Jumbuck HS-16JCG601-B, 4 Burner Hooded Comet BBQ Operation Instruction Manual
1
BBQ ASSEMBLY & OPERATION INSTRUCTIONS
6 BURNER BUILT IN BBQ – MODEL HS-16JCG601-B
WARNING
Important! Please read these instructions carefully before use!
FOR OUTDOOR USE ONLY
DO NOT OPERATE THIS APPLIANCE BEFORE READING THE
INSTRUCTION BOOKLET
DO NOT PLACE ARTICLES ON OR AGAINST THIS APPLIANCE
DO NOT STORE CHEMICALS OR FLAMMABLE MATERIALS OR
SPRAY AEROSOLS NEAR THIS APPLIANCE
DO NOT OPERATE THIS APPLIANCE INDOORS
DO NOT ENCLOSE THIS APPLIANCE
DO NOT LIGHT OR OPERATE WITH COVER ON
2
3
SAFETY INSTRUCTIONS
IMPORTANT: Read the assembly instructions of this booklet before removing the contents of
the carton.
IMPORTANT SAFETY INSTRUCTIONS
1. This BBQ is an OUTDOOR APPLIANCE ONLY. It should NOT be used indoors.
2. READ ALL OPERATING INSTRUCTION BEFORE LIGHTING.
3. Do not perform any servicing on the BBQ yourself. This includes internal adjustment of the
regulator and gas valves. Servicing can only be carried out by authorised technicians.
4. When cylinder is replaced or reconnected, check for leaks.
5. Do not store chemicals or flammable materials near this appliance.
6. Unsupervised children should not be near a BBQ while cooking or during warm up or cool down.
7. People with flammable clothing such as nylon etc. should keep well away from the BBQ when it
is operating.
8. Do not leave food unattended on the BBQ.
9. In case of a fat fire, immediately turn the LPG cylinder valve off.
10. Particular care must be taken when removing drip tray. Hot fat can cause serious injury.
11. This BBQ should not be located under overhead combustible construction and proper clearances
must be maintained at all times from combustible construction and/or materials, with
MINIMUM clearances as follows:
From Sides 200 mm
From Back 500 mm
Overhead 1000 mm
Note: This BBQ must be located in a non-combustible bench structure as explained in the
installation section of this manual.
12. Turn all gas valves off including cylinder after use.
13. Never leave burners on high for more than 10 minutes unless actually cooking. If the burner
makes a hissing sound when lit, it may be burning inside. Turn burner off, allow it to cool and
light it again.
14. Do not allow buildup of unburned gas.
15. Remove stickers (where fitted) from hood before use.
4
FOR YOUR SAFETY
If you smell gas:
1. Shut off gas to the appliance at the cylinder.
2. Open hood.
3. Extinguish any flames.
4. If odour continues, immediately call your gas
supplier.
FOR YOUR SAFETY
1. Do not store or use gasoline or other
flammable vapors or liquids in the vicinity
of this or any other appliance.
2. An LPG cylinder not connected for use shall
not be stored in the vicinity of this or any
other appliance.
For Outdoor Use Only.
Improper installation, adjustment, alteration, service or maintenance
can cause property damage, injury or death. Read the installation,
operating and maintenance instructions thoroughly before installing
or servicing this equipment.
Warning: accessible parts may be very hot. Keep young children
away.
Do not move the appliance during use.
Turn off the gas supply at the gas cylinder after use.
Any modification of the appliance may be dangerous.
Installer to leave instructions with the consumer and consumer to
retain them for future reference.
Do not replace the grill with an extra hotplate. The warranty will be
void and it violates the gas approval, the grill provides the
ventilation needed for the BBQ to operate safely. It is not designed to
be a solid hotplate device.
Please ensure all packaging and transit protection materials are
removed prior to using the BBQ.
5
IMPORTANT
This appliance shall only be used in an above ground open-air situation with natural ventilation,
without stagnant areas, where gas leakage and products of combustion are rapidly dispersed by
wind and natural convection.
WARNING
A strong gas smell or the hissing sound of gas indicates a serious problem with your BBQ or the LPG
gas cylinder. Failure to immediately follow the steps listed below could cause serious bodily injury,
death, or property damage.
Shut off gas supply to the BBQ.
Turn the control knobs to OFF position.
Put out any flame with a class B fire extinguisher and clear the area of people.
Open BBQ Lid.
Move away from the LPG gas cylinder .
Do not try to fix the problem yourself.
If odour continues or you have a fire you cannot extinguish, call your fire department immediately.
NOTE: The normal flow of gas through the Regulator and Hose Assembly can create a humming
sound. A low volume of sound is perfectly normal and will not interfere with operation of the BBQ.
If humming sound is loud and excessive you may need to purge air from the gas line.
Strong winds and low temperatures can affect the heating and performance of your BBQ so factor in
these elements when positioning your BBQ outdoors for cooking.
Never use your BBQ in a garage, porch, shed, breezeway or any other enclosed area. Your BBQ is to
be used outdoors only, at least 200mm from the sides and 500mm from the back of any combustible
surface. Your BBQ should not be placed under any surface that will burn. Do not obstruct the flow of
ventilation air around the BBQ. This BBQ is not intended to be installed in or on recreational
vehicles and/or boats.
6
SPECIFICATION
LPG REGULATOR & HOSE ASSEMBLY (Supplied with BBQ) : 2.75kPa, POL type regulator and 8mm
ID, Class A hose with 3/8SAE Female outlet. AGA approved.
NATURAL GAS REGULATOR (Not supplied with BBQ): 1.0kPa, ½” Inlet and Outlet, AGA approved.
NATURAL GAS HOSE ASSEMBLY (Not supplied with BBQ): 10mm ID, Class B or D, AGA approved.
Overall Dimensions: 1058mm W x 551mm D x 481.5mm H
Gas Connection Point: Right hand rear corner under the BBQ
Burner Configuration Table - Universal LPG
BURNERS NOMINAL GAS
CONSUMPTION
TEST POINT
PRESSURE
INJECTOR
SIZE
BBQ 11MJ/h (per burner) ULPG @ 2.75kPa 0.90mm
Burner Configuration Table - Propane
BURNERS NOMINAL GAS
CONSUMPTION
TEST POINT
PRESSURE
INJECTOR
SIZE
BBQ 13MJ/h (per burner) Propane @ 2.75kPa 0.98mm
Burner Configuration Table – Natural Gas
BURNERS NOMINAL GAS
CONSUMPTION
TEST POINT
PRESSURE
INJECTOR
SIZE
BBQ 13MJ/h (per burner) Natural Gas @ 1:00kPa 1.62mm
7
Assemblyinstructionsteps
4
1
2
5
3
6
7
8
Loading...