Kolcraft JU004 Owner's Manual

©2007 Kolcraft®Enterprises, Inc. S72J-T 5/07

Jeep Wrangler®All-Weather Umbrella
Stroller Instruction Sheet

Instrucciones para carriola Jeep
Wrangler

®

All-Weather

Feuillet d'Instructions pour Poussette
pour Jeep

®

Wrangler® All-Weather

2

Avoid serious injury from falling or sliding out. Always use Restraint
System. Your child's safety depends on you. Proper stroller use cannot be
assured unless you follow these instructions. DO NOT USE STROLLER
UNTIL YOU READ AND UNDERSTAND THESE INSTRUCTIONS.

IMPORTANT SAFETY INFORMATION:

How to Keep Your Child Safe While Using this Stroller

•

Assembly by Adult Required.

• NEVER LEAVE YOUR CHILD UNATTENDED WHILE IN STROLLER.
Accidents can happen quickly while your back is turned. You must
always keep your child in view while your child is in the stroller,
even when sleeping. Do not use this product as a bed. Your child
may become tangled in straps or pads and suffocate.

• Always use restraint system to keep child from standing up or
falling out of the stroller.

• Always lock the stroller open before allowing your child in or near
the stroller. This prevents injuries caused by stroller collapsing.

•

Only use this stroller with children who weigh less than 35 lbs.
(15.8 kg) or are less than 40” (1 meter) tall. Use by larger children may
damage the stroller, or cause a hazardous unstable condition to exist.

•Only use this stroller when child can sit up unassisted or only use

product in recline position (select models).

• Always set the wheel brakes when stroller is not moving, especially
on an incline. This prevents the stroller from rolling away.

What to Avoid While Using this Stroller

• Always balance the weight of the stroller evenly. To prevent the
stroller from becoming unstable or tipping:

• Do not place parcels or accessory items on the stroller canopy,

seat, or over the handle.

• Do not put more than 3 lbs. (1.36 kg) in the cargo bags or rear

storage bag (select models).

• Do not allow children to play with or hang onto the stroller.

• Never use this stroller on stairways or escalators.

• Make sure children are clear of any moving parts if you adjust the
stroller, otherwise they may be injured.

• This is not an exercise stroller! Do not use this product while
running, jogging, in-line skating or participating in other athletic
activities.

•

DO NOT use any infant car seats with this product. Serious injury could
occur.

WARNING

Continued on next page

3

To Open Stroller

Release clip on side of stroller.

Push front of stroller downward.

Press down folding bar to lock stroller.

Parts List

2

3

How to Assemble Your Stroller

1

Stroller Frame

Storage Bag

(Select Models)

Canopy

Front Wheels (2)

2

1

3

Rear Wheels (4)

Cup Holder

(Select Models)

Cargo Bags (2)

Cotter Pins (2) Washers (6)

Hub Caps (4)

Axles (2)

• Take care when folding and unfolding to prevent finger pinching.

• Product may become unstable if a parcel bag, other than the one
recommended by the manufacturer is used.

• DO NOT allow children to climb into stroller unassisted. Stroller
may tip over and injure child.

• Only use replacement parts supplied by the manufacturer.

4

5

6

7

8

9

7

To Assemble Front Wheels

If stroller arrives to you with the wheels
off, follow the instructions below.

With the arrow on the front wheel facing
toward the stroller post, place wheel on
stroller until it locks onto stroller. Repeat
for other front wheel.

NOTE: To remove, squeeze tabs on
bottom of post and pull wheel off.

1

4

To Assemble Rear Wheels

For the right rear wheel assembly, slide
the wheel onto the axle.

Slide first washer onto axle.

Insert axle with washer and wheel into
right rear wheel assembly as shown.
Make sure axle is inserted into rear
wheel assembly from the inside wheel.

Slide second washer onto axle.

Slide other wheel onto axle.

Slide third washer onto axle.

Fit straight part of cotter pin through
hole on axle.

Line up tabs in each of the hub caps with
slots in the wheel, snap hub caps into place.

Repeat for left side.

1

3

Wheel

RIGHT REAR WHEEL ASSEMBLY

Axle

Wheel

Washer Washer Washer

Cotter Pin

Hub Cap

2

3

1

Arrow

Hub Cap

5

To Attach Cup Holder (select models)

Attach cup holder to left handle by lining
hole over pin and snap into place.

TO CLEAN: Top rack dishwasher safe.

1

1

WARNING

Do not place more than 1 lb (0.45 kg) in
this cup holder to avoid tipping!
Do not place hot liquids in this cup
holder. Hot liquids can burn your child.

To Attach Canopy

To attach canopy, align canopy clips in­between both screws on back of stroller.

Make sure elastic band is attached
around base of canopy bracket.

To lock canopy open, push down on
both side hinges located on inside of
canopy. To fold, push up to release
hinges.

1

1

2

3

2

3

To Attach Cargo Bags

To attach cargo bags, wrap velcro
around frame of stroller as shown.
Repeat for other side.

1

WARNING

Do not put more than 3 lbs (1.36 kg)
in this cargo bag.

6

To Secure Child In Stroller

Lock both foot brakes to keep stroller
from rolling.

Place crotch strap between child’s legs.

Adjust restraint system to fit snugly
around child’s waist.

To fasten restraint system buckles - push
together. Be sure both buckles are
fastened to secure child safely.

To unsnap restraint system buckles ­press tabs to release.

1

How to Properly Use Your New Stroller

3

WARNING

Avoid serious injury from falling or slid­ing out. Always use restraint system.

2

3

4

5

To Operate Brakes

1

Push both levers down to lock.

Pull both levers up to unlock.

2

Unlock

Lock

4

5

7

To Recline Seat

(select models)

1

Unhook clips from both sides of stroller.

Attach clips to lower bar.

To Roll-Up All-Weather Seat Pad

1

1

To keep child cool during hot weather,
roll up seat pad for better air circulation.
During cold weather, roll down.

Unthread buckles from seat pad as
shown.

Roll up seat pad and fasten Velcro at top
of seat as shown.

2

2

1

2

2

WARNING

SUFFOCATION HAZARD! Do not use
Roll-Up seat pad as a blanket or
weather cover.

Clips

To Adjust Canopy

1

1

To lock canopy open, push down on
both side hinges.

To close, push hinges up.

To adjust canopy to block sun or wind,
gently push canopy forward to desired
position.

2

3

2

4

5

4

5

Care & Maintenance

•

To keep your stroller running smoothly and avoid squeaking wheels use a silicone
or graphite based lubricant. It is important to get it into the axle and the wheel
assembly.

• Clean metal parts with a damp cloth and wipe dry.

• Clean woven fabric or vinyl parts with mild soap and water solution.

• Dry wet stroller with a soft cloth to prevent rusting.

• When storing stroller, never stack other items on top of it; this may damage the stroller.

• Periodically check for worn parts, loose screws, torn materials or stitching.

• Replace any damaged parts immediately.

• Cupholder is top rack dishwasher safe.

8

To Fold Stroller

1

BEFORE FOLDING: Lock brakes.

Close canopy.

Pull red lever backwards and lift up
hinge.

Push handlebars forward and squeeze
stroller together.

Lock clip on side of stroller.

2

3

3

2

9

Personal Record Card

Once in a while, we are less than perfect and one of our products reaches a customer with
a problem. In most cases, we can solve your problem with replacement parts. Please
contact us before you return one of our products to the store. Once a product is returned,
it cannot be resold. The materials and the energy used to make it are wasted.

Please fill in the information in the space provided and attach a copy of your purchase
receipt. You will need this information to obtain warranty service.

You can find the Model Number and Date of Manufacture on a sticker located on the rear
stroller leg, or sewn on the back of the seat.

Please direct any comments, questions or replacement part requests to:

Kolcraft®Enterprises, Inc. Consumer Service Department
10832 NC Highway 211East
Aberdeen, NC 28315

1-800-453-7673 in U.S. & Canada, 1-910-944-9345 outside U.S. & Canada
Eastern Standard Time, 8 am-6:45 pm Monday - Thursday, 8 am-3:30 pm Friday

fax: [phone]
e-mail: [e-mail]

Model / Style Number: _________________________

Date of Manufacture:___________________________

Date of Purchase: ______________________________

Jeep®is a registered trademark of DaimlerChrysler Corporation, and is used under license by
Kolcraft

®

. © DaimlerChrysler Company, LLC 2007.

Kolcraft®warrants this product to be free of defects in materials and workmanship, as follows:
For a period of ONE YEAR from the date of purchase, Kolcraft will repair or replace, at its
option, the defective product. If you have a problem or are not satisfied with this product,
please contact the Consumer Service Department at Kolcraft.

REPAIR OR REPLACEMENT AS PROVIDED UNDER THIS WARRANTY IS THE EXCLUSIVE
REMEDY OF THE CONSUMER. KOLCRAFT SHALL NOT BE LIABLE FOR ANY INCIDENTAL
OR CONSEQUENTIAL DAMAGES FOR BREACH OF ANY EXPRESS OR IMPLIED WARRAN­TY ON THIS PRODUCT, EXCEPT TO THE EXTENT REQUIRED BY APPLICABLE LAW. ANY
IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE
ON THIS PRODUCT IS LIMITED TO THE DURATION OF THIS WARRANTY.

Some states do not allow the exclusion or limitation of warranties set forth above, so the
above exclusions may not apply to you. This warranty gives you specific legal rights, and you
may also have other rights which vary from state to state. We sincerely thank you for your
purchase of this Kolcraft product.

To obtain warranty service, please call Kolcraft’s Consumer Service Department at
1-800-453-7673 in U.S. and Canada, 1-910-944-9345 outside U.S. and Canada or contact us
via email at [e-mail]

If the product is returned to Kolcraft’s Consumer Service Department for repair or
replacement, it must be shipped prepaid and adequately insured.

For further information visit www.kolcraft.com
Recall WEBSITE

: HELP KEEP YOUR CHILD SAFE. Check www.recall.gov to see if any prod-

ucts you use with your child or any of your child's toys have been recalled.

Limited Warranty

Turn to page 27 to see a list of
replacement parts