Kleenmaid CH40S User Manual

COOKTOP

c o l l e c t i o n

Instructions for Use

and Warranty Details

Solid Hotplate Cooktops

CH40S - 600 mm Stainless Steel

CH41W - 600 mm White

CH42B - 600 mm Black

C

ongratulations on the purchase of your

new Kleenmaid appliance.This appliance
has been designed and manufactured to
give you years of reliable performance.

For best results, carefully read the
instructions on how to install your new appliance. Correct
installation will avoid delays and unnecessary service calls.

Once installation is complete, read this booklet and get to
know the controls and the features of your new appliance.

If you need further information call our

Customer Care Centre

1300 652 100

We reserve the right to alter the specifications with no
influence on the operation of the appliance.This instruction
manual cannot be reason for claim.

CONTENTS

General description . . . . . . . . . . . . . . . . . . . . . . . . . . 2

Use of controls . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

Use of pans . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

Cleaning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

Connections sheamtic . . . . . . . . . . . . . . . . . . . . . . . . . 7

Wiring diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

Warranty and service . . . . . . . . . . . . . . . . . . . . . . . . . 9

1

WARNING

MAKE

MAX
POWER - (W)

TYPE

TENSION

a) Repair of any fault in your hob must be carried out only by an
Authorized Repair Service, otherwise the guarantee is not valid.

b) The technical details and identification of the appliance are shown on
the specifition plate.

c) Consult his plate before procceding with electrical connection.

d) Electrical connection must be carried out by a specialist familiar with
the laws and official regulations governing such while they are not
covered by a pan.

Fill in the data table in the manual with all the data of the cooker that
appear on its label.

2

USE OF CONTROLS

Make sure that you operate the
right control for the burner you
wish to use

1

ELECTRICAL PLATES

Electrical plates have 6 positions giving
different heat outputs. Table 1, gives a
guide to these outputs.

To operate it, you may turn the control
to the left or to the right, as you wish.

GENERAL DESCRIPTION

USE O

4 ELECTRIC HOTPLATE

TYPE: EI-4E

1,5kW

1,5kW

2kW

2kW

USE OF PANS

3

135 W 165 W

1500W.p Hot

2000W.p Hot

175 W 220 W

250 W 500 W

300 W 850 W

750 W 1500 W

1150 W 2000 W

TABLE 1

012345 6

OFF LOW

Keep warm

Prepare

delicate sauces

and cremes

MEDIUM

Boil and roast

white meats,

fish or

puddings.

Boil potatoes,
pulses, soups

Prepare

sauces

HIGH

Boil and roast red

meats, minced meat,

omelettes.

Fry potatoes, fish,

pasta.

Boil relatively large

quantities of water

MINIMUM MÁXIMUM

Make sure that the diametre of the
pan is equal to or bigger than the
plate you are going to use.

The plate should not be lit without a
pan.
The base of the pan should be flat
and dry.

ELECTRICAL PLATES

4

IMPORTANT: First of all, switch off the equipment.

CLEANING

If your top is stainless steel, there are
adequate products available in shops that
you may use. Once it is clean, rinse the top
with water and a soft cloth.

If the top is enamelled, use soapy water to
clean it. Never use abrasive products or
pads. Immediately remove all stains of
vinegar, lemon and acids spillage in
general.

Clean electric plates immediately with water
and soap.Then, heat the plate slightly and rub
it with mewspaper.

5

INSTALLATION

Before the installation, please
check all measures of the
equipment and fit-in housing.

Cut out a piece of the worktop
following the instructions.
Equipment type “X” for fire
protection grade.

NOTE:
The worktop must be provided
with a shelf “A” so that the top
cannot be reached from inside,
due to the temperatures it
reaches.

Such shelf will be located once
the top has been fixed in the
worktop.

Place the hob face down on a
table, and after removing the
backing paper,affix the sealing
gasket all around the hob.
A: operating table
B: joint
C: Bottom cover

NOTE: DO NOT SILICONE SEAL THIS APPLIANCE TO THE WORK SURFACE.

150 Máx.

6

INSTALLATION

Then, place the hob in the cavity
in the woktop. Press down tightly
so that sealing joint is perfectly
closed.

Fix the 4 clamps underneath the
hob to the corresponding 4
corners of the cavity. (Clamps
and nuts are supplied in the
accessory bag).

7

CONNECTIONS SCHEAMTIC

The hot plate is supplied with a power cable
(N2GMH2G types) prepared for 220...240V AC.
If the type of connections to which the hotplate is to be installed is other than
220 to 240 V Ac rmove the cable and make the connection according to the
adjacent drawings. (The cable must support temperatures of up to 120ºC).
The hotplate must be connected to the mains with a plug that meets the EEC
7 publication or with a multi-pole with a distance between the open contacts
of a least 3 mm.

This device conforms to European directives 73/23/Cee and 89/336/CEE

Total power
Hotplate: 60 cms., 6,3kW

PLATE

60 cms 27,5 A 32 A220...240V~ 14 A 16 A220...240V~

Three phase ∆

Voltage Tensión

Protection

Int.nominal

by phases

Protección

Int.nominal

por fases

PLATE

60 cms 11 A 12 A380...400V~ 16 A 20 A380...400V~

Three phase ∆

Voltage Voltage

Protection

Int.nominal

by phases

Protection

Int.nominal

by phases

8

WIRING DIAGRAM

1 - Hot Plate 1500W

2 - Hot Plate 2000W

3 - Hot Plate 1500W

4 - Hot Plate 2000W

5 - Switch

6 - Switch

7 - Switch

8 - Switch

9 - Neon

10 - Main Block

COLOURS

T-R = Red

AZ = Blue

V-A = Green-Yelow

M = Brown

B = White

N = Black

WARRANTY AND SERVICE

DOMESTIC WARRANTY - FULL FIVE YEAR WARRANTY

In addition to all statutory rights which you, the Consumer, have under the relevant laws in
respect of this appliance,during the first five years of ownership as the original purchaser
of this Kleenmaid appliance, we guarantee that any fault caused by faulty material or
workmanship becoming apparent will be rectified free of charge for parts and labour,
provided that all service is performed during normal working hours by Kleenmaid or
their designated Agents.Where the appliance is installed outside the normal servicing
area of the above, the Purchaser must pay for the cost of transporting the appliance to and
from the Agent or the Agent’s travelling cost to and from the Purchaser’s home.

COMMERCIAL WARRANTY - ONE YEAR WARRANTY

When this appliance is installed in a commercial application, you, the Consumer, have
under the relevant laws in respect of this appliance, during your first one year of
ownership as the original purchaser of the Kleenmaid appliance, we guarantee that any
fault caused by faulty material or workmanship becoming apparent, will be rectified free
of charge for parts and labour, provided that all service is performed during normal
working hours by Kleenmaid or their designated Agents.Where the appliance is installed
outside the normal servicing area of the above, the Purchaser must pay for the cost of
transporting the appliance to and from the Agent or the Agent’s travelling cost to and from
the Purchaser’s home.

WHAT THESE WARRANTIES DO NOT COVER

We are not responsible for any damage or malfunction unless caused by a defect in
material or workmanship. This includes but is not limited to abuse, misuse, improper
installation and transportation damage.We are not responsible for any consequential
damages from any malfunction.

WARRANTY DOES NOT COVER REPLACEMENT OF LIGHT GLOBES OR
GLASS BREAKAGE DUE TO IMPACT

In case of fractured glass do not use your appliance.

WARRANTY REGISTRATION

Please complete the enclosed warranty card and post it to us or phone our Customer Call
Centre.

SERVICE ASSISTANCE

To assist you when phoning our Customer Call Centre number to arrange a service call
please complete the following details and have them ready when you call.

Model Number: Date of purchase:

Kleenmaid Store purchased from:

KLEENMAID CUSTOMER CALL CENTRE

CONTACT NUMBER

1300 652 100

Date of installation:

9

Other products in Kleenmaid’s

range of world’s best appliances:

• Washers

• Dryers

• Vacuum Cleaners

• Dishwashers

• Cooktops

• Cookware

• Rangehoods

• Ovens

• Refrigerators & Freezers

• Sinks & Taps

• Waste Disposals

Kleenmaid Head Office:

PO Box 5560, Maroochydore Business Centre, Queensland 4558

For sales information on the full range of quality
kitchen and laundry appliances, phone 13 13 08

*10-00

C60T060A1

Printed on recycled paper.