Jaypro Sports LC-6 User Manual

-- Little Champ Easy Adjust Backboard Adapter --
Installation Instructions
Call Jaypro Sports Equipment at 1-800-243-0533
during regular business hours for technical support.
www.jaypro.com
Page 1 of 16
ITEM
IMAGE
DESCRIPTION
QTY
1
FAN BACKBOARD (P/N: FSGB-1)
1
2
LITTLE CHAMP REAR FRAME
(PRE-ASSEMBLED)
1
3
FOLDING RIM (P/N: G-35)
1
4
TOP BOARD MOUNT PLATE (P/N: LC-6A15)
1
5
BOTTOM BOARD MOUNT PLATE (P/N: LC-6A16)
1
6
MEDIUM SUPPORT ARMS * (P/N: LC-6A11)
2
7
LARGE SUPPORT ARMS * (P/N: LC-6A12)
2
8
LITTLE CHAMP HANDLE (P/N: LC-6A17)
1
9
LITTLE CHAMP CRANK HANDLE (P/N: HA-2H)
1
10
5/16” x 1-1/2” LONG CARRIAGE BOLT (P/N: HB4078)
4
ITEM
IMAGE
DESCRIPTION
QTY
PARTS LIST (QTY: SINGLE UNIT)
Page 2 of 16
- 1/2" Socket or Box Wrenches
-
Tape Measure
- Level
-
Screwdriver
- Tape Measure
- 8 ft to 10 ft step ladder
-
Socket Wench
ITEM
IMAGE
DESCRIPTION
QTY
11
5/16” x 2” LONG HEX HD CAP (P/N: HS282)
2
12
5/16” x 3-3/4” LONG HEX HD CAP (P/N: HS5317)
2 13
5/16” x 1-1/2” FLAT MACHINE SCREW (P/N: HS5316)
4
14
5/16” FLAT WASHER (P/N: HW2049)
14
15
5/16” NYLON LOCK NUT (P/N: HN261)
8
16
5/16 ID x 1” LONG SLEEVE BEARING
(P/N: HM6544)
2
17
5/16 ID x 3/4” LONG SLEEVE BEARING
(P/N: HM6543)
4
18
WARNING LABEL (P/N: LC-ISA)
USE UNDER CLOSE ADULT SUPERVISION ONLY! DESIGNED FOR YOUTH PLAY ONLY! DO NOT ALLOW DUNKING!
1
19
WARNING LABEL (P/N: LC-ISB)
INSTALLATION AND REMOVAL SHOULD BE DONE BY TWO ADULTS! INSPECT UNIT BEFORE EACH USE TO MAKE SURE IT IS PROPERLY INSTALLED!
WHEN NOT IN USE, REMOVED UNIT TO AVOID UNAUTHORIZED PLAY!
1
20
HEIGHT LABELS
(PRE-APPLIED)
2
ITEM
IMAGE
DESCRIPTION
QTY
Tools Require:
o Unpack all parts and check against parts list to ensure that all have been included. o Inspect all parts for damage. Report any damages to the trucking company. o See additional parts see Maintenance on the last page.
* Extra support arms are included to accommodate various backboards.
Page 3 of 16
IMPORTANT NOTICE:
The LC-6, Little Champ is designed for youth play only, specifically for children between the ages of 5 to 11 yrs old.
The LC-6, Little Champ, is not designed to be used for slam dunking. Slam dunking may result in damage to the unit, or serious injury.
CAREFULLY READ ALL INSTRUCTIONS AND WARNINGS BEFORE INSTALLING AND USING THE LITTLE CHAMP.
The Little Champ should be set-up and removed only by authorized adults who are familiar with the handling procedures contained herein.
The Little Champ should be used only under close supervision of authorized adults.
Two adults are required to safely install and remove the Little Champ. One person is required to assist in lifting the unit and then helping to guide it over the rim and into place.
The entire Little Champ unit weighs about 50 lbs. Do not attempt to install the Little Champ by yourself, or if the weight exceeds that which you can safely handle over your head.
Always employ safe lifting techniques when lifting the Little Champ into place. Although the Little Champ may be installed from the floor, the use of a step ladder is highly recommended.
The Little Champ should only be installed on a sturdy backstop and rim system. Do not install the Little Champ if the backstop system, including rim and backboard are not sound.
Do not install the Little Champ on a rim that is compromised or is not level.
When not in use, the Little Champ should be removed and stored away to prevent unauthorized use.
Before each use, thoroughly inspect the unit to ensure it is properly installed and all hardware is secured. Make sure the unit is not dislodged on the rim prior to any use.
According to the BGC (Boys and Girls Club) Youth Basketball Rules the following goal heights are recommended:
- 5-6 yrs old should play at 8 ft goal height
- 7-8 yrs old should play at 8 ft goal height
- 9-11 yrs old should play at 9 ft goal height
Page 4 of 16
Table of Contents
I. Initial Set-Up: .................................................................................................................. 6
II. Installing the Little Champ:.......................................................................................... 14
III. Adjusting Height: ........................................................................................................ 15
IV. Maintenance:............................................................................................................... 16
Figure 1 (Goal Adjustment) ................................................................................................ 7
Figure 2 (Backboard Adjustment) ....................................................................................... 7
Figure 3 (Little Champ Plum Adjustment) .......................................................................... 8
Figure 4 (Attach frame boardmounts)................................................................................. 9
Figure 5 (Backboard Assembly) ........................................................................................ 10
Figure 6 (Goal Rim Assembly) .......................................................................................... 11
Figure 7 (Support Arms For Large Backboards) .............................................................. 12
Figure 8 (Warning Lable Placements) .............................................................................. 13
Figure 9 (Install Pictures Step by Step) ............................................................................ 14
Figure 10 (How To Remove) ............................................................................................. 15
Figure 11 (Complete Parts List) ....................................................................................... 16
DESCRIPTION:
The LC-6 Little Champ is designed to attach to a standard regulation size rim whose height is at 10 ft. The LC-6 has the following design features and assembling considerations:
The Little Champ is designed to sit over the rim and lock into place by grabbing
underneath the backboard.
Adjustable bumpers are spaced along the rim mounting frame, at the front and
sides, in order to pick up the inner ring of the rim.
The support arms are designed to accommodate numerous types of rectangular
backboards, both with or without edge padding. The Little Champ comes with 3 different support arms to accommodate various size backboards. The support arms that are preassembled fit on a standard 42” rectangular backboard, with or without edge padding.
Initial set-up requires that the mounting frame be adjusted to achieve the best fit
on the rim and the type of backboard. Initial set-up is done without the Little Champ backboard and rim installed.
Page 5 of 16
+ 11 hidden pages