CHIRP 3200
TECHNICAL REFERENCE MANUAL
D101-05373
Revision 1.00
September 2011
Knudsen Engineering Limited
10 Industrial Road
Perth, Ontario, Canada
The information contained in this document is proprietary data of Knudsen
Engineering Limited. Any disclosure, use or reproduction of this information
for other than the specific purpose intended is expressly prohibited unless
agreed to in writing by Knudsen Engineering Limited.
CHIRP 3200 BOM
D224-04401
USB PROCESSOR MODULE
D309-04412
LONG PULSE TRANSMITTER MODULE
D309-04375
POWER DISTRIBUTION MODULE
FOUR PORT USB HUB MODULE
MECHANICALS
CABLE ASSEMBLIES
D309-04414
D309-04495
CABLE ROUTING
Assembly List
Chirp 3200, Single Channel, AC
Page
1
of 1D229
-
04401
-
REV3.01 Assembly List
29/09/2011
http://kelserver/ASP/KELInv/pf/PartsList.asp?pid=7395
Part #: D229-04401-REV3.01
Description:
Part # Description Manufacturer Reference Qty
D209-03810-REV2 Name Plate (3.9" x 1.65") KEL 1
D209-05110-REV1 3U Rack Case Lower PCB Plate KEL 1
D209-05111-REV1 3U Rack Case Upper PCB Plate KEL 1
D209-05118-REV1 3U Rack Case AC Input Panel KEL 1
D209-05120-REV1 3U Rack Case Connector Panel KEL 1
D209-05121-REV1 3U Rack Case Front Panel KEL 1
D209-05124-REV1 Transducer Connector Blank Plate KEL 3
D20F-04418-REV1 Artwork - Chirp 3200 Front Panel KEL 1
D20F-05095-REV1 Artwork - PAC-19 Rack Lid KEL 1
D20F-05118-REV1 Artwork - 3U Rack Case AC Input Panel KEL 1
D20F-05120-REV1 Artwork - 3U Rack Case Connector Panel KEL 1
D20K-05121-REV1 Painting - 3U Rack Case Front Panel KEL 1
D219-04203-REV2 Receive Signal Cable KEL 1
D219-04204-REV3 Drive Signal Cable KEL 1
D219-04316-REV2 USB Hub Power KEL 1
D219-04317-REV2 BNC Cable KEL 6
D219-04550-REV2 Module Power Cable KEL 2
D219-04551-REV2 Module USB Cable KEL 1
D219-04583-REV1 Power Switch Assembly KEL 1
D219-04584-REV1 AC Input Assembly KEL 1
D219-04585-REV2 Transmit Output Cable KEL 1
D219-05094-REV3 AC Supply Output KEL 1
D219-05103-REV1 USB Input Cable KEL 1
D309-04375-REV2.70 Wide Input Long Pulse Transmitter Module KEL 1
D309-04412-REV2.05 USB Processor Module - 5509 KEL 1
D309-04414-REV1.02 Power Distribution Module KEL 1
D309-04495-REV1.02 USB Hub - Four Port KEL 1
ECF504-BAS USB B-A PANEL ADAPTER L-COM 1
HN-2003 6-32 HEX NUT SPAE-NAUR 6
MS-2343P Machine Screw, 4-40/flathead/phillips/stainless/1/4" SPAE-NAUR 2
MS-2352P Machine Screw, 6-32/flathead/phillips/stainless/3/8" SPAE-NAUR 4
MS-2357P Machine Screw, 6-32/binding/phillips/stainless/1/2" SPAE-NAUR 4
MS-2427P Machine Screw, 4-40/panhead/phillips/stainless/3/8" SPAE-NAUR 14
MS-2428P Machine Screw, 6-32/panhead/phillips/stainless/3/8" SPAE-NAUR 55
N-2-BK CABLE CLAMP, BLACK, 1/8" RICHCO 4
N-4-BK CABLE CLAMP, BLACK, 1/4" RICHCO 11
N-6-BK CABLE CLAMP BLACK, 3/8" RICHCO 6
N-8-BK CABLE CLAMP BLACK, 1/2" RICHCO 2
NV1-1G000 Switch Mode Power Supply Lambda 1
SB19-5 RACK BOX, 3U STRONGBOX 1
W-2023 #4 SPLIT LOCKWASHER SPAE-NAUR 14
W-2024 #6 SPLIT LOCKWASHER SPAE-NAUR 59
Input
5
4
3
2
1
C5509 PROCESSOR MODULE
D D
SCHEMATIC INDEX :
Page 1 - DSP CONTROL
Page 2 - DSP POWER & JTAG
C C
Page 3 - MEMORY PAGE
Page 4 - CPLD
Page 5 - USB I/O
Page 6 - TEST SIGNAL GENERATOR
B B
Page 7 - ANALOG INPUT, GAIN, FILTER
Page 8 - ANALOG TO DIGITAL
Page 9 - POWER SOURCES/RESETS
A A
KNUDSEN ENGINEERING LTD.
KNUDSEN ENGINEERING LTD.
KNUDSEN ENGINEERING LTD.
Title
Title
Title
C5509 PROCESSOR MODULE
C5509 PROCESSOR MODULE
C5509 PROCESSOR MODULE
Size Document Number Rev
Size Document Number Rev
Size Document Number Rev
B
B
B
Date: Sheet
Date: Sheet
Date: Sheet
Tuesday, April 24, 2007
Tuesday, April 24, 2007
5
4
3
2
Tuesday, April 24, 2007
D301-04412
D301-04412
D301-04412
00
00
00
1
of
of
of
2.0
2.0
2.0
5
DIGITAL SIGNAL PROCESSOR
VDD
OUT
5
A[0..13]
+3.3V+3.3V
4
3
R113
R113
1 2
10K
10K
BOOT
USB POWERDET
12
R116
R116
10K
10K
12
FB101
FB101
BEAD2A
BEAD2A
CLKIN
12
C101
C101
0.1uF
0.1uF
16V
16V
RESET#
MODE
PINS
12
SDA
/SH7-MAX5822.D5
/SH3-M24C32.D4
/SH7-MAX5822.D5
SCL
/SH3-M24C32.D4
/SH5-USB I/O.C2
PU
/SH5-USB I/O.C2
DP
DN
/SH5-USB I/O.C2
/SH9-TPS3307.A1
INT1#
INT2#
/SH4-CPLD.D1
GPIO0
/SH4-CPLD.D1
GPIO1
/SH4-CPLD.D1
GPIO2
/SH4-CPLD.D1
GPIO3
/SH4-CPLD.C4
GPIO6
GPIO4
12
A0
A1A1
A2A2
A3
A4
A5
A6
A7
A8
A9
A10
A12
A13
TP101TP101
C102
C102
33pF
33pF
50V
50V
/SH4-CPLD.C1
/SH4-CPLD.C1
/SH3-FLASH.B4
/SH5-USB I/O.B2
R117
R117
10K
10K
RN102 33RN102 33
RN104RN104
RN106RN106
R10333R103
1
4
3
2
1
4
3
2
1
4
3
2
1
1 2
1 2
+3.3V
12
R105
R105
10K
10K
1 2
33
R104
R104
100
100
R11433R114
33
/SH3-SDRAM.C4
A[0..13]
D D
12
8MHz
R102
R102
10K
10K
OSCILLATOR
U101
U101
CB3LV8
CB3LV8
1
OE/ST
2
GND
C C
B B
A A
+3.3V
R111
R111
1 2
10K
10K
R112
R112
1 2
10K
10K
JP101JP101
1 2
1 2
JP102JP102
4
U1A
U1A
DSP TMS320VC5509APGE
DSP TMS320VC5509APGE
5
55
A0
6
54
A1
7
52
A2
8
51
A3
5
50
A4
6
48
A5
7
47
A6
8
46
A7
5
44
A8
6
43
A9
7
42
A10
8
39
A12
38
A13
40
A11
14
X1
13
X2/CLKIN
12
R106
R106
10K
10K
89
SDA
90
SCL
2
PU
3
DP
4
DN
91
RESET#
93
INT0#
94
INT1#
96
INT2#
97
INT3#
99
INT4#
12
GPIO0
10
GPIO1
9
GPIO2
143
GPIO3
141
GPIO6
142
GPIO4
6
GPIO7
105
AIN0
106
AIN1
112
RTCINX1
111
12
R118
R118
10K
10K
RTCINX2
4
DSP CTRL
C2/#AWE/HR/#W
C1/#AOE/#HINT
C0/#ARE/GPIO8
19
17
16
C13/SDA10/GPIO13
C10/#SDRAS/#HAS/GPIO12
C11/#SDCAS/#HCS
C12/#SDWE/#HDS1
C14/CLKMEM/#HDS2
C7/#CE3/HCNT1/GPIO1125C6/#CE2/HCNT0
23
C3/ARDY/HRDY
D10
D11
D12
D13
D14
D15
C4/#CE0/GPIO9
C8/#BE0/#HBEO
C9/#BE1/#HBE1
TIN/TOUT0
CLKOUT
GPIO10
CLKR0
DR0
FSR0
CLKX0
DX0
FSX0
CLKR1
DR1
FSR1
CLKX1
DX1
FSX1
CLKR2
DR2
FSR2
CLKX2
DX2
FSX2
3
+3.3V
12
R101
R101
2.2K
2.2K
20
4
3
2
1
4
3
2
1
4
3
2
1
4
3
2
1
1
2
3
4
1
2
3
4
R10733R107
1 2
33
R11033R110
1 2
33
1
2
3
4
1
2
3
4
R11533R115
1 2
33
5
6
7
8
5
6
7
8
5
6
7
8
5
6
7
8
8
7
6
5
8
7
6
5
1 2
8
7
6
5
8
7
6
5
57
D0
58
D1
59
D2
61
D3
62
D4
63
D5
65
D6
66
D7
67
D8
69
D9
70
71
74
75
76
77
21
26
27
35
34
28
32
31
101
XF
140
15
22
137
135
136
134
131
133
130
128
129
127
124
125
123
120
121
119
116
117
3
RN10133 RN10133
RN103RN103
RN105RN105
RN107RN107
RN10833 RN10833
RN10933 RN10933
R10933R109
33
RN11033 RN11033
RN11133 RN11133
D0
D1
D2
D3
D4
D5
D6
D7
D8
D9
D10
D11
D12
D13
D14
D15
DSPCLKOUT
CLKX0
CE0#
BE0#
BE1#
SDA10
SDRAS#
SDCAS#
SDWE#
CLKMEM
TOUT0
DSPCLKOUT
GPIO10
DR0
CLKX0
DX0
FSX0
CLKR1
DR1
FSR1
CLKX1
DX1
FSX1
CLKR2
DR2
FSR2
CLKX2
DX2
FSX2
D[0..15]
/SH3-SDRAM.D4
/SH3-SDRAM.B4
/SH3-SDRAM.B4
/SH3-SDRAM.B4
/SH3-SDRAM.D4
/SH3-SDRAM.D4
/SH3-SDRAM.D4
/SH3-SDRAM.D4
/SH4-CPLD.D4
/SH4-CPLD.D4
/SH3-M24C32.D4
/SH3-FLASH.A4
/SH3-FLASH.A4
/SH3-FLASH.A4
/SH6-AD5541.B5
/SH4-CPLD.D4
/SH4-CPLD.C4
/SH4-CPLD.C4
/SH4-CPLD.D4
/SH4-CPLD.C4
/SH4-CPLD.C4
/SH8-AD7677.B1
/SH8-AD7677.B1
/SH8-AD7677.B3
/SH4-CPLD.C4
/SH4-CPLD.C4
/SH4-CPLD.C4
2
/SH6-AD5541.B5
/SH6-AD5541.B5
2
1
D[0..15]
/SH3-SDRAM.C2
XF
/SH4-CPLD.A4
+3.3V +3.3V
12
C103
C103
0.1uF
5
VCC
U102 SN74AHC14U102 SN74AHC14
GND
3
4
A2Y
0.1uF
16V
16V
R108
R108
1 2
220
220
McBSP0
McBSP1
MT1MT1
MT2MT2
MT3MT3
MT4MT4
MT5MT5
McBSP2
1
1
KNUDSEN ENGINEERING LTD.
KNUDSEN ENGINEERING LTD.
KNUDSEN ENGINEERING LTD.
Title
Title
Title
C5509 PROCESSOR MODULE
C5509 PROCESSOR MODULE
C5509 PROCESSOR MODULE
Size Document Number Rev
Size Document Number Rev
Size Document Number Rev
B
B
B
Date: Sheet
Date: Sheet
Date: Sheet
Tuesday, April 24, 2007
Tuesday, April 24, 2007
Tuesday, April 24, 2007
D301-04412
D301-04412
D301-04412
1
1
1
19
19
19
1
MT6MT6
21
DS101
DS101
LED
LED
GRN
GRN
1
2.0
2.0
of
of
of
2.0
5
4
3
2
1
DSP POWER & JTAG
D D
+3.3V
R201
R201
1 2
5.11
5.11
C C
B B
+1.6V
+1.6V
FB201
FB201
1 2
BEAD3A
BEAD3A
FB202
FB202
1 2
BEAD3A
BEAD3A
USB VCC
12
+
+
12
+
+
/SH7-TPS767D301.C1
12
C202
R20210R202
1 2
10
C202
0.1uF
0.1uF
16V
16V
C201
C201
1uF
1uF
16V
16V
C204
C204
10uF
10uF
16V
16V
+1.6V +3.3V
U1B
U1B
DSP TMS320VC5509APGE
DSP TMS320VC5509APGE
18
CVDD1
29
CVDD2
30
CVDD3
41
CVDD4
53
CVDD5
68
CVDD6
78
CVDD7
83
CVDD8
87
CVDD9
118
CVDD10
132
CVDD11
110
RCVDD
109
ALOG VCC
12
C203
C203
0.1uF
0.1uF
16V
16V
12
C205
C205
0.1uF
0.1uF
16V
16V
5
107
104
95
92
RDVDD
USBVDD
AVDD
ADVDD
USBPLLVDD
USBPLLVSS
DSP POWER
U1C
U1C
DSP TMS320VC5509APGE
DSP TMS320VC5509APGE
TRST#
TMS
DSP JTAG
TDO
TCK
EMU0
EMU1/OFF#
TDI
84
86
82
81
85
79
80
DVDD1
DVDD2
DVDD3
DVDD4
DVDD5
DVDD6
DVDD7
DVDD8
DVDD9
VSS1
VSS2
VSS3
VSS4
VSS5
VSS6
VSS7
VSS8
VSS9
VSS10
VSS11
VSS12
VSS13
VSS14
VSS15
VSS16
VSS17
VSS18
AVSS
ADVSS
8
24
49
56
72
88
98
126
139
1
7
11
33
36
37
45
60
64
73
100
102
113
114
115
122
138
144
108
103
+3.3V
12
12
R203
R203
R204
R204
4.7K
4.7K
4.7K
4.7K
J201
J201
JTAG PRGRM I/F
JTAG PRGRM I/F
2
112
4
334
6
556
8
778
10
9910
12
111112
14
131314
12
R205
R205
4.7K
4.7K
12
12
+
+
A A
+3.3V
12
+
+
C206
C206
10uF
10uF
16V
16V
C220
C220
10uF
10uF
16V
16V
C207
C207
0.1uF
0.1uF
16V
16V
12
C221
C221
0.1uF
0.1uF
16V
16V
5
12
12
12
C208
C208
0.1uF
0.1uF
16V
16V
C222
C222
0.1uF
0.1uF
16V
16V
C209
C209
0.1uF
0.1uF
16V
16V
12
C223
C223
0.1uF
0.1uF
16V
16V
12
12
C210
C210
0.1uF
0.1uF
16V
16V
12
C224
C224
0.1uF
0.1uF
16V
16V
12
C211
C211
0.1uF
0.1uF
16V
16V
12
C225
C225
0.1uF
0.1uF
16V
16V
12
C212
C212
C213
C213
0.1uF
0.1uF
0.1uF
0.1uF
16V
16V
16V
16V
12
12
C226
C226
C227
C227
0.1uF
0.1uF
0.1uF
0.1uF
16V
16V
16V
16V
4
12
12
12
C214
C214
0.1uF
0.1uF
16V
16V
C228
C228
0.1uF
0.1uF
16V
16V
C215
C215
0.1uF
0.1uF
16V
16V
12
C229
C229
0.1uF
0.1uF
16V
16V
12
12
C216
C216
0.1uF
0.1uF
16V
16V
C217
C217
0.1uF
0.1uF
16V
16V
12
12
C218
C218
0.1uF
0.1uF
16V
16V
C219
C219
0.1uF
0.1uF
16V
16V
KNUDSEN ENGINEERING LTD.
KNUDSEN ENGINEERING LTD.
KNUDSEN ENGINEERING LTD.
Title
Title
Title
C5509 PROCESSOR MODULE
C5509 PROCESSOR MODULE
C5509 PROCESSOR MODULE
Size Document Number Rev
Size Document Number Rev
Size Document Number Rev
B
B
B
Date: Sheet
Date: Sheet
Date: Sheet
Tuesday, April 24, 2007
Tuesday, April 24, 2007
3
2
Tuesday, April 24, 2007
D301-04412
D301-04412
D301-04412
29
29
29
1
of
of
of
2.0
2.0
2.0
5
MEMORY: FLASH/SDRAM/I2C EEPROM
CLKMEM
/SH1-DSP CTRL.C2
CE0#
SDWE#
SDCAS#
SDRAS#
A[0..13]
/SH1-DSP CTRL.D5
SDA10
BE0#
BE1#
/SH1-DSP CTRL.C2
/SH1-DSP CTRL.C2
/SH1-DSP CTRL.C2
/SH1-DSP CTRL.C2
/SH1-DSP CTRL.C2
/SH1-DSP CTRL.C2
/SH1-DSP CTRL.C2
D D
C C
A[0..13]
4
CLKMEM
3
+3.3V +3.3V
U301
U301
MT48LC4M16
MT48LC4M16
A1
A2
A3
A4
A5
A6
A7
A8
A9
A10
A12
A13
A0
38
CLK
37
CKE
19
CS#
16
WE#
17
CAS#
18
RAS#
23
A0
24
A1
25
A2
26
A3
29
A4
30
A5
31
A6
32
A7
33
A8
34
A9
35
A11
20
BA0
21
BA1
22
A10
15
DQML
39
DQMH
36
NC1
40
NC2
SDRAM
64Mbit[4Mx16]
VDD1
VDD2
VDD3
VDDQ1
VDDQ2
VDDQ3
VDDQ4
DQ0
DQ1
DQ2
DQ3
DQ4
DQ5
DQ6
DQ7
DQ8
DQ9
DQ10
DQ11
DQ12
DQ13
DQ14
DQ15
VSS1
VSS2
VSS3
VSSQ1
VSSQ2
VSSQ3
VSSQ4
1
14
27
3
9
43
49
2
4
5
7
8
10
11
13
42
44
45
47
48
50
51
53
28
41
54
6
12
46
52
D0
D1
D2
D3
D4
D5
D6
D7
D8
D9
D10
D11
D12
D13
D14
D15
2
D[0..15]
+3.3V
1
12
12
+
+
C301
C301
10uF
10uF
16V
16V
C302
C302
0.1uF
0.1uF
16V
16V
D[0..15]
12
C303
C303
0.1uF
0.1uF
16V
16V
/SH1-DSP CTRL.D2
12
12
C304
C304
0.1uF
0.1uF
16V
16V
C305
C305
0.1uF
0.1uF
16V
16V
12
12
C306
C306
0.1uF
0.1uF
16V
16V
C307
C307
0.1uF
0.1uF
16V
16V
12
C308
C308
0.1uF
0.1uF
16V
16V
SPI FLASH
B B
/SH1-DSP CTRL.A4
GPIO4
DX0
/SH1-DSP CTRL.B2
CLKX0
/SH1-DSP CTRL.B2
/SH1-DSP CTRL.B2
DR0
McBSP0
A A
GPIO10
/SH1-DSP CTRL.B5
SCL
/SH1-DSP CTRL.B5
SDA
/SH1-DSP CTRL.B5
5
CLKX0
+3.3V
12
C310
C310
0.1uF
0.1uF
16V
16V
R30233R302
1 2
33
4
R30333R303
1 2
33
16Mbit
U302
U302
W25P16
W25P16
7
HOLD#
3
1
5
VCC
WP#
CS#
DOUT
DIN
CLK6VSS
I2C EEPROM
32KBit
U303
U303
M24C32
M24C32
VCC8E0
7
WC
6
SCL
5
SDA
1
2
E1
3
E2
4
Vss
3
8
R30133R301
1 2
2
33
4
+3.3V+3.3V
12
C309
C309
0.1uF
0.1uF
16V
16V
KNUDSEN ENGINEERING LTD.
KNUDSEN ENGINEERING LTD.
KNUDSEN ENGINEERING LTD.
Title
Title
Title
C5509 PROCESSOR MODULE
C5509 PROCESSOR MODULE
C5509 PROCESSOR MODULE
Size Document Number Rev
Size Document Number Rev
Size Document Number Rev
B
B
B
Date: Sheet
Date: Sheet
Date: Sheet
Tuesday, April 24, 2007
Tuesday, April 24, 2007
2
Tuesday, April 24, 2007
D301-04412
D301-04412
D301-04412
39
39
39
1
of
of
of
2.0
2.0
2.0
5
4
3
2
1
CPLD
D D
/SH1-DSP CTRL.C2
Z407
Z407
ESD
ESD
SPSR
SPSR
2 1
DSPCLKOUT
McBSP1
GPIO6
TOUT0
/SH1-DSP CTRL.C2
CLKR1
/SH1-DSP CTRL.B2
CLKX1
/SH1-DSP CTRL.A2
FSR1
/SH1-DSP CTRL.B2
FSX1
/SH1-DSP CTRL.A2
DX1
/SH1-DSP CTRL.A2
CLKX2
/SH1-DSP CTRL.A2
DX2
/SH1-DSP CTRL.A2
FSX2
/SH1-DSP CTRL.A2
/SH1-DSP CTRL.B4
XF
/SH1-DSP CTRL.C1
RESET
/SH9-TPS3307.A1
J401J401
1
1
2
2
3
3
4
4
5
5
6
6
7
7
8
8
J402J402
1
1
2
2
C C
J403J403
1
1
2
2
Z401
Z401
ESD
ESD
SPSR
SPSR
2 1
+3.3V
J405
J405
JTAG I/F
JTAG I/F
1
1
2
2
3
3
4
4
5
5
6
6
B B
2 1
123
876
Z402
Z402
ESD
ESD
SPSR
SPSR
+3.3V
123
876
2 1
4
RN403
RN403
10K
10K
5
Z403
Z403
ESD
ESD
SPSR
SPSR
4
RN401
RN401
10K
10K
5
2 1
Z404
Z404
ESD
ESD
SPSR
SPSR
TCK
123
876
4
RN402
RN402
10K
10K
5
Z405
Z405
Z406
Z406
ESD
ESD
ESD
ESD
SPSR
SPSR
SPSR
SPSR
2 1
2 1
+3.3V
DSPCLKOUT
CLKR1
CLKX1
U401
U401
XCR3064XL
XCR3064XL
9
17
29
41
37
38
39
40
27
28
30
42
43
44
2
3
5
6
8
10
20
26
32
1
7
VCC1
VCC2
VCC3
VCC4
IN3/CLK3
IN2/CLK2
IN1/CLK1
IN0/CLK0
FSR1
FSX1
DX1
IO1
IO2
IO3
IO4
IO5
IO6
IO7
GPIO6
XF
RESET
TCK
TDO
TDI
TMS
CPLD
GPIO0
GPIO1
GPIO2
GPIO3
IMPULSE
WARP
#INT1
#INT2
DR1
TEST SELECT1
TEST SELECT2
TX_Y
TX_B
TX_X
TX_A
PORT_EN
GND1
GND2
GND3
12
13
14
15
21
22
23
25
R40133R401
1 2
11
18
19
35
34
33
31
4
16
24
36
33
U402
U402
74LCX125
2
5
12
9
7
74LCX125
A0
A1
A2
A3
GND
VCC
OE0
OE1
OE2
OE3
O0
O1
O2
O3
GPIO0
/SH1-DSP CTRL.A4
GPIO1
/SH1-DSP CTRL.A4
GPIO2
/SH1-DSP CTRL.A4
GPIO3
/SH1-DSP CTRL.A4
IMPULSE
/SH8-AD7677.B3
WARP
/SH8-AD7677.B3
INT1#
/SH1-DSP CTRL.B4
INT2#
/SH1-DSP CTRL.B4
DR1
/SH1-DSP CTRL.B2
TEST SELECT1
TEST SELECT2
+3.3V
12
14
3
6
11
8
1
4
13
10
C401
C401
0.1uF
0.1uF
16V
16V
/SH6-ADG821.B2
/SH6-ADG821.B2
PINS
BOOT
MODE
J404J404
1
2
3
4
5
6
7
8
1
2
3
4
5
6
7
8
TX OUT
J406
J406
JTAG-CPLD
JTAG-CPLD
14
131314
12
111112
10
9910
8
778
6
556
4
334
2
112
A A
5
4
+3.3V
12
12
+
+
C402
C402
10uF
10uF
16V
16V
C403
C403
0.1uF
0.1uF
16V
16V
12
C404
C404
0.1uF
0.1uF
16V
16V
3
12
12
C405
C405
0.1uF
0.1uF
16V
16V
C406
C406
0.1uF
0.1uF
16V
16V
TP401TP401
1
2
KNUDSEN ENGINEERING LTD.
KNUDSEN ENGINEERING LTD.
KNUDSEN ENGINEERING LTD.
Title
Title
Title
C5509 PROCESSOR MODULE
C5509 PROCESSOR MODULE
C5509 PROCESSOR MODULE
Size Document Number Rev
Size Document Number Rev
Size Document Number Rev
B
B
B
Date: Sheet
Date: Sheet
Date: Sheet
Tuesday, April 24, 2007
Tuesday, April 24, 2007
Tuesday, April 24, 2007
D301-04412
D301-04412
D301-04412
49
49
49
1
of
of
of
2.0
2.0
2.0
5
4
3
2
1
USB I/O
D D
J501
J501
USB HDR
USB HDR
VCC
1
1
D-
2
C C
MOLEX
VERTICAL
2
3
4
5
6
J502
J502
USB I/O
USB I/O
D+
3
GND
4
SHIELD
5
SHIELD
6
VCC
1
1
D-
2
2
D+
3
3
GND
4
4
SHIELD
5
5
SHIELD
6
6
R50133R501
1 2
33
R50233R502
1 2
33
R503
R503
1 2
1.5K
1.5K
FB501
FB501
1 2
BEAD3A
BEAD3A
DN
/SH1-DSP CTRL.B4
/SH1-DSP CTRL.B4
DP
/SH1-DSP CTRL.B4
PU
12
R504
R504
300K
300K
B B
RIGHT
ANGLE
A A
5
J503
J503
USB I/O
USB I/O
12
C501
C501
0.01uF
VCC
1
1
D-
2
2
D+
3
3
GND
4
4
SHIELD
5
5
SHIELD
6
6
12
R5060R506
0
FB502
FB502
1 2
BEAD3A
BEAD3A
4
3
0.01uF
50V
50V
12
R505
R505
680K
680K
USB POWERDET
/SH1-DSP CTRL.A4
2
KNUDSEN ENGINEERING LTD.
KNUDSEN ENGINEERING LTD.
KNUDSEN ENGINEERING LTD.
Title
Title
Title
C5509 PROCESSOR MODULE
C5509 PROCESSOR MODULE
C5509 PROCESSOR MODULE
Size Document Number Rev
Size Document Number Rev
Size Document Number Rev
B
B
B
Date: Sheet
Date: Sheet
Date: Sheet
Tuesday, April 24, 2007
Tuesday, April 24, 2007
Tuesday, April 24, 2007
D301-04412
D301-04412
D301-04412
59
59
59
1
of
of
of
2.0
2.0
2.0
5
4
3
2
1
TEST SIGNAL GENERATOR
U601
U601
ADR423AR
ADR423AR
D D
C C
FSX0
DX0
CLKX0
B B
A A
+5V
12
+
+
/SH1-DSP McBSP0.B4
/SH1-DSP McBSP0.B4
/SH1-DSP McBSP0.B4
C602
C602
10uF
10uF
16V
16V
5
TRIM
2
12
C603
C603
0.1uF
0.1uF
16V
16V
5
VIN
3
NC2
4
GND
12
C606
C606
0.1uF
0.1uF
16V
16V
U603
U603
AD5541LR
AD5541LR
3
REF
4
CS
6
DIN
5
SCLK
NC1
VOUT
TP1
TP2
VDD
VOUT
DGND
AGND
7
6
1
8
8
1
2
7
12
+
+
C604
C604
47uF
47uF
10V
10V
+5V
12
C607
C607
0.1uF
0.1uF
16V
16V
1 2
R6041KR604
1K
12
C609
C609
470pF
470pF
100V
100V
4
+3VREF
U602B
U602B
AD8656AR
AD8656AR
6
-IN2
5
+IN2
/SH7-MAX5822.D5
OUT2
-VS
4
TP601TP601
1
+5V
12
C605
C605
0.1uF
0.1uF
16V
8
C611
C611
1uF
1uF
16V
16V
C613
C613
1uF
1uF
16V
16V
+VS
OUT1
16V
1
1 2
2.0V
1 2
2.5V
R606
R606
10K
10K
R612
R612
10K
10K
U602A
U602A
AD8656AR
AD8656AR
2
-IN1
3
+IN1
+5V
+5V
12
12
12
12
R605
R605
15K
15K
R609
R609
10K
10K
R611
R611
10K
10K
R613
R613
10K
10K
1.5V +/- 1.5V
12
12
3
7
C601
C601
1 2
2700pF
2700pF
50V
50V
U604A
U604A
AD8656AR
AD8656AR
2
3
6
5
12
R6021KR602
1 2
1K
R603
R603
1 2
10K
10K
8
+VS
-IN1
OUT1
+IN1
R610
R610
1 2
10K
10K
U604B
U604B
AD8656AR
AD8656AR
-IN2
OUT2
+IN2
-VS
4
R601
R601
100K
100K
+5V
Z601
Z601
ESD
ESD
SPSR
SPSR
2 1
Z602
Z602
ESD
ESD
SPSR
SPSR
2 1
12
C608
C608
0.1uF
0.1uF
16V
16V
2.5V +/- 1.5V
R607
R607
TEST SELECT1
2.5V +/- 1.5V
TEST SELECT2
2
1 2
24.9
24.9
1
7
J601J601
AC Coupled Output
1
1
2
2
J602J602
DC Output
1
1
2
2
+5V
12
C610
C610
0.1uF
0.1uF
16V
16V
U605
U605
ADG821BRM
ADG821BRM
1
R608
R608
1 2
24.9
24.9
/SH4-CPLD.B3
Z603
Z603
ESD
ESD
SPSR
SPSR
2 1
/SH4-CPLD.B3
KNUDSEN ENGINEERING LTD.
KNUDSEN ENGINEERING LTD.
KNUDSEN ENGINEERING LTD.
Title
Title
Title
C5509 PROCESSOR MODULE
C5509 PROCESSOR MODULE
C5509 PROCESSOR MODULE
Size Document Number Rev
Size Document Number Rev
Size Document Number Rev
B
B
B
Date: Sheet
Date: Sheet
Date: Sheet
Tuesday, April 24, 2007
Tuesday, April 24, 2007
Tuesday, April 24, 2007
5
7
3
Z604
Z604
ESD
ESD
SPSR
SPSR
2 1
1
5
7
3
S1
S2
IN1
IN2
U606
U606
ADG821BRM
ADG821BRM
S1
S2
IN1
IN2
D301-04412
D301-04412
D301-04412
VDD
D1
D2
GND
J603J603
1
1
2
2
3
3
ANALOG OUT
VDD
D1
D2
GND
8
2
6
4
8
2
6
4
1
/SH7-AD605.B4
ININ+
/SH7-AD605.B4
+5V
12
C612
C612
0.1uF
0.1uF
16V
16V
of
of
of
69
69
69
2.0
2.0
2.0
5
4
3
2
1
ANALOG INPUT,GAIN
U701
U701
MAX5822
R70133R701
SCL
/SH1-DSP CTRL/SYS.B4
/SH1-DSP CTRL/SYS.B4
SDA
D D
+3VREF
/SH7-ADR423.D4
+5V
12
R705
R705
10K
10K
12
12
C C
J701J701
1
2
3
4
R708
R708
499
499
C705
C705
0.1uF
0.1uF
16V
16V
1
SIG IN+
2
3
SIG IN-
4
1 2
R7160R716
1 2
0
R7170R717
1 2
0
33
R70233R702
1 2
33
12
C702
C702
0.1uF
0.1uF
16V
16V
+5V +5V
ANALOG INPUT
B B
IN+
/SH6-ADG821.C1
/SH6-ADG821.C1
IN-
Note:
R716 & R717 can be replaced with
capacitors if AC-coupled input is required.
NON- POPULATED COMPONENTS:
C715
C716
A A
5
MAX5822
SCL4VDD
5
SDA
6
REF
ADD3OUTA
2
GND
OUTB
ANALOG
GAIN CONTROL
DAC
R709
R709
10K
10K
12
R718
R718
10K
10K
12
R710
R710
10K
10K
12
R719
R719
10K
10K
U704A
U704A
AD8656AR
AD8656AR
2
3
U704B
U704B
AD8656AR
AD8656AR
6
5
12
D701 SDMG0340LC-7-FD701 SDMG0340LC-7-F
+5V
8
-IN1
+IN1
-IN2
+IN2
-VS
4
+3.3V
12
C701
C701
0.1uF
R703
R703
1 2
10K
10K
1
3
2
1
12
1
7
C719
C719
0.1uF
0.1uF
16V
16V
4
0.1uF
16V
16V
1 2
1 2
1
7
8
+5V
2
3
D702 SDMG0340LA-7D702 SDMG0340LA-7
+VS
OUT1
OUT2
R704
R704
1 2
10K
10K
C709
C709
2.2uF
2.2uF
16V
16V
C710
C710
2.2uF
2.2uF
16V
16V
C715
C715
1 2
2.2uF
2.2uF
16V
16V
DNI
DNI
C716
C716
1 2
2.2uF
2.2uF
16V
16V
DNI
DNI
1
C707
C707
0.1uF
0.1uF
16V
16V
C713
C713
2.2uF
2.2uF
16V
16V
TP702TP702
1
12
C704
C704
0.1uF
0.1uF
16V
16V
12
13
1
IN+
IN-
8
3
2
6
7
9
12
C714
C714
0.1uF
0.1uF
16V
16V
ANALOG GAIN
U702
U702
AD605AR
AD605AR
VPOS1
VPOS2
VGN1
VGN2
+IN1
-IN1
+IN2
-IN2
VOCM
C706
C706
1 2
2.2uF
2.2uF
16V
16V
TP704TP704
1
VREF
OUT1
FBK1
OUT2
FBK2
GND1
GND2
R706
R706
1 2
0
TP703TP703
1
+2.5V REF
/SH8-ADR421.D1
16
15
12
JP701JP701
14
10
12
JP702JP702
11
4
5
Note:
- Jumpers JP701 and JP702
normally not populated.
- Jumpers used for gain control
C708
C708
1 2
0.056uF
0.056uF
16V
16V
R713
R713
1 2
5.76K
5.76K
+5V
12
C711
C711
0.1uF
0.1uF
16V
16V
R711
R711
1 2
4.12K
4.12K
R714
R714
1 2
5.9K
5.9K
R720
R720
1 2
6.04K
6.04K
R722
R722
1 2
16.2K
16.2K
ANALOG FILTER
NON- POPULATED RESISTORS:
R706
R725
R727
R729
3
2
0
DNI
DNI
R707
R707
1 2
5.9K
5.9K
U703
U703
LTC1562CG-2
LTC1562CG-2
1
INV B
2
V1 B
3
V2 B
5
V+
6
SHDN
8
V2 A
9
V1 A
10
INV A
R724
R724
1 2
3.74K
3.74K
R725
R725
1 2
0
0
DNI
DNI
R726
R726
1 2
9.76K
9.76K
R727
R727
1 2
0
0
DNI
DNI
Title
Title
Title
Size Document Number Rev
Size Document Number Rev
Size Document Number Rev
B
B
B
Date: Sheet
Date: Sheet
Date: Sheet
20
INV C
19
V1 C
18
V2 C
15
AGND
4
V1-
7
V2-
14
V3-
17
V4-
16
V5-
13
V2 D
12
V1 D
11
INV D
KNUDSEN ENGINEERING LTD.
KNUDSEN ENGINEERING LTD.
KNUDSEN ENGINEERING LTD.
C5509 PROCESSOR MODULE
C5509 PROCESSOR MODULE
C5509 PROCESSOR MODULE
Tuesday, April 24, 2007
Tuesday, April 24, 2007
Tuesday, April 24, 2007
R712
R712
1 2
6.04K
6.04K
R715
R715
1 2
5.9K
5.9K
R721
R721
1 2
5.9K
5.9K
R723
R723
1 2
3.57K
3.57K
TP705TP705
R7280R728
1 2
0
R729
R729
1 2
0
0
DNI
DNI
D301-04412
D301-04412
D301-04412
1
FILTER OUT
79
79
79
1
12
C712
C712
1uF
1uF
16V
16V
/SH8-AD8022.B5
of
of
of
2.0
2.0
2.0
TP701TP701
12
C703
C703
0.1uF
0.1uF
16V
16V
+5V
12
12
5
ANALOG TO DIGITAL
U801
U801
ADR421AR
ADR421AR
+5V
D D
12
12
+
+
C803
C803
10uF
10uF
16V
16V
C804
C804
0.1uF
0.1uF
16V
16V
5
TRIM
2
VIN
3
NC2
4
GND
NC1
VOUT
TP1
TP2
7
6
1
8
+2.5V REF
12
+
+
C805
C805
47uF
47uF
10V
10V
4
TP801TP801
1
3
+5V
R801
R801
1 2
100
100
12
12
+
+
C806
C806
C807
C807
0.1uF
0.1uF
10uF
10uF
16V
16V
16V
16V
12
12
+
+
C808
C808
C809
C809
10uF
10uF
0.1uF
0.1uF
16V
16V
16V
16V
2
+3.3V
12
+
+
C801
C801
10uF
10uF
16V
16V
1
12
C802
C802
0.1uF
0.1uF
16V
16V
+2.5V REF
/SH7-AD605.C3
R80315R803
15
+3.3V
/SH4-CPLD.C1
WARP
IMPULSE
/SH4-CPLD.D1
RESET
/SH9-TPS3307.A1
FSR2
/SH1-DSP CTRL.B2
ADC IN+
12
C812
C812
2700pF
2700pF
50V
50V
TP803TP803
1
U802
U802
AD7671ASTZ
AD7671ASTZ
2
AVDD
19
DVDD
8
SER/PAR*
16
D7/RDC/SDIN
18
OVDD
6
WARP
7
IMPULSE
33
RESET
35
CNVST*
43
IND(4R)
42
INC(4R)
41
INB(2R)
40
INA(R)
39
INGND
34
PD
4
BYTESWAP
5
OB/2C*
31
RD*
32
CS*
1
AGND1
36
AGND2
20
DGND1
30
DGND2
17
OGND
REF
REFGND
D2/DIVSCLK[0]
D3/DIVSCLK[1]
D4/EXT/INT
D5/INVSYNC
D6/INVSCLK
D8/SDOUT
D9/SCLK
D10/SYNC
D11/RDERROR
D12
D13
D14
D15
BUSY
NC1
NC2
NC3
NC4
NC5
NC6
+2.5V REF
12
C810
C810
0.1uF
TP806TP806
1
0.1uF
16V
16V
1 2
R80433R804
33
R80533R805
1 2
33
DR2
/SH1-DSP CTRL.B1
CLKR2
/SH1-DSP CTRL.B2
37
38
9
D0
10
D1
11
12
13
14
15
21
22
23
24
25
26
27
28
29
3
44
45
46
47
48
C C
+5V
12
C811
C811
0.1uF
0.1uF
16V
16V
U803
U803
7
V+
AD8655AR
AD8655AR
2
IN-
6
OUT
FILTER OUT
B B
/SH7-LTC1562-2.A1
3
IN+
V-
4
Z801
Z801
ESD
ESD
SPSR
SPSR
2 1
J801J801
FILTER OUT
1
1
2
2
1 2
ANALOG TO DIGITAL
CONVERSION
A A
KNUDSEN ENGINEERING LTD.
KNUDSEN ENGINEERING LTD.
KNUDSEN ENGINEERING LTD.
Title
Title
Title
C5509 PROCESSOR MODULE
C5509 PROCESSOR MODULE
C5509 PROCESSOR MODULE
Size Document Number Rev
Size Document Number Rev
Size Document Number Rev
B
B
B
Date: Sheet
Date: Sheet
Date: Sheet
Tuesday, April 24, 2007
Tuesday, April 24, 2007
5
4
3
2
Tuesday, April 24, 2007
D301-04412
D301-04412
D301-04412
89
89
89
1
of
of
of
2.0
2.0
2.0
5
4
3
2
1
POWER SUPPLIES/RESETS
DC IN
(10V - 35V)
D D
J901J901
1
1
2
2
C C
12
+
+
C901
C901
10uF
10uF
50V
50V
12
12
C902
C902
1uF
1uF
50V
50V
12
R901
R901
100K
100K
C905
C905
0.1uF
0.1uF
50V
50V
5
6
2
7
U901
U901
LT3493
LT3493
VIN
SHDN
GND
GND_PAD
BOOST
D901
D901
3
12
C903
C903
0.1uF
0.1uF
16V
16V
4
SW
2 1
1
FB
DL4148
DL4148
L901
L901
1 2
10uH
10uH
D902
D902
B340-13
B340-13
21
12
12
C904
C904
22pF
22pF
50V
50V
R902
R902
59K
59K
12
R903
R903
11K
11K
TP906TP906
1
12
C906
C906
10uF
10uF
16V
16V
12
21
R906
R906
220
220
DS901
DS901
LED
LED
GRN
GRN
+5V
+5V
12
12
C907
C907
0.1uF
0.1uF
16V
16V
C909
C909
0.1uF
0.1uF
16V
16V
5
6
4
3
11
12
10
9
29
1
2
7
8
13
14
U902
U902
TPS767D301
TPS767D301
1INA
1INB
1EN#
1GND
2INA
2INB
2EN#
2GND
GND-PAD
NC1
NC2
NC3
NC4
NC5
NC6
1OUTA
1OUTB
1RESET#
1FB/SENSE
2OUTA
2OUTB
2RESET#
NC7
NC8
NC9
NC10
NC11
NC12
NC13
TP901TP901
USB VCC
+1.6V
+1.6V
+3.3V
+3.3V
/SH2-DSP PWR.C4
23
24
12
R904
R904
10.7K
28
25
17
18
22
15
16
19
20
21
26
27
10.7K
1 2
R905
R905
30.1K
30.1K
12
+
+
C908
C908
10uF
10uF
16V
16V
12
+
+
C910
C910
10uF
10uF
16V
16V
1
TP902TP902
1
12
+
+
C911
C911
47uF
47uF
10V
10V
12
12
+
+
FB901
FB901
BEAD3A
BEAD3A
C912
C912
10uF
10uF
16V
16V
12
TP903TP903
1
C913
C913
0.1uF
0.1uF
16V
16V
REGULATOR
5V TO 1.6V AND 3.3V
B B
+3.3V +1.6V
D903
D903
2 1
MMBD4148-7
MMBD4148-7
D904
D904
2 1
MMBD4148-7
MMBD4148-7
OPTIONAL CROSS COUPLING
D905
D905
2 1
MMBD4148-7
MMBD4148-7
TP904TP904
1
12
R908
R908
8.66K
8.66K
12
R909
R909
43K
43K
12
R910
R910
43K
43K
+3.3V+1.6V +3.3V+3.3V
U903
12
C914
C914
0.1uF
0.1uF
16V
16V
U903
TPS3307-18D
TPS3307-18D
8
VDD
1
SENSE1
2
SENSE2
3
SENSE3
7
#MR
#RESET
RESET
GND
12
R907
R907
10K
10K
5
6
4
RESET#
RESET
/SH1-DSP CTRL.B4
/SH4-CPLD.A4
/SH8-AD7677.B3
RESET CIRCUIT
A A
TP905TP905
1
5
4
SW901SW901
A1B
KNUDSEN ENGINEERING LTD.
KNUDSEN ENGINEERING LTD.
2
3
2
KNUDSEN ENGINEERING LTD.
Title
Title
Title
C5509 PROCESSOR MODULE
C5509 PROCESSOR MODULE
C5509 PROCESSOR MODULE
Size Document Number Rev
Size Document Number Rev
Size Document Number Rev
B
B
B
Date: Sheet
Date: Sheet
Date: Sheet
Wednesday, May 02, 2007
Wednesday, May 02, 2007
Wednesday, May 02, 2007
D301-04412
D301-04412
D301-04412
99
99
99
1
of
of
of
2.0
2.0
2.0
5
4
3
2
1
LONG PULSE TRANSMITTER MODULE - BULKHEAD
D D
SCHEMATIC INDEX :
Page 1 - WIDE RANGE INPUT & HV POWER
Page 2 - HV CURRENT LIMITER & +5V POWER
C C
Page 3 - TRANSMISSION
Page 4 - FILTER, PICKUP, CAPS, SD CIRCUIT
Page 5 - +15V POWER
B B
A A
KNUDSEN ENGINEERING LTD.
KNUDSEN ENGINEERING LTD.
KNUDSEN ENGINEERING LTD.
Title
Title
Title
LONG PULSE TRANSMITTER-BULKHEAD
LONG PULSE TRANSMITTER-BULKHEAD
LONG PULSE TRANSMITTER-BULKHEAD
Size Document Number Rev
Size Document Number Rev
Size Document Number Rev
B
B
B
Date: Sheet
Date: Sheet
Date: Sheet
Wednesday, June 06, 2007
Wednesday, June 06, 2007
5
4
3
2
Wednesday, June 06, 2007
D301-04375
D301-04375
D301-04375
1
00
00
00
2.00
2.00
2.00
of
of
of
5
4
WIDE RANGE INPUT TO CONSTANT HV OUTPUT
3
2
1
MT2MT2
1
TP101TP101
1
D103
D103
1.5KE39CA
1.5KE39CA
2
MT3MT3
1
POWER
1
D101
Q101
Q101
Si7846
Si7846
D4
G
D101
2 1
ES3CB
ES3CB
D102
D102
2 1
ES3CB
ES3CB
7
5
8
D1
D26D3
Q102
Q102
Si7846
Si7846
S2
S1
S3
1
3
2
Title
Title
Title
LONG PULSE TRANSMITTER-BULKHEAD
LONG PULSE TRANSMITTER-BULKHEAD
LONG PULSE TRANSMITTER-BULKHEAD
Size Document Number Rev
Size Document Number Rev
Size Document Number Rev
B
B
B
Date: Sheet
Date: Sheet
Date: Sheet
12
+
+
C105
C105
22uF
22uF
200V
200V
12
R110
R110
330K
330K
12
R111
R111
6.04K
6.04K
KNUDSEN ENGINEERING LTD.
KNUDSEN ENGINEERING LTD.
KNUDSEN ENGINEERING LTD.
D301-04375
D301-04375
Tuesday, July 10, 2007
Tuesday, July 10, 2007
Tuesday, July 10, 2007
D301-04375
L101
L101
1 2
47uH
47uH
L102
C110
C110
0.01uF
0.01uF
50V
50V
C114
C114
0.01uF
0.01uF
50V
50V
L102
1 2
47uH
47uH
R10310R103
1 2
10
R10910R109
1 2
10
12
+
+
C117
C117
2.2uF
2.2uF
25V
25V
12
+
+
C119
C119
10uF
10uF
16V
16V
+12V
8
D4
G
4
S1
R102
R102
1 2
0.015
0.015
1W
1W
7
5
D1
D26D3
S2
S3
1
3
2
4
R107
R107
1 2
0.015
0.015
1W
1W
2
12
MT4MT4
MT5MT5
1
5
C101
C101
10uF
10uF
50V
50V
VIN
/SH5-LTC3780.D5
1
MT6MT6
C102
C102
10uF
10uF
50V
50V
1
12
MT7MT7
C103
C103
10uF
10uF
50V
50V
C111
C111
0.01uF
0.01uF
50V
50V
1
12
+
+
12
12
MT8MT8
C104
C104
680uF
680uF
50V
50V
R101
R101
825K
825K
R105
R105
274K
274K
U101
U101
LT3782
LT3782
27
12
C109
C109
2.2uF
2.2uF
50V
50V
12
C112
C112
1uF
1uF
16V
16V
MT9MT9
1
1
4
MT10MT10
MT11MT11
1
fsync2
/SH5-LTC6908.A4
fsync2 = 392.156kHz
R104
R104
1 2
60.4K
60.4K
12
R106
R106
1 2
80.6K
80.6K
12
12
C115
C115
100pF
100pF
50V
50V
12
1
C113
C113
22pF
22pF
50V
50V
R108
R108
13K
13K
C116
C116
6800pF
6800pF
50V
50V
VCC
5
SYNC
2
SGATE1
1
SGATE2
17
RUN
14
SS
10
SLOPE
6
DELAY
7
DCL
11
RSET
15
VC
3
NC1
18
NC2
25
NC3
26
NC4
4
GND
29
POWERPAD
D104
D104
S1B
S1B
VR101
VR101
LM317AEMP
LM317AEMP
12
C118
C118
0.1uF
0.1uF
50V
50V
IN3OUT1
OUT2
ADJ
1
12
R113
R113
866
866
3
BGATE1
VEE1
SENSE1+
SENSE1-
BGATE2
VEE2
SENSE2+
SENSE2-
GBIAS
GBIAS1
GBIAS2
21
2
4
23
24
8
1 2
9
20
19
13
1 2
12
16
FB
28
22
21
TP102TP102
1
12
R112
R112
100
100
12
12
HV
12
+
+
C106
C106
330uF
330uF
200V
200V
15
15
15
1
HV
2.00
2.00
2.00
of
of
of
D D
J101
J101
INPUT
INPUT
1
1
2
2
C C
B B
A A
MT1MT1
1
5
4
3
2
1
HV CURRENT LIMITER & +5V POWER
D D
HIGH VOLTAGEHV CURRENT LIMITER
HV
C C
TP201TP201
1
Q201
Q201
2SD1264A
2SD1264A
E3C
2
12
12
C201
C201
1uF
1uF
250V
250V
R202
R202
15K
15K
25W
25W
B
1
8
1
4
5
VR201
VR201
TL431
TL431
REF
CATHODE
NC1
NC2
R201
R201
1 2
10
10
2W
2W
ANODE1
ANODE2
ANODE3
ANODE4
7
6
3
2
D201
D201
2 1
S3M
S3M
12
21
R203
R203
27K
27K
1W
1W
DS201
DS201
LED
LED
GRN
GRN
+5 VOLTAGE REGULATOR
TP202TP202
1
HV RAIL
TP203TP203
1
B B
A A
5
4
+15V
VR202
VR202
LM2937
LM2937
VOUT
3
1
12
C202
C202
0.1uF
0.1uF
50V
50V
3
VIN
2
Gnd1
4
Gnd2
TP204TP204
1
12
C203
C203
10uF
10uF
50V
50V
2
+5V
+5V
KNUDSEN ENGINEERING LTD.
KNUDSEN ENGINEERING LTD.
KNUDSEN ENGINEERING LTD.
Title
Title
Title
LONG PULSE TRANSMITTER-BULKHEAD
LONG PULSE TRANSMITTER-BULKHEAD
LONG PULSE TRANSMITTER-BULKHEAD
Size Document Number Rev
Size Document Number Rev
Size Document Number Rev
B
B
B
Date: Sheet
Date: Sheet
Date: Sheet
Wednesday, June 06, 2007
Wednesday, June 06, 2007
Wednesday, June 06, 2007
D301-04375
D301-04375
D301-04375
1
25
25
25
2.00
2.00
2.00
of
of
of
5
4
3
2
1
HV RAIL
TRANSMISSION
w/ISOLATION
+15V +15V
12
C303
C303
0.1uF
0.1uF
50V
50V
U301
U301
IRS2110S
11
12
14
13
4
5
9
10
16
15
IRS2110S
VDD
HIN
LIN
SHDN
NC1
NC2
NC3
NC4
NC5
VSS
3
VCC
8
Y
HO
7
VB
6
VS
1
B
LO
2
COM
R30122R301
1 2
12
12
C304
C304
C305
C305
10uF
10uF
0.1uF
0.1uF
50V
50V
50V
50V
12
12
C306
C306
C307
C307
4.7uF
4.7uF
4.7uF
4.7uF
50V
50V
50V
50V
D301
D301
Z5248
Z5248
2 1
R30210R302
1 2
10
D304
D304
Z5248
Z5248
2 1
22
D302
D302
DL4148
DL4148
D303
D303
MURS120
MURS120
R30522R305
1 2
22
D305
D305
DL4148
DL4148
21
+15V
21
21
NC2
+15V
12
C302
C302
0.1uF
0.1uF
50V
50V
6
V+
7
5
8
+5V
12
C301
D D
U302
U302
HCPL-0738
HCPL-0738
2
R303
R303
1 2
220
220
R304
R304
1 2
220
220
C C
1
3
4
Cathode 1
Anode 1
Cathode 2
Anode 2
8
VDD
7
Y
Vo1
6
B
Vo2
5
Gnd
C301
0.1uF
0.1uF
50V
50V
1
2
4
3
U303
U303
EL7212
EL7212
NC1
IN A
IN B
GND
OUT A
OUT B
2
D
Q301
S
3
2
D
S
3
Q301
IXFX120N20
IXFX120N20
Q302
Q302
IXFX120N20
IXFX120N20
Y
OUT_A
B
/SH4-FILTER.A5
G
1
G
1
J301
J301
TX IN
TX IN
1
Y -
1
2
Y +
2
3
B -
3
4
B +
4
5
X -
5
6
X +
6
7
A -
7
8
A +
8
B B
R308
R308
1 2
220
220
R309
R309
1 2
220
220
A A
5
U305
U305
HCPL-0738
HCPL-0738
2
Cathode 1
1
Anode 1
3
Cathode 2
4
Anode 2
X
A
VDD
Gnd
Vo1
Vo2
+5V
12
C308
C308
0.1uF
0.1uF
50V
50V
U306
U306
EL7212
EL7212
8
7
6
5
1
NC1
2
IN A
4
IN B
3
GND
SD
/SH4-LM211.C2
4
V+
OUT A
OUT B
NC2
12
C309
C309
0.1uF
0.1uF
50V
50V
6
7
5
8
+15V +15V+15V
R30622R306
1 2
12
C310
C310
0.1uF
0.1uF
50V
50V
U304
U304
IRS2110S
11
12
14
13
4
5
9
10
16
15
IRS2110S
VDD
HIN
LIN
SHDN
NC1
NC2
NC3
NC4
NC5
VSS
3
3
VCC
8
X
HO
7
VB
6
VS
1
A
LO
2
COM
12
12
12
C311
C311
10uF
10uF
50V
50V
C313
C313
4.7uF
4.7uF
50V
50V
C312
C312
0.1uF
0.1uF
50V
50V
12
C314
C314
4.7uF
4.7uF
50V
50V
D306
D306
Z5248
Z5248
2 1
R30710R307
1 2
10
D309
D309
Z5248
Z5248
2 1
2
22
D307
D307
21
DL4148
DL4148
+15V
D308
D308
21
MURS120
MURS120
R31022R310
1 2
22
D310
D310
21
DL4148
DL4148
KNUDSEN ENGINEERING LTD.
KNUDSEN ENGINEERING LTD.
KNUDSEN ENGINEERING LTD.
Title
Title
Title
LONG PULSE TRANSMITTER-BULKHEAD
LONG PULSE TRANSMITTER-BULKHEAD
LONG PULSE TRANSMITTER-BULKHEAD
Size Document Number Rev
Size Document Number Rev
Size Document Number Rev
B
B
B
Date: Sheet
Date: Sheet
Date: Sheet
Wednesday, June 06, 2007
Wednesday, June 06, 2007
Wednesday, June 06, 2007
HV RAIL
2
D
Q303
S
3
2
D
S
3
Q303
IXFX120N20
IXFX120N20
Q304
Q304
IXFX120N20
IXFX120N20
1
G
1
G
1
D301-04375
D301-04375
D301-04375
X
/SH4-FILTER.A5
OUT_B
A
2.00
2.00
2.00
of
of
of
35
35
35
5
TX FILTER,CAPS,SD CCT
4
HV RAIL
3
2
1
CAPACITOR BANK
C401
C401
2700uF
2700uF
200V
200V
R402
R402
0.020
0.020
1W
1W
12
+
+
12
R403
R403
0.020
0.020
1W
1W
12
+
+
D D
POWER
12
C402
C402
2700uF
2700uF
200V
200V
12
R404
R404
0.020
0.020
1W
1W
12
+
+
12
C403
C403
2700uF
2700uF
200V
200V
R405
R405
0.020
0.020
1W
1W
12
+
+
12
R406
R406
0.020
0.020
1W
1W
SHUTDOWN
CIRCUIT
C C
B B
12
R409
R409
3.9K
3.9K
12
R4131KR413
1K
12
R4101KR410
1 2
1K
12
12
R4141KR414
C407
C407
1K
0.1uF
0.1uF
50V
50V
C404
C404
2700uF
2700uF
200V
200V
12
R411
R411
680
680
R407
R407
0.020
0.020
1W
1W
12
+
+
C405
C405
2700uF
2700uF
200V
200V
12
R408
R408
0.020
0.020
1W
1W
+15V+5V
12
C406
C406
0.1uF
0.1uF
50V
50V
5
8
U401
U401
2
+
+
7
C
C
3
-
-
LM211
LM211
64 1
12
R401
R401
2.7K
2.7K
25W
25W
+15V
12
R412
R412
10K
10K
TP401TP401
1
SD
DISCHARGE RELAY
K401
K401
G6S-2F-DC12
G6S-2F-DC12
4
9
1
12
/SH3-IRS2110S.A4
3
5
10
8
SERIES PICK-UP
F401
T401
T401
1 5
6
4 7
XFMR FILTRAN
XFMR FILTRAN
FILTER
D405
21
3
D405
2 1
S3M
S3M
D408
D408
S3M
S3M
21
JP402JP402
1 2
D404
21
D404
2 1
S3M
S3M
D407
D407
S3M
S3M
D403
L401
L401
5
1 2
18uH
18uH
L402
L402
1 2
18uH
18uH
12
C409
C409
0.18uF
0.18uF
250V
250V
12
12
C410
C410
0.18uF
0.18uF
250V
250V
C408
C408
1.8uF
1.8uF
250V
250V
T402
T402
2 3
1 4
KEL_TFMR
KEL_TFMR
4
/SH3-FETS.D1
OUT_A
A A
/SH3-FETS.B1
OUT_B
D403
2 1
S3M
S3M
D406
D406
S3M
S3M
F401
1 2
1.5A
1.5A
F402
F402
1 2
1.5A
1.5A
J402
J402
3PIN-SABRE-HV
3PIN-SABRE-HV
3A
3A
3B
3B
2A
2A
2B
2B
1A
1A
1B
1B
1
D401
D401
P0300SARP
P0300SARP
2
TO TRANSDUCER
KNUDSEN ENGINEERING LTD.
KNUDSEN ENGINEERING LTD.
KNUDSEN ENGINEERING LTD.
Title
Title
Title
LONG PULSE TRANSMITTER-BULKHEAD
LONG PULSE TRANSMITTER-BULKHEAD
LONG PULSE TRANSMITTER-BULKHEAD
Size Document Number Rev
Size Document Number Rev
Size Document Number Rev
B
B
B
Date: Sheet
Date: Sheet
Date: Sheet
Tuesday, June 12, 2007
Tuesday, June 12, 2007
2
Tuesday, June 12, 2007
1
D402
D402
P0300SARP
P0300SARP
2
J401 J401
1
1
2
RECEIVE SIGNAL
2
3
3
4
4
JP401JP401
1 2
NOTE: Jumper normally left unconnected.
D301-04375
D301-04375
D301-04375
45
45
45
1
2.00
2.00
2.00
of
of
of
5
+ 15V POWER
VIN
/SH1-J101.C4
D D
+6V
4
3
12
C502
C502
4.7uF
4.7uF
50V
50V
12
C503
C503
4.7uF
4.7uF
50V
50V
2
D501
D501
21
S1B
S1B
VR501
VR501
LM317AEMP
LM317AEMP
12
C504
C504
0.1uF
0.1uF
50V
50V
IN3OUT1
2
4
OUT2
ADJ
1
1
+6V
12
R502
R502
100
100
+6V
12
C505
C505
1uF
1uF
16V
16V
12
R504
R504
10K
10K
R5050R505
1 2
0
12
12
C511
C511
1000pF
1000pF
50V
50V
C514
C514
0.1uF
0.1uF
50V
50V
for Vpllfltr = 2.4V, f = 400kHz.
R513
R513
1 2
100K
100K
C517
C517
0.01uF
0.01uF
50V
50V
C520
C520
0.01uF
0.01uF
50V
50V
R5210R521
1 2
0
R5230R523
1 2
0
R5250R525
1 2
0
R5260R526
1 2
0
fsync1
fsync1 = 392.156kHz
12
C516
C516
1000pF
1000pF
50V
50V
OUT1
OUT2
MOD
12
12
4
5
6
12
12
C518
C518
47pF
47pF
50V
50V
C521
C521
0.022uF
0.022uF
50V
50V
fsync1
fsync2
R515
R515
0
0
DNI
DNI
R519
R519
0
0
DNI
DNI
12
12
2
1
3
7
12
R50710R507
10
D505
D505
52C36
52C36
2 1
C515
C515
0.01uF
0.01uF
50V
50V
R512
R512
10K
10K
U502
U502
LTC6908
LTC6908
V+
SET
GND
GND_PAD
C C
12
R508
R508
220K
220K
2 1
12
D506
D506
52C4V7
52C4V7
C522
C522
0.1uF
0.1uF
50V
50V
+6V
12
R510
R510
0
0
DNI
DNI
12
R511
R511
0
0
DNI
DNI
R524
R524
1 2
255K
255K
+6V
12
12
5
12
R509
R509
0
0
DNI
DNI
B B
+5V
A A
12
C512
C512
4.7uF
4.7uF
50V
50V
/SH1-LT3782.C3
4
22
30
21
23
10
11
31
19
7
6
8
3
5
U501
U501
LTC3780
LTC3780
EXTVCC
PGOOD
INTVCC
FCB
VIN
RUN
PLLFLTR
PLLIN
ITH
STBYMD
SS
SGND
PGND
TG2
BOOST2
TG1
BOOST1
SW2
SW1
BG1
BG2
SENSE+
SENSE-
VOSENSE
GND_PAD
32
NC19NC212NC313NC416NC525NC628NC729NC8
21
15
14
26
27
17
24
20
18
1
12
2
4
33
D502
D502
MBRS140
MBRS140
C510
C510
1 2
0.22uF
0.22uF
16V
16V
C519
C519
100pF
100pF
50V
50V
3
21
1 2
R514
R514
1 2
1.24K
1.24K
R520
R520
1 2
1.24K
1.24K
D503
D503
MBRS140
MBRS140
C513
C513
0.22uF
0.22uF
16V
16V
G
4
7
5
8
D1
D4
D26D3
Q501
G
4
8
7
D4
S1
1
Q501
Si4450
Si4450
7
5
S2
S1
S3
1
3
2
L501
L501
1 2
4.7uH
4.7uH
5
D1
D26D3
Q504
Q504
D507
D507
Si4450
Si4450
B340-13
S2
S3
2
3
2 1
12
B340-13
R516
R516
0.020
0.020
1W
1W
8
D1
D4
D26D3
D504
D504
Q502
G
4
G
4
12
R517
R517
0.020
0.020
1W
1W
Q502
B340-13
B340-13
Si4450
Si4450
S2
S1
S3
1
3
2
7
8
D4
D26D3
S2
S1
1
2
2
2 1
5
D1
Q503
Q503
Si4450
Si4450
S3
3
12
12
Title
Title
Title
LONG PULSE TRANSMITTER-BULKHEAD
LONG PULSE TRANSMITTER-BULKHEAD
LONG PULSE TRANSMITTER-BULKHEAD
Size Document Number Rev
Size Document Number Rev
Size Document Number Rev
B
B
B
Date: Sheet
Date: Sheet
Date: Sheet
12
R503
R503
383
383
JP501JP501
1
2
12
C506
C506
22uF
22uF
25V
25V
R518
R518
113K
113K
R522
R522
21.5K
21.5K
KNUDSEN ENGINEERING LTD.
KNUDSEN ENGINEERING LTD.
KNUDSEN ENGINEERING LTD.
Tuesday, July 10, 2007
Tuesday, July 10, 2007
Tuesday, July 10, 2007
12
12
C507
C507
22uF
22uF
25V
25V
C508
C508
22uF
22uF
25V
25V
J501J501
12
+
+
C509
C509
330uF
330uF
50V
50V
1
1
2
2
Vout = 0.8(1+ R518/R521)
D301-04375
D301-04375
D301-04375
3
55
55
55
1
of
of
of
+15V
TP501TP501
1
12
R506
R506
1.6K
1.6K
1/2W
1/2W
21
DS501
DS501
LED
LED
GRN
GRN
+15V
2.00
2.00
2.00
5
J1J1
AC/DC IN
1
1
J2J2
EXTERNAL FUSE
J3J3
DC IN
MT3MT3
1
2
2
1
1
2
2
F12AF1
MT4MT4
12
+
+
12
1
1 2
3 4
C1
C1
33uF
33uF
63V
63V
C5
C5
1uF
1uF
25V
25V
2A
12
+
+
12
C2
C2
33uF
33uF
63V
63V
C6
C6
8200pF
8200pF
50V
50V
12
+
+
C3
C3
33uF
33uF
63V
63V
12
C7
C7
330pF
330pF
50V
50V
1
1
2
2
1
D D
A
B
C C
B B
MT1MT1
A A
C
MT2MT2
1
1
D2
D2
1.5KE39CA
1.5KE39CA
2
12
R2
21KR221K
4
D1
D1
1
3
30CTH02S
30CTH02S
2
3
4
1
11
9
8
2
5
10
13
14
21
U1
LM5005U1LM5005
VIN1
VIN2
VCC
SS
RAMP
RT
SD
SYNC
AGND
PGND1
PGND2
POWERPAD
+5V SUPPLY
COMP
BST
SW1
SW2
PRE
OUT
3
20
18
17
19
16
IS1
15
IS2
12
7
FB
6
12
C4
C4
0.022uF
0.022uF
50V
50V
C10
C10
1 2
3000pF
3000pF
50V
50V
D3
B380-13D3B380-13
2 1
C11
C11
1 2
750pF
750pF
50V
50V
L1
1 2
33uHL133uH
R5
1 2
13.7KR513.7K
2
12
12
+
+
+
+
C8
12
R3
3.09KR33.09K
12
R41KR4
1K
C8
68uF
68uF
16V
16V
C9
C9
68uF
68uF
16V
16V
12
R1
R1
330
330
1/2W
1/2W
21
DS1
DS1
LED
LED
GRN
GRN
1
2
1
2
1
2
1
2
1
2
1
2
1
2
1
2
1
2
3
4
5
6
7
8
J4
OUTPUTJ4OUTPUT
1
2
J5
OUTPUTJ5OUTPUT
1
2
J6
OUTPUTJ6OUTPUT
1
2
J7
OUTPUTJ7OUTPUT
1
2
J8
OUTPUTJ8OUTPUT
1
2
J9
OUTPUTJ9OUTPUT
1
2
J10
J10
OUTPUT
OUTPUT
1
2
J11
J11
OUTPUT
OUTPUT
1
2
J12 J12
1
2
3
4
5
6
7
8
1
+5V OUT
KNUDSEN ENGINEERING LTD.
KNUDSEN ENGINEERING LTD.
KNUDSEN ENGINEERING LTD.
Title
Title
Title
POWER DISTRIBUTION MODULE
POWER DISTRIBUTION MODULE
POWER DISTRIBUTION MODULE
Size Document Number Rev
Size Document Number Rev
Size Document Number Rev
B
B
B
Date: Sheet
Date: Sheet
Date: Sheet
Friday, February 09, 2007
Friday, February 09, 2007
5
4
3
2
Friday, February 09, 2007
D301-04414
D301-04414
D301-04414
1
11
11
11
1.00
1.00
1.00
of
of
of
5
4
3
2
1
POWER SUPPLIES
D D
J102J102
1
1
2
2
DC IN
(10V - 35V)
J101J101
C C
B B
A A
1
1
2
2
12
+
+
C102
C102
10uF
10uF
50V
50V
12
12
C103
C103
1uF
1uF
50V
50V
12
R101
R101
100K
100K
C108
C108
0.1uF
0.1uF
50V
50V
5
6
2
7
U101
U101
LT3493
LT3493
VIN
SHDN
GND
GND_PAD
BOOST
D101
D101
3
12
C101
C101
0.1uF
0.1uF
50V
50V
4
SW
2 1
1
FB
DL4148
DL4148
L101
L101
1 2
10uH
10uH
D102
D102
B340-13
B340-13
21
12
12
C107
C107
22pF
22pF
50V
50V
12
R103
R103
59K
59K
R106
R106
11K
11K
12
TP101TP101
C109
C109
10uF
10uF
16V
16V
1
21
DS101
DS101
LED
LED
GRN
GRN
12
R105
R105
499
499
1/2W
1/2W
+5V
JP101JP101
1
3
2
+5V
U102
U102
MIC5219-3.3
MIC5219-3.3
1
VIN
3
EN/SDN
2
12
C104
C104
1uF
1uF
50V
50V
GND
VOUT
BYP
5
4
12
C105
C105
470pF
470pF
100V
100V
21
DS102
C106
C106
22uF
22uF
16V
16V
MT101MT101
12
1
DS102
LED
LED
GRN
GRN
R104
R104
330
330
1/2W
1/2W
12
+
+
TP102TP102
1
MT102MT102
1
+3.3V
12
R102
R102
1.5K
1.5K
MT103MT103
1
+3.3V
MT104MT104
1
KNUDSEN ENGINEERING LTD.
KNUDSEN ENGINEERING LTD.
KNUDSEN ENGINEERING LTD.
Title
Title
Title
4-PORT USB HUB
4-PORT USB HUB
Size Document Number Rev
Size Document Number Rev
Size Document Number Rev
B
B
B
Date: Sheet
Date: Sheet
Date: Sheet
Tuesday, September 04, 2007
Tuesday, September 04, 2007
5
4
3
2
Tuesday, September 04, 2007
4-PORT USB HUB
D301-04495
D301-04495
D301-04495
1
1.00
1.00
1.00
of
of
of
12
12
12
5
U201
R202
R202
15K
15K
C209
C209
4.7uF
4.7uF
25V
25V
12
12
12
C210
C210
4.7uF
4.7uF
25V
25V
C213
C213
0.1uF
0.1uF
50V
50V
C217
C217
0.1uF
0.1uF
50V
50V
U201
UPD720114
UPD720114
47
21
22
13
9
20
30
48
2
1
17
19
18
16
15
14
37
12
24
33
VBUSM
DMU
DPU
BUS_B
VDD33(1)
VDD33(2)
VDD33(3)
VDD33REG
VSSREG
VDD25OUT
AVDD1
AVDD2
AVSS
AVSS(R)
RREF
TEST
SYSRSTB
VDD25(1)
VDD25(2)
VDD25(3)
4-PORT USB HUB
R201
R201
1 2
10K
10K
12
C208
C208
0.1uF
0.1uF
50V
50V
12
C212
C212
4.7uF
4.7uF
25V
25V
1 2
12
C216
C216
0.1uF
0.1uF
50V
50V
R207
R207
2.43K
2.43K
12
12
12
C202
D D
J201J201
USB IN
1
1
2
2
3
3
4
4
5
5
+3.3V
12
C206
C206
0.1uF
0.1uF
50V
50V
C C
1 2
12
C211
C211
0.1uF
0.1uF
50V
50V
1 2
BEAD3A_60ohm
BEAD3A_60ohm
+3.3V
12
R210
R210
10K
10K
B B
12
C214
C214
1uF
1uF
50V
50V
C202
1uF
1uF
50V
50V
12
C207
C207
0.1uF
0.1uF
50V
50V
FB201
FB201
BEAD3A_60ohm
BEAD3A_60ohm
FB202
FB202
12
C215
C215
0.1uF
0.1uF
50V
50V
4
DM1
DP1
DM2
DP2
DM3
DP3
DM4
DP4
AMBER
GREEN
LED1
LED2
LED3
LED4
PPB1
CSB1
PPB2
CSB2
3
VBUS1
25
26
VBUS2
28
29
31
32
34
35
X201
R216
R216
0
0
DNI
DNI
X201
30MHz
30MHz
1
12
R212
R212
10K
10K
12
R217
R217
0
0
DNI
DNI
3
2
12
R204
R204
10K
10K
12
12
R214
R214
R213
R213
10K
10K
510K
510K
U202
U202
MIC2026
MIC2026
4
ENB
3
FLGB
1
ENA
2
FLGA
12
R218
R218
0
0
DNI
DNI
X2
X1
10
8
7
6
5
4
3
45
46
43
44
1 2
1 2
1 2
1 2
+3.3V
+3.3V
R205
R205
330
330
R206
R206
330
330
R208
R208
330
330
R209
R209
330
330
12
0
R211
R211
510K
510K
12
R2030R203
1 2
11
OUTB
OUTA
GND
12
C203
C203
0.1uF
0.1uF
50V
50V
VBUS4+3.3V
12
C205
C205
0.1uF
0.1uF
50V
50V
21
DS201
DS201
LED
LED
GRN
GRN
5
8
7
IN
12
C220
C220
1uF
1uF
50V
50V
6
1
2
3
4
5
1
2
3
4
5
21
DS202
DS202
LED
LED
AMBER
AMBER
F201
F201
1 2
PTC
PTC
2.5A
2.5A
1 2
1 2
J203J203
USB2
J205J205
USB4
R215
R215
0
0
DNI
DNI
1
2
3
4
5
1
2
3
4
5
JP201JP201
21
VBUS3
DS203
DS203
LED
LED
GRN
GRN
+5V
12
C201
C201
0.1uF
0.1uF
50V
50V
12
C204
C204
0.1uF
0.1uF
50V
50V
21
DS204
DS204
LED
LED
AMBER
AMBER
FB203
FB203
1 2
BEAD3A_60ohm
BEAD3A_60ohm
12
+
+
C218
C218
220uF
220uF
16V
16V
2
J202J202
USB1
1
1
2
2
3
3
4
4
5
5
J204J204
USB3
1
1
2
2
3
3
4
4
5
5
21
DS207
DS207
LED
LED
GRN
GRN
21
DS208
DS208
LED
LED
AMBER
AMBER
21
DS205
DS205
LED
LED
GRN
GRN
VBUS1
12
+
+
21
DS206
DS206
LED
LED
AMBER
AMBER
FB204
FB204
1 2
BEAD3A_60ohm
BEAD3A_60ohm
C219
C219
220uF
220uF
16V
16V
VBUS2
1
12
12
R220
R220
R219
R219
10K
10K
510K
510K
23
A A
5
VSS1
27
VSS2
36
VSS3
42
VSS4
PPB3
CSB3
PPB4
CSB4
4
40
41
38
39
12
12
R222
R222
R221
R221
510K
510K
10K
10K
4
3
1
2
U203
U203
MIC2026
MIC2026
ENB
FLGB
ENA
FLGA
OUTB
OUTA
GND
JP202JP202
5
8
7
IN
12
C223
C223
1uF
1uF
50V
50V
6
3
1 2
R223
R223
1 2
0
0
DNI
DNI
FB205
FB205
1 2
BEAD3A_60ohm
BEAD3A_60ohm
12
+
+
C221
C221
220uF
220uF
16V
16V
VBUS3
FB206
FB206
1 2
BEAD3A_60ohm
BEAD3A_60ohm
12
+
+
C222
C222
220uF
220uF
16V
16V
2
VBUS4
KNUDSEN ENGINEERING LTD.
KNUDSEN ENGINEERING LTD.
KNUDSEN ENGINEERING LTD.
Title
Title
Title
4-PORT USB HUB
4-PORT USB HUB
Size Document Number Rev
Size Document Number Rev
Size Document Number Rev
B
B
B
Date: Sheet
Date: Sheet
Date: Sheet
Tuesday, September 04, 2007
Tuesday, September 04, 2007
Tuesday, September 04, 2007
4-PORT USB HUB
D301-04495
D301-04495
D301-04495
1
of
of
of
22
22
22
1.00
1.00
1.00
0.000
0.325
1.275
5.175
5.725
0.0000.000
0.200
2.000
6-32 drill and tap
4 places
3.800
4.500
5.200
7.000
8.800
9.000
6.675
10.575
11.225
16.075
16.375
CSOS-632-4
insert this side
25 places
0.000
0.500
3.500
5.500
8.500
0.000
0.125
0.250
PROJECT:
SHEET:
DRAWN:
DESIGN:
ENGINEER:
SIZE D
D. Gibson
D. Gibson
3U Rack
TITLE Lower PCB Plate
D203-05110FILE:
D209-05110KEL I.D.:
SCALE:
NTS
6-32 drill and tap
3/8" deep
8 places
4) All dimensions are in inches
3) FINISH: break all sharp edges and remove burrs
2) MATERIAL: 1/4" aluminum
1) TOLERANCES: ± 0.005 inches unless specified
NOTES:
- timesave and clear anodize
REV
Prototype1
10-02-17
DATEDESCRIPTION
3.600 (B)
0.000
0.200
1.000
0.625
3.56 (C)
3.500
2.425
4.900
3.900
6.800
7.000
0.000
0.125
0.250
0.0000.000
0.325
1.000
1.375
2.250
3.000
3.925
4.375
5.000
5.600
7.975
8.425
9.200
9.675
10.250
12.025
12.475
0.000
A A A A A A A A
B B
B
B
6-32 drill and tap
8 places
0.825
3.425
6-32 drill and tap
3/8" deep
16 places
4.875
B
B
7.475
8.925
B
insert other side
CSOS-632-4
12 places
B
C
11.525
CSOS-632-4
insert this side
24 places
12.975
BB
C
14.810
15.375
16.075
16.375
PROJECT:
SHEET:
DRAWN:
DESIGN:
ENGINEER:
SIZE D
D. Gibson
D. Gibson
3U Rack
TITLE Upper PCB Plate
D203-05111FILE:
D209-05111KEL I.D.:
SCALE:
NTS
0.000
0.125
0.250
AAAAAAA A
0.000
0.500
AAAAAAA A
2.500
4.500
6.500
15.575
4) All dimensions are in inches
3) FINISH: break all sharp edges and remove burrs
2) MATERIAL: 1/4" aluminum
1) TOLERANCES: ± 0.005 inches unless specified
NOTES:
- timesave and clear anodize
REV
Prototype1
10-02-17
DATEDESCRIPTION
0.000
0.250
0.450
0.585
1.735
1.870
0.0000.000
0.250
4 places
6-32 drill and tap
0.680
1.305
1.930
2.350
2.600
4) All dimensions are in inches
3) FINISH: break all sharp edges and remove burrs
2) MATERIAL: 1/8" aluminum
- timesave and clear anodize
1) TOLERANCES: ± 0.005 inches unless specified
NOTES:
PROJECT:
SHEET: SCALE:
KEL I.D.:
FILE:
D203-05118
4-40 drill and tap
2 places
3.500
3.750
DESIGN:
ENGINEER:
D. Gibson
D. Gibson
Production Release1 10-03-08
TITLE:DRAWN:
D209-051183U Rack
AC Plate
DATEDESCRIPTIONREV
1=1SIZE A
0.000
0.325
0.450
0.600
1.000
2.125
3.000
3.350
3.700
3.825
4.594
5.000
5.406
0.000
0.844
1.250
1.656
0.916
0.694
1.584
2.644
2.794
1/8" radius
3.700
#6 clearance hole, 4 places
4) All dimensions are in inches
NOTES:
1) TOLERANCES: ± 0.005 inches unless specified
2) MATERIAL: Part number IMP-5: Manu Strongbox
3) FINISH: break all sharp edges and remove burrs
6.844
7.250
7.656
8.700
9.094
9.500
ENGINEER:
DESIGN:
DRAWN:
PROJECT:
SHEET: NTS
3U Rack Case
D. Gibson Connector Panel
D. Gibson
TITLE
KEL I.D.:
D203-05120
D209-05120
9.906
11.344
11.750
12.156
12.750
14.000
14.118
15.024
15.142
Ø 1.00
REV DESCRIPTION DATE
4-40 drill and tap, 18 places
Production Release1 10-03-12
SCALE:FILE:
0.000
0.000
3.220
3.970
5.220
4) All dimensions are in inches
3) FINISH: break all sharp edges and remove burrs
2) MATERIAL: Part number FP-5: Manu Strongbox
1) TOLERANCES: ± 0.005 inches unless specified
NOTES:
SHEET: NTS
3U Rack Case
D. Gibson Front Panel
D. Gibson
TITLE
KEL I.D.:
D203-05121
D209-05121
15.500
16.640
REV DESCRIPTION DATE
Production Release1 10-03-12
ENGINEER:
DESIGN:
DRAWN:
PROJECT:
SCALE:FILE:
19.000
22-01-3047
1
Use crimp tool 11-01-0185Ffor 08-50-0114 crimps
22-01-3047
342
Strip outer sheath back 1". Heatshrink over cut end.
ENGINEER:
DESIGN:
DRAWN: TITLE:
PROJECT:
1 of 1
D. Gibson
N. PRETTY
4
Red
White
3
Green
2
22-01-3047
1
Black
1
REV DESCRIPTION DATE
2 Production Release
FILE:
KEL I.D.:
D215-04203
D219-04203
SCALE:SHEET:
NTS
1
22-01-3047
Receive Signal Cable
11-06-13
22-01-3087
Use crimp tool 11-01-0185Ffor 08-50-0114 crimps
22-01-3087
1
BROWN
22-01-3087
4
342
WHITE
3
GREEN
786
Strip outer sheath back 1". Heatshrink over cut end
ENGINEER:
DESIGN:
DRAWN: TITLE:
PROJECT:
8
ORANGE
BLACK
7
6
5
BLUE
5
2
1
YELLOW
RED
1
REV DESCRIPTION DATE
3 Production Release
1 of 1
FILE:
KEL I.D.:
D215-04204
D219-04204
SCALE:SHEET:
NTS
D. Gibson
Drive Signal Cable
N. PRETTY
22-01-3087
1
11-05-30
Back View of 39-01-2025
39-01-2025
Confirm good crimp prior to insertion into 39-01-2025
Use crimp tool 63811-5000 for 39-00-0039 crimps
1
2
39-01-2025
1
2
83049-10
83049-4
PROJECT:
SIZE A 1=1
FILE:
KEL I.D.:
D215-04316
D219-04316
SCALE:SHEET:
DRAWN: TITLE:
D. Gibson USB Hub Power Input
ENGINEER:
DESIGN:
2
1
Confirm good crimp prior to insertion into housing
use crimp tool 11-01-0185 for 08-50-0114 crimps
22-01-3027
1
22-01-3027
REV DESCRIPTION DATE
2
Connector Change
11-06-13
Install heat shrink over solder connections
Ground Tab
Center Pin
1
2
83049-10
83049-9
Confirm good crimp prior to insertion into housing
use crimp tool 11-01-0185 for 08-50-0114 crimps
PROJECT:
SIZE A 1=1
FILE:
KEL I.D.:
D215-04317
D219-04317
SCALE:SHEET:
DRAWN: TITLE:
D. Gibson BNC Cable
ENGINEER:
DESIGN:
1
2
1
REV DESCRIPTION DATE
2 Production Release 11-06-13
Back View of 39-01-2025
1
2
2
1
Cut wires to proper length after twisting
9918-xxx-4 YELLOW
9918-xxx-10 BLACK
PROJECT:
1 of 1
FILE:
KEL I.D.:
D215-04550
D219-04550
SCALE:SHEET:
DRAWN: TITLE:
D. Gibson
Module Power Cable
2
1
ENGINEER:
DESIGN:
39-01-202539-01-2025
Confirm good crimp prior to insertion into 39-01-2025
Use crimp tool 63811-5000 for 39-00-0039 crimps
N. PRETTY
39-01-202539-01-2025
REV DESCRIPTION DATE
2 Production release
11-05-30
NTS
22-01-3057
Use crimp tool 11-01-0185 for 08-50-0114 crimps
1
22-01-3057
Cut wires already twisted and install heat shrink over cable
5
83049-2
6
Use crimp tool 11-01-0185 for 08-50-0114 crimps
ENGINEER:
DESIGN:
DRAWN: TITLE:
PROJECT:
5
83049-9
342
83049-5
4
3
22-01-3067
83049-10
1
2
83049-10
1
REV DESCRIPTION DATE
2 Production Release
1 of 1
FILE:
KEL I.D.:
D215-04551
D219-04551
SCALE:SHEET:
NTS
D. Gibson
Module USB Cable
N. PRETTY
1
22-01-3067
11-06-13
5) twist wires until tight
AML31FBA4AD
CABLE ASSEMBLY INSTRUCTIONS
1) Use crimps 39-00-0039 and tool 63811-5000 for part 39-01-2025
2) Use crimps 39-00-0182 and tool 63811-5000 for part 39-01-2080
3) Use crimps 770476-1 and tool 63811-0400 for part 640250-5
4) Install heatshrink over switch connections
12
Blk
640250-5
1
2
3
4
5
9918-xxx-5 GREEN
22-01-3027
Schematic View
2
83049-xxx-10 BLACK
1
94724
1
83049-xxx-2 RED
ENGINEER:
DESIGN:
DRAWN: TITLE:
PROJECT:
12
9918-xxx-10 BLACK
9918-xxx-9 WHITE
AML31FBA4AD
21
22
83049-xxx-2 RED
11
9918-xxx-10 BLACK
9918-xxx-9 WHITE
83049-xxx-10 BLACK
Actual View (twisted)
22
11
Red
21
1
39-01-2025
REV DESCRIPTION DATE
1 PRODUCTION DESIGN
1 of 1
FILE:
KEL I.D.:
D215-04583
D219-04583
SCALE:SHEET:
NTS
J. MITCHELL
Power Switch
J. MITCHELL
N. PRETTY
1
640250-5
2
1
8
1
2
3
5
4
39-01-20280
6
7
39-01-2025
1
94724
5
1
Back View
8
4
39-01-2080
14 Apr 2010
719W-00/04
719W-00/04
Loop each wire through the terminal prior to soldering
Install heat shrink to each terminal
Install heat shrink over entire back of 719W-00/04 after
installation in echosounder
N
1
L
9918-9
39-01-2021
2
9918-10
E
9918-5
1
94724
N
L
N - Neutral
L - Line
Back View
E
E - Earth ground
719W-00/04
Front View
Cut wires to proper length after twisting
PROJECT:
1 of 1
FILE:
KEL I.D.:
D215-04584
D219-04584
DRAWN: TITLE:
D. Gibson
AC Input Assembly
Ensure proper fuse installed
(install spare as well)
ENGINEER:
DESIGN:
Use ring terminal crimp tool on appropraite colour setting
Add small amount of solder into crimp to ensure connection
Install heat shrink over entire crimp leaving ring exposed
REV DESCRIPTION DATE
1 Production Release
N. PRETTY
Use crimp tool 63811-5000 for 39-00-0041 crimps
Confirm good crimp prior to insertion into39-01-2021
1
94724
39-01-2021
SCALE:SHEET:
14 Apr 2010
NTS
3
BCA
8918-10
2
MS3470W12-3S
Back View
C A
B
Thread on M83723/15N12R after wire insertion into MS3470W12-3S
but prior to installation of 44441-2003-P
Use crimp tool M22520/1-10 (18awg setting) on crimps supplied with connector
Insert crimps into MS3470W12-3S using blue/white insertion toolregen
8918-5
8918-9
1
Cut wires to proper length after twisting
1 of 1
FILE:
44441-2003-P
PROJECT:
REV DESCRIPTION DATE
ENGINEER:
DESIGN:
DRAWN: TITLE:
2
Use crimp tool 63811-0400 (setting B) for 43375-0001 crimps
Ensure insulation properly bound
D. Gibson
Add small amount of solder into crimp to ensure connection
N. PRETTY
Wire Change
KEL I.D.:
Back View
D215-04585
D219-04585
SCALE:SHEET:
NTS
TX Output Cable
321
44441-2003-P
1
11-09-29
39-01-2245
39-01-2245
8
1
6
9918-9 White
2
39-01-2025
9918-10 Black
Back View
6
8
131
Use crimp tool 63811-5000 for 39-00-0039 crimps
Confirm good crimp prior to insertion into housings
Cut wires to proper length after twisting
12
24
PROJECT:
1 of 1
FILE:
KEL I.D.:
D215-05094
D219-05094
SCALE:SHEET:
NTS
DRAWN: TITLE:
DG / JM
AC Supply Output
ENGINEER:
DESIGN:
N. PRETTY
1
39-01-2025
REV DESCRIPTION DATE
3 Production Release
11-09-29
USBFAA_6
VCC
USBFAA_6
SHIELD
GND
D+
D-
PROJECT:
1 of 1
FILE:
KEL I.D.:
D215-05103
D219-05103
DRAWN: TITLE:
D. Gibson
USB Input Cable
2
Black
1
Shield
REV DESCRIPTION DATE
1 Production Release
White
4
Green
3
22-01-3057
Red
Strip outer sheath back 1". Heatshrink over cut end.
ENGINEER:
DESIGN:
N. PRETTY
Use crimp tool 11-01-0185 for 08-50-0114 crimps
22-01-3057
1
5
SCALE:SHEET:
11-06-13
NTS
CABLE LENGTHS AND CONNECTIONS
Model:
Part Number:
D219-05103-Rev1
USB Input Cable
3"
Connecotor Panel - USB Interface (ECF504-BAS)
USB Hub - J201
Chirp 3200
D229-04401-Rev3.01
PART NUMBER NAME DESCRIPTION LENGTH FROM TO
D219-04203-Rev2 Receive Signal Cable Channel 1 16" Channel 1 LPTM - J401 Channel 1 USB Processor Module - J701
D219-04204-Rev3 Drive Signal Cable Channel 1 6" Channel 1 USB Processor Module - J404 Channel 1 LPTM - J301
D219-04316-Rev2 Hub Power 9" PDM USB Hub - J102
D219-04317-Rev2 BNC Cable Channel 1 Analog Out 6" Connector Panel - Analog Out 1 Channel 1 USB Processor Module - J801
D219-04317-Rev2 BNC Cable Channel 2 Analog Out 6" Connector Panel - Analog Out 2 Channel 2 USB Processor Module - J801
D219-04317-Rev2 BNC Cable Channel 3 Analog Out 9" Connector Panel - Analog Out 3 Not Connected
D219-04317-Rev2 BNC Cable Channel 4 Analog Out 9" Connector Panel - Analog Out 4 Not Connected
D219-04317-Rev2 BNC Cable Sync In 9" Connector Panel - Sync In Channel 1 USB Processor Module - J402
D219-04317-Rev2 BNC Cable Sync Out 9" Connector Panel - Sync Out Channel 1 USB Processor Module - J403
D219-04550-Rev2 Module Power Cable Channel 1 USB Processor Module 16" PDM - J9 Channel 1 USB Processor Module - J901
D219-04550-Rev2 Module Power Cable Channel 1 - LPTM 21" PDM - J10 Channel 1 LPTM - J101
D219-04551-Rev2 Module USB Cable Channel 1 16.5" USB Hub - J202 Channel 1 USB Processor Module - J501
D219-04583-Rev1 Power Switch Input 20" Switch - 39-01-2025 AC Input Cable
D219-04584-Rev1 AC Input Cable 4" Connector Panel - AC Input Plate Power Switch - 39-01-2025
D219-04585-Rev2 Transmit Output Cable Channel 1 24" Connector Panel - Transducer Output 1 Channel 1 LPTM - J402
D219-05094-Rev3 AC Supply Output 4.5" AC Supply PDM - J3
Output 17" Switch - 640250-5 AC Supply Input
Bulb 25" Switch - 39-01-2080 PDM - J12
Ground 6" 640250-5 Chassis
Loading...