Kitchen and Home 5-ZG-36-SS, 5-ZSS-36X-LPG, 5-ZG-36-SS-LPG, 4-GCW, 4-GCW-LPG 5-GCW Instruction Manual

1

Instruction Manual

Built-In Gas Cooktop

5-ZG-36-SS, 5-ZG-36-SS-LPG 5-ZSS-36X, 5-ZSS-36X-LPG

4-GCW, 4-GCW-LPG 5-GCW, 5-GCW-LPG

2-GCW , 2-GCW-LPG 2-SSW , 2-SSW-LPG

2

BEFORE YOU BEGIN

Read this manual completely and carefully. Installation of this cooktop must conform with local codes, or in
the absence of local codes, with the National Fuel Gas Code. This appliance is ETL certified by Intertek.

Note to Consumer:
Keep the manual for future reference.
This appliance must be properly grounded.

- Proper installation is the responsibility of the installer..

- Product failure due to improper installation is not covered under the Warranty.

- Remove all tape and packaging..

- Make sure the burners are properly seated and level..

- Take the accessory pack out of the packing.

- Check to be sure that no cooktop parts have come loose during shipping.

- IMPORTANT – Observe all governing codes and ordinances.

NOTICE

− Prior to installation, make sure gas and pressure supplied is compatible with the appliance settings

− Settings of this appliance are stated on the rating label.

−

This gas cooktop is not connected to a combustion products evacuation device. Particular attention
shall be given to the relevant requirement regarding ventilation.

−

Use of this gas cooktop will produce heat, moisture and products of combustion. Ensure that the
kitchen is well ventilated. Keep a window open or install a mechanical ventilation device.

3

Contents

1. Close-up view......................................................................................04

2. Using your cooktop............................................................................05

3. Cleaning…………………………………................................................06

4. Useful tips…….....................................................................................07

5. Troubleshooting…...............................................................................08

6. Installation ….................……………....................................................09

7. Burners and nozzle specifications ...................................................13

8. Different types of gas ….....................................................................15

4

Congratulations for choosing this appliance, which you will find dependable and very easy to use.
This manual will explain how to achieve the best performance and also extend the life of your appliance.
Thank you

Close-up View

5-ZG-36-SS, 5-ZG-36-SS-LPG, 5-ZSS-36X, 5-ZSS-36X-LPG

5-GCW, 5-GCW-LPG

4-GCW, 4-GCW-LPG

2-GCW , 2-GCW-LPG , 2-SSW , 2-SSW-LPG

5

1. Small burner

2. Medium burner

3. Large burner

4. X Large wok burner

5. Ignitor

6. Safety device - If the flame accidentally goes out (spills, drafts, etc.), it stops the delivery
of gas to the burner.

7. Control knobs

Using your cooktop

Gas Burners

Position of the corresponding gas burner is indicated on each control knob.
Burners are different in size and power. Choose the most appropriate one for the diameter of the cookware
being used.
Each burner has following settings:
OFF
High
Low

Our cooktops are equipped with a safety device

The knob must be kept pressed for about 6 seconds after ignition until the flame/temperature has been
detected.
Ignition switch is integrated in the control knob.

To ignite a burner:

Simply press the corresponding knob and turn it in the counter-clockwise direction

to the high setting and keep pressed until the burner is lit.

Caution:

If the flame goes out accidentally, turn off the gas using the control knob and wait at least 1

minute before restarting it.

To turn off a burner:

Turn the knob in the clockwise direction until it stops at the OFF position.