Krushr K024 User Guide
US/Can
Save these instructions
User Guide
Conservez ces instructions
Guide de l’utilisateur
F86/024 /, F86/021, F86/018, F86/015, F86/012
Krushr plc
www.krushr.com
Custom made Krushr bags available from your local dealer or www.krushr.com
Des sacs sur-mesure Krushr sont disponibles chez votre revendeur local ou sur www.krushr.com
A34/053-R1 March 2015
Models: / Modèles :
US/Can
Index
Please read all safety information before you operate this appliance
Safety Symbols .......................................................................................................... 3
Safety Information .................................................................................................... 4
Grounding Instructions and Electrical Safety ............................................................ 7
Parts Identification .................................................................................................... 9
Before you Start - Initial Set Up ............................................................................... 10
How to use the Main Collection Bin ........................................................................ 12
How to use the Can Crush Drawer .......................................................................... 15
How to Empty the Can Collection Drawer .............................................................. 16
Additional Storage Drawers .................................................................................... 16
How to fit a Krushr Bag ........................................................................................... 17
Care and Cleaning ................................................................................................... 19
Customer Care ......................................................................................................... 20
2
US/Can
Meaning/Description
WARNING/CAUTION
An appropriate safety instruction should be followed or caution to
a potential hazard exists
PROTECTIVE EARTH/GROUND
To identify any terminal which is intended for connection to an
external conductor for protection against electric shock in case of
a fault or the terminal of a protective earth (ground) electrode
DANGEROUS VOLTAGE
To indicate hazards arising from dangerous voltages
HEAVY
This product is over 40 lbs (18 kg) and reference should be made
to the safety instructions for provision for lifting and moving
Electrical rating 120V, 60Hz, 270W
Safety Symbols
PLEASE READ BEFORE YOU COMMENCE INSTALLATION
Save these instructions
The following safety symbols are used with your Krushr appliance and supporting
documentation
3
US/Can
Safety Information
PLEASE READ BEFORE YOU OPERATE
All safety messages will tell you what the potential hazard is, tell you how to
reduce the chance of injury, and tell you what can happen if the instructions are
not followed. Read all instructions before using your Krüshr Recycling
Compactor. Your safety and the safety of others are very important.
IMPORTANT: Please keep a copy of this User Guide safe and at hand.
This is the safety alert symbol. This symbol alerts you to potential
hazards. All safety messages will follow the safety alert symbol and either the
word “CAUTION” or “WARNING”.
WARNING
Do not use the appliance in any way not covered in this User Guide or for any
purpose other than those explained in the following pages.
WARNING
All repairs must be performed by a qualified service technician using only
original equipment factory replacement parts.
WARNING
Do not operate with a damaged cord set, plug or motor actuator or after
damage in any manner. If the appliance is damaged, then please seek repair by
an authorised engineer.
WARNING
When using an electrical appliance, basic precautions should always be
followed, including the following:
4
The Krüshr is intended for household use only. Use only as described in
this User Guide
This appliance is not intended for use by persons (including children)
with reduced physical, sensory and mental capability or lack of
experience and knowledge unless they have been given supervision or
instruction concerning use of the appliance by a person responsible for
their safety. Young children should be supervised to ensure that they do
not play with the appliance
Do not treat the appliance as a toy or novelty
Do not touch moving parts
Do not use any attachments or components other than those
recommended by the manufacturer
Do not disassemble the appliance unless you are an authorised Krüshr
service engineer. Incorrect reassembly can cause electric shock when
subsequently used
Handle a loaded rubbish container with care. Sharp objects can pierce
any bin liner and cause injury
Do not overload any bin or drawer with heavy material
Do not place glass in the compaction zones
Do not crush or store toxic or volatile flammable materials or
compressed substances such as aerosols and lighters
Do not crush or store lighted cigarettes, cigars or other hot or burning
items or deposit them anywhere within the appliance
Ensure that cans/bottles or any other receptacles to be placed into the
appliance are free of fluids and have had their caps/lids or ring pulls
removed
Do not crush batteries or any other product containing batteries
Do not overfill any bin or drawer
Do not crush sealed containers
Do not lean on or sit on or otherwise exert pressure on any part of the
appliance particularly (but not limited to) any drawer or bin when open
Do not attempt to manually override any internal switches
US/Can
5
US/Can
WARNING
Do not under any circumstances operate the appliance without a main door
fitted. The main door protects you from the mechanism during operation.
CAUTION
Do not use steam cleaning product to clean your appliance. The manufacturer
will not be liable for any damages or loss arising as a consequence.
CAUTION
Do not use harsh chemicals to clean your appliance. Some chloride-containing
cleaning products can damage your appliance and may present health hazards.
WARNING
Your Krüshr appliance is not for continuous duty. Ensure that each actuator
fitted within the appliance does not exceed 2 minutes of continuous use
(approximately six cycles of either the Can Crush Drawer or Main Collection
Bin). Once used continuously, wait 18 minutes before re-use.
6
US/Can
Grounding Instructions and Electrical Safety
Grounding Instructions
This appliance must be grounded to a metal permanent wiring system, or, an
equipment grounding conductor must be run with the circuit conductors and
connected to the equipment grounding terminal or lead on the appliance. See
the installation instructions for information on electrical requirements or seek
the advice of a qualified electrician.
Electric shock could result if the electrical supply for the appliance covered in
this User Guide is incorrectly installed or if the appliance has been improperly
grounded. Do not use the appliance if you are not certain the electrical supply
has been correctly installed or the appliance has been properly grounded.
The appliance is equipped with a three-conductor cord and three-prong
ground type plug to fit the proper grounding type receptacle. The green – or
green and yellow – colored conductor in the cord is the grounding wire. Never
connect the green – or green and yellow – wire to a live terminal.
IMPORTANT: If the supply cord is damaged, the cord must be replaced by the
manufacturer, its service agent or similarly qualified person in order to avoid a
hazard.
WARNING – READ THESE INSTRUCTIONS THOROUGHLY BEFORE CONNECTING
THIS PRODUCT TO THE MAINS SUPPLY
Electrical Safety
Before switching on make sure that the voltage of your electricity supply is the
same as that indicated on the rating place. This appliance is for use on a nominal
120 volt circuit. It has a plug as shown in sketch A in Figure 1. The adapter shown
7
US/Can
Figure 1. Grounding
GROUNDED
OUTLET
GROUNDED
OUTLET BOX
GROUNDING
PIN
ADAPTER
METAL SCREW
TAB FOR GROUNDING
SCREW
Sketch A
Sketch B
Sketch C
in sketches B and C of Figure 1 is available for connecting a plug as shown in
sketch A to a two prong receptacle as shown in sketch B. The green colored rigid
tab, lug, or the like extending from the adapter must be connected to a
permanent ground such as a properly grounded outlet box.
This appliance is fitted with a non-rewireable plug. Should the cord set become
damaged it should be replaced by a qualified electrician following the wiring
instructions shown below.
Unplug the appliance from outlet before servicing.
Do not modify the plug attached to the appliance.
Use only with a grounded receptacle.
When not in use or uninstalled the appliance should be kept in a clean, cool and
dry environment and with the main door firmly closed. The power cord must be
kept away from any heat source and sharp instruments.
8
Model:
Control Panel
Behind this panel sits the vertical
compaction mechanism. The Blue
Button is the power switch which
operates the recycling compactor.
Can Crush Drawer
Can Collection Drawer
For the storage of metal cans/tins
and other metal objects
Additional Storage Drawers
Two additional compartments for
the storage of other waste types
including items that cannot be
crushed – such as glass.
Main Collection Bin
For the storage of plastics paper card
and food packaging
F86/012 (F86/015)
Parts Identification
F86/024
F86/018 (F86/021)
NOTE: all drawers feature handles for ease of removal out of the appliance
for portability.
US/Can
9
US/Can
Before you Start - Initial Set Up
Install your appliance and ensure either a stainless steel door or furniture door is
fitted in accordance with the instructions contained in the Installation Manual.
Ensure the door is closed before turning the power on. Once the power is on you
will hear a bleeping noise indicating that the appliance is setting itself for use.
Ensure all packaging and literature has been removed from the appliance and that
the bottom plate inside the Main Collection Bin is inserted smooth side facing
inside the bin.
Please Note: As a safety precaution all drawers inside the appliance and the main
door must be fully closed for the appliance to operate. A rapid bleeping alarm will
sound if a drawer or door is open. Close the open drawer or door to stop the
alarm.
POWER CUT
In the event of a power cut the appliance will automatically reset itself by
returning the crushing mechanisms to their neutral position provided that all
drawers and main door are fully closed.
DO NOT OPERATE
Do not operate the appliance without a main door fitted.
DUTY CYCLE
The design of this appliance envisages that its compaction mechanisms will not
need to be subject to continuous operation and the motors used have been
specified accordingly. Each compaction mechanism should not be subject to more
than two minutes continuous use (approximately 6 cycles of either the Can Crush
Drawer or compaction of the Main Collection Bin). In the event of continuous
operation for two minutes, the relevant mechanisms should not be used for 18
minutes before further operation. Failure to comply with this requirement will
cause the relevant motor to exceed its “duty cycle” and will void your warranty.
10
US/Can
WHEN NOT IN USE
When the appliance is not in use, the main door must be kept firmly closed.
CHILD SAFETY LOCK
Never let children play with the appliance. To prevent unsupervised use of this
appliance by children a child lock has been fitted on the inner base the appliance
to the side of the Main Collection Bin. Remove the bin to access the key lock. Turn
the lock anticlockwise to disengage the power as required and clockwise to
reengage. Remove the key for safe keeping.
IMPORTANT
DO NOT push rubbish down into the Main Collection Bin or drawers with your
hands as this may damage the appliance. The appliance will compact your
recycling for you when in operation.
DO NOT compact items that may develop offensive odours such as food and
beverage waste, disposable hygiene items or any items which have a moisture
content. This compactor is for dry recyclable waste only NOT for food or beverage
waste.
11
US/Can
1. Open the appliance door and
make sure your bin is ready for use.
The removable bin base should be
inserted flat side facing upwards
inside the bin so that it rests on the
flanges at the bottom.
We recommend you use a custom fit
Krüshr bag to line the bin so as to ease
emptying the compacted waste and of
course help to keep the bin clean.
Before fitting a bag we suggest you
look to see how the bin sits on the
four rollers on top of its frame.
Plastics
Plastic Bottles
Mixed Paper &
Card
Cartons
How to use the Main Collection Bin
Suitable for use with the following recycling waste: bulky plastic, card and paper
packaging items
See separate section for instructions on how to fit a Krüshr bag.
2. Once the bin is ready for use, place your recycling materials into the bin.
ONLY when the bin is at least two thirds full should you press the power switch
(blue button) and shut the door. You will hear a slow bleeping noise which
indicates that compaction is in operation. During this operation the compaction
mechanism moves down inside the main bin exerting significant force. Do not
12
Loading...