Jaypro Sports PVB-1500 User Manual
JAYPRO PVB SERIES COLLEGIATE NET SYSTEM
Installation and Operating Instructions
Applicable Part Numbers/Models:
PVB-1500: Steel Collegiate Net System
PVB-4500/PVB-5000: Featherlite Collegiate Net system
JSL-Inst040
www.jayprosports.com
PVB Series Collegiate Net System Instructions
Table of Contents
1 Safety ................................................................................................................ 2
2 Specifi cations .................................................................................................. 2
3 Introduction ..................................................................................................... 2
4 Required Tools ................................................................................................. 3
5 Included Hardware & Components ............................................................ 4
5.1 System Components .............................................................................. 4
5.2 Ha rdwa re ................................................................................................. 5
6 Assembly .......................................................................................................... 6
7 Maintenance .................................................................................................. 9
- 1 of 9-
JSL-Inst040
www.jayprosports.com
PVB Series Collegiate Net System Instructions
1 Safety
• WARNING: Do not attempt to remove the height adjuster pin if the net is under
tension.
• WARNING: Always use protective padding around each upright during use.
• WARNING: Uprights are heavy. Do not attempt to lift or install without assistance.
• IMPORTANT: Follow all warning labels on equipment.
• IMPORTANT: Inspect for damage before and after each use.
2 Specifications
PVB-1500
PVB-4500
(3” FLOOR
SLEEVE)
PVB-5000
UPRIGHT
OUTER
DIAMETER HEIGHT RANGE
3-1/2”
(89mm)
3-1/2”
(89mm)
3-1/2”
(89mm
6’6” to 8’2”
(2.0m to 2.5m)
6’6” to 8’2”
(2.0m to 2.5m)
6’6” to 8’2”
(2.0m to 2.5m)
#
OF
POSITIONS WEIGHT
16
Pin Stops
16
Pin Stops
16
Pin Stops
152 lbs
(69kg)
104 lbs
(47kg)
104 lbs
(47kg)
PPER
U
UPRIGHT
MATERIAL
Aluminum
6063
Aluminum
6063
Aluminum
6063
L
UPRIGHT
MATERIAL
Steel
Aluminum
6063
Aluminum
6063
OWER
3 Introduction
Note: The Flex Net supplied with this system will stretch slightly during the first few uses.
This is a natural consequence of the headband fibers being stretched under tension.
During this break-in period, the headband and net body may sag during use. Simply
increase tension to remove the sag.
These instructions assume that the appropriate ground sleeves have been correctly
installed:
• The inside bottom surface of the ground sleeves must be 10” below ground level
(Figure 3-1).
• The PVB-1500 and PVB-5000 standards will fit most 3-1/2” inner diameter ground
sleeves (or 4” ID sleeves with adapter).
• The PVB 4500 will fit most 3’’ inner diameter ground sleeves.
1
• The Flex-Net will work with ground sleeves spaced 35’ to 37’ apart on center
.
Please consult the instructions and specifications supplied with your ground sleeves for
more information.
If you require additional information or support to install or operate your volleyball system,
please contact the Jaypro Sports customer support team, Monday through Friday,
8:30AM to 5:00 PM (EST), at 1-800-243-0533.
1
NCAA and NFHS rules require that the upright standards must be installed at least 3’3”
(1m) outside the court boundaries. Jaypro recommends 36’ spacing on center to satisfy
both regulations.
- 2 of 9-
JSL-Inst040
www.jayprosports.com
Loading...