Jumbuck HS-UM006D Assembly & Operation Instructions
ASSEMBLY & OPERATION
INSTRUCTIONS (HS
WARNING
FOR
OUTDOOR
USE ONLY
FOR YOUR SAFETY
If you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open flame.
3. Open hood.
4. If odour continues, immediately call
your gas supplier.
For outdoor use only.
Improper installation, adjustment, alteration, service or
maintenance can cause property damage, injury or death
Read the installation,
instructions thoroughly before installing or servicing this
equipment.
Warning: accessible parts may be very hot. Keep young
children away.
Do not move the appliance during use.
Turn off the gas supply at the gas cylinder after us
Any modification of the appliance may be dangerous.
Installer to leave instructions with the consumer and
consumer to retain them for future reference.
Do not replace the grill with an extra
warranty will be voided and it
The
grill provides the ventilation needed for the BBQ to
operate
device.
-
UM006D
FOR YOUR SAFETY
1.
Do not store or use gasoline or other
flammable vapours
or liquids in the
vicinity of this or any other appliance.
2. An LP cylinder not
connected for use
shall not be stored in the vicinity of this
or any other appliance.
operating and maintenance
hotplate. The
violates
the gas
safely. It
is not designed to be a solid hotplate
)
G
AS Grill
.
e.
approval.
Important! Please read these instructions carefully before use!
SAFETY INSTRUCTIONS
IMPORTANT: Read the assembly instruction of this booklet before removing the contents
of this carton.
IMPORTANT SAFETY INSTRUCTIONS
This appliance shall only be used in an above ground open
stagnant areas
, where gas leakage and products of combustion are rapidly dispersed by wind and
1.
This barbecue is an
outdoor appliance only
indoors.
2. READ ALL OPERATING INSTRUCTION BEFORE LIGHTING.
3. Do
not perform any servicing on the barbecue yourself. This includes internal adjustment of
the regulator and gas valves. Servicing can only be carried out by authorized technicians.
4. When cylinder is replaced or reconnected, check for leaks.
5. Do not st
ore chemicals or flammable materials near this appliance.
6. Unsupervised children should not be near a barbecue while cooking or during warm up or
cool down.
7. People with flammable clothing such as nylon etc. should keep well away from the barbecue
when it is operating.
8. Do not leave food unattended on the barbecue.
9. In case of fat fire, turn cylinder off.
10. Particular care must be taken when removing drip tray. Hot fat can cause serious injury.
11.
This BBQ should not be located under overhead
clearances must be maintained at all times from combustible construction and/or materials,
with MINIMUM
clearances as follow:
From Sides 200mm
From Back 500mm
High 1000mm
12. Turn
all gas valves off including cylinder after use.
13. Never leave burners on high for more than 10 minutes unless actually cooking. If the burner
makes hissing sound when lit, it may be burning inside. Turn burner off, allow it to cool and try
again.
14. D
o not allow build up of unburned gas.
15.
Remove sticker from hood before use.
UNIVERSAL LPG
-
air situation with natural ventilation, without
natural convection
. Under no circumstances should it be use
combustible construction and proper
DO NOT
OPERATE THIS APPLIANCE BEFORE READING THE
INSTRUCTION BOOKLET
DO NOT
PLACE ARTICLES ON OR AGAINST THIS APPLIANCE
DO NOT
STORE CHEMICALS OR FLAMMABLE MATERIALS OR
SPRAY AEROSOLS NEAR THIS APPLIANCE
DO NOT
OPERATE THIS APPLIANCE INDOORS
DO NOT
ENCLOSE THIS APPLIANCE
DO NOT
LIGHT OR OPERATE WITH COVER ON
WARNING
A strong gas smell or the hissing sound of gas
the LP gas tank. Failure to immediately follow the steps listed below could cause serious bodily
injury, death, or property damage.
Shut off gas supply to the gas grill.
Turn the control knobs to OFF
Put out any flame with a class B fire extinguisher.
Open Grill Lid.
Get away from the LP gas tank.
Do not try to fix the problem yourself.
If odour continues or you have a fire you cannot extinguish, call your fire department. Do not call
near th
e LP gas tank because your telephone is an electrical device and could create a spark
resulting in fire and/or explosion.
NOTE:
The normal flow of gas through the Regulator and Hose Assembly can create a humming
sound. A low volume of sound is perfectly
grill. If humming sound is loud and excessive you may need to purge air from the gas line or reset
the regulator excess gas flow device. This purging procedure should be done every time a new LP
gas tank
is connected to your grill.
OTHER CONSIDERATION
Strong winds and low temperatures can affect the heating and performance of your gas grill so
factor in these elements when positioning your grill outdoors for cooking.
Never use your gas grill in a garage, p
grill is to be used outdoors only, at least 70cm from the back and side of any combustible surface.
Your gas grill should not be placed under any surface that will burn. Do not obstruct the flow of
ventilation air around the gas grill housing. This gas grill is not intended to be installed in or on
recreational vehicles and/or boats
indicates a serious problem with your gas grill or
position.
normal and will not interfere with operation of the
orch, shed, breezeway or any other enclosed area. Your gas
PARTS LIST
PART NUMBER
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
PART NAME
SUPPLIER CODE
THERMOMETER
UM006D01
TOP COVER
UM006D 02
GREASE TRAY
UM006D 03
OIL CUP
UM006D 04
WARMING GRID
UM006D 05
COOKING PLATE
UM006D 06
COOKING GRID
UM006D 07
SIDE PANEL
UM006D 08
LEG-R
UM006D 09
WHEEL
UM006D 10
WHEEL AXIS
UM006D 11
REGULATOR
UM006D 12
SPACER
UM006D 13
CYLINDER HOOK
UM006D 14
VALVE SUPPORT
UM006D 15
KNOB
UM006D 16
KNOB SUPPORT
UM006D 17
BOTTOM SHELF
UM006D 18
BURNER
UM006D 19
VALVE
UM006D 20
CONTROL PLATE
UM006D 21
LEG-L
UM006D
FLAME TAMER
UM006D 23
BODY
UM006D 24
FRONT PLATE
UM006D 25
LEG SUPPORT
UM006D 26
BODY SIDE R UP
UM006D 27
BODY SIDE L UP
UM006D 28
BODY BACK UP
UM006D 29
22
1.BBQ body …. 1pc 2. Leg-L
....
5. wheel axis....1pcs
6 . Wheel(170) ... 2
9. Flame tamer.. 2pcs
10.
Cooking grid
1pc
13. Oil cup ....... 1pc
14.B
ottom
17.body side L
up.....1pc
18.Body side R up..1pc
..... 2pcs 3. Leg-R ......... 2pcs
pcs 7. Cylinder Hook.......
1pc
…... 11.Cooking plate…...
1pc
shelf... 1pc 15.Warm grid.....1pc
19.body back up...1pc
4. Side panel ..... 2pcs
8. Grease tray.....1pc
12. Spacer........ 8pcs
16.Leg support….2pcs
20.Hood…1pc
AAAA
BBBB
CCCC
DDDD
EEEE
Bolt
M6 x 15 mm
Bolt
M6 x 90 mm
Spring
Washer
Ø6.0 mm
Flat Washer
Ø6 mm
Flat Washer
Ø10 mm
12pcs
FFFF
8 pcs
GGGG
Bolt
M5 x 10mm
8pcs
HHHH
Bolt
M6x35mm
8 pcs
IIII
2 pcs
JJJJ
Bolt
M6
x 65 mm
Pin
2 pcs
6pcs
4pcs
4pcs
2 pcs
Nut M10
Assembly Instructions
Remove all contents from packaging, and make sure all parts are present before attempting to assemble! Tighten all bolt
connections by hand first, then when the grill is fully assembled, go back and
STEP 1
Assemble legs and left side shelf as shown.
STEP 2
Assemble the left and right side shelf.
tighten.
Loading...