Iron Chief America 87695, 87696, 87697, The Beast 87695, The Beast 87696 Owner's Manual

Owner’s Manual / Assembly Guide

“The Beast”™ Charcoal Grill / Smoker / Oven

MODEL# 87695, 87696, 87697

Features:

• Works as a Smoker a Grill and an Oven

• Heavy Duty Solid Steel Construction

• Airtight Seal

• Air Dampers for Positive Flow Control

• Easy-to-Read Thermometer

• Side Smokestack

• 2 ea 360º casters for ease of movement

• Adjustable Height Charcoal Tray

• 1000 sq-in cooking surface

• Wood preparation tray

• Wood handles

WARNING

!

For Outdoor Use Only (outside any enclosure)

SAVE THESE INSTRUCTIONS FOR FUTURE REFERENCE. IF YOU ARE
ASSEMBLING THIS UNIT FOR SOMEONE ELSE, GIVE THIS MANUAL BACK
TO OWNER TO SAVE FOR FUTURE REFERENCE.

WARNING:
Improper installation, adjustment, alteration, service or maintenance could

cause injury or property damage Read the installation, operation and
maintenance instructions thoroughly before assembling or servicing this

equipment.

Failure to follow these instructions could result in fire or explosion that could
cause property damage, personal injury or death.

DANGER:
DO NOT use charcoal grill for indoor cooking or heating. TOXIC fumes can

accumulate and cause asphyxiation. Do not use in or on boats or recreational
vehicles.

This charcoal grill is not intended for commercial use.

Table of Contents

Important Safety Information.……………………………….. Page 4 - 5

Illustrated Parts List……………………………….…………. Page 6 - 7

Hardware List ……………………………………….………. Page 8

Out - Of - The - Box Instructions …………………………… Page 9

Assembly Instructions…………………............................... Page 10 – 16

Lighting The Beast™ …………………............................… Page 17

Cleanning & Care …………………............................……. Page 17

Page 3

87695, 87696, 87697 - Owner’s Manual

WARNING:

FOR YOUR SAFETY

1. DO NOT store or use gasoline or any other flammable vapors and liquids within 25 feet (8m)
of this or any other appliance.

2. When cooking with oil/grease, do not allow the oil/grease to exceed 350°F (177°C). Do not
store of use extra cooking oil in the vicinity of this or any other appliance.

3. An LP Cylinder not connected for use should be stored a minimum of 10 feet (3m) away from

this or any other appliance. Never fill the cylinder beyond 80 percent full. If the above

information not followed exactly, a fire causing death or serious injury may occur.

NOTE:
Minimum distance from sides and back of unit to walls or railings is 36 inches (914mm).
Do not use under overhead construction. This appliance not intended for commercial use.
Do not locate this outdoor cooking appliance under overhead unprotected combustible surface.

For Outdoor Use Only,

IMPORTANT NOTICE:
READ ALL INSTRUCTIONS PRIOR TO ASSEMBLY AND USE

Read and understand all warnings and precautions prior to operating your grill.

Page 4

CAUTION

1. This grill is intended to be used with Charcoal Briquettes, Lump wood Charcoal or natural woods

2. Never attempt to attach this grill to the self-contained propane system of a camper trailer, motor

home or house.

3. This grill is not intended to be used in or installed on recreation vehicles and/or boats..

4. Do not attempt to move the grill while it is lit.

5. Do not use the grill unless it is completely assembled and all parts are securely fastened and

tightened.

6. Keep grill area clear and free from combustible materials, gasoline and other flammable vapors

and liquids.

7. Do not touch metal parts of grill until it has completely cooled (about 45 minutes) to avoid

burns, unless you are wearing protective gear (BBQ mittens, pot holders, etc.)

8. Do not alter this grill in any manner.

WARNING

1. This grill is for outside use only, and should not be used inside any building, garage or any other
enclosed area.

2. The use of alcohol, prescription or non-prescription drugs may impair the operator’s ability to

properly assemble or safely operate the grill.

3. Always open grill lid slowly and carefully as heat and steam trapped within the grill can burn you
severely.

4. Always place your grill on a hard, level surface far away from combustibles. An asphalt or
blacktop surface may not be acceptable for this purpose.

5. Do not leave a lit grill unattended. Keep children and pets away from the grill at all times.

6. Do not place this grill on any type of tabletop surface.

7. Do not use the grill in high winds.

Page 5

Illustrated parts list: 87695, 87696, 87697

1. CHARCOAL GRILL BODY....1PC 2. CHARCOAL GRILL BODY....1PC

4. THERMOMETER……1 PC 5. HOOD WOOD HANDLE……….1PC 6.UPPER COOKING RACK…..1PC

3. SMOKESTACK ………...1PC

7. SIDE WOOD HANDLE…….2PCS 8. BUTTERFLY DAMPER…….…1PC 9. CHARCOAL TRAY CRANK

LEVER ……………………….…1PC

10. CHARCOAL TRAY ARM……1PC 11. METAL BRACKET (L) ..…….1PC 12.METAL BRACKET(R)……...1PC

Page 6