Kingsford CBT1126W User Manual
OWNER’S MANUAL
Made from 75% Bagasse
(Environmentally Friendly Sugar
Cane Pulp By-product)
20” Rectangle Portable Charcoal Grill
Model No. CBT1126W
WARNING
FOR YOUR SAFETY:
For Outdoor Use Only
(outside any enclosure)
WARNING
FOR YOUR SAFETY:
1. Improper installation, adjustment, alteration,
service or maintenance can cause injury or
property damage.
2. Read the installation, operation and
maintenance instructions thoroughly before
installing or servicing this equipment.
3. Failure to follow these instructions could
result in fire or explosion, which could cause
property damage, personal injury or death.
4. This instruction manual contains important
information necessary for the proper
assembly and safe use of the appliance.
5. Read and follow all warnings and
instructions before assembling and using
the appliance.
6. Follow all warnings and instructions when
using the appliance.
7. Keep this manual for future reference.
Table of Contents
Important Safeguards . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Page 2
Exploded View & Hardware. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
Assembly Instructions. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
Operating Instructions. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
First Use . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Lighting Instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Cooking. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Controlling Flare-ups. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Tips. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Cleaning and Care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Product Registration . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Limited Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
California Proposition 65: Combustion by-products produced when using this product
contain chemicals known to the State of California to cause cancer, birth defects, and
other reproductive harm.
California Proposition 65: Wash your hands after handling this product.
Save these instructions for future reference.
If you are assembling this unit for someone else,
give this manual to him or her to read and save
for future reference.
Manufactured in China for: Blue Rhino Global Sourcing, Inc
Winston-Salem, NC USA • 1.800.762.1142, www.bluerhino.com
© 2011 Blue Rhino Global Sourcing, Inc. All Rights Reserved
Kingsford® and the Kingsford logo are registered trademarks of the Kingsford Products Company, LLC and are used under license
by Blue Rhino Global Sourcing, Inc. All rights reserved. CBT1126W-OM-103 ES
20” Rectangle Portable Charcoal Grill
Model No. CBT1126W
WARNING
FOR YOUR SAFETY
Do not store or use gasoline or other flammable liquids or vapors in the
vicinity of this or any other appliance.
DANGER: Failure to follow the dangers, warning and cautions in this manual may result in serious bodily injury or death, or in a fire or an explosion
causing damage to property.
WARNING:
This grill is for outdoor use only, and shall not be used in a building,
garage or any other enclosed area.
For residential use only. This grill is NOT for commercial use.
Never use charcoal that has been pre-treated with lighter fluid. Use only
a high grade plain charcoal, charcoal/wood mixture, lump charcoal or
cooking wood. The conversion to or attempted use of any other fuel
source in this charcoal grill is dangerous and will void your warranty.
This grill is not intended for and should never be used as a heater. TOXIC
fumes can accumulate and cause asphyxiation.
Do not use grill for indoor cooking. Toxic carbon monoxide fumes can
accumulate and cause asphyxiation.
This grill is safety certified for use in the United States and Canada only.
Do not modify for use in any other location. Modification will result in a
safety hazard and will void the warranty.
Do NOT operate, light or use this appliance within ten (10) feet (3.05 m)
of walls, structures or buildings.
Apartment Dwellers: Check with management to learn the requirements
and fire codes for using an a charcoal grill in your apartment complex.
If allowed, use outside on the ground floor with a ten (10) foot (3.05 m)
clearance from any structure. Do not use on or under balconies.
Minimum clearance from sides and back of unit to combustible
construction is 36 inches (91.4 cm). Do not use this appliance under any
type of overhang or roof.
Do not use gasoline, kerosene or alcohol for lighting.
Do not use in an explosive atmosphere. Keep grill area free and clear
from combustible materials, gasoline and other flammable vapors and
liquids.
Do not store or use gasoline or other flammable liquids or vapors within
25 feet (7.62 m) of this appliance.
Do not alter grill in any manner. Any altering will void your warranty.
Do not use the grill unless it is COMPLETELY assembled and all parts are
securely fastened and tightened.
This grill should be thoroughly cleaned and inspected on a regular basis.
Use only Blue Rhino Global Sourcing, Inc. factory authorized parts. The
use of any part that is not factory authorized can be dangerous and will
void your warranty.
Do not use this appliance without reading “Operating Instructions” in
this manual.
Do not touch metal parts of grill until it has completely cooled (about
45 min.) to avoid burns, unless you are wearing protective gear (pot
holders, gloves, BBQ mittens, etc.).
Never touch grates (charcoal or cooking), ashes or coals to see if they
are hot.
Do not use on wooden decks, wooden furniture or other combustible
surfaces.
Do not use in or on boats or recreational vehicles.
Position grill so wind can not carry ashes to combustible surfaces.
Do not use in high winds.
Never operate this appliance unattended.
Never lean over the grill when lighting.
Do not leave a lit grill unattended. Keep children and pets away from grill
at all times.
Do not attempt to move grill when in use. Allow the grill to cool (about
45 min.) before moving or storing.
When cooking, fire extinguishing materials shall be readily accessible. In
the event of an oil/grease fire, do not attempt to extinguish with water.
Use type BC dry chemical fire extinguisher or smother with dirt, sand or
baking soda.
Always open grill lid carefully and slowly as heat and steam trapped
within grill can severely burn you.
If grill has not been cleaned, a grease fire can occur that may damage
the product.
Do not place empty cooking vessels on the appliance while in operation.
Use caution when placing anything on the grill while the appliance is in
operation.
Never add lighting fluid to hot or even warm coals as flashback may
occur causing serious injury or damage to property.
Always place your grill on a hard, non-combustible level surface. An
asphalt or blacktop surface may not be acceptable for this purpose.
Do not remove the ashes until they are completely and fully
extinguished.
Live hot briquettes and coals can create a fire hazard.
Always empty the bottom bowl and grill after each use.
Do not place fuel (charcoal briquets, wood or lump charcoal) directly into
bottom of grill. Place fuel only on the charcoal pan/grid.
Do not allow charcoal to rest on the walls of grill. Doing so will greatly
reduce the life of the metal and finish of your grill.
Check to make sure the air vents are free of debris and ash before using
the grill.
Extinguished coals and ashes should be placed a safe distance from all
structures and combustible materials.
With a garden hose, completely wet the surface beneath and around grill
to extinguish any ashes, coals or embers which may have fallen during
the cooking or cleaning process.
Always wear protective gloves when adding fuel (charcoal briquets,
wood or lump charcoal) to retain desired heat level.
Keep all electrical cords away from a hot grill.
Always use a meat thermometer to ensure food is cooked to a safe
temperature.
Never cover entire cooking area with aluminum foil.
Use protective gloves when assembling this product.
Do not force parts together as this can result in personal injury or
damage to the product.
Death, serious injury or damage to property may occur if the above is not
followed exactly.
DANGER
Contact Blue Rhino Global Sourcing, Inc. at 1.800.762.1142 for assistance. Do not return to place of purchase.
For great recipes and tips, visit www.kingsford.com.
page no.
3
Parts List
1
Warming Rack
2
Handle
3
Lid Air Vent
4
Cooking Grid
5
Lid
6
Top Hinge (2)*
7
Bottom Hinge (2)*
8
Air Vent*
9
Charcoal Grid
10
Bottom Bowl
11
Lock (2)*
12
Rear Left Leg
55-09-333
55-11-398
55-14-794
55-11-399
55-11-400
55-15-330
55-15-329
55-10-102
55-11-401
55-11-402
55-09-443
55-11-103
Exploded View
1
2
18
3
4
5
13
Front Left Leg
14
Rear Leg Support
15
Front Leg Support
16
Rear Right Leg
17
Front Right Leg
18
Brand Plate*
* Pre-assembled
55-11-404
55-11-405
55-11-406
55-11-407
55-11-408
55-10-586
6
9
8
7
10
12
11
13
14
Hardware
A
Screw
M5x12 Nickel Plated Phillips Truss Head
15
7 pcs
16
17
Tools Required for Assembly (Not Included)
#2 Phillips Head Screwdriver 1 pc
B
C
D
E
F
G
H
J
I
Wing Bolt
Wing Nut
Wing Nut
Washer
Washer
Lock Washer
Lock Washer
Pin
Cotter Pin
M5x12 Nickel Plated
M5 Nickel Plated
M6 Nickel Plated
ø6 Nickel Plated
ø6 Heat Resistant
ø5 Nickel Plated
ø6 Nickel Plated
ø5x 32 Nickel Plated
ø1.2 x 30 Black Coated
4 pcs
1 pc
2 pcs
2 pcs
2 pcs
1 pc
2 pcs
2 pcs
2 pcs
Assembly Instructions
20” Rectangle Portable Charcoal Grill
Model No. CBT1126W
1
DO NOT RETURN PRODUCT TO STORE.
For assistance call Blue Rhino Global Sourcing, Inc. at
1.800.762.1142 toll free. Please have your owner’s manual
and model number available for reference.
For Easiest Assembly:
• To avoid losing any small components or hardware, assemble
your product on a hard level surface that does not have cracks
or openings.
• Clear an area large enough to layout all components and
hardware.
• When applicable, tighten all hardware connections by hand
first. Once the step is completed go back and fully tighten all
hardware.
• Follow all steps in order to properly assemble your product.
To complete assembly you will need:
• (1) Bag of charcoal.
Assemble Base
2
3
Typical assembly: approximately 20 minutes.
Attach Bottom Bowl
4
A
Attach Lid Air Vent and Handle
x 6
B
A
C
x 1
E
x 1
F
G
H
D
x 4
x 2
x 2
x 2
x 1
x 2
Contact Blue Rhino Global Sourcing, Inc. at 1.800.762.1142 for assistance. Do not return to place of purchase.
For great recipes and tips, visit www.kingsford.com.
page no.
5
5
Attach Lid
Insert Warming Rack
6
7
I
Insert Charcoal Grid and Cooking Grid
x 2
J
x 2
Lock Lid
Note: Lid must be locked before transporting.
8
Unlock Lid
Note: Always unlock and open lid before lighting.
Loading...