King Kooker Fire Pit User Manual
English
PORTABLE PROPANE FIRE PIT
ASSEMBLY INSTRUCTIONS
AND
USE AND CARE MANUAL
MODEL/SERIAL # __________
IMPROPER INSTALLATION, ADJUSTMENT, ALTERATION, SERVICE, MAINTENANCE
OR USE CAN CAUSE INJURY OR PROPERTY DAMAGE. READ THE INSTALLATION,
OPERATING AND MAINTENANCE INSTRUCTIONS THOROUGHLY BEFORE
INSTALLING OR SERVICING THE EQUIPMENT.
METAL FUSION, INC.
712 St. George Avenue.
Jefferson, LA 70121
If you have any problems or questions
Call Us Toll Free at
1-800-783-3885
7:30 A.M. to 3:30 P.M. CST • Monday through Friday
(504) 736-0201
www.kingkooker.com
FAILURE TO FOLLOW THESE INSTRUCTIONS
AND WARNINGS COULD RESULT IN FIRE, EXPLOSION, BURN HAZARD OR CARBON
MONOXIDE POISONING WHICH COULD CAUSE PROPERTY DAMAGE,
PERSONAL INJURY OR DEATH.
DANGER
If you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open flame.
3. If odor continues, keep away from the appliance and immediately call
your gas supplier or Fire Department.
Do not store or use gasoline or other flammable vapors and liquids in the vicinity
of this or any other appliance.
An LP-cylinder not connected for use shall not be stored in the vicinity of this or
any other appliance.
For Outdoor Use Only.
CARBON MONOXIDE HAZARD
DANGER
This appliance can produce carbon monoxide
which has no odor.
Using it in an enclosed space can kill you.
Never use this appliance in an enclosed space
such as a camper, tent, car or home.
FAILURE TO FOLLOW THESE INSTRUCTIONS AND WARNINGS COULD RESULT IN
FIRE, EXPLOSION, BURN HAZARD OR CARBON MONOXIDE POISONING WHICH COULD
CAUSE PROPERTY DAMAGE, PERSONAL INJURY OR DEATH.
2
READ AND UNDERSTAND BEFORE USING THIS PRODUCT
Throughout this manual the words appliance, burner and fire pit will be used
interchangeably to refer to the King Kooker® Outdoor Fire PIt.
1) This is an ATTENDED appliance. Do NOT leave this appliance unattended while
the burner is lit. Monitor the appliance when hot after use. Heated equipment can
remain at high temperatures which can cause burns long after operation.
2) Keep children, pets and unauthorized persons away from the appliance at all
times.
3) The use of alcohol, prescription or non-prescription drugs may impair your ability
to properly assemble or safely operate this appliance. Do NOT assemble or
operate this appliance if using alcohol, prescription or non-prescription drugs.
4) This appliance is for OUTDOOR use only. Do NOT use in a building, garage, tent
or any other enclosed area. Do NOT use in or on a recreational vehicle or boat.
NEVER use this appliance as a heater.
5) Do not locate this appliance under ANY overhead construction. Keep a minimum
clearance of 10 ft. (3.05m) from the sides, front and back of the appliance to ANY
construction. Keep the area clear of any combustible materials, gasoline and
other flammable vapors and liquids. Do not use on or under ANY apartment or
condo balcony or deck.
6) When operating, the appliance must be on a level, stable, noncombustible surface
such as brick, concrete or dirt. Not suitable are surfaces such as wood, asphalt or
plastic which may burn, blister or melt.
7) Check all fittings for leaks before each use. Keep the fuel supply hose away from
any heated surfaces. Only the LP hose/regulator assembly specified by Metal
Fusion, Inc. should be used with this appliance. This regulator is set for an outlet
pressure of 0.5 PSI.
8) The burner should be inspected before each use. If the burner is damaged, it must
be replaced before operating the appliance. Only the burner specified by Metal
Fusion, Inc. should be used with this appliance.
9) Do NOT obstruct flow of combustion air and/or ventilation air for fire pit.
10) When operating, have a Type BC or ABC fire extinguisher readily available.
11)
This appliance gets dangerously hot in use. Do NOT move the appliance when in use.
Allow the appliance to cool completely before moving or storing. Avoid bumping of or
impact with the appliance to prevent contact with hot appliance.
12)
ALWAYS
hair and clothing from coming into contact with the appliance while in use or
still hot.
keep a safe distance from the appliance when in operation.
ALWAYS keep
13) Solid fuels, such as wood, charcoal and paper, should never be burned in this
appliance.
3
14) In the event of rain, snow, hail, sleet or other forms of precipitation while in
operation, turn off the appliance burners and gas supply. Do not attempt to
move the appliance. Do not use this appliance if any part has been under water.
Immediately call a qualified service technician to inspect the appliance and to
replace any part of the control system and any gas control which has been
under water.
15) See Use and Care section for LP Gas Cylinder Information. A 20 pound
(9 kg) cylinder should be used with this appliance. The LP-gas supply cylinder
used must have a protective collar and must be constructed and marked in
accordance with the specifications for LP-gas cylinders of the U. S. Department
of Transportation (DOT) or the National Standard of Canada, CAN/CSA-B339,
Cylinders, Spheres and Tubes for the Transportation of Dangerous Goods. Do
not store a spare LP-gas cylinder under or near this appliance. Never fill the
cylinder beyond 80% full. For proper vapor withdrawal, the 20 lb. (9 kg) cylinder
should be used in the proper upright position. Cylinder must be turned off while
not in use. Failure to follow these instructions and warnings could result in fire
or explosion which could cause property damage, personal injury or death.
16) This appliance is not intended for commercial use.
17) Use King Kooker® appliances only in accordance with state and local ordinances,
or in the absence of local codes, with the National Fuel Gas Code, ANSIZ223.1/
NFPA 54, Storage and Handling of Liquefied Petroleum Gases, ANSI/NFPA 58 or
CSA B149.1, Natural Gas and Propane Installation Code.
Children and adults should be alerted to the hazards of high surface
temperatures and flames and should stay away to avoid burns or clothing
ignition.
Young Children should be carefully supervised when they are in the area
of the appliance.
Clothing or other flammable materials should not be hung from the
appliance, or placed on or near the appliance.
Any guard or other protective device removed for servicing the appliance
must be replaced prior to operating the appliance.
Installation and repair should be done by a qualified service person. The
appliance should be inspected before use and at least annually by a
qualified service person. More frequent cleaning may be required as
necessary. It is imperative that control compartment, burners, and
circulating air passageways of the appliance be kept clean.
FAILURE TO FOLLOW THESE INSTRUCTIONS AND WARNINGS COULD RESULT IN
FIRE, EXPLOSION, BURN HAZARD OR CARBON MONOXIDE POISONING WHICH
COULD CAUSE PROPERTY DAMAGE, PERSONAL INJURY OR DEATH.
4
READ AND UNDERSTAND ALL INSTRUCTIONS BEFORE
USING YOUR KING KOOKER® PRODUCT
TABLE OF CONTENTS
Warnings. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-4
Table of Contents .......................................................................................................................5
Warranty ...............................................................................................................................6
Owner’s Registration ..................................................................................................................7-8
Section I - King Kooker® Fire Pit Assembly .................................................................................................9
Brass Fitting with Manual Valve Assembly Instructions ...................................................................................10
Lava Rock Instructions ............................................................................................................10
Sandbag Filling Instructions ........................................................................................................11
Section II - Use and Care ................................................................................................................12
LP Gas Cylinder Information ........................................................................................................12
Connection Instructions ...........................................................................................................13
Leak Test Instructions .............................................................................................................13
Placement Instructions ............................................................................................................14
Lighting and Operating Instructions ..................................................................................................15
Turning Off and Storing the Appliance after Use ........................................................................................16
Maintenance Instructions ..........................................................................................................16
Section III - Frequently Asked Questions ...................................................................................17
5
METAL FUSION, INC.
LIMITED ONE-YEAR WARRANTY
WHAT THIS WARRANTY COVERS
This warranty covers all components of this appliance to be free from defects in materials and
workmanship, with the exceptions stated below.
HOW LONG COVERAGE LASTS
This warranty runs for one year from the date of purchase. Please keep your receipt with this manual
for future reference.
WHAT IS NOT COVERED
This warranty does not cover the following:
Incidental and Consequential Damages. This warranty does not cover incidental and
consequential damages arising in any way out of the use of this appliance. The liability of Metal
Fusion, Inc. is, in any event, limited to the amount of the original purchase price of this appliance,
and remains in force only as long as the product remains in its original, as-built configuration.
Some states do not allow the exclusion or limitation of incidental or consequential damages, so
the above limitation or exclusion may not apply to you.
Neglectful Operation. This warranty does not cover any loss or damage arising in any way
due to the negligent operation of this appliance.
Altered, Repaired or Misused Equipment. This warranty does not cover any loss or damage
arising in any way out of the use of this appliance when it has been altered, repaired by persons
other than Metal Fusion, Inc., or when it has been abused or misused, or when it has been used
other than in accordance with the manufacturer’s operating instructions.
Other Assumed Responsibilities. Unless otherwise provided by law, this warranty does
not cover any responsibility or liability arising in any way out of the use of this product where that
responsibility or liability was purportedly assumed by any other person or agent.
Paint, Discoloration, and Rust. This warranty does not cover the paint on the appliance,
as in a normal use of the appliance, the paint will be burned off. Nor does this warranty cover
discoloration or rust to the appliance as these occurrences are part of the appliance’s normal
wear and tear.
WHAT METAL FUSION, INC. WILL DO
Metal Fusion, Inc. will repair or replace any appliance that proves to be defective in materials or
workmanship. In the event repair is not possible or economically feasible, Metal Fusion, Inc. will
replace your appliance with an identical or substantially equivalent appliance. Metal Fusion, Inc. will
perform this service at no charge to you, except for the actual cost of shipping and handling the
appliance or replacement parts.
HOW TO GET SERVICE
In the event you have a problem or malfunction with your appliance, call Metal Fusion, Inc. at (800)
783-3885.
HOW STATE LAW APPLIES
This warranty gives you specific rights, and you may have other rights which vary from state to
state.
6
Loading...