Jilong Rectangular User Manual

Download

Page 1

RP-14-GB(V2)

IMPORTANT SAFETY RULES

READ, UNDERSTAND, AND FOLLOW ALL INSTRUCTIONS CAREFULLY

BEFORE INSTALLING AND USING THIS PRODUCT !

RECTANGULAR FRAME POOL

OWNER’S MANUAL

FOR FOLLOWING SIZES:

-4mx2mx99 cm (13’x6,5’x39”)

-4mx2.07mx1.22m (13’x6,8’x48”)

-5.4mx2.74mx1.22m (18’x9’x48”)

Drawing for illustration purpose only. Actual product may vary. Not to scale.

DO NOT RETURN PRODUCT TO STORE

STOP!

CONTACT YOUR LOCAL AFTER SALES SERVICE CENTER

READ CAREFULLY AND KEEP IT FOR FUTURE REFERENCE!

Page 2

RP-14-GB(V2)

IMPRTANT SAFETY RULES------------------------------------------------------------------------------------02

PART REFERENCE------------------------------------------------------------------------------------------------04

SITE SELECTION---------------------------------------------------------------------------------------------------06

SET UP THE POOL-----------------------------------------------------------------------------------------------07

FILL THE POOL WITH WATER--------------------------------------------------------------------------------08

DISASSEMBLY AND STORAGE -----------------------------------------------------------------------------09

IN-SEASON POOL MAINTENANCE AND WATER CARE-------------------------------------------10

CONTENTS

TROUBLE SHOOTING ------------------------------------------------------------------------------------------11

LIMITED WARRANTY ------------------------------------------------------------------------------------------ 12

PART1-IMPORTANT SAFETY RULES

WARNING:

safety of those in and around the pool, ALWAYS STRICTLY OBSERVE the following safety and maintenance instructions:

1). It is the responsibility of the pool owner to identify and obey all local and state laws pertaining to above ground

swimming pool safety PRIOR to set-up or use of the pool. These include, but are not limited to, laws on: decks,

fences, barriers, covers, pool ladders, lighting, and required safety equipment. Please consult your local authori-

ties to ensure compliance.

2). Do not allow unattended Children in the pool. Always make sure that at least one responsible adult is supervis-

ing all Children and those who do not know how to swim AT ALL TIMES. Never swim / bathe in the pool alone.

3). NEVER permit diving or jumping into the pool. Never enter the pool from any decks or other raised surfaces.

The water level in your pool is extremely shallow and is not suitable for these activities. Failure to heed these in-

structions can result in serious injury or even death.

4). Do not permit Children or adults to engage in any “rough-housing” or other aggressive sports or activity in or

around the pool. Failure to observe this guideline can result in serious injury for those in and around the pool area.

5). Always maintain the proper pool safety equipment in an easily accessible area adjacent to your pool. Clearly

post emergency phone numbers as well as safety advisories and rules (such as “No Jumping or Diving” and “Do

Not Swim Alone”). Do not allow bathers in the pool unless the area is sufciently bright or lighted.

6). All ltrations are in agreement with the installation standard NF C 15-100 that specify that all electric appliances located within 3.50 m for the pond and with a free access should have a low voltage supply of 12V. All electrical appliance supplied with 220V must be located at least at 3.50 meter from the edge of the pond. Consult the manufacturer for any change of one or several elements to the ltration system.(For France Market)

7). the safety of your children is up to you! The risk is greatest when children are younger than 5 years old. The

accidents do not only happen to others! Be ready to face it!

8). Watch and act:

To enhance the enjoyment of your pool and protect the

Page 3

RP-14-GB(V2)

PART1-IMPORTANT SAFETY RULES

- Supervision of children must be close and constant;

- Designate one responsible for security;

- Strengthen monitoring when there are multiple users in the pool;

- Teach your children to swim as soon as possible;

- Wet neck, arms and legs before entering the water;

- Learn lifesaving, especially those specic to children;

- Forbid diving or jumping in front of young children;

- Forbid running and violent games around the pool;

- Do not allow access to the pool without a shirt or bra for a child not knowing how to swim and not accompanied

in the water;

- Do not leave toys near unmonitored pool;

- Keep water clear and healthy;

- Store water treatment products out of reach of children;

9). Plan:

- Phone near the pool accessible to not leave your children unattended when you call;

- Buoy and pole near the pool;

10). Moreover, some devices may contribute to security:

- Barrier whose portal will be constantly kept closed (e g a hedge cannot be regarded as a protective barrier);

- Manual or automatic cover properly positioned and secured protection;

- Electronic sensor to detect or drop in service and operational, but not a substitute for close supervision;

11). Accident:

- Remove the child from the water as quickly as possible;

- Call for help immediately and follow the advice that given to you;

- Replace wet clothes with warm blankets;

12). Store and view pool numbers of rst aid:

- Fire: (18 for France);

- EMS: (15 for France);

- Poison Center.

13). Prohibit access to the pool for the deterioration or the system (s) lter;

14). Do not submerge;

15). Do not walk on the edge;

16). Warning: Never put the empty swimming pool in the open air.

Stay away from drains & suction fittings

Your hair,body & jewelry can get sucked into drain.

You could be held under water & drown!

Zone 2

2.5m

Zone 1

2.5m

2.0m 2.0m 1.5m1.5m

Zone 0

Zone 2

Page 4

RP-14-GB(V2)

PART2-PART REFERENCE

-4mx2mx99 cm (13’x6,5’x39”)

-4mx2.07mx1.22m (13’x6,8’x48”)

NOTE: Drawing for illustration purpose only. Actual product may vary. Not to scale.

Before assembling your pool, layout and review the contents to become familiar with all the parts

you will be using during the assembly:

4mx2mx99 cm (13’x6,5’x39”)

NO. NAME QUANTITY

Horizontal

Beam A

Horizontal

Beam B

Horizontal

Beam C

Horizontal

Beam D

Horizontal

Beam E

6 L-Tube 4 393042 4 393050 4 290434 4 290442

7 U-Tube 10 393043 10 393051 10 290433 10 290441

8 Sleeve 8 290435 8 290435 8 290435 8 290435

2 393037 2 393045 2 290428 2 290436

2 393038 2 393046 2 290429 2 290437

2 393039 2 393047 2 290430 2 290438

2 393040 2 393048 2 290431 2 290439

2 393041 2 393049 2 290432 2 290440

SERIAL

NUMBER

4mx2.07mx1.22m

(13’x6,8’x48”)

QUANTITY

SERIAL

NUMBER

4mx2mx99 cm

(13’x6,5’x39”)

QUANTITY

SERIAL

NUMBER

4mx2.07mx1.22m

(13’x6,8’x48”)

QUANTITY

SERIAL

NUMBER

9 T-Joint 20 393010 20 393010 20 290177 20 290177

10 Hole Strainer 2 290312 2 290312 2 290312 2 290312

11 Stopper 2 290311 2 290311 2 290311 2 290311

Drainage Valve

14 Pool Liner 1 393044 1 393052 1 011414 1 011413

Cover

Drainage Valve

Connector

Color GREY GREY BLUE BLUE

1 290367 1 290367 1 290367 1 290367

1 290365 1 290365 1 290365 1 290365

Page 5

RP-14-GB(V2)

PART2-PART REFERENCE

-5.4mx2.74mx1.22m 18’x9’x48”)

NOTE: Drawing for illustration purpose only. Actual product may vary. Not to scale.

5.4mx2.74mx1.22m (18’x9’x48”)

NO. NAME QUANTITY SERIAL NUMBER QUANTITY SERIAL NUMBER

Horizontal Beam

4 L-Tube 4 290320 4 393056

5 U-Tube 14 290399 14 393057

6 Sleeve 8 290435 8 290435

7 T-Joint 28 290177 28 393010

Horizontal Beam

6 290180 6 393053

4 290196 4 393054

4 290319 4 393055

8 Hole Strainer 2 290368 2 290368

Drainage Valve

11 Pool Liner 1 011228 1 393058

Cover

Drainage Valve

connector

Pool Cover 1 016114N 1 016114NV01

Ground Cloth 1 016108N 1 016108NV01

Color BLUE GREY

1 290367 1 290367

1 290365 1 290365

Page 6

RP-14-GB(V2)

+3°

Bumpy,Sloping Ground-INCORRECT

Flat,Level Ground-CORRECT

PART3-SITE SELECTION

WARNING:

forming irregularities, or collapse, which can result in property damage or serious injury for those in or around the pool area!

WARNING:

for use of a “leveling agent”, then your set-up site is likely unsuitable. FAILURE TO OBEY THIS WARNING MAY RESULT IN SERIOUS PERSONAL INJURY.

CAUTION:

vegetation underneath the ground cloth(If applicable) will die. Furthermore, try to avoid setting the ground cloth(If applicable)in areas prone to aggressive plant and weed species, as they may grow through the ground cloth(If applicable).

CAUTION:

a Ground Fault Circuit Interrupter (GFCI). The pool should be set no closer than 10 ft. to the power source, but no further than the length of the lter pump cord. Under no circumstances should an extension cord be used to extend the range of the connection.

Pools installed on inadequately level surfaces are subject to leaking,

Do not use sand during setup process. If it appears that there is a need

Please choose your set-up area carefully, as lawn and other desirable

The pool must be accessible to a 110 or 230-volt AC outlet protected by

It is absolutely essential to select a suitable site for your pool BEFORE attempting to

ll it with any water. Please select a set-up site which strictly conforms to the following

guidelines:

Guide1. Ensure that the area is rm, at (no bumps or mounds of earth) and extremely level, with a grade not exceeding

3° of slope at any point in the set-up area.

Guide2. Make sure that the area you have selected to set-up the pool is completely free of sticks, stones, sharp objects or

other foreign debris.

Guide3. Select an area that is not directly underneath overhead power lines or trees. Additionally, make sure that the pool

set-up area does not contain underground utility pipes, lines, or cables or any kind.

Guide4. If a ground cloth is provided with your pool kit, its use is highly recommended. The ground cloth will help protect

the pool liner from damage due to weed growth, sharp objects, and debris.

Guide5. If at all possible, choose an open location on your property that is exposed to direct sunlight. This will help to

warm your pool.

Page 7

RP-14-GB(V2)

PART4-SET UP THE POOL

IMPORTANT: Do not start assembly if any pieces are missing. For replacement pieces call the Consumer Service

telephone number in your area.

The number of persons required for installation: 2 adult at least.

Total installation time except the time for site preparation and water lling : 45 minutes for size 13’×6.5'×39"/13'×6.8'×48"; 60 minutes for size 18’×9'×48".

Step1. ACCOUNT FOR ALL PARTS.

Remove all the parts from the carton(s) and place them on the ground in the location where they are to be assembled

Check each part according to “PART REFERENCE” .Make sure all the pieces to be assembled are accounted for.

Step2. INSTALL DRAIN VALVES COVER AND STOPPER

Make sure that outer drain plug is inserted into the outer drain cap and drain valve cover is screwed on tightly.Plug the con-

nection holes with the stoppers. (The out drain plug changes according to different size of pool.)

STOPPER Out Drain Plug A Out Drain Plug BDrain Vavle Cover

Step3. INSTALL THE U-TUBES

Slide each U-tube through the bottom addition connected belt T-joint

Step4. INSTALL HORIZONTAL BEAM

For the long side sleeve of the pool:

BEAM E BEAM D

For 4mx2mx99 cm (13’x6,5’x39”)/4mx2.07mx1.22m (13’x6,8’x48”), the combination is E-D-C

BEAM C

BEAM A

For 5.4mx2.74mx1.22m (18’x9’x48”), the combination is C-A-A-A-B

BEAM A BEAM A

BEAM C

BEAM B

Slide combined beams into sleeve,the hole on the beams should face outwards.

For the short side sleeve of the pool:

BEAM A

For 4mx2mx99 cm (13’x6,5’x39”)/4mx2.07mx1.22m (13’x6,8’x48”), the combination is A-B

BEAM B

Page 8

RP-14-GB(V2)

Step5. INSTALL HORIZONTAL BEAM AND L-TUBE

Plastic Sleeve

Use the connection end of the L tube to connect the adjacent horizontal tubes with transparent plastic sleeve.

Step6. INSTALL HORIZONTAL BEAM AND U-TUBES

BEAM B BEAM C

For 5.4mx2.74mx1.22m (18’x9’x48”), the combination is B-C

Slide combined beams into sleeve,the hole on the beams should face outwards.

Find the one side holes on the horizontal beam.Place and lock the T-joints into the holes.Ensure they are fully connected

PART5-FILL THE POOL WITH WATER

WARNING:

start lling in the center.The pool is not level enough, and must be corrected! You

shall pull out the drain plug, release the water completely, disassemble the pool completely,locate the pool on a plane surface, repeat set up instructiion.

WARNING:

heavy rainfall you may need to empty some of the water to ensure the level is correct.

Do not leave pool unattended while lling with water.

If more than 1~2 inches of water collects on any one side before you

DO NOT OVERFILL as this could cause the pool to collapse.In times of

1. Make sure the drain tting is plugged securely and the cap is in place. Start lling the pool with water. After about 1-inch of water is on the bottom, stop lling and smooth wrinkles out of the

bottom of the pool. Pull the outer wall out from the top edge, all

around the bottom of the pool, so that it lls evenly.

2. Contineue lling the pool until water level.

Page 9

PART6-DISASSEMBLY AND STORAGE

RP-14-GB(V2)

WARNING:

Do not let your children stand at downfold and face the water outlet

during the drainage. The water current may sweep your children.

WARNING:

Pool should be stored at places where is cool and dry, with no sharp object surroued, or no heavy objects lying above, which may cause damage to the pool.

Step1. If you have a lter pump, make sure that the electricity source to the lter pump has been disconnected. Step2. Check to ensure that the out drain plug is rmly inserted on the inside of the pool. Step3. Attach your garden hose to the drainage valve connector, and placing the other end of the hose in an area where the

water can drain safely, such as a storm drain or street gutter. Remember that because water always nds its own level, the end

of the hose must be lower in elevation than the pool to ensure complete drainage.

Step4.If you have a lter pump, insert the stopper into the inlet and outlet xtures, on inside of pool, and then disconnect the

lter pump hoses.

Step5. Attach the drainage valve connector to the drain outlet by turning connector in a clockwise direction. Step6. Open the out drain plug on the inside of the pool and the water will begin to drain immediately. Step7. Disconnect the hose and drainage valve connector when nished. Step8. Replace the out drain plug on the inside of the pool. Step9. Be sure that the pool liner is completely dry before folding the pool for long-term storage. Leaving the pool exposed to

sunlight for a few hours will clean and speed the drying process and make it easier to fold the pool for storage. (Never attempt

to fold or stow a pool that is not completely dry as this could lead to a proliferation of mold or mildew build-up during the time

the pool is in storage.)

Step10. Remember, proper off-season storage is critical to protect your investment in your pool.(espeically in winter) Once

drained and dry, your pool should be carefully folded and wrapped in a ground cloth (if available) or other similar protective

tarp-like material. The pool and all applicable accessories such as the pump, cover, ground cloth, ladder, hoses, clamps, and

hardware should be kept together and stored indoors, in a reasonably warm, dry and weatherproof location.

FOLDING INSTRUCTION

Before folding, it’s better to dry all parts and pool completely by lying them in the sun for one hour or so.(PIC.1). And then, spread some talcum powder to prevent the vinyl from sticking together.

Step1. Please fold the protrusion sides inside to gain rectangle shape.(PIC.2). Step2. Fold each half of the rectangle to gain a smaller rectangle shape.(PIC.3). Step3. Fold each ends backwards. (PIC.4). Step4. Fold the rest ends together to create an ultimate rectangle one.(PIC.5). TIPS1. Please remove air inside to make the folded pool thin and at during each folding. TIPS2. The original packing can be used for storage.

PIC.1 PIC.3 PIC.4PIC.2

PIC.5

Page 10

RP-14-GB(V2)

PART7-IN-SEASON POOL

MAINTENANCE AND WATER CARE

WARNING:

other small particles from your pool water. However, to maintain pool water that is perfectly clear, algae free, and safe from harmful bacteria, it is VERY IMPORTANT TO ENGAGE IN A CONSISTENT REGIMEN OF CHEMICAL TREATMENT. Contact your local pool supply retailer for guidance on the safe and effective use of chlorine, shock, algaecide and other such chemicals.

WARNING:

pool while it is occupied. Never add any chemicals or substances to your pool if you cannot verify the

exact quantity or type to add to the water. Consult a pool supply retailer for specic instructions and

guidelines concerning the use of chemicals in your pool.

WARNING:

that the pH and chlorine concentration in the water is optimal for safe and enjoyable bathing throughout

the season. Please consult your pool supply retailer to nd a suitable testing kit and instructions on its

use.

WARNING:

especially for the children.

This product is designed to be storable, seasonal pools. If you live in a temperate area in which the pool will not be in use year-round, it is STRONGLY RECOMMENDED that you drain your pool, clean and dry it thoroughly, and store it in a protected area for the off-season. This will help extend the life of your pool and prevent a safety hazard from developing while the pool is not in use. During the season of use of the pool kit, the ltration system (if applicable) must be put into service each day, long enough to ensure at least a complete renewal of the volum of water.

If applicable, the lter pump included with your pool is designed to remove dirt and

To avoid skin and eye irritation or even injury to bathers, never add chemicals to the

It is highly recommended that pool owners frequently test their pool water to ensure

Non-respect of the maintenance rules may result in serious hazards for health and

In order to keep your pool water clean and hygienic all season long please closely adheres to the following guidelines:

1. The proper and consistent use of basic pool chemicals are required to maintain the proper pH balance in your pool water. Furthermore, the application of chemicals will help prevent the growth of harmful bacteria or algae in your pool, and assist your

lter-pump in keeping your water crystal clear. Chemicals that your pool may require include but are not limited to:

1) Tabular, Granular, or Liquid Chlorine: Disinfects pool water and inhibits algae growth.

2) PH Adjusting Chemicals: These are used to correct PH level and make water more or less acidic.

3) Algaecides: These chemicals are formulated to remove algae.

4) “Shock” (Super chlorinator): Eliminates certain organic and other combination compounds that can affect water clarity.

In order to obtain specic details on the use of chemicals, please consult a local pool supply retailer and provide them with the volume of water in your specic pool, and if desired, a sample of your pool water. This will enable them to properly instruct you on: 1) which chemicals to purchase, 2) what quantities of chemicals to purchase, and 3) how to use specic chemicals

safely and effectively.

2. Never let chlorine come into direct contact with the pool liner until it has completely dissolved. This means that granular or

tabulated chlorine is rst dissolved in a bucket of water before applying to pool water, and likewise, liquid chlorine is slowly and

evenly poured into pool water from various locations around perimeter of pool. DANGER: NEVER add water to chemicals. INSTEAD, always add chemicals to water. Also, never mix separate chemicals together, rather, add chemicals to the pool separately and allow them to circulate throughout the pool before adding additional types of chemicals.

3.We recommend that you purchase a test kit, and frequently test your pool water to make sure that your PH balance and chlorine levels are optimal. Your local pool supply retailer can provide information on purchasing and using a test kit that is most suitable for your needs. NOTE: Excessive chlorine levels or low (acidic) pH levels can damage your pool liner, so please take corrective action as soon as possible if testing reveals either condition.

The tasks of removing larger debris from your pool and keeping the inside of the pool liner clean are simplied by using a

Prompt Set Pool Maintenance Kit, which includes a leaf skimmer and garden hose powered vacuum. Maintenance Kits are

included as a bonus feature in larger pool systems, and can also be purchased separately as an accessory.Please contact

Page 11

RP-14-GB(V2)

PART7-IN-SEASON POOL

MAINTENANCE AND WATER CARE

your local after sale service center if you want to get advice on any repair during the life of the pool kit.

4. If applicable, check your lter-pump cartridge every two weeks (or more frequently during periods of heavy usage) to verify

whether it needs to be cleaned or replaced. If your cartridge is no longer white in color, attempt to spray it clean with a strong

blast of water from your garden hose. If your cartridge cannot be cleaned in this manner, the cartridge must be replaced. Failure

to frequently clean and/or replace your cartridges will affect the effectiveness of your lter pump and could shorten its useful life.

5. If your pool system included a cover, try to keep your pool covered at all times when not in use. This will help keep the wind

and other elements from depositing dirt and debris in your pool, and will also prevent excess rainwater from overlling your pool.

6. Remind your family and friends to always hose or rinse off any dirt or tanning oil from their hands, feet, and body prior to

entering the pool.

7. It’s necessary to monitor the bolts and hardware of the pool (eg. rust stain) when possible.

8. Once your pool has been lled with water for the season, take note if your pool becomes overlled due to rainwater or accidental overll. If this should occur, it is important to drain or bale out the excess water as soon as possible. If it is an inatable ring pool, the water level should never be higher than the bottom edge of the inatable ring.

PART8-TROUBLE SHOOTING

PROBLEM DESCRIPTION CAUSE REMEDY

COLORED

WATER

PARTICALS

SUSPENDED

IN WATER

PERSISTENT LOW WATER

LEVEL

ALGAE

POOL

WATER

IS COOL

• Water turns blue, brown, or black

when first treated with chlorine.

• Water looks “milky” or cloudy. • “Hard Water” caused by an elevat-

• Pool appears to be losing water on

a daily basis.

• Water has greenish tint.

• Green, brown or black spots

appear on pool liner.

• Pool bottom is slippery and/or an

unpleasant odor is present.

• Water is not warming to a comfortable swimming temperature.

• The chlorine is oxidizing minerals

in your water. This commonly occurs with water from different sources.

ed pH.

• Chlorination is inadequate.

• Foreign debris in water.

• Bathers are not cleaning their feet

prior to entering pool.

• Tear or hole in pool liner.

• Tear or hole in a filter pump hose.

• Hose clamps are too loose.

• Evaporation from high summer

temperatures.

• Algae is present. • Apply “shock” treatment (super-

• Pool was set up in an excessively

shady or tree lined area.

• Heat is escaping from pool water.

• Adjust pH to recommended level.

• Run filter until water is clear.

• Regularly clean cartridge.

• Adjust pH. Check with a swimming

pool supply retailer for correct water treatment.

• Ensure proper chlorine level.

• Clean or replace your filter.

• Spray off dirt with a high-pressure

hose before entry.

• Locate damage and repair with the

included patch kit.

• Repair or replace hoses.

• Tighten all hose clamps.

• Keep pool covered when not in

use.

chlorinator). Check pH and adjust to an appropriate level per your local pool supply retailer.

• Vacuum or lightly scrub pool liner.

• Test water often to maintain proper

chlorine levels.

• Relocate pool to a more open

location where it can get maximum exposure to sunlight during peak daylight hours.

• Keep your pool covered whenever

it is not in use.

1110

Page 12

RP-14-GB(V2)

We warrant all components contained in this Prompt Set™ Pool/SPA Pool (excluding the lter pump unit) against defects in

materials and workmanship under normal use and service, for a period of 90days from the date of purchase for the original

owner only.

If any of the components have been consumer-replaced, damaged, or misused, the corresponding warranty on those compo-

nents is invalidated. In this situation, you will be advised of the cost of replacement parts and processing instructions.

If a veriable manufacturing defect is found during the relevant time period, we agree to repair or replace at its option any

product under warranty provided proper proof of purchase is presented.

This limited warranty is not valid if the product is used for commercial purposes, or if the damage is caused by an accident, an

act of God, consumer misuse, neglect or abuse, vandalism, improper use of chemicals, exposure to extreme weather condi-

tions or negligence during product set up or disassembly.

We cannot be held responsible for the cost of installation, labor, or transportation expenses incurred due to the replacement of

defective parts. This limited warranty, furthermore, does not cover any unauthorized alterations to the product.

PART9-LIMITED WARRANTY

Model Size Water Capacity Pump Ladder

JL017233NG/NN/ND

JL017233N

JL017233NF

JL017445NG/NN/ND/NC/NF

JL017445N

JL017445-1NG/NN/ND/NC/NF

JL017234NG/NN/ND/NF

JL017234N

JL017451NG/NN/ND/NC/NF

JL017451N

JL017451-1NG/NN/ND/NC/NF

JL016110NG/NN/ND/NF

4mx2mx99 cm (13’x6,5’x39”) 1854Gal(7020L)

4mx2.07mx1.22m (13’x6,8’x48”) 2343Gal(8870L)

5.4mx2.74mx1.22m (18’x9’x48”) 4171Gal(15787L)

√ ×

× ×

√ √

× ×

√ √

× ×

√ √

× ×

√ √

JL016110N

JL017443NG/NN/ND/NC/NF

JL017443-1NG/NF

5.4mx2.74mx1.22m (18’x9’x48”) 4171Gal(15787L)

× ×

√ √

Jilong Rectangular User Manual

Specifications and Main Features

Frequently Asked Questions

User Manual