780 the bi-compressor only electronic)
• control panel at the top of the appliance
The door on door series has a version with electronic and mechanical controls for each model, except
for the bi-compressor, which is available as an electronic model only. The models are:
Type
Freezer 76 electronic
Freezer 76 mechanical
Freezer 109 electronic
Freezer 109 mechanical
Refrigerator 157 electronic
Refrigerator 157 mechanical
Refrigerator 187 electronic
Refrigerator 187 mechanical
Refrigerator 227 electronic
Refrigerator 227 mechanical
3/4 star compartment 143 electronic
3/4 star compartment 143 mechanical
3/4 star compartment 173 electronic
3/4 star compartment 173 mechanical
3/4 star compartment 215 electronic
3/4 star compartment 215 mechanical
Capacity
(litres)
Controls
Bi-compressor 209 + 76 electronic
For internal use only
Loading...