Kozy-World EF6023R, EF7033R, EF6123R, EF7133R Installation Instructions And Owner's Manual
1
Installation Instructions and Owner’s Manual
ANSI/UL1278. MOVABLE AND WALL-OR CEILING HUNG ELECTRIC ROOM HEATERS
INSTALLER: DO NOT DISCARD THIS MANUAL-LEAVE FOR HOME OWNER
Freestanding
Electric Fireplace
WARNING! IF THE INFORMATION IN THIS MANUAL IS NOT FOLLOWED EXACTLY, A FIRE
MAY RESULT CAUSING PROPERTY, PERSONAL INJURY OR LOSS OF LIFE.
FOR YOUR SAFETY
DO NOT STORE
OR USE GASOLINE OR OTHER
FLAMMABLE VAPORS OR LIQUIDS
IN THE VICINITY OF THIS OR ANY
OTHER APPLIANCE
KW-IE23A610W-0610
Kozy-World
®
World Marketing of America, Inc.
P.O. Box 192, Rt. 22 West
Mill Creek, PA 17060
KOZY WORLD PHONE NUMBER:
(814) 643-1775
EF6023R EF7033R
EF6123R EF7133R
EF6023R & EF6123R SHOWN
2
Important Instructions ….…………………………………………………………....2
Locating Your Electric Fireplace…………………………………….………….......3
Clearance To Combustibles………………………………………….…………......3
Electrical Connections…..……………………………………………….……….....3
Electrical Specifications…………………………………………...……………......3
Installing decorating logs..……………………………………………………........4
Service Instructions…………………………………………………………….…......5
Replacing Light Bulbs…………………………………….……………………........5
Maintenance of Motors………………………………………...........…………….…5
Glass Information……………………………………………...........………………..5
Electrical Wiring Diagram……………………………………........………….......…6
Operating Instructions………………………………………………………....…........7
Specification........………………………………………………………………...........8
Replacement Parts..……………………………………………………........9
Replacement Parts List........................……………………………………………..10
1
TABLE OF CONTENTS
PLEASE READ THE INSTALLATION & OPERATION INSTRUCTIONS
BEFORE USING THIS APPLIANCE
IMPORTANT: Read all instructions and warnings carefully before starting installation. Failure to follow
these instructions may result in a possible electric shock, fire hazard and will void the warranty.
3
IMPORTANT INSTRUCTIONS
When using electrical appliances, basic precautions
should always be followed to reduce the risk of fire,
electric shock, and injury to persons, including the
following:
1.Read all instructions before using this heater.
2.This appliance is hot when in use. To avoid
burns, do not come in contact with heater. Keep
combustible materials, such as furniture,
pillows, bedding, papers, clothes, and curtains
at least 3 feet (1m.) from the front of the heater.
3.Extreme caution is necessary when any heater
is used by or near children or invalids and when-
ever the heater is left operating and unattended.
4.Always unplug heater when not in use.
5.Do not operate any heater with a damaged cord
or plug or after the heater malfunctions, has
been dropped or damaged in any manner.
6.Any repairs to this appliance should be carried
out by a qualified service person.
7.Under no circumstances should this electric fire-
place be modified. Parts having to be removed
for servicing must be replaced prior to operat-
ing this electric fireplace again.
8.Do not use outdoors.
9.This heater is not intended for use in bathrooms,
laundry areas or similar indoor locations. Never
use this appliance near a bathtub or other wa-
ter container.
10.Do not run cord under carpeting. Do not cover
cord with throw rugs, runners or similar
coverings. Arrange cord away from traffic areas
and where it will not be tripped over.
11.To disconnect heater, turn controls to OFF, then
remove plug from outlet.
12. Connect to properly grounded outlets only.
13.When this appliance is installed, it must be electri-
cally grounded in accordance with local codes with
the current CSA C22.1 Canadian local codes for
USA installations. Follow local codes and National
Electrical Code, ANSI/NFPA NO.70 and Canadian
Cord: C 22.2 NO.0.
14. Do not insert or allow foreign objects to enter any
ventilation or exhaust opening as this may cause
electric shock, fire or damage to the heater.
15.To prevent a possible fire, do not block air intakes
or exhaust in any manner. Do not use on soft
surfaces, such as a bed, where openings may
become blocked.
16.This heater gets hot and it contains internal parts
that sparks and arcs. Do not use it in areas where
gasoline, paint, or flammable liquids are used or
stored.
17.Use this heater only as described in this manual.
Other uses not recommended by the manufac-
turer may cause fire, electric shock, or injury.
18.Avoid the use of an extension cord because it may
overheat and cause a risk of fire. However if you
must use an extension cord, the cord shall be No.
14AWG minimum size and rated not less than 1900
watt. The extension cord must be a three wire cord
with grounding type plug and cord connector.
19. This electric fireplace heater should not be used
as a drying rack for clothing. Also, do not hang
Christmas stockings or decorations on or near it.
20.SAVE THESE INSTRUCTIONS.
2
4
CLEARANCE TO COMBUSTIBLES
ELECTRICAL CONNECTION
A 15 AMP, 120 Volt, 60Hz circuit with a properly grounded outlet
is required. Preferably, the fireplace will be on a dedicated
circuit. Other appliances on the same circuit may cause the
circuit breaker to trip or the fuse to blow when the heater is on
operation. The unit comes standard with a 6’ (1828mm) long
three wire cord exiting from the rear of the fireplace. Plan the
installation to avoid the use of an extension cord. If an exten-
sion cord must be used, it must be a minimum 14 AWG three
wire with grounding type plug connector and rated no less
than 1900 Watts. The cord shall not be more than 20 feet in
length.
ELECTRICAL SPECIFICATIONS
Sides....................................0 mm 0 inches
Floor.....................................0 mm 0 inches
Top........................................0 mm 0 inches
Voltage:120 VAC, 60 Hz
Total Amps:11.5 Amps
Total Watts:1380 Watts
Heater Rating:1200 Watts
WARNING: Electrical outlet wir-
ing must comply with local build-
ing codes and all other appli-
cable regulations to reduce the
risk of fire, electrical shock and
injury.
WARNING: Do not use this fire-
place if any part of it has been
under water. Immediately call a
qualified service technician to
inspect the fireplace and re-
place any part of the electrical
system if necessary.
3
LOCATING YOUR ELECTRIC FIREPLACE
Your new freestanding electric fireplace may be installed vir-
tually anywhere in your home. However when choosing a
location for your new electric fireplace, ensure that the gen-
eral instructions are followed. For best effect results, install
the electric fireplace out of direct sunlight.
(Adaptor NOT permitted in Canada)
Under C22.2 NO. 0 standard
Loading...