Jack A5 SERIES Parts Book
零件手册
n
4
Parts Manual
2
A5 系列 A5 Series
1
4.针杆、竖轴、下轴部件/Needlebar,UprightShaft&HookDrivingShaftCompone
序号
公司件号 Part NO. 名称 PartName 零件描述 Description 数量 Number
NO.
1 10122013 针杆上衬套孔塞 Rubber plug 1 1
3 14103005 针杆上衬套 Needle bar bushing upper 1 1
4 11402034 针杆（DLC处理） Needle bar 1 1
5 14104007 针杆连接柱(DLC处理） Needle bar connecting rod 1 1
6 101S11005 螺钉 SM9/64"x40 L= 6 Screw SM9/64"x40 L=6 1 1
7 14103010 针杆下套 Needle bar bushing lower 1 1
8 10113002 针杆线勾 Needle bar thread guide 1 1
2.上轴挑线分组件/MainShaft&ThreadTake-upComponents
序号
公司件号 Part NO. 名称 PartName 零件描述 Description 数量 Number
NO.
1 1413800100 Thread take-up asm. 1 1 13 101S11008 滑块导轨螺钉SM11/64"x40 L=8 Screw SM11/64"x40 L=8 2 2
2 11426001 Thread take-up asm. 1 1 14 14109001 针杆接头滑块导轨 Needle bar guide 1 1
3 101S15010 Thread take-up crank shaft 1 1 15 10425004 上轴伞齿轮 Upper shaft bevel gear 1 1
4 11411005 Screw 2 2 16 10425003 竖轴上伞齿轮 Upper small bevel gear asm 1 1
1.机壳、外装分组件/MachineFrame&MiscellaneousCoverComponents
序号
公司件号 Part NO. 名称 PartName 零件描述 Description 数量 Number
NO.
1 101S11001 后窗板螺钉SM3/16"×28 L=9 Screw SM3/16"×28 L=9 3 3 9 B01013 GB/T 27 6-1994轴承605 Thru st collar asm. 1 1 21 10403020 竖轴上 轴套 Upright shaft bushing upper 1 1
2 10122003 面板调节孔螺塞 Rubber plug 2 2 10 11438003 JK-8990-0337-02挑线杆 Thread take-up lever 1 1 22 10102007 竖轴 Upright sh aft 1 1
3 13837002 商标牌 Head card 1 1 11 B01014 GB/T 276-1994轴承608 Bearing 608 2 2 23 10403013 竖轴下轴套 Up right shaft bushing lower 1 1
4 303534 面板（喷漆） Face plate asm 1 1 12 101S15004 Screw SM 9/32"x28 L=16 1 1 24 10 403019 下轴后轴套 Hook drivin g shaft bushing back 1 1
5 13813005 左线钩 Thread guide left 1 1 13 101S11003 Sc rew SM9/32"x28 L=16 1 1 25 10108002 下 轴挡圈 Hook driving shaft snap ring 1 1
6 101S11007 右线钩螺钉SM11/64"×40 L=6 Screw SM11/64"×40 L=6 1 1 14 14104004 Needle bar crank 1 1 26 14003004 下轴中套 Lower shaft middle bushing 1 1
7 14122002 面板垫 Face plate gasket 1 1 15 101S15002 Screw SM1/4"x40 L=6 2 2 27 11304003 下轴 Hook driving shaft 1 1
11 10122013 针杆上衬套孔塞 Rubber plug 1 1 16 1410300200 Main shaft bushing front 1 1 28 11522001 油 封组件12 oil seal 12 1 1
12 10122005 挑线连杆销螺孔塞 Rubber plug 1 1 17 101S15006 Screw SM15/64"x28 L=7 1 1 29 1142201600 油封组件18 oil seal 18 2 2
13 10122004 针杆曲柄螺孔塞 Rubber plug 1 1 18 12203002 Main shaft bushing mid 1 1 30 14103004 下轴前轴套组件 Hook driving shaft bushing front 1 1
14 101S11004 挑线杆护罩螺钉SM3/16"×28 L=7 Screw SM3/16"×28 L=7 1 1 19 101S15007 Screw SM1/4"x40 L=8 2 2 31 10123009 下轴限油芯 Oil wick 1 1
15 13812018 挑线杆防 护罩 Thread take-up lever cover 1 1 20 10 108001 Main shaft thrust collar 1 1 32 101S30005 下轴限油螺钉 set screw 1 1
16 101S11004 挑线杆护罩螺钉SM3/16"×28 L=7 Screw SM3/16"×28 L=7 1 1 21 H03002 Snap ring 20 1 1 33 11418003 广濑中厚料旋梭(扩大缝纫范围) Hook asm（Hirose） 1 1
17 13512004 三孔线勾 3-hole thread guide 1 1 22 1131 0014 Feed eccentric cam 1 1 11418007 精品旋梭(国产) Hook asm（China） 1 1
18 10122005 挑线连杆销螺孔塞 Rubber plug 1 1 23 10112017 Cover plate 1 1 11418002 德盛有尾巴厚料旋梭(方德款) Hook asm（China Desheng） 1 1
19 114S11015 割线刀螺钉SM9/64"×40 L=6 Screw SM9/64"×40 L=6 2 2 24 101S11013 Screw SM1/4"x40 L=13 2 2 11418004 广濑厚料旋梭(新)(有尾巴) Hook asm（Hirose） 1 1
20 11419001 割线 刀 Knife 1 1 25 113S11003 Screw SM9/64"x40 L=5 2 2 34 10118003 梭心 Bobbin 1 1
21 20722007 油塞 Rubber plug 1 1 26 10103025 The rear axle sleeve 1 1 35 11218504 梭壳 Bobbin case asm. 1 1
22 13822001 操作屏孔塞 Rubber plug 2 2 27 10122105 Oil seal 1 1 36 10112016 旋梭定位钩 Finger postioner 1 1
23 13822007 后窗板垫 Side plate gasket 1 1 28 H030 01 Snap ring 15 1 1 37 116S11005 牙架曲柄螺钉 SM11/64"×40 L=13 Screw SM11/64"×40 L=13 1 1
24 302592 后窗板（喷漆） Side plate 1 1 29 14102060 Main shaft 1 1 38 101S11012 下轴挡圈螺钉 SM11/64"×40 L=4.8 Screw SM11/64"×40 L=4.8 2 2
2
5 101S11001 后窗板螺钉SM3/16"×28 L=9 Screw SM3/16"×28 L=9 11 11 30 13811021 Handwheel lable 1 1 39 113S14020 下轴后套螺钉SM11/64"×40 L=6 Screw SM11/64"×40 L=6 1 1
26 1381103000 一体机电控罩壳组件（鲍麦克斯） Electronic control box 1 1 31 S10009 Screw 2 2
27 W01009 GB/T97.1-1985垫圈 5 Washer 5 2 2 32 302830 Handwheel 1 1
28 114S13001 直驱电机螺钉M5×20 Screw M5×20 3 3 33 1383300700 Motor cover asm.powermax 1 1
29 114S30001 螺栓(内六角)M5×25 Screw M5×25 1 1 34 1383300900 Motor grating sensor asm 1 1
30 14133002 一体机电控组件（鲍麦克斯） Electronic control box 1 1 35 GB/T77-2000 Screw M3×4 1 1
31 10122006 送料调节器孔塞 Rubber plug 1 1 36 GB/T77-2000 Screw M6×6 1 1
32 10122007 下轴工艺孔塞 Rubber plug 1 1 37 1383300400 Motor rotor 1 1
33 138S05001 操作面板螺钉 Screw 2 2 38 13833003 1 1
34 14133001 一体机电控面板组件（鲍麦克斯） Control panel,powermax 1 1 39 GB/T93-1987 4 4
35 140S12001 底板支柱 Machine head stud 2 2 40 GB/T70.1 -2000 4 4
36 13822002 装饰条 Decorative article 1 1 41 GB/T78-2000 1 1
37 101S11004 螺钉 Screw 2 2 42 GB/T78-2000 1 1
38 1381300400 小夹线器组件 Thread tension asm. 1 1 43 GB/T9074.8 6 6 1 101S11010 压脚扳手螺钉SM9/64"x40 L=11 Screw SM9/64"x40 L=11 11
39 138S16019 小夹线器螺母 Thread tension nut 1 1 44 10122012 1 1 2 10128002 压脚扳手螺钉垫圈 Washer 1 1
40 11227001 小夹 线弹簧 Th read tension spring 1 1 45 11402007 1 0 3 13 811029 压脚扳手 Hand lifter 1 1
41 11212004 小夹 线板 Threa d tension disk 2 2 46 11438002 1 1 4 O01004 O型圈 Rubber ring 1 1
42 13810008 小夹 线器螺柱 Threa d tension post 1 1 47 114S300 04 1 1 5
43 138S08006 小夹线器固定螺钉SM3/16"×28 L=7 Screw SM3/16"×28 L=7 1 1 1 1 6 101S20001 前杠杆螺纹销 Screw 2 2
44 13812066 过线 板 Thread tension guide plate 1 1
45 14122001 橡皮塞(四孔) Rubber plug 1 1
46 10113004 右线 钩 Thread guide right 1 1 9 10112013 抬压脚拉杆 Knee lifter pull rod 1 1
47 101S11007 右线钩螺钉SM11/64"× 40 L=6 Scr ew SM11/64"x40 L=6 1 1 10 H05003 GB/T896-1986挡圈 5 Snap ring 2 2
48 101S15010 左销螺钉SM15/64"×28 L=10.5 Screw SM 15/64"×28 L=10.5 1 1 11 11329020 挡圈 5 Snap ring 5 5
49 10126002 松线钉 Tension release pin 1 1 12 1011 2010 压脚升降板 Lifting plat e 1 1
50 10122014 挑线簧调节座O型圈 Rubber ring 1 1 13 101S20004 抬压脚拉杆螺钉SM3/16"x32 Hinge Screw SM3/16"x32 1 1
51 101S15005 夹线紧固螺钉SM9/64"x40 L=5.5 Screw SM9/64"x40 L=5.5 1 1 14 101S20003 后杠杆轴位螺钉SM15/64"x28 Hinge screw SM15/64"x28 1 1
52 10127001 挑线簧 Thread take-up spring 1 1 15 11312034 抬压脚后杠杆 Knee lifter back lever 1 1
53 10103011 挑线簧调 节座 Thread tension base 1 1 16 11326005 销子 Pin 1 1
54 10112005 夹线 板 Thread tension disk 2 2 17 P04001 开口销 GB/T91 2×14 Cotter pin 1 1
55 10112006 松线板 Disk stopper 1 1 18 11326006 电磁铁 接头 Sol enoid connector 1 1
56 101s30002 夹线螺钉 Thread tension post 1 1 19 113S16004 法兰螺母M8 Flange n uts M8 1 1
57 10127002 夹线 弹簧 Threa d tension spring A 1 20 11322008 电磁铁上垫片 washer 1 1
58 10112007 夹线制动 板 Thr ead disk rotating stopper 1 1 21 1383001200 抬压脚电磁铁组件 Solenoid asm. 1 1
59 138S16013 夹线螺母 Thread te nsion nut 1 1 22 101S11001 后窗板螺钉SM3/16"×28 L=9 screw SM3/16"×28 L=9 4 4
60 1381300500 夹线器组件 Th read tension asm. 1
61 1383002700 电子夹线器组件 Nest less e-device 1 1
62 S10008 凹端紧定螺钉M4X6 Screw M4X6 1 1 25 14012015 Knee lifter c onnecting rod
63 11413011 固定 式缓线钩 Threa d guide 1 1 26 14126006
64 401S16001 螺母SM9/64"x40 Nut SM9/64"x40 1 1 27 1411200300
65 138S11002 卷边器座螺钉SM11/64"x40 L=5.5 Screw SM11/64"x40 L=5.5 1 1 28 138S08006
66 13812019 卷边器座 Ruler stop seat 1 1 29 1413000900
67 104S17002 针板螺钉(进口) SM11/64"x40 Screw SM11/64"x40 2 2 30 11329020
68 11414006 定做专用针板(扩大缝纫范围) Needle plate 1 31 14101017
11315001 针板(兄弟款 ) Needle pla te 1 32 14126002
69 10115002 推板 Slide plate 1 1 33 1012 6003
70 10127009 推板簧 Slide plate spring 1 1 34 10128001
71 101S11019 推板簧螺钉SM3/32"x56 L=2 Screw SM3/32"x56 L=2 2 2 35 10127003
72 10128016 螺纹销橡胶垫圈(薄) Washer 1 1 36 13811027
73 13812007 卡簧 Buckle 1 1 37 1381102700
74 S04021 螺钉 Screw 1 1 38 13811028
75 13822001 操作 屏孔塞 Ru bber plug 1 1 39 10102003
76 S10007 GB/T80凹端紧定螺钉M4×4(发黑) Screw 2 2 40 11427033
77 21012018 油封垫 Oil sealing washer 1 1 41 10409001
78 14112008 防油 板 Oil pr eventing plate 1 1 42 101S15007
79 14123002 防油 板油棉 Oil cotton 1 1 43
80 14112004 防油 罩 Oil pr eventing plate 1 1 44 11402009
81 14123001 防油 罩油棉 Oil cotton 1 1 45 101S11009
1
1
5 B08003 Bearing support 2 2 17 10425002 竖轴下伞齿轮 lower large bevel gear asm 1 1
6 11438004 Bearin g 1 1 18 101S15014 齿轮螺钉SM1/4"x4 0 L=7 Screw SM1/4"x40 L=7 8 8
7 114S11008 Th read take-up lever crand rod 2 2 19 10425001 下轴伞齿轮 Hook drive shaft bevel gear 1 1
8 11408002
49 12203004
14123003
51
3
挑线组件
JK-8990-0338挑线连杆销
JK-5550-0615左销螺钉
JK-8990-0340轴承支撑挡圈
GB/T5801-1986滚针轴承K 7x10x10
JK-8990-0337-03挑线杆连杆
JK-8990-0360挡圈螺钉
JK-8990-0339挡圈
针杆曲柄紧固螺钉 SM9/32"x28 L=16
针杆曲柄定位螺钉SM9/32"x28 L=16
针杆曲柄
送料轴挡圈螺钉SM1/4"x40 L=6
上轴前轴套组件
夹线器螺钉SM15/64"x28 L=7
主轴中轴套
压杆导架螺钉SM1/4"x40 L=8
上轴挡圈
挡圈20
送料偏心轮
送料偏心轮盖板
送料偏心轮螺钉 SM1/4"x40 L=13
护针片螺钉 SM9/64"x40 L=5
上轴后轴套
上轴后套挡油油封
GB/T894.1-1986挡圈15
上轴
手轮贴条
螺钉
手轮（喷漆）
电机罩壳组件（配鲍麦克斯）
电机光栅组件（配鲍麦克斯）
内六角平端紧定螺钉M3×4
内六角平端紧定螺钉M6×6
电机转子总成
电机定子总成（配鲍麦克斯）
弹垫5
内六角圆柱头螺钉M5×50 8.8级
内六角锥端紧定螺钉M6×8
内六角锥端紧定螺钉M3×4
一十字槽小盘头螺钉组合件M3×8
上轴孔塞
JK-8990-0337-004挑线杆轴
JK-8990-0337-01针杆连杆
JK-8990-0337-05挑线曲柄左螺钉
JK-8988-0301-2针杆连杆铜套
上轴毡塞
Screw 1 1 20 113S11036 一字开槽紧定螺钉SM15/64"x28 L=4.7 Screw SM15/64"x28 L=4.7 1 1
Motor stator,powermax
Spring washer 5
Screw M5×50
Screw M6×8
Screw M3×4
Screw
Rubber plug
Needle bar crand
needle bar connecting rod
Screw（left twist)
needle-bar rod copper sleeve
Rubber plug
1 1 7 10128016 螺纹销橡胶垫圈(薄) Washer 22
9 10117001 机针（14#） Needle 1 1
10 10413001 针杆下衬套线勾 Lower bushing thread guide 1 1
11 104S11006 支针螺钉(进口) SM1/8"x 44 L=4.5 Screw SM1/8"x44 L =4.5 1 1
12 10109001 针杆连接柱滑块 Slide block 1 1
3.压料、自动抬压脚分组件/PresserBar，AutoLifterComponents
序号
公司件号 Part NO. 名称 PartName 零件描述 Description 数量 Number
NO.
1411000200
8 1011201100 抬压脚前杠杆分部件 Lift front lever component 1 1
23
14022009
24 H03042
14103012
46 1401600200
47 14127002
压脚扳手凸轮分部件 Hand lifter cam asm. 1 1
抬压脚顶杆密封帽
G
B/T894.1-1986轴用弹性挡圈-A型5x0.6 Snap ring
抬压脚顶杆
前杠杆轴销
抬压脚前杠杆组件
小夹线器固定螺钉SM3/16"×28 L=7
松线电磁铁组件
挡圈5
松线顶板
松线顶板连接销
松线辅钉
松线辅钉垫片
松线辅钉弹簧
调压螺钉
调压螺钉组件
调压螺母
调压导杆
调压簧
压杆导架
压杆导架螺钉 SM1/4"x40 L=8
压杆衬套
压杆
活压脚螺钉 SM9/64"x40 L=10.5
带刀压脚组件（(少鸟巢装置专用）
松线顶板复位簧
Seal cap
Pin
Knee lifter lever asm
Screw SM3/16"×28 L=7
Solenoid
Snap ring 5
Wire release plate
Pin
Thread release supporti ng pin
washer
Spring
Press regulating scre w
Presser regulating screw nut asm.
Press regulating nut
Press regulating guide bar
Press regulating spri ng
Presser bar guide bracket
Screw SM1/4"x40 L=8
Presser bar bushing,lo wer
Presser bar
Screw SM9/64"x40 L=10.5
Presser foot asm(For the No Bird's Ne
Spring
1 1
1 1
1 1
1 1
1 1
1 1
1
1 1
1 1
1 1
1 1
1 1
1 1
1 1
1 1
1 1
1 1
1 1
1 1
1
1 1
1 1
1 1
1 1
1 1
1
1
5
5.送料分组件/FeedMechanismComponents
序号
公司件号 Part NO. 名称 PartName 零件描述 Description 数量 Number
NO.
1 11405015 倒送料连杆 Reverse feed connecting rod 1 1
2 11426021 倒送料连杆销 Connecting rod pin 1 1
3 101S11005 螺钉 SM9/64"x40 L=6 Screw SM9/64"x40 L=6 6 6
4 11401015 送料调节器 Feed regulator 1 1
5 11403043 送料调节器轴套
6 101S11023 送料调节器轴端螺钉SM3/16"x28 L=6.5
7
13826005
8 10122016 送料调节螺钉O形圈 Rubber ring 1 1
9 13811008 固定表盘
10 H05018 GB/T896-1986挡 圈3.5
11
13811009
12 13827002 按钮 复位簧 Spring 1 1
13812010 上限位片
13
14 1381100700 标盘旋钮组件 Knob c omponent 1 1
101S11022 送料距旋钮螺钉SM3/16"x28 L=18 Screw SM3/16"x28 L=18 1 1
15
10126011 送料曲柄销 Feed rocker cran k pin 1 1
16
101S20005 抬牙连杆轴位螺钉 SM9/32"x28 hinge Screw SM9/32"x28 1 1
17
10104002 送料曲柄 Feed rocker shaft crank 1 1
18
101S11016 送料曲柄螺钉SM3/16"x28 L=14 Screw SM3/16"x28 L=14 1 1
19
400093 抬牙连杆 Connecting rod 1 1
20
101S11016 送料曲柄螺钉 SM3/16"x28 L=14 Screw SM3/16"x28 L=14 1 1
21
10104004 抬牙后曲柄 Feed driving sha ft crank 1 1
22
400091 送料连杆 Rocker shaft connecti ng rod 1 1
23
10126006 送料连杆销 Connecting rod pin 1 1
24
101S16003 抬牙连杆轴位螺母 SM9/32"x28 Hinge Screw SM9/32"x28 1 1
25
101S11023 送料调节器轴端螺钉SM3/16"x28 L=6.5 Screw SM3/16"x28 L=6.5 1 1
26
13803021
27
28 13822003 倒送 料轴O形圈 Rub ber ring 1 1
29 13802010 倒缝送料 轴 Rever se feed shaft 1 1
30 13803020 倒送料轴 中套 Reverse feed shaft bushing mid 1 1
31 13822056 倒送料轴中套油封 Mid bushing oil seal 1 1
32 302665 倒缝扳手（喷漆） Reverse feed lever asm 1 1
33 138S10010 内六角锥端紧定螺钉M5X8 Screw M5X8 1 1
34 101S15002 送料轴挡圈螺钉SM1/4"x40 L=6 Screw SM1/4"x40 L=6 4 4
35 10108003 送料 轴挡圈 Fe ed rocker shaft snap ri ng 2 2
36 10403015 轴套 Bushing 2 2
37 H03001 GB/T894.1- 1986挡圈 15 Snap ring 15 2 2
38 10104003 抬牙叉形 曲柄 Driving shaft crank 1 1
39 101S11020 抬牙叉形曲柄螺钉SM11/64"x40 L=10.5 Screw SM11/64"x40 L=10.5 1 1
40 11414002 送料 牙 Feed do g 1
11314001 送料牙(兄弟款) Feed dog(Brother type) 1
41 470060 牙架 Feed bar asm. 1 1
42 101S11016 送料曲柄螺钉SM3/16"x28 L=14 Screw SM3/16"x28 L=14 1 1
43 10128003 牙架座螺钉垫圈 Washer 1 1
44 101S11025 复位 板螺钉SM11/64"x40 L=7 Screw SM11/64"x40 L=7 1 1
45 11226001 牙架 销 Feed bar pin 1 1
46 480095 牙架座 Feed bar bed. 1 1
47 101S11018 送料牙螺钉 SM1/8"x44 L=6 Screw SM1/8"x44 L=6 2 2
48 101S15010 左销螺钉 SM15/64"x 28 L=10.5 Screw SM15/ 64"x28 L=10.5 1 1
49 10126009 送料摆动板座左销 Left pin 1 1
50 10126007 短摆动板连杆销 Connecting pin 2 2
51 10109005 送料 短摆动板 Feed short shaking plate 2 2
52 10109004 送料 长摆动板 Feed long shaking plate 2 2
53 1120100200 送料摆动板座分部件 Feed shaking plate bed components 1 1
54 10126010 送料摆动板座右销 Right pin 1 1
55 113S14010 左销螺钉SM15/64"x28 L=12 Screw SM15/64"x28 L=12 1 1
56 11427011 送料 调节弹簧 Spring 1 1
57 11329020 挡圈5 Snap ring 5 2 2
58 14012005 油量检测装置固定板 Fixed plate 1 1
59 13827006 倒送料拉 簧 Rever se feed pull spring 1 1
60
1140402700
61 11321005 油管 Tube 1 1
62 114S30007 弹簧悬置螺钉 Screw 1 1
63 W02015 GB /T93-1987 弹簧垫圈M4 Spring washer M4 1 1
64 114S16004 螺母SM11/64"x40 Nut SM11/6 4"x40 1 1
65 S01102 螺钉 SM3/16"x28 L=18 Screw SM3/16"x28 L=18 1 1
66 14002003 送料 轴 Feed r ocker shaft 1 1
67 14002002 抬牙 轴 Feed dri ving shaft 1 1
68 S10035 GB/T80-2000螺钉M5×8 Screw 1 1
69 400689 牙架组件(成品 ) Feed bar asm. 1 1
70 14022003 送料 轴前孔塞 spout plug 11
71 14022004 右销 孔塞 spout plug 11
72 1142200800 油封组件22 oil seal 2 2
73 14003002 送料轴后 轴套 axle sl eeve 2 2
74 12422001 橡皮塞15.5 Rubber plug 15.5 2 2
标盘螺柱
标盘按钮
倒送料轴后轴套
倒送料曲柄组件 Feed reverse crank asm. 1 1
Feed regulator bushing 1 1
Screw SM3/16"x28 L=6.5
Feed regulator stud 1 1
Fixing dial plate 1 1
Snap ring 3.5
Dial plate button 1 1
Upper limit patch 1 1
Reverse feed shaft bushing back 1 1
11
11
s
6
8 11
8.润滑、油量检测组件/OilLublication、OilMeasuringComponents
序号
公司件号 Part NO. 名称 PartName 零件描述 Description 数量 Number
NO.
1 11211004 油窗 Oil sight window 1 1
2 10122019 油窗O形圈 Rubber ring 1 1
3 13821008 上轴供油管 Main shaft oil tube 1 1
4 112S30005 油泵连接螺柱 Oil pump connecting stud 1 1
5 11329010 开口挡圈10 Snap ring 10 1 1
6 10121001 下轴供油管 Hook driving shaft oil tube 1 1
7 10112020 油泵安装板 Oil pump installing base 1 1
8 W03002 弹垫 Spring wash er 1 1
6.切线装置部件/ThreadTrimmerComponents
序号
公司件号 Part NO. 名称 PartName 零件描述 Description 数量 Number
NO.
1 14112005 刀架压板 Knife bracket press compo nent 1 1 13 10122018 回油柱塞 Plunger 1 1
2 114S17001 刀架压板螺钉 Screw 3 3
3 14119002 辅助动刀 knife 1 1
4 1410700200 剪线辅刀架组件 Knife bracket 1 1
5 113S17002 活动刀固定螺钉SM11/64"x40 L=4.4 Screw SM11/64"x40 L=4.4 1 1
6 131S01002 JK-8995-0432 螺钉SM11/ 64*40 S crew SM11/64*40 1 1
7 14119001 活动刀 knife 1 1
8 14107001 剪线主刀架 Knife bracket 1 1
9 113S17002 活动刀固定螺钉SM11/64"x40 L=4.4 Screw SM11/64"x40 L=4.4 1 1
10 131S01002 JK-8995-0432 螺钉SM1 1/64*40 Screw SM11/64*40 1 1
11 14112001 分线片 Needle guard patch 1 1
12 201S11009 螺钉SM9/64"x40 L=5.5 Screw SM9/64"x40 L=5.5 1 1
13 113S20001 连杆螺钉SM11/64"x40 hinge Screw SM11/64"x40 1 1
14 11312005 连杆 Connecting rod 1 1
15 141S20002 剪线曲柄轴位螺钉 Screw 1 1
16 14104003 剪线辅曲 柄 Cran k 1 1
17 S10007 GB/T80凹端紧定螺钉M4×4(发黑) Screw 1 1
18 14104001 剪线 曲柄 Crank 1 1
19 S05004 螺钉M5x14 Screw M5x14 1 1
20 11327001 弹簧 Spring 1 1
21 11230004 14孔 接线器 Plug 1 1
22 11230005 电线 插针 Pin 2 2
23 14103003 剪线轴套 Thread cutting shaft bu shing 1 1
24 11503005 驱动曲柄轴衬套 Crank drive shaft bushing 1 1
25 113S14002 螺钉SM11/64"x40 L=5.5 Screw SM11/64"x40 L=5.5 1 1
26 11322002 扭簧 端盖 Sprin g cover 1 1
27 11327002 弹簧 Spring 1 1
28 14104002 剪线凸轮曲柄轴 Crank shaft 1 1
29 1400400100 剪线驱动组件 Thread t rimmer drive asm. 1 1
30 116S14003 针杆曲柄销定位螺钉SM1/4"x40 L=4.5 Screw SM1/4"x40 L=4.5 1 1
31 11324001 滚柱 Roolling pi n 1 1
32 113S16002 螺母SM11/64"x40 Nut SM11/64"x40 1 1
33 116S14005 螺钉SM1/4"x40 L=10 Screw SM1/4"x40 L=10 2 2
34 11309030 凸轮 顶柱 Push rod 2 2
35 11310004 凸轮 Cam 1 1
36 14002004 切线驱动 轴 Shaf t 1 1
37 H05013 GB/T896-1986挡圈 Snap ring 1 1
38 10112003 针杆曲柄 护板 Cunter weight protecting 1 1
39 11322003 电磁 铁缓冲片 Soleno id cushion rubber 1 1
40 14022013 孔塞 8.5 spout plug 8.5 11
41 N01001 螺母 M4 Nut M4 2 2
42 W01013 GB/ T97.1-1985垫圈4.5 W asher 2 2
43 11309001 切线电磁铁顶销 Solenoid pin 1 1
44 1401200200 切线电磁铁支架组件 Bracket 1 1
45 S17002 GB/T70.2-2000内六角平圆头螺钉M6x10 Screw M6x10 2 2
46 14012001 切线杠杆 Tangent lever 1 1
47 H03015 GB/T894.1 卡簧 8 Ring 8 1 1
48 10112003 针杆曲柄 护板 Needle bar crank protecting plate 1 1
49 112S16006 螺母SM1/4"X40 Nut SM1/4"X40 1 1
50 O01004 O型圈 Rubber ring 1 1
51 1413003400 剪线电磁铁组件 Thread trimmer solenoid asm. 1 1
52 11322001 驱动曲柄止动块 Crank driver stopper block 1 1
53 14130001 12孔 接线器 Plug 1 1
7
9 209S12001 压脚螺钉SM11/64＂×40 L=10.5 Screw SM11/64＂×40 L =10.5 1 1
10 10103022 油泵体衬 套 Oil pump bushing 1 1
11 101S30007 柱塞螺钉 Plunger Sc rew 1 1
12 10127013 柱塞簧 Plunger spring 1 1
14 10120001 油泵体 Oil pump 1 1
15 S04009 油泵螺钉 Screw 3 3
16 10111003 油泵 叶轮 Oil pump impeller 1 1
17 10112021 油泵叶轮 托板 Oil pump impeller cover 1 1
18 10111007 油泵盖 Lubricating oil pump cover 1 1
19 101S30006 螺钉 Screw 3 3
20 1012000100 油泵分部件 Lub ricating oil pump component 1 1
21 W02004 GB/ T93-1987弹垫M6 Spring Washer M6 1 1
22 10136001 供油 管接头 Ru bber joint 1 1
23 116S30003 抬牙叉固定螺钉SM15/64＂×28 L=14.5 Screw SM15/64＂×28 L=14.5 1 1
24 14021003 铝油 管 Aluminu m tubing 1 1
25 14021001 油管 Tubing 1 1
26 14036004 油盘 油嘴 Oil nozzle 1 1
27 14036002 回油 嘴 Oil no zzle 2 2
28 11412055 油管 卡簧 Oil pipe clamp spring 5 5
29 10423005 油线 Oil wick 2 2
30 14036003 供油 嘴 Oil no zzle 1 1
31 O01004 GB/T3452.1-1992 O形圈4x1.8 Ru bber ring 4x1.8 1 1
32 140S30001 油量调节螺钉 Oil volu me adjusting screw 1 1
33 10127015 回油毡夹 Oil felt clamp 1 1
10123006 回油毡 Oi l felt felt 1 1
34
35 101S11004 挑线杆护罩螺钉SM3/16"×28 L=7 Screw SM3/16"×28 L=7 1 1
36 10112023 回油管夹 Oil tube clamp 1 1
37 10121007 回油管部 件 Oil return tube component 1 1
38 10121008 回油 管 Oil ret urn tube 1 1
42 1403000200 油量检测装置组件 Oil measuring device 1 1 1 1011203100 机头连接钩部件 Hinge component 2 2
43 N01009 螺母 Nut 1 1
44 W02003 弹性 垫圈 Washe r 1 1 3 10131004 螺丝刀（小） Screw driver,small 1 1
45 14012005 油量检测装置固定板 Pull spring fixing plate 1 1 4 10131003 螺丝刀（中） Screw driver,medium 1 1
46 14011004 油量检测 罩壳 Shell 1 1 5
47 14002005 导向柱 Guide pillar 1 1 6 10122060 机头连接钩座 Head connecting rubber cushion 2 2
48 14011002 浮子 Float 1 1 7 14022023 机头支架 Nose support 2 2
49 H05009 开口挡圈 Ring 1 1 8 101S30010 机头连接钩座钉 Nail 4 4
7.绕线器组件/BobbinComponents
序号
公司件号 Part NO. 名称 PartName 零件描述 Description 数量 Number
NO.
1 1413103900 绕线器组件 Bobbin winder asm. 1 1 12 10118003 梭心 Bobbin 2 2
2 14113001 压线控制板 Thread press control plate 1 1 13 14002015 抬压脚轴连接杆 Connecting rod 1 1
3 14111001 绕线衬垫 Winding pad 1 1 14 101110120 0 油箱部件 Oi ler component 1 1
4 13819001 割线刀 Knife 1 1 15 13831018 防尘罩 Dust cover 1 1
5 114S11008 螺钉M4x6 Screw M4x6 1 1 16 14011001 油盘托盘组件 Di sk tray 1 1
6 14131001 绕线器装置主座 Bobbin winder bed 1 1 17 1383100300 线架组件 Th read stand asm. 1 1
7 GB/T 896-1986 开口挡圈5 Snap ring 1 1 18 20131019 线架杆顶防护橡皮 Spool rest rod rubber cap 1 1
8 10127061 复位板拉簧 Spring 1 1 19 S04050 螺钉M5 L=16 Screw M5 L=16 3 3
9 13812110 调节板 Regulating plate 1 1 20 W01047 垫圈M5 Washer M5 2 2
10 10110030 绕线凸轮 Bobbin winder cam 1 1 21 N01034 螺母M5 Nut M5 4 4
11 S09042 螺钉 Screw 1 1 22 13831022 上线架过线杆 Spool rest arm upper 1 1
12 1380510600 绕线器连杆组件 Bobbin winder connecting rod 1 1 23 10113011 过线圈（内） Thread guide ring 2 2
13 13827103 满线 复位簧 spr ing 1 1 24 10113010 过线圈(外) Thread guide ring 2 2
14 10127060 弹簧 Spring 1 1 25 13831019 线架杆上节 Spo ol rest rod upper 1 1
15 GB/T 896-1986 开口挡圈4 Snap ring 1 1 26 13831021 线架 杆接头 Spo ol rest rod joint 1 1
16 13802111 绕线器主 轴 Bobb in winder mian shaft 1 1 27 13831020 线架杆下节 Spo ol rest rod lower 1 1
17 14102002 绕线凸轮 轴 Bobb in winder cam shaft 1 1 28 1012 2106 橡胶垫圈 Spool rest rod rubber ring 2 2
18 S09103 绕线轮螺钉 Screw 2 2 29 W01048 垫圈M1 6 Washer M16 2 2
19 13831102 绕线轮 Bobbin winder wheel 1 1 30 N02004 螺母 M16 Spool rest rod nut M16 1 1
20 O01110 O型圈 Ring 1 1 31 S04051 螺钉 M5 Spool rest arm lower screw M5 1 1
21 11422062 密封 垫 Washer 1 1
22 114S11003 螺钉SM3/16"×28 L=10 Screw SM3/16"×28 L=10 3 3 33 W02027 弹 簧垫圈 M5 Sprin g washer M5 2 2
23 1381300600 底线夹线器 Bobb in thread tension asm. 1 1
24 13811004 夹线 螺母 Thre ad tension nut 1 1 35 13831024 线盘 Spool rest 2 2
25 11427006 小夹线弹簧 Spring 1 1 1 14011003 罩壳 Box 1 1 36 20131010 线盘垫 Spool rest cushion 2 2
26 10112005 夹线板 Thread tension disk 2 2 2 1403003500 拨线电磁铁组件 Dial the line electromagnet components 1 1 37 20131006 线盘钉 Spool pin 2 2
27
11413022
28
112S13004
29
114S16001
30
11435013
31
S10009
32
W01013
33
GB/T97.1
34
141S11001
26 S17011 GB/T70.2-2000内六角平圆头螺钉M3×12 Allen flat round head screw 1 1 13 140S20021 拨线连杆轴位螺钉 Dial the line connecting rod shaft screw 1 1 邮编：318000
27 14012020 拨线连杆 Dial the line connecti ng rod 1 1 14 14027020 复位弹簧 Res et spring 1 1 国内销售部：
28 H03055 GB/T894.1-1986轴 用挡圈A型4 Shaft with a collar 1 1 15 14003008 复位衬套 Reset the bushing 1 1 电话：0086-0576-88177788 88177789
29 N01050 GB/T6170-2000六角 螺母M3 Hexagonal n ut 1 1 16 14012024 拨线传动板 Dial the line drive board 1 1 传真：0086-0576-88177758
30 1401200800 拨线驱动连杆组件 Line drive connecting rod component
31 S05037 GB/T70.1-2000内六角圆柱头螺钉M3×14 Hex cylinder head screw 1 1 18 140S20020 拨线传动板轴位螺钉 Dial the line drive board shaft screw 1 1 电话：0086-0576-88177782 88177774
32 14002008 拨线驱动 轴 Lin e drive shaft 1 1 19 14012021 压片支架 Table t bracket 1 1 传真：0086-0576-88177787
33 N01051 GB/T6170-2000六角螺母 M4 Hexagonal n ut 1 1 20 W01099 GB/T848-2002小垫圈A级3×0.5 Small washer 1 1 免费售后服务电话：400-8876858
34 14013009 线勾 Wire hook 1 1 21 S17010 GB/T70.2-2000内六角平圆头螺钉M3×4 Allen flat round head screw 1 1 http://www.chinajack.com
35 W02100 GB/ T93-1987弹簧垫圈4×0.8 Spring washer 1 1 22 N06 001 滚花螺母3 K nurl nut 1 1
36 W01097 GB/T97.3-2006平垫圈4x0.8 washer 1 1 23 14013011 压片 tablet 1 1 资料如有更改，恕不另行通知，以实物为准。
37 W01098 GB/ T6170-2000小垫圈A级5×1 Small washer 2 2 24 14013010 滑压片 Sliding tablet 1 1
38 11329020 开口 挡圈5 Op en ring 1 1 25 14022025 橡胶圈 Rubber ring 1 1
夹线过线板 Thread tension guide plate 1 1 3 14022026 橡皮垫 Rubber mat 1 1 38 13831025 线团防松垫 Spool retainer 2 2
夹线螺钉 Screw 1 1 4 14028020 缓冲垫片 Buffer gasket 1 1
螺母SM11/64"×40 Nut SM11/64"×40 1 1 5 1401200600 勾线装置组件 Cancel the device components 1 1
绕线器驱动轮 Driving wheel 1 1 6 14022027 橡皮垫块 Rubber pad 1 1
螺钉M6×8 Screw M6×8 2 2 7 101S11001 后窗板螺钉SM3/16"x28 L=9 After throwing a screw 2 2
GB/T97.1-1985垫圈4.5 Washer 1 1 8 1401200700 拨线电磁铁支架组件 Dial the line electromagnet stent compone 1 1
垫圈4 Washer 1 1 9 S15010
螺钉M3x4 Screw M3x4 1 1 10 140S16008 拨线传动板轴位螺母 Dial the line shaft drive plate a nut 1 1
9
11.油盘、膝抬压脚分组件/OilCeservoir，KneeLifterComponents
序号
公司件号 Part NO. 名称 PartName 零件描述 Description 数量 Number
NO.
1 113S11004 松线导管压板螺钉M4x8 Screw M4x8 1 1
2 101S11023 送料调节器轴端螺钉 Screw 1 1
10131001
3
9.自动倒送料开关、感应抬压脚组件/AutomaticReverseFeedComponents
序号
公司件号 Part NO. 名称 PartName 零件描述 Description 数量 Number
NO.
1 101S11004 挑线杆护罩螺钉SM3/16"×28 L=7 Screw SM3/16"×28 L=7 1 1
2 1383003600 双开关组件 Auto reverse feed switch asm 1 1
3
116S30003 抬牙叉固定螺钉SM15/64"×28 L=14.5 Screw SM15/64"×28 L=14.5
4 W02004 GB/T93-1987弹垫M6 Spring washer M6 2 2
5
11628005
6 1383003400
7 11326005 销子
8
P04001 开口销 GB/T91 2×14
9 11322040
10 11328031 垫片 Washer 1 1
11
H05014
12 11227006
13 14112006 自动倒送料连杆 Auto reverse feed connecting rod 1 1
14 141S20004
15 112S16007
16 14104005
17 112S16008
18 112S20001
19 11212029
20 11329020
21 11211005 尼龙 扎带 Cable band 8 8
22 1413003300 短线头电磁铁组件 Thread trimmer solenoid asm. 1 1
23 14112002
24 101S11026
25
N01001
26
O01004 O型圈 Rubber ring
27 112S16006 螺母SM1/4"X40 Nut SM1/4"X40 1 1
28 W01013 GB/ T97.1-1985垫圈4.5 Washer 2 2
29 14126001
30 14105001
31 141S20001
32 14127001
33
S05254
34 1403003000 下感应探头组件
35 14013022
36 113S11004
37 13822030
38 14105002 辅助 连杆 rod 1 1
39 141S20003
抬牙叉固定螺钉垫圈 Washer 2 2
自动倒送料电磁铁
橡胶垫片 rubber plunger
GB/T896-1986开口挡圈 Snap ring 1 1
自动倒送料连杆顶弹簧 Plunger spring
曲柄短螺钉SM11/64"×40 Hinge Screw SM11/64"×40
曲柄长螺母SM1/4"×28
自动倒送料曲柄
曲柄短螺母SM11/64"×40 Nut SM11/64"×40
曲柄长螺钉 SM1/4"×28
自动倒送料拉杆
开口挡圈5 Snap ring 5
短线头电磁铁支架 Bracket
油泵安装螺钉SM15/64"x28 L=9
螺母 M4 Nut M4 2 2
短线头电磁铁顶销 pin
短线头连杆
倒送料连杆轴位螺钉
复位扭簧 Lower sensor
GB/T70.1-2000螺钉M2.5× 4 Screw M2.5×4 1 1
过线压板 Wire guide press plate
松线导管压板螺钉M4x8
橡皮塞（单孔） Rubber plug
轴位螺钉SM11/64"x40 Screw SM11/64"X40
Auto reverse feed solenoi d 1 1
Pin
Cotter pin 1 1
Nut SM1/4"×28 1 1
Auto reverse feed crank 1 1
Hinge Screw SM1/4"×28 1 1
Auto reverse feed pull sha ft 1 1
Screw SM15/64"X28 L=9 2 2
rod 1 1
Screw 1 1
Lower sensor
Screw M4x8 1 1
22
11
11
11
11
11
11
11
11
11
11
11
11
11
11
10
10.少鸟巢装置/NoBird'sNestComponents
序号
公司件号 Part NO. 名称 PartName 零件描述 Description 数量 Number
NO.
GB/T9074.8-1988十字槽小盘头螺钉组合
11 14026004 拨线传动 销 Dia l the line drive pin 1 1
12 14008001 滑动衬套 The sliding sleeve 1 1 公司地址：台州市椒江区机场南路十五号
1 1 17 140S16007 拨线连杆轴位螺母 Dial the line connecting rod shaft nut 1 1 国贸部：
Philips small head screw assembly 7 7
4 14022001 油盘密封垫 Seal 1 1
5 S05242 油盘固定螺钉M6x40 Screw M6 L=40 2 2
6 S05240 油盘固定螺钉M6x20 Screw M6 L=20 2 2
7 14001005 油盘 Oil reservoir 1 1
O01005
8
114S11011
9
10 14013023 电线压板 Wire clamp 1 1
11 10112027 抬压脚双向曲柄 Knee lifter crank 1 1
12 14027016 双向曲柄 扭簧 Knee li fter spring 1 1
13 H05010 GB/T896-1986挡 圈10 Snap rin g 10 1 1
14 1400200100 抬压脚轴组件 Knee lif ter shaft 1 1
15 140S10002 双向曲柄螺钉 Screw 1 1
16 101S15012 双向曲柄限位调节螺钉M6 L=20 Screw M6 L=20 2 2
17 101S16004 双向曲柄限位调节螺母 M6 Nut M6 3 3
12
12.机头附件/MachineHeadAccessories
序号
公司件号 Part NO. 名称 PartName 零件描述 Description 数量 Number
NO.
2 14022022 机头座垫 Die cushion 2 2
20731047
9 10111011 机头支柱 Machine head rest pin 1 1
10 10117021 机针（ 14#） Needl e 4
10117022 机针DP×5# 21（厚料） Needl e 4
11 20131039 漏斗 Funnel 1 1
32 N01034 螺母 M5 Nut M5 2 2
34 13831023 下线架过线杆 Spool rest arm lower 1 1
油盘磁铁 Oil reservoir mag net 1 1
O形圈
齿轮箱盖螺钉 Screw 1 1
螺丝刀（大） Screw driver,large 1 1
Rubber ring 1 1
杰克缝纫机股份有限公司
杰克缝纫机
全球销量遥遥领先
www.chinajack.com
2017.4
Loading...