Page 1
Figure 1: VA9203 Spring Return Electric Valve
Actuator
VA9203-xxx-xx Series Electric Spring Return Valve
Actuators
Product Bulletin
VA9203-GGx-2Z, VA9203-AGx-2Z, VA9203-Bxx-2
The VA9203-xxx-xx Series Electric Spring Return Valve
Actuators are direct-mount valve actuators. These
bidirectional actuators are used to provide accurate
positioning on Johnson Controls® VG1000 Series 1/2,
3/4, and 1 in. (DN15, DN20, and DN25) ball valves in
Heating, Ventilating, and Air Conditioning (HVAC)
applications. A mechanical spring return system
provides rated torque with or without power applied to
the actuator. The series includes the following control
options:
• On/Off, 24 V, or 85 to 264 VAC power
• On/Off and Floating Point, 24 V power
• Proportional, 24 V power, for 0(2) to 10 VDC or
0(4) to 20 mA Control Signal
An accessory crankarm and remote mounting kit are
available for applications where the actuator cannot be
direct-coupled to the damper shaft. An optional line
voltage auxiliary switch indicates an end-stop position
or performs switching functions within the selected
rotation range.
Code No. LIT-12011702
Issued May 2018
Table 1: Features and Benefits (Part 1 of 2)
Features Benefits
Direct Mounting with a Single Screw Reduces installation time and cost.
Electronic Stall Detection Protects from overload at all angles of rotation. Power consumption is
reduced holding mode. The actuator may be stalled anywhere in its
rotation range without the need for mechanical end switches.
Double-Insulated Construction Eliminates need for electrical ground connection for regulatory agency
Microprocessor-Controlled Brushless DC
Motor (-AGx and -GGx Models)
External Mode Selection Switch
(-AGx and -GGx Models)
Integral Cables with Colored and Numbered
Conductors
Integral 1/2 in. (13 mm) Threaded Conduit
Connector(s)
Optional Integrated Auxiliary Switch Provides adjustable switch point with line voltage capability.
Plenum Rated Models Enable use in other environmental air spaces (plenums) in accordance
compliance.
Provides constant runtime independent of torque and ensures long life.
Permits control logic reversal for Floating Control (-AGx Models). Permits
calibration input signal range selection, and control logic reversal for
Proportional Control (-GGx Models).
Simplify installation and field wiring.
Simplify installation and field wiring.
with section 300.22(C) of the National Electric Code.
VA9203-xxx-xx Series Electric Spring Return Valve Actuators Product
Bulletin
1
Page 2
Table 1: Features and Benefits (Part 2 of 2)
Features Benefits
Optional Thermal Barrier Provides for 284°F (140°C) hot water or 15 psi saturated steam
applications.
Available Weather Shield for Field Mounting Provides NEMA 3R protection for the actuator.
Override Control (Proportional Models Only) Supports manual control system override application through field wiring.
Underwriters Laboratories Inc.® (UL),
CE Mark, and C-Tick Compliance
Manufactured under International Standards
Organization (ISO) 9001 Quality Control
Standards
5-Year Warranty Protects consumer investment.
Provides internationally recognized regulatory agency approvals.
Ensures quality.
IMPORTANT: Use these VA9203-xxx-xx Series
Electric Spring Return Actuators only to control
equipment under normal operating conditions.
Where failure or malfunction of the electric actuator
could lead to personal injury or property damage to
the controlled equipment or other property,
additional precautions must be designed into the
control system. Incorporate and maintain other
devices, such as supervisory or alarm systems or
safety or limit controls, intended to warn of or protect
against failure or malfunction of the electric actuator.
VA9203-GGx-2Z Series Proportional Actuators
The VA9203-GGx-2Z Series Actuators provide
proportional modulation of VG1000 1/2, 3/4, and 1 inch
ball valves in HVAC systems that are controlled by an
electronic controller or positioner. The actuator
responds to 0 to 10 VDC or 2 to 10 VDC control
signals. With the addition of a 500 ohm resistor, the
actuator responds to a 0 to 20 mA or 4 to 20 mA signal.
A 0 to 10 VDC or 2 to 10 VDC feedback signal
indicates position and provides support for
master-subordinate applications.
Manual control system override applications are
supported through field wiring, and include:
• override to MIN position
• override to MAX position
• override to MIN, MID, and MAX position
The VA9203-GGA-2Z actuators include plenum-rated
cables and are specially configured for installation in
spaces used for environmental air-handling purposes,
other than ducts and plenums, as specified in National
Fire Protection Association (NFPA) 70: National
Electrical Code section 300.22(C), Other Space Used
for Environmental Air. The space over a hung ceiling,
when used for environmental air handling purposes, is
an example of the type of space for which these
actuators are configured.
VA9203-AGx-2Z Series On/Off and Floating Point Actuators
The VA9203-AGx-2Z Series Actuators provide on/off
control or modulation of VG1000 1/2, 3/4, and 1 inch
ball valves in HVAC systems. Floating point control can
be provided from a triac or relay. On/off control can be
provided from a manual switch, controller, auxiliary
switch from a fan motor contactor, or similar device.
The VA9203-AGA-2Z actuators include plenum-rated
cables and are specially configured for installation in
spaces used for environmental air-handling purposes
other than ducts and plenums as specified in National
Fire Protection Association (NFPA) 70: National
Electrical Code section 300.22(C), Other Space Used
for Environmental Air. The space over a hung ceiling,
when used for environmental air handling purposes, is
an example of the type of space for which these
actuators are configured.
VA9203-xxx-xx Series Electric Spring Return Valve Actuators Product Bulletin
2
Page 3
VA9203-Bxx-2 Series On/Off Actuators
The VA9203-Bxx-2 Series Actuators provide on/off
control of VG1000 1/2, 3/4, and 1 inch ball valves in
HVAC systems. On/off control can be provided from a
manual switch, controller, auxiliary switch from a fan
motor contactor, or similar device.
Operation
VA9203-xxx-xx Series Actuators provide 95º of
rotation. A graduated scale from 0% to 100% and a
position indicator provide visual indication of stroke.
When power fails during service, the mechanical spring
return system returns the valve to the home position.
VA9203-GGx-2Z Series Proportional Actuators
The VA9203-GGx-2Z Series uses a brushless DC
motor controlled by a microprocessor. The
microprocessor drives the motor at constant speed,
independent of torque. The microprocessor also
monitors the brushless DC motor’s rotation to prevent
damage to the actuator in a stall condition. The
actuator can be stalled anywhere within its rotation
range without the need for mechanical end switches.
Power consumption is reduced in the holding mode.
The VA9203-GGC-2Z version is provided with one
integrated, line-voltage-capable auxiliary Single-Pole,
Double-Throw (SPDT) switch. The switch point is
independently and continuously adjustable throughout
the full range of actuator stroke. The auxiliary switch is
double-insulated so an electrical ground is not
required.
VA9203-AGx-2Z Series On/Off and Floating Point Actuators
The VA9203-AGx-2Z Series uses a brushless DC
motor controlled by a microprocessor. The
microprocessor drives the motor at constant speed,
independent of torque. The microprocessor also
monitors the brushless DC motor’s rotation to prevent
damage to the actuator in a stall condition. The
actuator can be stalled anywhere within its rotation
range without the need for mechanical end switches.
Power consumption is reduced in the holding mode.
The VA9203-AGB-2Z version is provided with one
integrated, line-voltage-capable auxiliary SPDT switch.
The switch point is independently and continuously
adjustable throughout the full range of actuator stroke.
The auxiliary switch is double-insulated so an electrical
ground is not required.
VA9203-Bxx-2 Series On/Off Actuators
The VA9203-Bxx-2 Series uses a DC brush motor
controlled by analog electronics. The actuator can be
stalled anywhere within its rotation range without the
need for mechanical end switches. Power consumption
is reduced in the holding mode. Two different voltage
ratings are available for on/off actuators.
• VA9203-BGx-2: AC 24 V 50/60 Hz or DC 24 V
power
• VA9203-BUx-2: AC 85 to 265 V 50/60 Hz power
The VA9203-BUx-2 actuators are double-insulated so
an electrical ground is not required. The VA9203-BxB-2
versions are provided with one integrated,
line-voltage-capable auxiliary SPDT switch. The switch
point is independently and continuously adjustable
throughout the full range of the actuator stroke. The
auxiliary switch is double-insulated so an electrical
ground is not required.
VA9203-xxx-xx Series Electric Spring Return Valve Actuators Product Bulletin
3
Page 4
Wiring Diagrams
1
2
34
~
(+)
Y
COM
U
BLK
RED
GRY
ORN
+
+
12
34
~
(+)
Y
COM
U
BLK
RED
GRY
ORN
0(4)...20 mA
+
+
DC 0(2)...10 V Control
0(4)...20 mA Control with
External Resistor
AC/DC
24 V
DC 0(2)...10 V
AC/DC
24 V
DC 0(2)...10 V
DC 0(2)...10 V
Master-Subordinate Application
Y
DC 0(2)...10 V
+
U
+
1
2
34
BLK
RED
GRY
ORN
AC/DC
24 v
~
(+)
DC 0(2)...10 V
COM
+
1
2
34
BLK
RED
GRY
ORN
500 / 0.25 W
Ƽ
Figure 2: VA9203-GGx-2Z Control Wiring
Diagrams
Figure 3: Control Wiring Diagrams (Overrides)
VA9203-GGx-2Z Series Proportional Actuators
VA9203-xxx-xx Series Electric Spring Return Valve Actuators Product Bulletin
4
Page 5
VA9203-Bxx-2 Series On/Off Actuators
Figure 4: VA9203-Bxx-2 Control Wiring
Diagrams
AC 85...264 V 50/60 Hz
L1N
WHT BLK
2
1
AC 24 V 50/60
DC 24 V
RED
BLK
2
1
+
-
~
F
I
G
:
V
A
9
2
0
3
B
x
x
2
_
w
i
r
i
n
g
Figure 5: Optional Auxiliary Switch Wiring
5.0 (2.9 ) A 240 V
~
21
22
23
BLK/
RED
BLK/
BLU
BLK/
GRY
S1
21
23
22
21
COM
NC
NO
Figure 6: VA9203-AGx-2Z Control Wiring
Diagrams
~
+
-
24 VAC
24 VDC
RA
RA
DADA
4
BLK
RED
GRY
ORN
1
23
Floating Control, Four Wire
~
+
-
24 VAC
24 VDC
RA
RA
DADA
4
BLK
RED
GRY
ORN
1
2
3
On/Off Control, Two Wire
~
+
-
24 VAC
24 VDC
RARADADA4
BLK
RED
GRY
ORN
1
2
3
Open/Close, Single Wire Control
24 VAC
24 VDC
~
+
-
RARADA
DA
4
BLK
RED
GRY
ORN
1
2
3
RARADADA4
BLK
RED
GRY
ORN
1
2
3
FIG:VA92xx-AGx_c ntrlwir
Floating Control, Multiple Actuators with One Transformer
VA9203-AGx-2Z Series On/Off and Floating Point Actuators
VA9203-xxB-2x Auxiliary Switch
VA9203-xxx-xx Series Electric Spring Return Valve Actuators Product Bulletin
5
Page 6
Ordering Information
Table 2 shows the VA9203-xxx-xx Series Electric
Spring Return Valve Actuator models.
Table 2: VA9203-xxx-xx Series Electric Spring Return Valve Actuator Models
Code Number
VA9203-AGA-2Z
VA9203-AGB-2Z
VA9203-BGA-2
VA9203-BGB-2
VA9203-BUA-2
VA9203-BUB-2
VA9203-GGA-2Z
VA9203-GGB-2Z
Rotation
Time For 90°
Power On – Running (Seconds)
Power Off – Spring Return (Seconds)
90 <25 X 6 5.1 (2.8) –
90 <25 X 6 5.1 (2.8) –
<75 <75 X 6 5.0 (2.5) –
<75 <75 X 6 5.0 (2.5) –
<75 <75 X – – 0.06 (0.02)
<75 <75 X – – 0.06 (0.02)
90 <25 X 6 5.1 (2.8) – X X X X
90 <25 X 6 5.1 (2.8) – X X X X X
Power
Requirement
85 to 264 VAC +/- 10%
24 VAC +/- 20% VDC +20%/-10%
Power Consumption Input Signal Position
On/Off
0(2) to 10 VDC
VA: Running (Holding)
VA Rating, Transformer Sizing
Amperage: Running (Holding)
On/Off and Floating Point
0(4) to 20 mA (with 500 ohm Resistor)
X
X
X
X
X
X
Feedback
0(2) to 10 VDC
Auxiliary
Switch
1 SPDT, 5.0 A (2.9 A Inductive) at 240 V
XX X
XX X
XX X
Electrical
Connection
120 in. (3.05 m) 19 AWG Plenum Cable
48 in. (1.2 m) 18 AWG Appliance Cable
XX
XX
XX
1/2 in. (13 mm) Conduit Connectors
Accessories
Table 3: Accessories/Repair Parts (Order Separately)
Code Number Description
M9000-560 Ball Valve Linkage Kit for Applying M9203 and M9208 Series Actuators to VG1000 Series Valves
M9000-561 Thermal Barrier Extends M(VA)9104, M(VA)9203, and M(VA)9208 Series Electric Spring Return Actuator
M9000-342 Weathershield Kit for VG1000 Series Ball Valve application of VA9104, VA9203, and VA9208 Series
M9000-607 Position Indicator for VG1000 Series Ball Value Applications (Quantity 5)
(Quantity 1)
Applications to Include Low Pressure Steam (Quantity 1)
Electric Spring Return Actuators (quantity 1)
VA9203-xxx-xx Series Electric Spring Return Valve Actuators Product Bulletin
6
Page 7
Dimensions
Figure 7: Spring Return VA9203 Actuated VG1241, VG1245, VG1841, and VG1845 Series Ball Valve
Dimensions, in. (mm)
Port Mar king
Locations
F
I
G
:
V
A
9
2
0
3
X
_
d
i
m
s
3-1/4
(82)
D
A
3-1/2 (89)
Clearance Required
2-7/8
(73)
See Figure 7, Table 4, and Table 5 for valve
actuator dimensions.
Table 4: VA9203 Actuated VG1241, VG1245, VG1841, and VG1845 Series NPT Ball Valve Dimensions, in.
(mm)
Valve Size
in. (DN)
1/2 (DN15) 4-5/8 (117.3) 21/32 (17) 1-7/32 (31) 6-31/32 (177) 2-33/64 (64) 11/32 (9) 1-1/4 (32)
3/4 (DN20) 4-5/8 (117.3) 21/32 (17) 1-7/32 (31) 7-1/8 (181) 2-51/64 (71) 11/32 (9) 1-13/32 (36)
1 (DN25) 4-11/16 (119) 3/4 (19) 1-19/64 (33) 7-31/64 (190) 3-13/32 (87) 11/32 (9) 1-45/64 (43)
1. Port A must always be connected to the coil.
1
ABC D E F G
Table 5: VA9203 Actuated VG1271, VG1275, VG1871, and VG1875 Series Sweat Ball Valve and VA9203
Actuated VG1291, VG1295, VG1891, and VG1895 Series Press Ball Valve Dimensions, in. (mm)
Valve Size,
in. (DN)
1/2 (DN15) 4-5/8 (117.3) 21/32 (17) 1-7/32 (31) 7-13/64 (183) 3-25/32 (96) 11/32 (9) 1-1/4 (32)
3/4 (DN20) 4-5/8 (117.3) 21/32 (17) 1-7/32 (31) 7-3/4 (197) 4-3/32 (104) 11/32 (9) 1-13/32 (36)
1 (DN25) 4-11/16 (119) 3/4 (19) 1-19/64 (33) 8-3/16 (208) 4-41/64 (118) 11/32 (9) 1-45/64 (43)
1. Port A must always be connected to the coil.
1
ABC D EFG
VA9203-xxx-xx Series Electric Spring Return Valve Actuators Product Bulletin
7
Page 8
See Figure 8 and Table 6 for valve actuator dimensions
Figure 8: Spring Return VA9203 Actuated VG1241, VG1245, VG1841, and VG1845 Series Ball Valve
with Optional M9000-561 Thermal Barrier Installed Dimensions, in. (mm)
Port Marking
Locations
F
I
G
:
V
A
9
2
0
3
X
_
d
i
m
s
t
h
b
r
2-7/8
(73)
3-1/4
(82)
A
D
3-1/2 (89)
Clearance Required
with optional M9000-561 Thermal Barrier installed.
Table 6: VA9203 Actuated VG1241, VG1245, VG1841, and VG1845 Series Ball Valve with Optional
M9000-561 Thermal Barrier Installed Dimensions, in. (mm)
Valve
AB C D E FG
Size in.
1
(DN)
1/2 (DN15) 6 (152) 21/32 (17) 1-7/32 (31) 6-31/32 (177) 2-33/64 (64) 11/32 (9) 1-1/4 (32)
3/4 (DN20) 6 (152) 21/32 (17) 1-7/32 (31) 7-1/8 (181) 2-51/64 (71) 11/32 (9) 1-13/32 (36)
1 (DN25) 6-1/16 (154) 3/4 (19) 1-19/64 (33) 7-31/64 (190) 3-13/32 (87) 11/32 (9) 1-45/64 (43)
1. Port A must always be connected to the coil.
Repair Information
A number of replacement parts are available; see
Table 3 for more details. If a VA9203-xxx-xx Series
Electric Spring Return Actuator fails to operate within
its specifications, replace the unit. For a replacement
electric actuator, contact the nearest
Johnson Controls® representative.
VA9203-xxx-xx Series Electric Spring Return Valve Actuators Product Bulletin
8
Page 9
Technical Specifications
VA9203-GGx-2Z Series Proportional Electric Spring Return Actuator (Part 1 of 2 )
Power Requirements AC 24 V (AC 19.2 V to 28.8 V) at 50/60 Hz: Class 2 (North America) or Safety
Extra-Low Voltage (SELV) (Europe), 4.7 VA Running, 2.7 VA Holding Position
DC 24 V (DC 21.6 V to 28.8 V): Class 2 (North America) or SELV (Europe)
1.8 W Running, 1 W Holding Position
Minimum Transformer Size: 6 VA per Actuator
Input Signal/Adjustments Factory Set at DC 0 to 10 V, CW Rotation with Signal Increase
Selectable DC 0 (2) to 10 V or 0 (4) to 20 mA with Field -Furnished 500 ohm
0.25 W Minimum Resistor
Switch Selectable Direct or Reverse Action with Signal Increase
Control Input Impedance Voltage Input: 100,000 ohm
Current Input: 500 ohm with Field-Furnished 500 ohm Resistor
Feedback Signal DC 0 (2) to 10 V for Desired Rotation Range up to 95°
Corresponds to Rotation Limits, 0.5 mA at 10 V Maximum
Auxiliary Switch
Rating
Spring Return Direction is Selectable with Mounting Position of Actuator:
Rated Torque Power On
Rotation Range Maximum Full Stroke: 95°
Rotation Time for
90 Degrees of
Travel
Life Cycles 60,000 Full Stroke Cycles with 27 lb·in. (3 N·m) Load
Audible Noise
Rating
Electrical
Connections
Conduit Connections Integral 1/2 in. (13 mm) Threaded Conduit Connector(s)
-xxB Models One Single-Pole, Double-Throw (SPDT), Double-Insulated Switch with Silver
Contacts:
AC 24 V, 50 VA Pilot Duty
AC 120 V, 5.8 A Resistive, 1/4 hp, 275 VA Pilot Duty
AC 240 V, 5.0 A Resistive, 1/4 hp, 275 VA Pilot Duty
Actuator Face Labeled A is Away from Valve: CCW Spring Return
Actuator Face Labeled B is Away from Valve: CW Spring Return
(Running)
Power Off
(Spring Returning)
Power On
(Running)
Power Off
(Spring Returning)
Power On
(Running)
Power On
(Holding)
Power Off
(Spring Returning)
-GGA-2Z Models 120 in. (3.05 m) UL 444 Type CMP Plenum Rated Cable with 19 AWG
-GGB-2Z Models 48 in. (1.2 m) UL 758 Type AWM Halogen Free Cable with 18 AWG
27 lb·in (3 N·m) All Operating Temperatures
27 lb·in (3 N·m) All Operating Temperatures
Adjustable Stop: 35° to 95° Maximum Position
90 Seconds Constant for 0 to 27 lb·in. (3 N·m) Load, at all Operating
Conditions
12 to 17 Seconds for 0 to 27 lb·in. (3 N·m) Load, at Room Temperature
16 Seconds Nominal at Full Rated Load
22 Seconds Maximum with 27 lb·in. (3 N·m) Load, at -22°F (-30°C)
1,500,000 Repositions with 27 lb·in. (3 N·m) Load
<37 dBA at 27 lb·in. (3 N·m) Load, at a Distance of 39-13/32 in. (1 m)
<20 dBA at a Distance of 39-13/32 in. (1 m)
<56 dBA at 27 lb·in. (3 N·m) Load, at a Distance of 39-13/32 in. (1 m)
(0.75 mm
(0.85 mm
2
) Conductors and 1/4 in. (6 mm) Ferrule Ends
2
) Conductors and 1/4 in. (6 mm) Ferrule Ends
VA9203-xxx-xx Series Electric Spring Return Valve Actuators Product Bulletin
9
Page 10
VA9203-GGx-2Z Series Proportional Electric Spring Return Actuator (Part 2 of 2 )
Fluid
Temperature
Limits
Ambient
Conditions
Enclosure Rating NEMA 2 (IP54) for all Mounting Directions
Compliance United States UL Listed, CCN XAPX, File E27734; to UL 60730-1A: 2003-08, Ed. 3.1,
Shipping Weight -GGA Models 2.0 lb (0.9 kg)
VG12x1 and VG18x1
Series
VG12x5 and VG18x5
Series
VG12x5 and VG18x5
Series with
M9000-561 Thermal
Barrier Installed
Standard Operating -22 to 140°F (-30 to 60°C); 90% RH Maximum, Noncondensing
Storage -40 to 185°F (-40 to 85°C); 95% RH Maximum, Noncondensing
Canada UL Listed, CCN XAPX7, File E27734; to UL 60730-1:02-CAN/CSA: July 2002,
Europe CE Mark – Johnson Controls declares that this product is in compliance with
Australia and New
Zealand
-GGB Models 2.4 lb (1.1 kg)
23 to 203°F (-5 to 95°C), Not Rated for Steam Service
-22 to 212°F (-30 to 100°C), Not Rated for Steam Service
-22 to 284°F (-30 to 140°C) water; 15 psig (103 kPa) at 250°F (121°C)
Saturated Steam
Automatic Electrical Controls for Household and Similar Use; and
UL 60730-2-14: 2002-02, Ed. 1, Part 2 Particular Requirements for Electric
Actuators
Plenum Rated (UL 2043). Suitable for use in other environmental air space
(plenums) in accordance with Section 300.22 (C) of the National Electric Code
3rd Ed., Automatic Electrical Controls for Household and Similar Use; and
CSA C22.2 No. 24-93 Temperature Indicating and Regulating Equipment
the essential requirements and other relevant provisions of the EMC Directive
2004/108/EC and Low Voltage Directive 2006/95/EC.
RCM Mark, Australia/NZ Emissions Compliant
VA9203-AGx-2Z Series On/Off and Floating Point Electric Spring Return Actuators (Part 1 of 2 )
Power Requirements AC 24 V (AC 19.2 V to 28.8 V) at 50/60 Hz: Class 2 (North America) or Safety
Extra-Low Voltage (SELV) (Europe), 5.1 VA Running, 2.8 VA Holding Position
DC 24 V (DC 21.6 V to 28.8 V): Class 2 (North America) or SELV (Europe)
1.9 W Running, 1.1 W Holding
Holding Position Minimum Transformer Size: 6 VA per Actuator
Input Signal/Adjustments AC 19.2 to 28.8 V at 50/60 Hz or DC 24 V +20%/-10%
Class 2 (North America) or SELV (Europe)
Minimum Pulse Width: 500 ms
Control Input Impedance 4,700 ohm Control Inputs
Auxiliary Switch
Rating
Spring Return Direction is Selectable with Mounting Position of Actuator:
Rated Torque Power On
Rotation Range Maximum Full Stroke: 95°
-xxB Models One Single-Pole, Double-Throw (SPDT), Double-Insulated Switch with Silver
Contacts:
AC 24 V, 50 VA Pilot Duty
AC 120 V, 5.8 A Resistive, 1/4 hp, 275 VA Pilot Duty
AC 240 V, 5.0 A Resistive, 1/4 hp, 275 VA Pilot Duty
Actuator Face Labeled A is Away from Valve: CCW Spring Return
Actuator Face Labeled B is Away from Valve: CW Spring Return
27 lb·in. (3 N·m) All Operating Temperatures
(Running)
Power Off
(Spring Returning)
27 lb·in. (3 N·m) All Operating Temperatures
VA9203-xxx-xx Series Electric Spring Return Valve Actuators Product Bulletin
10
Page 11
VA9203-AGx-2Z Series On/Off and Floating Point Electric Spring Return Actuators (Part 2 of 2 )
Rotation Time for
90 Degrees of
Travel
Life Cycles 60,000 Full Stroke Cycles with 27 lb·in. (3 N·m) Load
Audible Noise
Rating
Electrical
Connections
Conduit Connections Integral 1/2 in. (13 mm) Threaded Conduit Connectors
Fluid
Temperature
Limits
Ambient
Conditions
Enclosure Rating NEMA 2 (IP54) for all Mounting Directions
Compliance United States UL Listed, CCN XAPX, File E27734; to UL 60730-1A: 2003-08, Ed. 3.1,
Shipping Weight -AGA Models 2.0 lb (0.9 kg)
Power On
(Running)
Power Off
(Spring Returning)
Power On
(Running)
Power On
(Holding)
Power Off
(Spring Returning)
AGA-2Z Models 120 in. (3.05 m) UL 444 Type CMP Plenum Rated Cable with 19 AWG
AGB-2Z Models 48 in. (1.2 m) UL 758 Type AWM Halogen Free Cable with 18 AWG
VG12x1 and VG18x1
Series
VG12x5 and VG18x5
Series
VG12x5 and VG18x5
Series with
M9000-561 Thermal
Barrier Installed
Standard Operating -22 to 140°F (-30 to 60°C); 90% RH Maximum, Noncondensing
Storage -40 to 185°F (-40 to 85°C); 95% RH Maximum, Noncondensing
Canada UL Listed, CCN XAPX7, File E27734; to UL 60730-1:02-CAN/CSA: July 2002,
Europe CE Mark – Johnson Controls declares that this product is in compliance with
Australia and New
Zealand
-AGB Models 2.4 lb (1.1 kg)
90 Seconds Constant for 0 to 27 lb·in. (3 N·m) Load, at all Operating
Conditions
12 to 17 Seconds for 0 to 27 lb·in. (3 N·m) Load, at Room Temperature
16 Seconds Nominal at Full Rated Load
22 Seconds Maximum with 27 lb·in. (3 N·m) Load, at -22°F (-30°C)
1,500,000 Repositions with 27 lb·in. (3 N·m) Load
<37 dBA at 27 lb·in. (3 N·m) Load, at a Distance of 39-13/32 in. (1 m)
<20 dBA at a Distance of 39-13/32 in. (1 m)
<56 dBA at 27 lb·in. (3 N·m) Load, at a Distance of 39-13/32 in. (1 m)
(0.75 mm
(0.85 mm2) Conductors and 1/4 in. (6 mm) Ferrule Ends
23 to 203°F (-5 to 95°C), Not Rated for Steam Service
-22 to 212°F (-30 to 100°C), Not Rated for Steam Service
-22 to 284°F (-30 to 140°C) water; 15 psig (103 kPa) at 250°F (121°C)
Saturated Steam
Automatic Electrical Controls for Household and Similar Use; and
UL 60730-2-14: 2002-02, Ed. 1, Part 2 Particular Requirements for Electric
Actuators
Plenum Rated (UL 2043). Suitable for use in other environmental air space
(plenums) in accordance with Section 300.22 (C) of the National Electric Code
3rd Ed., Automatic Electrical Controls for Household and Similar Use; and
CSA C22.2 No. 24-93 Temperature Indicating and Regulating Equipment
the essential requirements and other relevant provisions of the EMC Directive
2004/108/EC and the Low Voltage Directive 2006/95/EC.
RCM Mark, Australia/NZ Emissions Compliant
2
) Conductors and 1/4 in. (6 mm) Ferrule Ends
VA9203-xxx-xx Series Electric Spring Return Valve Actuators Product Bulletin
11
Page 12
VA9203-Bxx-x Series On/Off Electric Spring Return Actuator (Part 1 of 2 )
Power
Requirements
Auxiliary Switch
Rating
Spring Return Direction is Selectable with Mounting Position of Actuator:
Rated Torque Power On
Rotation Range Maximum Full Stroke: 95°
Rotation Time
for 90 Degrees
of Travel
Life Cycles 60,000 Full Stroke Cycles with 27 lb·in. (3 N·m) Load
Audible Noise
Rating
Electrical
Connections
Conduit Connections Integral 1/2 in. (13 mm) Threaded Conduit Connectors
Fluid
Temperature
Limits
Ambient
Conditions
Enclosure Rating NEMA 2 (IP54) for all Mounting Directions
-BGx-2 Models AC 24 V (AC 19.2 V to 28.8 V) at 50/60 Hz: Class 2 (North America) or Safety
Extra-Low Voltage (SELV) (Europe), 5 VA Running, 1.6 VA Holding Position DC
24 V (DC 21.6 V to 28.8 V): Class 2 (North America) or SELV (Europe)
2.8 W Running, 0.8 W Holding Position
Minimum Transformer Size: 6 VA per Actuator
-BUx-2 Models AC 100 V to 240 V (AC 85 V to 264 V) at 50/60 Hz: 0.06 A Running,
0.02 A Holding Position
-xxB-2 Models One Single-Pole, Double-Throw (SPDT), Double-Insulated Switch with Silver
Contacts:
AC 24 V, 50 VA Pilot Duty
AC 120 V, 5.8 A Resistive, 1/4 hp, 275 VA Pilot Duty
AC 240 V, 5.0 A Resistive, 1/4 hp, 275 VA Pilot Duty
Actuator Face Labeled A is Away from Valve: CCW Spring Return
Actuator Face Labeled B is Away from Valve: CW Spring Return
(Running)
Power Off
(Spring Returning)
Power On
(Running)
Bxx-2 Models
Power Off
(Spring Returning)
Power On
(Running)
Power On
(Holding)
Power Off
(Spring Returning)
Actuator
(All Models)
Auxiliary Switches
(-xxB-2 Models)
VG12x1 and
VG18x1 Series
VG12x5 and
VG18x5 Series
VG12x5 and
VG18x5 Series
with M9000-561
Thermal Barrier
Installed
Standard
Operating
Storage -40 to 185°F (-40 to 85°C); 95% RH Maximum, Noncondensing
27 lb·in. (3 N·m) All Operating Temperatures
27 lb·in. (3 N·m) All Operating Temperatures
53 to 71 Seconds Constant for 0 to 27 lb·in. (3 N·m) Load, at Room Temperature
60 Seconds Nominal at Full Rated Load (0.25 rpm)
37 to 46 Seconds for 0 to 27 lb·in. (3 N·m) Load, at Room Temperature
44 Seconds Nominal at Full Rated Load
75 Seconds Maximum with 27 lb·in. (3 N·m) Load at -22°F (-30°C)
<36 dBA at 27 lb·in. (3 N·m) Load, at a Distance of 39-13/32 in. (1 m)
<20 dBA at a Distance of 39-13/32 in. (1 m)
<35 dBA at 27 lb·in. (3 N·m) Load, at a Distance of 39-13/32 in. (1 m)
48 in. (1.2 m) UL 758 Type AWM Halogen Free Cable with 18 AWG (0.85 mm
Conductors and 0.25 in. (6 mm) Ferrule Ends
48 in. (1.2 m) UL 758 Type AWM Halogen Free Cable with 18 AWG (0.85 mm
Conductors and 0.25 in. (6 mm) Ferrule Ends
23 to 203°F (-5 to 95°C), Not Rated for Steam Service
-22 to 212°F (-30 to 100°C), Not Rated for Steam Service
-22 to 284°F (-30 to 140°C) water; 15 psig (103 kPa) at 250°F (121°C) Saturated
Steam
-22 to 140°F (-30 to 60°C); 90% RH Maximum, Noncondensing
2
)
2
)
VA9203-xxx-xx Series Electric Spring Return Valve Actuators Product Bulletin
12
Page 13
Metasys® and Johnson Controls® are registered trademarks of Johnson Controls.
All other marks herein are the marks of their respective owners. © 2018 Johnson Controls.
Building Technologies & Solutions
507 E. Michigan Street, Milwaukee, WI 53202
VA9203-Bxx-x Series On/Off Electric Spring Return Actuator (Part 2 of 2 )
Compliance United States UL Listed, CCN XAPX, File E27734; to UL 60730-1A: 2003-08, Ed. 3.1, Automatic
Electrical Controls for Household and Similar Use; and UL 60730-2-14: 2002-02,
Ed. 1, Part 2 Particular Requirements for Electric Actuators
Plenum Rated (UL 2043). Suitable for use in other environmental air space
(plenums) in accordance with Section 300.22 (C) of the National Electric Code
Canada UL Listed, CCN XAPX7, File E27734; to UL 60730-1:02-CAN/CSA: July 2002,
Europe CE Mark – Johnson Controls declares that this product is in compliance with the
Australia and New
Zealand
Shipping Weight -xxA Models 2.0 lb (0.9 kg)
-xxB Models 2.4 lb (1.1 kg)
The performance specifications are nominal and conform to acceptable industry standards. For application at conditions beyond these
specifications, consult the local Johnson Controls office. Johnson Controls, Inc. shall not be liable for damages resulting from misapplication or
misuse of its products.
3rd Ed., Automatic Electrical Controls for Household and Similar Use; and CSA
C22.2 No. 24-93 Temperature Indicating and Regulating Equipment
essential requirements and other relevant provisions of the
EMC Directive 2004/108/EC and the Low Voltage Directive 2006/95/EC.
RCM Mark, Australia/NZ Emissions Compliant
VA9203-xxx-xx Series Electric Spring Return Valve Actuators Product Bulletin 13
Published in U.S.A. www.johnsoncontrols.com
Loading...