Kussmaul 091-9C-HO User Manual

BOOK# 091-9C-HO-3

4-22-2002

INSTRUCTION MANUAL

PUMP-PLUS HO

HIGH OUTPUT

AIR COMPRESSOR / BATTERY CHARGER

MODEL #091-9C-HO

NOTE :

This charger is designed for

vehicles with dual batteries

and negative ground.

INPUT :120 volt, 50/60 Hz

OUTPUT: 13.25 VOLTS, 11 AMPERES

3 YEAR WARRANTY

KUSSMAUL ELECTRONICS CO., INC.

170 CHERRY AVE., WEST SAYVILLE, N.Y. 11796

TEL: in NY 631-567-0314 TOLL FREE: 800-346-0857 FAX: [phone]

INTRODUCTION

The Pump Plus HO Automatic Battery Charger is a compact, completely
automatic, dual channel battery charger designed for vehicles with a two battery
system. The charger is ruggedized to withstand the shock and vibration encoun­tered by vehicle mounted equipment.

Battery Charger Features:

• Independent charge controls for each battery

• Automatic current limiting

• Optional dual battery charge/condition indicator

• Power “ON” LED indicator

DESCRIPTION

Independent Charge Controls

The Pump Plus HO contains two independent charge controls, one for each
battery. This allows each battery to be independently charged while maintain­ing battery isolation. Each battery is individually sensed, eliminating the need
for sense wires. Each of the charge controls is completely automatic and stops
charging the battery when it is fully charged. There is no trickle charge and
therefore no danger of overcharging and water boil-off.

Automatic Current Limiting

When batteries are severely discharged, some battery chargers can be over­loaded due to the high charging current required. The Pump Plus HO contains an
automatic current limit. This circuit limits the output current to the rated 11 am­peres when charging a deeply discharged battery or if the starter cranks the en­gine while starting. The current limiter thus eliminates the need for an ignition
interlock circuit.

SPECIFICATION

Input: 120 volts A.C., 50/60 Hz., 3 amperes
Input Fuse: 5 amperes, fast acting
Pump Fuse: 15 amperes, slow blow
Output Volts: 13.25 volts, nominal
Output Current: 0 to 11 amperes, D.C., output determined by the state of charge of the

batteries

Remote Charge Indicator: Red Led indicates charging current

Green Led indicates batteries are fully charged

Weight: 12 lb.

INSTALLATION RECORD & WARRANTY

Date Installed

Installed By

Vehicle Identification

Vehicle Owner

WARRANTY

All products of Kussmaul Electronics Company Inc. are warranted to
be free of defects of material or workmanship. Liability is limited to repair­ing or replacing at our factory, without charge, any material or defects
which become apparent in normal use within 3 years from the date the
equipment was shipped.

Kussmaul Electronics Company, Inc. shall have no liability for dam­ages of any kind to associated equipment arising from the installation and
/or use of the Kussmaul Electronics Company, Inc. products. The pur­chaser, by the acceptance of the equipment, assumes all liability for any
damages which may result from its installation, use or misuse, by the
purchaser, his or its employees others.