Page 1
Contents
K 5500 model overview . . . . . . . . . . . . . . 1-2
Filter performance . . . . . . . . . . . . . . . . . . . .2
Safety Instructions . . . . . . . . . . . . . . . . . . .3
Assembling and operating the cleaner
Preparation . . . . . . . . . . . . . . . . . . . . . . .4
Attaching the accessory holder . . . . . . .4
Setting the suction tube . . . . . . . . . . . . . .4
Filling the water filter container . . . . . .4-5
Switching on . . . . . . . . . . . . . . . . . . . . . .5
Working with the carpet turbo nozzle,
hard floor nozzle, crevice nozzle,
upholstery nozzle and furniture brush . . .6
Suction control . . . . . . . . . . . . . . . . . . . . .6
Wet vacuuming . . . . . . . . . . . . . . . . . . . .6
Taking a break . . . . . . . . . . . . . . . . . . . . .7
Storage of accessories . . . . . . . . . . . . . .7
Shutdown, transporting and storing . . . .7
Care / Maintenance
Cleaning the appliance and accessories 8
Changing the intermediate filter . . . . . . .8
Changing the HEPA combination filter . .8
Cleaning the suction manifold in the
water filter container . . . . . . . . . . . . . . . .9
Service
Warranty . . . . . . . . . . . . . . . . . . . . . . . . .9
Customer service . . . . . . . . . . . . . . . . . .9
Technical specifications . . . . . . . . . . . . .9
Circuit diagram . . . . . . . . . . . . . . . . . . . .9
Troubleshooting . . . . . . . . . . . . . . . . . . . .10
Assembly diagram . . . . . . . . . . . . . . . .11
Model K 5500 Part No. 1.195-107.0
Vacuum Cleaner Operator Manual
USA: 1-800-537-4129
www.karcher-usa.com
CAN: 1-800-465-4980
www.karcher.ca
MEX:
01-800-024-13-13
www.karcher.com.mx
Manual Part No. 5.960-032.0
K5500 Vacuum Manual7/24 7/29/02 11:33 AM Page 1
Page 2
Item Description – Continued
13. Intermediate filter
Filters suspended matter
and protects the suction turbine.
14. Container cover
15. Air guard
16. Water filter container
Filters the vacuumed up
dirt in the water bath.
17. HEPA-Plus filter
consists of:
HEPA filter
Filters 99.99 % of all particles
over 0.3 micron in size.
Exhaust air filter
Filters the cooling air of the
suction turbine (not pictured).
18. Anti-foaming liquid
(Kärcher foam stop, not pictured)
19. Allergy guide (not pictured) In this brochure we deal with the increasingly important topic of
allergies and their causes. You will find it worthwhile to spend a little time reading this brochure.
The K 5500 vacuum cleaner features a completely
new Kärcher water filter system which picks up
even the smallest particles. The additional HEPAPlus high-performance filter catches all allergens.
99.99 % of all particles over 0.3 microns in size
are removed from the exhaust air which is then
cleaner than the ambient air.
2
16
15
14
13
12
Rear View
The supplied items illustrated on the
these pages are intended to give you
an overview of the appliance and
accessories. Information on operating
the appliance can be found on the
following pages.
The effect of the Kärcher water filter vacuum cleaner
MODEL 5500 OVERVIEW
- continued
FILTER PERFORMANCE
Item Description
1. ON / OFF Switch
Press to switch on; press
again to switch off.
2. Cord rewind button
Press to wind up the cable.
3. Carpet turbo nozzle
Can be adjusted to clean
different types of carpet.
Ideal for deep cleaning.
4. Stainless steel telescopic
suction tube
Infinitely variable length adjustment for ergonomic handling.
5. Fine nozzle
For gentle cleaning of
furniture and dusting books.
6. Upholstery nozzle
For cleaning upholstery, etc.
7. Handle with soft grips
Suction performance variable
using false-air slide.
8. Suction hose
Flexible and sturdy hose for
convenient vacuuming. Easily
detachable for service and
storage.
9. Accessory holder
For furniture brush and
upholstery nozzle.
10 Crevice nozzle
For edges, crevices and
around radiators.
11. Carry handle
For carrying the appliance
on stairs, etc.
12. Hard floor nozzle
Includes nylon and natural
bristle brushes for different
types of hard surfaces.
1
MODEL 5500 OVERVIEW
8
5
10
11
3
4
6
7
1
Note: When unpacking the appliance, make sure that all listed parts are supplied. Please
inform your dealer if there has been any damage during transportation.
2
9
Front View
12
K5500 Vacuum Manual7/24 7/29/02 11:33 AM Page 2
Water filter K 5500 Intermed ia te fil te r HEPA
Respirable particles
Fine dust
Domestic dust mites (excretions)
Bacteria
Dust
Pollen
Spores
Coarse dirt (animal hair, fluff, crumbs)
Filtration efficiency (%) of all particles over 0.3 m in size
Page 3
4
ASSEMBLY INSTRUCTIONS
OPERATING INSTRUCTIONS
1. Preparation
• Connect the suction hose
• Connect the telescopic suction tube
and carpet turbo nozzle.
1. Setting telescopic suction tube
• Unlock the tube by moving the lock ring
and set the tube to the desired length by
drawing the inner pipe out or by sliding it
in further.
You can vacuum in a comfortable, upright
position by setting the telescopic suction
pipe to suit your height.
click
2. Filling the water filter container
• Press the unlock button and pull out the
water filter container.
The appliance is delivered with the
intermediate filter and curved air guard
already assembled. When filling the container,
ensure that these components (see: Supplied
items) have been assembled correctly. They
may be the cause of poor suction
performance or premature failure of the
intermediate filter.
2. Attaching the accessory holder
• Connect the handle to the telescopic
suction tube.
The accessory holder is for storing the
furniture brush and upholstery nozzle.
3
Safety Warnings
When using an electrical appliance, basic
precautions should always be followed,
including the following:
READ ALL INSTRUCTIONS
BEFORE USING THIS APPLIANCE
WARNING-
To reduce the risk of fire,
electric shock, or injury:
1. Do not leave appliance when plugged
in. Unplug from outlet when not in use
and before servicing.
2.
WARNING-
To Reduce The Risk Of
Electric Shock. Do not use outdoors or
on wet surfaces."
3. Do not allow to be used as a toy.
Close attention is necessary when
used by or near children.
4. Use only as described in this manual.
Use only manufacturer's
recommended attachments.
5. Do not use with damaged cord or
plug. If appliance is not working as it
should, has been dropped, damaged,
left outdoors, or dropped into water,
return it to a service center.
6. Do not pull or carry by cord, use cord
as a handle, close a door on cord, or
pull cord around sharp edges or
corners. Do not run appliance over
cord. Keep cord away from heated
surfaces.
7. Do not unplug by pulling on cord. To
unplug, grasp the plug, not the cord.
8. Do not handle plug or appliance with
wet hands.
9. Do not put any object into openings.
Do not use with any opening blocked;
keep free of dust, lint, hair, and
anything that may reduce air flow.
10. Keep hair, loose clothing, fingers, and
all parts of body away from openings
and moving parts.
11. Turn off all controls before unplugging.
12. Use extra care when cleaning on
stairs.
13. Do not use to pick up flammable or
combustible liquids, such as gasoline,
or use in areas where they may be
present.
14. Always turn off this appliance before
connecting or disconnecting motorized
nozzle.
15. Hold plug when rewinding onto cord
reel. Do not allow plug to whip when
rewinding.
16. This appliance is provided with double
insulation. Use only identical
replacement parts. See instructions for
Servicing of Double-Insulated
Appliances.
17. Do not pick up anything that is burning
or smoking, such as cigarettes,
matches, or hot ashes.
18. Do not use without all filters in place.
SAVE THESE INSTRUCTIONS!
SERVICING OF DOUBLEINSULATED APPLIANCES
In a double-insulated appliance, two
systems of insulation are provided
instead of grounding. No grounding
means is provided on a doubleinsulated appliance, nor should a
means for grounding be added to the
appliance. Servicing a double-insulated
appliance requires extreme care and
knowledge of the system, and should
be done only by qualified service
personnel. Replacement parts for a
double-insulated appliance must be
identical to the parts they replace.
IMPORTANT SAFETY INSTRUCTIONS – Read First!
Customer Service
USA: 1-800-537-4129
www.karcher-usa.com
CAN: 1-800-465-4980
www.karcher.ca
MEX:
01-800-024-13-13
www.karcher.com.mx
K5500 Vacuum Manual7/24 7/29/02 11:33 AM Page 4
Page 4
5. Use and assembly of
the hard floor nozzle
The hard floor nozzle includes nylon and
natural bristle brush inserts for cleaning
smooth hard surfaces. Use the nylon brush
set for ceramic tile or similar scratch
resistant surfaces. Use the soft natural
brushes for finished wood floors or other
scratch sensitive surfaces. To change the
brushes use a flat bladed screw driver or putty knife to gently pry open the plastic nozzle clips
to release the brush inserts. Then slide the replacement brushes into the white plastic holder
and snap holder back into place. Brushes must be replaced as a set for proper operation.
6
OPERATING INSTRUCTIONS –
continued
4. Using the carpet turbo nozzle
Slide the turbo control switch on the floor nozzle to a regulate the brushing action.
Full closed (+) increases brushing action for deep pile carpets and full open (-) for
8.
Wet vacuuming
Use either the crevice nozzle, upholstery nozzle or the hard surface nozzle with the nylon
bristles for vacuuming wet surfaces (do not use the carpet turbo nozzle for wet surfaces).
• When the water filter container is empty, up to 2.5 liters or 1/2 gallon of liquid can be
vacuumed.
Damp dirt or small quantities of liquid up to approximately 0.5 liters or 2 cups can be
vacuumed at any time when the water filter container is full. Use the crevice nozzle or the
handle without attached accessory.
6.
Suction control (false-air slide)
Due to the high constant suction capacity
of the appliance, the suction nozzles may
be too powerful for cleaning carpets,
upholstery, curtains, etc. In this case use
the false air slide to reduce the suction
capacity. After use, close again.
7. Using the crevice nozzle
Crevice nozzle: For edges, crevices,
radiators, etc.
Upholstery nozzle: For cleaning upholstery
and curtains
Furniture brush: (can be rotated 360°)
For gentle cleaning of furniture, dusting
books, dashboards, etc.
OPERATING INSTRUCTIONS –
continued
5
• Remove the cover from the water filter
container and fill the water filter container
up to the MAX mark with tap water
(approximately 2 liters or 1/2 gallon).
• Re-attach the cover. Push in the water
filter container all the way and pull up
until it “clicks” into position.
If the water level in the container drops
below the “MIN” mark during operation,
please refill with water.
3. Switching on
• Unwind the power chord completely and
insert the plug into the power outlet.
• To switch on, press the On/Off switch.
Do not vacuum large quantities of powdered
substances such as cocoa, flour, washing
powder, custard powder, etc.
click
• Add a capful of anti-foaming liquid
(Kärcher Foam Stop) to the water filter
container.
The vacuum cleaner operates on the basis of swirling suction air into the water
filter. The vacuumed material and detergent residues from the floor covering are
being filtered in the water bath. Under certain circumstances this may result in the
formation of foam. To prevent this, add a capful of anti-foaming liquid to the water
filter bath. The anti-foaming liquid is environmentally friendly and completely
biodegradable. Slight foam formation during operation is normal and does not
impair function.
K5500 Vacuum Manual7/24 7/29/02 11:33 AM Page 6
Page 5
8
CARE AND MAINTENANCE
1. Cleaning the appliance
and accessories
• If required, wipe down the exterior of
the appliance with a damp cloth. Do
not use any aggressive agents such as
scouring powder.
• The suction hose and handle can be
dismantled for cleaning.
• Check the accessories for blockages and,
if required, clean. Do NOT use water to
clean the floor nozzle.
2. Changing the intermediate filter
• Under normal conditions of use please
change the intermediate filter after at least
8 weeks or earlier if required (see page 2,
model 5500 overview item number 13).
The intermediate filter must be disposed of in
the residual waste.
3. Changing the HEPA filter
The HEPA-Plus filter consists of the HEPA
filter and an exhaust air filter. To ensure
that the appliance cleans and functions
optimally, this filter should be changed
after 15 months. If damaged or very dirty,
change earlier.
• Remove the HEPA-Plus filter.
• Insert a new HEPA-Plus filter, ensuring that
it “clicks” into position.
• Attach the cover, ensuring that it “clicks”
into position.
• Remove the cover.
WARNING
• Before any care and maintenance
work on the machine, unplug
the power cord.
IMPORTANT
• Do not wash the
HEPA-Plus filter!
Press in on the left and right hose release
clips at the same time to dismantle the
hose for cleaning.
9. Storage of accessories
• After use, attach upholstery nozzle and
furniture brush to the accessory holder.
• Store the crevice nozzle and the Kärcher
foam stop on the appliance.
OPERATING INSTRUCTIONS –
continued
7
10. Taking a break
• To switch off, press the On/Off button.
• If taking a break from work, attach the
floor nozzle to the appliance.
• Clean and dry the cover and water filter
container.
• If the appliance is used regularly, wash
the intermediate filter every 2 weeks under
running water.
12. Transporting / Storing
• Transport the appliance by the
carrying handle.
• To ventilate the water filter container while
the appliance is in storage, do not insert
container fully into the appliance.
• Take the water filter container out of the
appliance (see: Filling the water filter
container).
• Remove the cover and air guard.
• Empty the water filter container via one
of the corners.
11. Shut down for storage
• To switch off, press the On/Off button.
• Pull the plug out of the power outlet.
• Press the cord rewind button. The power
cord is automatically wound up.
Note: After each use, the water filter
container, filter cover and baffle plate must
be cleaned and dried.
CAUTION
• All parts of the water filter system,
especially the intermediate filter,
must be dried thoroughly before
being stored!
K5500 Vacuum Manual7/24 7/29/02 11:33 AM Page 8
Page 6
TROUBLE SHOOTING
Symptom Cause Solution
Machine does
not work.
Suction
performance
decreases during
operation.
Intermediate filter
in container cover
is wet.
Excessive foam
formation in the
container.
Current power supply has
been interrupted.
Pull out power cord, check the
connection plug and power cord for
damage.
Intermediate filter in
container cover wet.
Wash and dry intermediate filter
or insert a new filter
(see Care / Maintenance page 7 & 8).
Air guard is missing or not
inserted correctly.
Insert air guard correctly (see model
overview page 1 & 2).
Excessive foam formation in
the water filter container.
Change water and add 1–2 capfuls of
Kärcher
foam stop. Wash and dry
intermediate filter or insert a new filter.
Suction
performance
inadequate.
Intermediate filter is missing
or not inserted correctly.
Check.
HEPA-Plus filter is dirty. Change HEPA-Plus filter
(see Care / Maintenance page 7 & 8).
Intermediate filter is dirty. Wash filter; if required, insert new filter
(see Care and Maintenance page 7 & 8).
Deposits in suction manifold. Remove deposits (see Care and
Maintenance page 7 & 8).
Water container not
inserted correctly.
Check (see Operation page 3 & 4).
False air slide on
handle open.
Close false air slide.
Accessory blocked. Remove blockage.
No or inadequate Foam
Stop.
Change water and add 1 capful of
Foam Stop to the water filter container.
10
Check MIN / MAX mark on the
container.
Too little or too much water
in the water container.
Often symptoms have causes which you can fix yourself with the aid of the following table. In
case of doubt, or if you encounter a symptom or cause not listed, please consult an authorized
Customer Service center.
Repair work on this machine may only be carried out by an authorized
Kärcher
Service Center.
WARNING!
To reduce the risk
of fire or electric
shock, do not remove this
cover, No user serviceable
parts inside. Repair should
be done by authorized
service personnel only.
Customer Service
USA: 1-800-537-4129
www.karcher-usa.com
CAN: 1-800-465-4980
www.karcher.ca
MEX:
01-800-024-13-13
www.karcher.com.mx
9
CARE AND MAINTENANCE –
continued
SERVICE
4. Cleaning the suction manifold
in the water filter container
• Deposits in the suction manifold can be
removed by rinsing from above with a jet
of water.
Warranty
Please refer to the warranty card included
with the product. Should you have any
questions regarding the warranty please feel
free to call our customer service department.
Circuit diagram
S1 Vacuum motor switch
C1 Interference suppressor
M1 Turbine
X1 Plug with cable rewinder
Technical Specifications
Rated voltage 120 V
Rated frequency 60 Hz
Power P max 1400 W
Power P nom 1200 W
Vacuum 90.55 inches water lift
Air flow rate 116.54 cubic feet per minute
Capacity of water filter container 1/2 gallon
Sound level 69 dB( A)
Weight without accessories 18 3/4 pounds
Connection cable 18 feet
Dimensions 19 x 12 x 24 inches
Nominal width, accessory Ø 1.5 inches
HEPA - Plus filter H 12 class in compliance
with EN 1822
We reserve the right to introduce technical
changes without prior notice.
Customer Service
USA: 1-800-537-4129
www.karcher-usa.com
CAN: 1-800-465-4980
www.karcher.ca
MEX:
01-800-024-13-13
www.karcher.com.mx
K5500 Vacuum Manual7/24 7/29/02 11:33 AM Page 10
Page 7
5.363-497.0
C
5.515-140.0
4.515-067.0
B
A
6.648-511.0USA
29.08.2000
55005500
1.195-107.0 * USA
6.414-630.0
5.031-723.0
B
6.906-250.0
6.906-247.0
D
6.902-116.0
D
6.901-045.0
A
4.070-403.0
6.414-631.0
C
5.006-190.0
4.063-684.0
6.906-000.0
6.906-000.0
6.906-000.0
6.902-111.0
6.906-249.0
6.290-852.0
(125 ml)
4.070-403.0
11
See letters for assembly (e.i. A to A, etc.)
K5500 Vacuum Manual7/24 7/29/02 11:33 AM Page 12
Loading...