Kleenmaid KCRHSO6010, KCRHSO9010 Instructions For Use And Warranty Details

Download

Page 1

cooking collection

Instructions for use and warranty details

Slide Out Rangehood

Model No.: KCRHSO6010

Model Nos.: KCRHSO6010 (60cm) & KCRHSO9010 (90cm)

Page 2

Dear Customer,

Thank you and congratulations for choosing Kleenmaid.

Your new appliance has been designed and meticulously tested to ensure that it meets all your culinary requirements, and has been carefully manufactured using top quality materials to give you years of reliable performance.

For best results, carefully read the instructions on how your new appliance is to be installed. Correct installation will avoid delays and unnecessary service call costs.

Once installation is complete, please read this instruction manual carefully and get to know the controls and the features of your new Kleenmaid appliance. These simple instructions will enable you to achieve excellent results from the very ﬁrst time you use it.

Again, congratulations and thank you for choosing The Best You Can Own.

KLEENMAID

Page 3

Page 4

Page 5

Page 6

Page 7

Page 8

Page 9

Page 10

Page 11

Page 12

Page 13

Page 14

Page 15

Page 16

EN - Instruction on mounting and use

Closely follow the instructions set out in this manual. All

responsibility, for any eventual inconveniences, damages or fires caused by not complying with the instructions in this manual, is declined. The hood is conceived for the suction of cooking fumes and steam and is destined only for domestic use. ! It is important to conserve this booklet for consultation at

any moment. In the case of sale, cession or move, make sure it is together with the product.

! Read the instructions carefully: there is important

information about installation, use and safety.

! Do not carry out electrical or mechanical variations on the

product or on the discharge conduits.

! It is important to conserve this booklet for consultation at

any moment. In the case of sale, cession or move, make sure it is together with the product.

! Read the instructions carefully: there is important

information about installation, use and safety.

! Do not carry out electrical or mechanical variations on the

product or on the discharge conduits. Note: the elements marked with the symbol “(*)” are optional accessories supplied only with some models or elements to purchase, not supplied.

Caution

WARNING! Do not connect the appliance to the mains until

the installation is fully complete. Before any cleaning or maintenance operation, disconnect hood from the mains by removing the plug or disconnecting the mains electrical supply. Always wear work gloves for all installation and maintenance operations. The appliance is not intended for use by children or persons with impaired physical, sensorial or mental faculties, or if lacking in experience or knowledge, unless they are under supervision or have been trained in the use of the appliance by a person responsible for their safety. This appliance is designed to be operated by adults, children should be monitored to ensure that they do not play with the appliance. This appliance is designed to be operated by adults. Children should not be allowed to tamper with the controls or play with the appliance. Never use the hood without effectively mounted grating! The hood must NEVER be used as a support surface unless specifically indicated. The premises where the appliance is installed must be sufficiently ventilated, when the kitchen hood is used together with other gas combustion devices or other fuels. The ducting system for this appliance must not be connected to any existing ventilation system which is being used for any other purpose such as discharging exhaust fumes from appliances burning gas or other fuels. The flaming of foods beneath the hood itself is severely prohibited. The use of exposed flames is detrimental to the filters and

may cause a fire risk, and must therefore be avoided in all circumstances. Any frying must be done with care in order to make sure that the oil does not overheat and ignite. Accessible parts of the hood may became hot when used with cooking appliance. With regards to the technical and safety measures to be adopted for fume discharging it is important to closely follow the regulations provided by the local authorities. The hood must be regularly cleaned on both the inside and outside (AT LEAST ONCE A MONTH). This must be completed in accordance with the maintenance instructions provided in this manual). Failure to follow the instructions provided in this user guide regarding the cleaning of the hood and filters will lead to the risk of fires. Do not use or leave the hood without the lamp correctly mounted due to the possible risk of electric shocks. We will not accept any responsibility for any faults, damage or fires caused to the appliance as a result of the nonobservance of the instructions included in this manual. This appliance is marked according to the European directive 2002/96/EC on Waste Electrical and Electronic Equipment (WEEE). By ensuring this product is disposed of correctly, you will help prevent potential negative consequences for the environment and human health, which could otherwise be caused by inappropriate waste handling of this product.

The symbol accompanying the product, indicates that this appliance may not be treated as household waste. Instead it should be taken to the appropriate collection point for the recycling of electrical and electronic equipment. Disposal must be carried out in accordance with local environmental regulations for waste disposal. For further detailed information regarding the process, collection and recycling of this product, please contact the appropriate department of your local authorities or the local department for household waste or the shop where you purchased this product.

Additional Installation Specifications:

Use only the fixing screws supplied with the product for installation. Use the correct length screws which are identified in the Installation Guide WARNING! Failure to install the screws or fixing device in accordance with these instructions may result in electrical hazards.

on the product, or on the documents

Page 17

Use

The hood is designed to be used either for exhausting or filter version.

Ducting version

In this case the fumes are conveyed outside of the building by means of a special pipe connected with the connection ring located on top of the hood. Attention! The exhausting pipe is not supplied and must be purchased apart. Diameter of the exhausting pipe must be equal to that of the connection ring. In the horizontal runs the exhausting pipe must be slightly slanted (about 10°) and directed upwards to vent the air easily from the room to the outside. Attention! If the hood is supplied with active charcoal filter, then it must be removed.

Connect the hood and discharge holes on the walls with a diameter equivalent to the air outlet (connection flange).

! Use a duct of the minimum indispensible length. ! Use a duct with as few elbows as possible (maximum

elbow angle: 90°).

! Avoid drastic changes in the duct cross-section. ! Use a duct as smooth as possible inside. ! The duct must be made of certified material. Attention! If the hood is supplied with carbon filter, then it must be removed.

Filter version

One active charcoal filter is needed for this and can be obtained from your usual retailer. The filter removes the grease and smells from the extracted air before sending it back into the room through the upper outlet grid.

Attention! If the hood is not supplied with carbon filter, then it must be ordered and mounted.

standards which assures the complete disconnection of the mains under conditions relating to over-current category III, in accordance with installation instructions. Warning! Before re-connecting the hood circuit to the mains supply and checking the efficient function, always check that the mains cable is correctly assembled. The hood is provided with a special power cable ; if the cable is damaged, request a new one from Technical Service.

Mounting

Before beginning installation:

• Check that the product purchased is of a suitable size for the chosen installation area. Remove the charcoal (*) filter/s if sup

• relative paragraph). if you want lo

•

Check (for transport reasons) that there is no other supplied material inside the hood screws (*), guarantees (*), etc.), eventually removing them and keeping them.

• If possible, disconnect and move freestanding or slide-in range from cabinet opening to provide easier access to rear wall/ceiling. Otherwise put covering over count from damage and debris. Select a flat surface for assembling the unit. Cover that surface with a protective covering and

in it

•

In addition check whether near the installation hood (in the area accessible also with the hood mounted) an electric socket is available and it is possible to connect a fumes discharge device to the outside (only suction version). Carry out all the masonry work necessary (e.g.

• installation of an electric socket and/or a hole for the passag

This hood is designed for fitting in a cabinet or on support.

use the hood in the filtering version.

e of the discharge tube).

This/these is/are to be mounted only

ertop,

cooktop or range to protect

place all canopy hood parts and hardware

plied (see also

(e.g. packets with

a thick, protective

area of the

some other

Installation

The minimum distance between the supporting surface for the cooking equipment on the hob and the lowest part of the range hood must be not less than 50cm from electric cookers and 65cm from gas or mixed cookers. If the instructions for installation for the gas hob specify a greater distance, this must be adhered to.

Electrical connection

The mains power supply must correspond to the rating indicated on the plate situated inside the hood. If provided with a plug connect the hood to a socket in compliance with current regulations and positioned in an accessible area, after installation. If it not fitted with a plug (direct mains connection) or if the plug is not located in an accessible area, after installation, apply a double pole switch in accordance with

Page 18

Operation

The hood is fitted with a control panel with aspiration speed selection control and a light switch to control cooking area lights.

Maintenance

ATTENTION! Before performing any maintenance operation,

isolate the hood from the electrical supply by switching off at the connector and removing the connector fuse. Or if the appliance has been connected through a plug and socket, then the plug must be removed from the socket.

Cleaning

The cooker hood should be cleaned regularly (at least with the same frequency with which you carry out maintenance of the fat filters) internally and externally. Clean using the cloth dampened with neutral liquid detergent. Do not use abrasive products. DO NOT USE ALCOHOL! WARNING: Failure to carry out the basic cleaning recommendations of the cooker hood and replacement of the filters may cause fire risks. Therefore, we recommend observing these instructions. The manufacturer declines all responsibility for any damage to the motor or any fire damage linked to inappropriate maintenance or failure to observe the above safety recommendations.

Grease filter - Fig. 10-21

Traps cooking grease particles. The grease filter must be cleaned once a month using non

aggressive detergents, either by hand or in the dishwasher, which must be set to a low temperature and a short cycle. When washed in a dishwasher, the grease filter may discolour slightly, but this does not affect its filtering capacity. To remove the grease filter, pull the spring release handle.

a. ON/OFF light switch b. Speed 1/OFF switch c. 2-speed selection d. 3-speed selection

Use the high vapours. It is recommended that the cooker hood suction is switched on for 5 minutes prior to cooking and to leave in operation during cooking and for another 15 minutes approximately after terminating cooking.

suction speed in cases of concentrated kitchen

Charcoal filter (filter version only) - Fig. 20

It absorbs unpleasant odours caused by cooking.

The saturation of the charcoal filter occurs after more or less prolonged use, depending on the type of cooking and the regularity of cleaning of the grease filter. In any case it is necessary to replace the cartridge at least every four mounths. The charcoal filter may NOT be washed or regenerated.

Remove the grease filters. Apply one charcoal filter each side and hook in onto the hood. Refit the grease filter.

Replacing lamps

Disconnect the hood from the electricity. Warning! Prior to touching the light bulbs ensure they are cooled down. Extract the drawer completely. Remove the grill. Replace the damaged lamp. Use Ø35mm E14 28W halogen candle lamps only. Put the grill back. If the lights do not work, make sure that the lamps are fitted properly into their housings before you call for technical assistance.

Page 19

KLEENMAID WARRANTY TERMS AND CONDITIONS

1. Compass Capital Services Pty Ltd ABN 96 138 214 525 trading as Kleenmaid will provide parts and labour to you the customer as set out herein.

2. Kleenmaid’s Products come with guarantees that cannot be excluded under the Australian Consumer Law. You are entitled to a replacement or refund for a major failure and for compensation for any other reasonably foreseeable loss or damage. You are also entitled to have the goods repaired or replaced if the goods fail to be of acceptable quality and the failure does not amount to a major failure.

3. The benefits given to you under this Kleenmaid Warranty are in addition to other rights and remedies to which you may be entitled under the Australian Consumer Law in relation to the Product to which this Kleenmaid Warranty relates. Subject to the conditions below, the Product is warranted by Kleenmaid and/or its agents to be free from defects in materials and workmanship for the Warranty Period for normal Domestic Use.

4. Product Identification: -

a. Kleenmaid reserves the right to reject claims for any services or work where you cannot produce for verification

the serial number and a proof of purchase for the Product (including but not limited to the original invoice).

b. This Kleenmaid Warranty will be voided if the serial number for the Product cannot be verified. This is not

intended to exclude, restrict or modify any right or remedy to which you may otherwise be entitled under the consumer guarantee provisions of the Australian Consumer Law.

c. In the event that a request for repair is made against this Kleenmaid Warranty where the serial number for the

Product cannot be verified or you cannot produce for verification a proof of purchase for the Product (including but not limited to the original invoice), the repairer will not carry out any repairs on the Product and you will be charged a service call-out fee.

5. What is covered by this Kleenmaid Warranty: -

a. The Product is covered for faulty workmanship or parts that have failed under normal Domestic Use. b. Kleenmaid and/or its agents will determine by objective testing if there are any defects in the Product and/or

faulty workmanship. c. This Kleenmaid Warranty is only applicable if repairs on Products are carried out within Mainland Australia. d. This Kleenmaid Warranty: -

i. covers a Product purchased as new, manufactured for use in Mainland Australia;

ii. commences from the date of delivery of the Product;

iii. provides for the labour and replacement parts necessary to maintain the Product in good operating condition

as specified in this Kleenmaid Warranty, however, if repair is needed because of Product failure during normal Do mestic Use, Kleenmaid has the option to repair or replace the defective Product or part of the Product with a product or part of like kind and quality. A replacement part may be new or reconditioned of like kind and quality an d may cost less than the original Product purchased and no charges or refunds will be made based on the replacement product or part cost difference; and

iv. is only applicable when the Product is used and operated in accordance with the Manufacturer’s instructions.

6. What is not Covered by this Kleenmaid Warranty (excluded):- a. any damage or failure to or of the Product or part of the Product:

i. due to the Product being inadequately serviced to manufacturer’s recommendations;

ii. resulting from environmental conditions including and not limited to dirt, dust, rodents, insects, rust,

corrosion, salt built-up, of or in any part of the Product; iii. resulting from excessive use but fair wear and tear is excepted; iv. resulting from poor installation including and not limited to positioning and externally fitted equipment

such as plumbing and drainage, cabling, antennae or due to incompatibility of connected equipment;

v. caused by overheating as a result of sitting or positioning of the Product, where there is no provision for

adequate ventilation or adequate protection from excessive dust; vi. if the Product has been dismantled, repaired or serviced by any person other than someone authorised by

Kleenmaid or its agents or representatives;

vii. caused by power surges or spikes, including and not limited to, mains power and telecommunications

connections, or to other unspecified sources, incorrect power current, voltage fluctuation, amperage

fluctuation, rust or corrosion;

viii. if the Product is dropped, collision of the Product with another object, use for which the Product is not

designed, damage to the Product caused by your own negligence, accidental or deliberate misuse of the

Product by you, theft, abuse, vandalism, flood, fire, earthquake, electrical storms or any other act of God

or any war related events; or ix. due to the introduction of abnormal heat loads to the Product;

b. costs of attendance and testing where no fault or defect covered by the terms of this Kleenmaid Warranty is

identified in the Product; c. initial setup and installation of the Product; d. normal maintenance costs and costs incurred through the installation of items listed as requiring periodic

replacement; e. Products with removed or altered serial numbers; f. consumables such as but not limited to bulbs/globes, gl as s, s eals , filters, batteries and remote controls; g. removal and reinstallation of an internal component not performed by an authorised Kleenmaid agent or

representative or auth oris ed s erv ice centr e;

Page 20

h. cosmetic or structura l items; or i. any failures due to interference from or with other products and/or sources.

7. This Kleenmaid Warranty ceases if: a. the Product ceases to carry the original manufacturer’s serial number or is sold at an auction; b. the Product is rented; c. damage to the Product has occurred as listed in point 7a; or d. there is failure to pay monies owing on invoices as a result of non-warranty work been carried out at the request

of the end user as per point 16 below.

8. Neither Kleenmaid nor its representatives provide loan equipment under the terms of this Kleenmaid Warranty.

9. Any unauthorised access to the internal hardware of the Product will void this Kleenmaid Warranty.

10. Repair Notice: Products presented for repair may be replaced by refurbished Products of the same type rather than

being repaired. Refurbished part s may be used to repair the Products.

11. Replacement items are “like for like” and is not “new for old” and does not indicate in any way that a faulty Product

will be replaced with a new part or unit. “Like for like” may either be a quality checked, refurbished or reconditioned unit of the same or later batch of model/size/specifications

12. The cost of making a claim under this Kleenmaid Warranty is not covered by Kleenmaid, including any costs of

transportation or travel expenses between your home and your nearest authorised servic e agent.

13. Kleenmaid accepts no liability for items that are lost, damaged, or stolen as a result of freight, transport or storage. If

you are required to transport the Product to an authorised service centre, you must ensure that it is securely packed and insured.

14. On Public Holidays or other periods when regular busine ss a nd w holes ale opera tio ns are temporarily ceased,

repairer availability and warranty response times may extend bey ond the stand ar d response times due to the unavailability of repairers and parts.

15. For any repair performed on a Product under this Kleenmaid Warranty where no fault can be found, or the item is

deemed by Kleenmaid or an authorised agent, to be not faulty under this Kleenmaid Warranty, or the repair or fault is not covered under this Kleenmaid Warranty, a ‘No Fault Found’ fee is payable by you. Kleenmaid will advise you of this cost and seek your agreement to pay such costs before commencing such repair s.

16. Any repairs or services required that are outside the terms and conditions of this Kleenmaid Warranty can be

carried out at your request at your cost (including where the Product has not been installed or set up correctly). Kleenmaid will always advise you of this cost and seek your agreement to pay such costs before commencing such repairs. A credit card may be required prior to the commencement of such services.

17. Extra charges will be payable by the customer should the Product not be readily accessible without special

equipment, such as but not limited to cranes and lifts or should the Product be installed in a position that service access is blocked and/or repair work is not possible without uninstalling the Product to gain access.

18. You, the customer, may be entitled to purchase an extended warranty in respect of the Product. Any extended

warranty will not be issued by Kleenmaid but by a third party. Any extended warranty services will be provided directly by the third party as principal and not as agent for Kleenmaid, under their extended warranty terms and conditions and not under this Kleenmaid Warranty.

19. To make a claim under this Kleenmaid Warranty, please have your proof of purchase and the serial number of the

Product ready and call (02) 9310 1207 during business hours.

20. This Kleenmaid Warranty is given by:

Name: Compass Capital Services Pty Ltd ABN 96 138 214 525 trading as Kleenmaid Business address: Level 2, Suite 3, 204 Botany Rd, Alexandria NSW Australia 2015 Telephone: (02) 9310 1207

21. Definitions: a. Australian Consumer Law means the Competition and Consumer Act 2010 (Cth). b. Domestic Use means use of the Product for personal, domestic or household purposes. c. Kleenmaid means Compass Capital Services Pty Ltd ABN 96 138 214 525 trading as Kleenmaid. d. Mainland Australia means the following States and Territories of Australia: New South Wales, Victoria, South

Australia, Western Australia, Queensland, Tasmania, Northern Territory, Australian Capital Territory. e. Product means the appliance sold by Kleenmaid to you as evidenced by the original purchase invoice. f. Warranty Period means the period of 36 months for domestic use, 12 months for non-domestic use or such

alternative period as may be specified.

UPDATE NOTICE: This Kleenmaid Warranty is current as at 7 March 2017 but is subject to variation from time to time. For the latest version of the Kleenmaid Warranty, please see our website

http://www.kleenmaid-appliances.com.au/support/your-kleenmaid-warranty

or phone us on (02) 9310 1207 .

Page 21