Jenn-Air 730-0165 User Manual

STAINLESS STEEL NATURAL GAS GRILL

MODEL NO.: 730-0165 ITEM NO: 31012

Jenn-Air is a Trademark of the Maytag Corporation and is used under license to Lowe’s Companies, Incorporated.

FOR OUTDOOR USE ONLY

PLEASE CONTACT 1-800-554-5799 FOR ASSISTANCE
DO NOT RETURN TO PLACE OF PURCHASE

TABLE OF CONTENTS

SECTION ONE
Safety Instructions…………………………..
Placement of the Grill……………………….

SECTION TWO
Side Shelf Assembly………………………….
Side Shelf Handle & Battery Installation….
Braking System Operations………………...
Installation of Natural Gas Regulator……….

SECTION THREE
Gas Hook Up & Leak Testing………………..
Installer Final Check…………………………

SECTION FOUR
Operating Instructions……………………….
Lighting Instructions…………………………
To Match Light the Grill……………………..
Lighting Illustrations………………………….
Using the Side Burner………………………
Care and Maintenance of Side Burner……...
Care and Maintenance of the Grill…………
Troubleshooting………………………………

WARNING

1-5
5

6
7
8
8

9
10

11
12
13
14
15
15
16
17

SECTION FIVE
Exploded View…………………………..
Parts List………………………………..

SECTION SIX
Grilling Hints………………………………..
Grill Cooking Chart………………………
Grill Recipe Suggestions……………….

SECTION SEVEN
Limited Warranty…………………………

18
19

20
20-22
23-24

25

To reduce the risk of fire, burn hazard or other
injury, read this Care and Use Manual carefully
and completely before using your grill.

SAFETY INSTRUCTIONS
RECOGNIZED SAFETY SYMBOLS, WORDS AND LABELS

WARNING

WARNING – Hazards or unsafe

practices which COULD result in severe
personal injury or death.

CAUTION

CAUTION – Hazards or unsafe practices
which COULD result in minor personal
injury.

WARNING
Do not try lighting this appliance without first reading
the “LIGHTING INSTRUCTIONS” section of this
manual.

Spiders and insects can nest inside the burners of
the grill and disrupt gas flow. This very dangerous
condition could cause a fire behind the valve panel,
thereby damaging the grill and making it unsafe for
operation.
Inspect the grill at least twice a year.

WARNING

WARNING

1. The grill and its individual shut-off valve must be disconnected from the gas supply piping
system during any pressure testing of that system at test pressure in excess of ½ psi. (3.5
kpa).

2. The grill must be isolated from the gas supply piping system by closing its individual
manual shut-off valve during any pressure testing of the gas supply piping system at test
pressure equal to or less ½ psi. (3.5 kpa).

WARNING
Never attempt to use damaged or obstructed equipment. See your local liquid propane dealer for
repair.

WARNING
Check all gas supply fittings for leaks before each use. Do not use the grill until all connections

have been checked and do not leak.
Do not smoke while leak testing.
Never leak test with an open flame.

CAUTION

When using the rotisserie burner, remove the
warming rack. High heat from the burner
may cause the warming rack to bend.

WARNING

The rotisserie motor is equipped with a plug and should
be plugged directly into a properly grounded receptacle.
DO NOT cut or remove the grounding prong from this
plug.
Keep the rotisserie motor electric cord away from the
heated surfaces of the grill. When not in use remove and
store the motor in a dry location

WARNING

1. Attach the coupling half (socket) to
the gas supply line in accordance
with NFPA54/ANSI Z223.1FUEL gas
code.

2. Prior to inserting the plug, test the
connection for leaks following the
leak test instructions on page 10.
After the leak test is completed, rinse
the connection with clean water to
remove any corrosive residue.

3. Do not use open flame to test for
leaks.

1

SAFETY INSTRUCTIONS

WARNING

Do not use the grill if the odor of gas is
present. Contact customer service at 1­800-554-5799.

When lighting, keep your face and hands
as far away from the grill as possible.

If you smell gas:

1. Shut off gas to the appliance.

2. Extinguish any open flame.

3. Open lid.

4. If odor continues, immediately call your
gas supplier or your fire department.

Do not store or use gasoline or other
flammable vapors and liquids in the vicinity
of this or any other appliance.

WARNING

WARNING

WARNING

CAUTION

When using a match to light the grill make
sure to use the attached lighting rod.

CAUTION

Before cleaning, make sure the gas supply
and control knobs are in the “OFF” position
and the burners have cooled.

WARNING

Failure to properly place the burner over
the orifice could cause a fire to occur
behind and beneath the valve panel,
thereby damaging the grill and making it
unsafe to operate.

WARNING

Do not leave the grill unattended while
cooking.

2

SAFETY INSTRUCTIONS

WARNING

Do not attempt to light the grill if gas odor is
present. Contact customer service at 1-800­554-5799.

When lighting, keep your face and body as far
away from the burner as possible.

BEFORE LIGHTING

Inspect the gas supply hose prior to turning on the
gas. If there is evidence of cuts, wear, or abrasion,
it must be replaced prior to use.

Only the pressure regulator and hose assembly
supplied with the unit should be used. Never
substitute regulators for those supplied with the
grill. Contact customer service for proper
replacement.

Leak check the piping and regulator connections
with a soap and water solution before operating
the grill (See the “Leak Testing” instructions on
page 9).

Do not turn “ON” the gas supply at the natural gas
shut off valve unless the Quick-Connect gas hose
is properly connected to the side burner gas pipe
system and all burner valves are in the “OFF”
position.

WARNING

Do not store or use gasoline or other flammable
vapors and liquids in the vicinity of this or any
other appliance.

USING THE SIDE BURNER

Inspect the gas supply hose prior to turning on
the gas. If there is evidence of cuts, wear or
abrasion, it must be replaced prior to use. Do
not use the side burner if gas odor is present.

Keep a spray bottle of soapy water near the
gas supply valve and check the connections
before each use.

ROTISSERIE DRIVE MOTOR

To ensure continued protection against electric
shock:

Connect to properly grounded outlets only.
Keep extension cord connections dry and off

the ground.
Do not expose to rain.
Do not use indoors.

WARNING

If you smell gas:

1. Shut off gas to the grill.

2. Open the top cover or lid.

3. Extinguish any open flames.

4. If the odor continues, immediately call your
gas supplier or local fire department.

3

SAFETY INSTRUCTIONS

WARNING

Do not try lighting this appliance without first
reading the “LIGHTING INSTRUCTIONS” section
of this manual.

TESTED IN ACCORDANCE WITH ANSI Z21.58
LATEST STANDARD and CSA 1.6 LATEST
STANDARD FOR OUTDOOR COOKING GAS
APPLIANCES.

Check your local building codes for the proper
method of installation. In the absence of local
codes, this unit should be installed in accordance
with the National Fuel Gas Code ANSI
Z223.1/NFPA 54, or CSA B149.1 Natural Gas and
Propane Installation Code, and the National
Electrical Code, ANSI/NFPA 70.

CALIFORNIA PROPOSITION 65-WARNING

The burning of gas fuel generates some by­products, which are known by the State of
California to cause cancer or reproductive harm.
To minimize exposure to these substances,
always operate this unit according to the care and
use manual, ensuring you provide good
ventilation when cooking with gas.

SAFETY PRACTICES TO AVOID INJURY

When properly cared for, your grill will provide
safe, reliable service for many years. However,
extreme care must be used as the grill produces
intense heat that can increase accident potential.

When using this appliance basic safety practices
must be followed, including the following:

Do not repair or replace any part of the grill unless
specifically recommended in this manual. All other
service should be referred to a qualified
technician.

The grill is for outdoor use only.

The grill is not intended to be installed in or on
recreational vehicles and/or boats.

Children should not be left alone or unattended in
an area where the grill is being used. Do not allow
children to sit, stand or play on or around the grill
at any time.

Do not store items of interest to children around or
below the grill or cart. Do not allow children to
crawl inside the cart.

Never let clothing, pot holders or other flammable
materials come in contact with or too close to any
grate, burner or hot surface until it has cooled.
The fabric could ignite, causing serious personal
injury.

For personal safety, wear proper apparel. Loose
fitting garments or sleeves should never be worn
while using this appliance. Some synthetic fabrics
are highly flammable and should not be worn
while cooking.

Only certain types of glass, ceramic, earthenware,
or other glazed utensils are suitable for grill use.
Other types of materials may shatter with sudden
temperature changes. Use only on low or medium
heat settings in accordance with the
manufacturer’s guidelines.

Do not heat unopened food containers as a build­up of pressure may cause the containers to burst.

Use a covered hand when opening the grill lid.
Never lean over an open grill.

When lighting a burner, always pay close
attention to what you are doing. Make certain you
are aware of which burner you are lighting so that
your body and clothing remain clear of open
flames.

4

SAFETY INSTRUCTIONS

When using the grill, do not touch the grill rack,
burner grate or immediate surroundings as these
areas become extremely hot and could cause
burns. Use only dry potholders. Moist or damp
potholders on hot surfaces may cause steam burns.
Do not use a towel or bulky cloth in place of
potholders. Do not allow potholders to touch hot
portions of the grill rack.

Grease is flammable. Let hot grease cool before
attempting to handle it. Do not allow grease
deposits to collect in the grease tray at the bottom
of the grill’s firebox. Clean the grease tray often.

Do not use aluminum foil to line the grill racks or
grill bottom. This can severely upset combustion air
flow or trap excessive heat in the control area.

For proper lighting and performance of the burners,
keep the burner ports clean. It is necessary to clean
them periodically for optimum performance. The
burners will only operate in one position and must
be mounted correctly for safe operation.

Clean the grill with caution. To avoid steam burns,
do not use a wet sponge or cloth to clean the grill
while it is hot. Some cleaners produce noxious
fumes or can ignite if applied to a hot surface.

INSECT WARNING

Spiders and other insects can nest inside the
burners of this and other grills, which could disrupt
gas flow. This dangerous condition could cause a
fire behind and beneath the valve panel, damaging
the grill and making it unsafe for operation.

Inspect the grill at least twice a year.

PLACEMENT OF THE GRILL

CLEARANCE
Non-Combustible Construction

A minimum of 3 inches clearance from the back
of the grill to non-combustible materials are
required for the lid to open fully.

WARNING
Do not install this unit into combustible
enclosures. There should be a minimum
clearance of 24 inches from all sides to
combustible materials.

Turn off all control knobs and make certain the grill
is cool before using any type of aerosol cleaner on
or around it. The chemical that produces the
spraying action could, in the presence of heat,
ignite or cause metal parts to corrode.

Do not use the grill to cook excessively fatty meats
or other products, which promote flare-ups.

Do not operate the grill under unprotected
combustible constructions. Use only in well­ventilated areas. Do not use in buildings, garages,
sheds, breezeways or other such enclosed areas.

This unit is intended for outdoor use only.
Keep the areas surrounding the grill free from

combustible materials, fluids, trash, and vapors
such as gasoline or charcoal lighter fluid. Do not
obstruct the flow of combustion and ventilation air. If
the unit is stored indoors, make sure it is cool.

Do not use briquettes of any kind in the grill.
The 730-0165 natural gas grill is designed for

optimum performance without the use of briquettes.
Do not place briquettes on the flame tamers, as this
will block the vent to the grill burners. Adding
briquettes can damage ignition components and
knobs, thus voiding the warranty.

Keep the back of the cart free and clear from
debris. Keep electrical supply cords and the
rotisserie motor cord away from heated areas of the
grill.

Never use the grill in extremely windy conditions. If
located in a consistently windy area (oceanfront,
mountaintop, etc.), a windbreak will be required.
Always adhere to the clearance specifications.

LOCATION

When determining a suitable location take into
account concerns such as exposure to wind,
proximity to traffic paths, and keeping gas supply
lines as short as possible.

Place the grill in well-ventilated areas. Never place
the grill in a building, garage, breezeway, shed or
other such enclosed areas. During heavy use, the
grill will produce a lot of smoke.

5

SIDE SHELF ASSEMBLY

Estimated Assembly Time: Approximately 5-7 minutes
Required Tools: Phillips Screwdriver

1. Open the grill lid and remove the side shelf from the fire box.

2. The screws used to attach the side shelves are already screwed into the side panels of the grill

cart. Remove the screws from the side panels.

3. Align the holes of the left side shelf with the holes in the grill cart. Insert the screws and tighten.

Note: The top two screws insert from inside the fire box while the bottom two screws insert
from under the left side shelf (see drawing).

4. Repeat steps 2 and 3 to install the right side burner to the right side panel.

Secure the bottom two screws
from below the side shelf.

Secure the top two screws
from inside the fire box.

6

SIDE SHELF HANDLE ASSEM BLY

Estimated Assembly Time: Approximately 5-7 minutes
Required Tools: Phillips Screwdriver

1. Remove the four side shelf handle screws from the side of the shelf.

2. Align the holes in the handle with the holes in the side shelf.

3. Insert the screws and tighten.

BATTERY INSTALLATION

1. Remove the ignition button housing.

2. Insert the battery into the housing with the positive terminal facing outward.

3. Replace the ignition button housing after the battery has been installed.

7