Jaypro Sports PVB-2500 User Manual
JAYPRO PVB SERIES SECOND FLOOR INTERNATIONAL NET SYSTEM
Installation and Operating Instructions
Applicable Part Numbers/Models:
PVB-2500: Second Floor International Net System
JSL-Inst046
www.jayprosports.com
PVB Series Second Floor International Net System Instructions
UPRIGHT
OUTER
DIAMETER
HEIGHT RANGE
# OF
POSITIONS
WEIGHT
UPPER
UPRIGHT
MATERIAL
LOWER
UPRIGHT
MATERIAL
PVB-2500
3-1/2”
(89mm)
6’6” to 8’2”
(1.8m to 2.5m)
16
Pin Stops
145 lbs
(66kg)
Aluminum
6063
Aluminum
6063
Table of Contents
1 Safety ................................................................................................................ 1
2 Specifications .................................................................................................. 1
3 Introduction ..................................................................................................... 2
4 Required Tools ................................................................................................. 4
5 Included Hardware & Components ............................................................ 4
5.1 System Components.............................................................................. 4
5.2 Hardware ................................................................................................. 6
6 Assembly .......................................................................................................... 7
7 Maintenance ................................................................................................ 11
1 Safety
WARNING: Do not attempt to remove the height adjuster pin if the net is under
tension.
WARNING: Always use protective padding around each upright during use.
WARNING: Uprights are heavy. Do not attempt to lift or install without assistance.
IMPORTANT: Follow all warning labels on equipment.
IMPORTANT: Inspect for damage before and after each use.
IMPORTANT: Do not use unless installed into floor anchors.
2 Specifications
- 1 of 11-
JSL-Inst046
www.jayprosports.com
PVB Series Second Floor International Net System Instructions
1
1
3 Introduction
Note: The Flex Net supplied with this system will stretch slightly during the first few uses.
This is a natural consequence of the headband fibers being stretched under tension.
During this break-in period, the headband and net body may sag during use. Simply
increase tension to remove the sag.
These instructions assume that the appropriate floor anchors have been correctly
installed:
The anchors must be internally threaded with 1/2'”-13 threads
The anchors must be installed 17” apart on center (see Figure 3-1).
The Flex-Net will work with upright standards spaced 35’ to 37’ apart on center
Please consult the instructions and specifications supplied with your floor anchors for
more information.
If you require additional information or support to install or operate your volleyball system,
please contact the Jaypro Sports customer support team, Monday through Friday,
8:30AM to 5:00 PM (EST), at 1-800-243-0533.
.
NCAA and NFHS rules require that the upright standards must be installed at least 3’3”
(1m) outside the court boundaries. Jaypro recommends 36’ spacing on center to satisfy
both regulations.
- 2 of 11-
JSL-Inst046
www.jayprosports.com
PVB Series Second Floor International Net System Instructions
Figure 3-1: Correct floor anchor layout.
Refer to instructions included with floor anchors for anchor installation details.
- 3 of 11-
JSL-Inst046
www.jayprosports.com
Loading...