Intex Ultra Frame Owner's Manual

Download

Page 1

(118IO) ULTRA FRAME POOL ENGLISH 7.5” X 10.3” PANTONE 295U 07/20/2012

118A

English

OWNER’S MANUAL

Ultra Frame™ Pool

12' - 24' (366 cm - 732 cm) models

IMPORTANT

SAFETY RULES

Read, understand, and follow

all instructions carefully before

installing and using this product.

Don’t forget to try these other fine Intex products: Pools, Pool Accessories, Inflatable Pools and In-Home Toys, Airbeds and Boats available at fine retailers or visit our website listed below. Due to a policy of continuous product improvement, Intex reserves the right to change specifications and appearance, which may result in updates to the instruction manual, without notice.

For illustrative purposes only. Accessories may not be provided with pool.

118-*A*-R1-1307

Rechte vorbehalten. Printed in China/Imprimé en Chine/Impreso en China/Gedruckt in China.

®™ Trademarks used in some countries of the world under license from/®™ Marques utilisées dans certains pays sous licence de/Marcas registradas utilizadas en algunos países del mundo bajo licencia de/Warenzeichen verwendet in einigen Ländern der Welt in Lizenz von/Intex Marketing Ltd. to/à/a/an Intex Trading Ltd., Intex Development Co. Ltd., G.P.O

Box 28829, Hong Kong & Intex Recreation Corp., P.O. Box 1440, Long Beach, CA 90801 • Distributed in the European Union by/Distribué dans l’Union Européenne par/Distribuido en la unión Europea por/Vertrieb in der Europäischen Union

durch/Intex Trading B.V., Venneveld 9, 4705 RR Roosendaal – The Netherlands

Page 2

(118IO) ULTRA FRAME POOL ENGLISH 7.5” X 10.3” PANTONE 295U 07/20/2012

118A

SAVE THESE INSTRUCTIONS

Page 2

English

TABLE OF CONTENTS

Warnings................................................................................ 3

Parts List & References....................................................... 4-5

Setup Instructions................................................................ 6-8

Pool Maintenance and Chemicals....................................... 9-10

Common Pool Problems...................................................... 9

Pool Draining........................................................................ 10

Storage.................................................................................. 10-11

General Aquatic Safety........................................................ 12

Special Introductory note:

Thanks for buying an Intex pool. Please read this manual before setting up your pool. This information will help extend the pool life and make the pool safer for

your family's enjoyment. View the video included before installation. A team of 2-3

people is recommended for pool set up. Additional people will speed up the

installation.

Page 3

(118IO) ULTRA FRAME POOL ENGLISH 7.5” X 10.3” PANTONE 295U 07/20/2012

118A

SAVE THESE INSTRUCTIONS

Page 3

English

SAFETY RULES

IMPORTANT SAFETY RULES

Read, Understand and Follow All Instructions Carefully Before Installing and Using this Product.

• Continuous and competent adult supervision of children and the disabled is required at all times.

• Secure all doors, windows and safety barriers to prevent unauthorized, unintentional or

unsupervised pool entry.

• Install a safety barrier that will eliminate access to the pool for young children and pets.

• Pool and pool accessories are to be assembled and disassembled by adults only.

• Never dive, jump or slide into an above-ground pool or any shallow body of water.

• Failure to set up pool on flat, level, compact ground or over filling could result in the pool’s

collapse and the possibility that a person lounging in the pool could be swept out/ejected.

• Do not lean, straddle, or exert pressure on the inflatable ring or top rim as injury or flooding could occur. Do not allow anyone to sit on, climb, or straddle the sides of the pool.

• Remove all toys and flotation devices from, in and around the pool when it is not in use.

Objects in the pool attract young children.

• Keep toys, chairs, tables, or any objects that a child could climb on at least four feet (1.22

meters) away from the pool.

• Keep rescue equipment by the pool and clearly post emergency numbers at the phone

closest to the pool. Examples of rescue equipment: coast guard approved ring buoy with

attached rope, strong rigid pole not less than twelve feet (12') [3.66m] long.

• Never swim alone or allow others to swim alone.

• Keep your pool clean and clear. The pool floor must be visible at all times from the outside

barrier of the pool.

• If swimming at night use properly installed artificial lighting to illuminate all safety signs,

ladders, pool floor and walkways.

• Stay away from the pool when using alcohol or drugs/medication.

• Keep children away from pool covers to avoid entanglement, drowning, or other serious

injury.

• Pool covers must be completely removed before pool use. Children and adults cannot be

seen under a pool cover.

• Do not cover the pool while you or anyone else is in the pool.

• Keep the pool and pool area clean and clear to avoid slips and falls and objects that may

cause injury.

• Protect all pool occupants from recreational water illnesses by keeping the pool water sanitized. Don’t swallow the pool water. Practice good hygiene.

• All pools are subject to wear and deterioration. Certain types of excessive or accelerated

deterioration can lead to an operation failure, and can ultimately cause the loss of large quantities of water from your pool. Therefore, it is very important that you properly maintain your pool on a regular basis.

• This pool is for outdoor use only.

• Empty and store the pool when not in use for a longer period. See storage instructions.

• While the swimming pool is in use, you will need to operate the filter pump to ensure that there is at least one complete change of water a day. Consult your pump’s manual to

calculate the necessary operating hours.

POOL BARRIERS AND COVERS ARE NOT SUBSTITUTES FOR CONTINUOUS AND COMPETENT ADULT SUPERVISION. POOL DOES NOT COME WITH A LIFEGUARD. ADULTS ARE THEREFORE REQUIRED TO ACT AS LIFEGUARDS OR WATER WATCHERS AND PROTECT THE LIVES OF ALL POOL USERS, ESPECIALLY CHILDREN, IN AND AROUND THE POOL.

FAILURE TO FOLLOW THESE WARNINGS MAY RESULT IN PROPERTY DAMAGE, SERIOUS INJURY OR DEATH.

Advisory:

Pool owners may need to comply with local or state laws relating to childproof fencing, safety barriers, lighting, and other safety requirements. Customers should contact their local building code enforcement office for further details.

WARNING

Page 4

(118IO) ULTRA FRAME POOL ENGLISH 7.5” X 10.3” PANTONE 295U 07/20/2012

118A

SAVE THESE INSTRUCTIONS

Page 4

English

PARTS LIST

NOTE: Drawings for illustration purpose only. Actual product may vary. Not to scale.

4 5

Page 5

(118IO) ULTRA FRAME POOL ENGLISH 7.5” X 10.3” PANTONE 295U 07/20/2012

118A

SAVE THESE INSTRUCTIONS

Page 5

English

PARTS REFERENCE

Before assembling your product, please take a few minutes to check the contents

and become familiar with all the parts.

12' (366 cm), 14' (427 cm), 16' (488 cm), 18' (549 cm), 20' (610 cm), 22' (671 cm) & 24' (732 cm) models

NOTE: Drawings for illustration purpose only. Actual product may vary. Not to scale.

REF

NO.

DESCRIPTION

12’ x 36” (366

cm x 91cm)

14’ x 42” (427

cm x 107cm)

14’ x 48” (427

cm x 122cm)

16’ x 48” (488

cm x 122cm)

18’ x 48” (549

cm x 122cm)

18’ x 52” (549

cm x 132cm)

20’ x 48” (610

cm x 122cm)

22’ x 52” (671

cm x 132cm)

24’ x 52” (732

cm x 132cm)

SPARE PART NO.

T - JOINT

11527 11359 11458

11449 11449 11450

11449 11450 11450

VERTICAL LEG

11528 11360 11459

11452 11452 11452

LEG CAP

11361 11361 11361

11453 11453 11453

HORIZONTAL BEAM

11529 11362 11362

11451 11451 11451

POOL LINER (DRAIN VALVE CAP INCLUDED)

11517 11363 11518

11080 11448 10989

11291 11512 11293

RESTRAINING ROPE (OPTIONAL)

10587 10587

10317 10317 10317

11292 11511 10420

GROUND CLOTH (OPTIONAL)

18932 18932

18927 18933 18933

11290 11510 18935

DRAIN CONNECTOR

10201 10201 10201

DRAIN VALVE CAP

10649 11044 11044

11044 11044 11044

POOL COVER

11054 11054

10754 18937 18937

11289 11509 18929

STRAINER HOLE PLUG (WITH 1 EXTRA)

10127 10127 10127

REF

NO.

DESCRIPTION

POOL SIZE &

QUANTITIES

12’

(366cm)

14’

(427cm)

16’

(488cm)

18’

(549cm)

20’

(610cm)

22’

(671cm)

24’

(732cm)

T - JOINT

12 14 16 18

20 22 24

VERTICAL LEG

12 14 16 18

20 22 24

LEG CAP

12 14 16 18

20 22 24

HORIZONTAL BEAM

12 14 16 18

20 22 24

POOL LINER (DRAIN VALVE CAP INCLUDED)

1 1 1 1

1 1 1

RESTRAINING ROPE (OPTIONAL)

1 1 1 1

1 1 1

GROUND CLOTH (OPTIONAL)

1 1 1 1

1 1 1

DRAIN CONNECTOR

1 1 1 1

1 1 1

DRAIN VALVE CAP

1 1 1 2

2 2 2

POOL COVER

1 1 1 1

1 1 1

STRAINER HOLE PLUG (WITH 1 EXTRA)

3 3

Page 6

(118IO) ULTRA FRAME POOL ENGLISH 7.5” X 10.3” PANTONE 295U 07/20/2012

118A

SAVE THESE INSTRUCTIONS

Page 6

English

SETUP INSTRUCTIONS

POOL SETUP

WARNING

IMPORTANT SITE SELECTION AND GROUND

PREPARATION INFORMATION

 • Thepoollocationmustallowyoutosecurealldoors,windows,andsafety

barriers to prevent unauthorized, unintentional or unsupervised pool entry.

 • Installasafetybarrierthatwilleliminateaccesstothepoolforyoungchildren

and pets.

 • Failuretosetupthepoolonflat,level,compactgroundandtoassemble,andfill

with water in accordance with the following instructions could result in the

pool’s collapse or the possibility that a person lounging in the pool could be

swept out/ejected, resulting in serious injury or property damage.

 • Riskofelectricshock:connectthefilterpumponlytoagroundingtype

receptacle protected by a ground-fault circuit interrupter (GFCI) or residual

current device (RCD). To reduce the risk of an electrical shock, do not use

extension cords, timers, plug adapters or converter plugs to connect the pump

to an electrical supply. Always provide a properly located outlet. Locate the cord

where it cannot be damaged by lawn mowers, hedge trimmers, and other

equipment. See the filter pump manual for additional warnings and instructions.

Select an outdoor location for the pool with the following requirements in mind:

1. The area where the pool is to be set up must be absolutely flat and level.

Do not set up the pool on a slope or inclined surface.

2. The ground surface must be compacted and firm enough to withstand the pressure and

weight of a fully set up pool. Do Not set up the pool on mud, sand, soft or loose soil

conditions.

3. Do Not set up the pool on a deck, balcony or platform.

4. The pool requires at least 4 feet of space all around pool from objects that a child could

climb on to gain access to the pool.

5. The chlorinated poolwater could damage the surrounding vegetation. Certain types of

grass such as St. Augustine and Bermuda, may grow through the liner. Grass growing

through the liner it is not a manufacture defect and is not covered under warranty.

Page 7

(118IO) ULTRA FRAME POOL ENGLISH 7.5” X 10.3” PANTONE 295U 07/20/2012

118A

SAVE THESE INSTRUCTIONS

Page 7

English

SETUP INSTRUCTIONS

POOL SETUP (continued)

You may have purchased this pool with the Intex Krystal Clear™ filter

pump. The pump has its own separate set of installation instructions. First assemble your pool unit and then set up the filter pump.

Estimated assembly time 45~60 minutes. (Note the assembly time is only

approximate and individual assembly experience may vary.)

1. Liner preparation

• Find a flat, level location that is free and clear of stones, branches or other sharp objects

that may puncture the pool liner or cause injury.

• Open the carton containing the liner, joints, legs, etc., very carefully as this carton can be

used to store the pool during the winter months or when not in use.

• Take out the ground cloth (7) and spread it over the cleared area. Then, take out the liner (5) and spread it out over the ground cloth, with the drain valve directed towards the draining area. Place the drain valve away from the house. Allow the sun to warm up the liner before inserting the beams (4) into the sleeve openings. IMPORTANT: Always set up the pool

unit with at least 2 persons. Do not drag the liner across the ground as this can cause liner damage and pool leakage (see drawing 1).

• During the setup of the pool liner, point the hose

connections or openings in the direction of the electrical power source. The outer edge of the pool should be

within reach of the pump’s electrical connection.

2. Frame assembly

• The frame pool’s legs (2) and beams (4) fall into two groups. The smaller diameters are the vertical legs. Both these legs and beams fit into the T-joints (1).

• Starting at any location, but always working in the same

direction, push the horizontal beam into the sleeve (see drawing 2.1). Once the beam is centered take one of the

T- joints (1), snap the joint to one end of the beam by aligning the hole and the spring-loaded pin. Repeat this procedure in a circular fashion until all the beams and joints have been connected (see drawing 2.2).

The last joint connection may be difficult to complete, but can be easily done by simultaneously raising this last joint and beam more than 2 inches (5 cm), and connect the beam to the joint while lowering these pieces to their normal position. The joint will slide into the beam (see drawing 2.3). Make sure the last joint is fully assembled before proceeding to assembling the legs.

2.1

2.3

2.2

Page 8

(118IO) ULTRA FRAME POOL ENGLISH 7.5” X 10.3” PANTONE 295U 07/20/2012

118A

SAVE THESE INSTRUCTIONS

Page 8

English

SETUP INSTRUCTIONS

POOL SETUP (continued)

IMPORTANT

Before allowing anyone to use the pool, hold a family meeting. Establish a set of rules that include, at a minimum, the important safety rules and general aquatic safety information in this manual. Review these rules on a regular basis and with all users of the pool, including guests.

• Next slide the vertical legs into the belt loop located in

the middle of the pool liner. The bottom of the leg should be inside the white restraining rope (6) located

near the liner’s bottom edge. Carefully slide the leg into the belt loop and place the leg’s bottom inside the rope

and then insert the top of the leg into the bottom of the

joint. Snap the leg into joint’s holes by aligning the hole and the spring-loaded pin. Attach the leg’s end

cap (3) to the bottom of the leg (see drawing 3).

• Grab the frame pool’s top beams in 2 – 3 locations and "shake" the pool to be sure all the joints, legs and beams "fit into each other".

• Pull gently, in an outward direction, the bottom of the leg; making sure the leg is inside

the restraining rope.

• If pool was purchased with a filter pump, read the Krystal Clear™ Filter Pump Manual first and then proceed to next installation step.

3. Filling of the pool

• Before filling the pool with water, ensure that the drain plug inside the pool is closed and

that the drain cap on the outside is screwed on tightly. Fill the pool with no more than 1

inch (2.5 cm) of water. Check to see whether the water is level.

IMPORTANT: If the water in the pool flows to one side, the pool is not completely level. Setting up the pool on unlevel ground will cause the pool to tilt resulting in the sidewall material bulging and a potential collapse of the pool. If the pool is not completely level, you must drain the pool, level the area or move the pool to a different area that is level, and re-fill the pool, following the above directions.

• Smooth out the bottom liner wrinkles (from inside the pool) by pushing out where the pool floor and pool sides meet. Or, (from outside pool) reach under the side of the pool,

grasp the pool floor and pull in an outward direction. If the ground cloth is causing the

wrinkles, have 2 adults pull from opposite sides to remove all wrinkles. Use the properly

assembled pool ladder when entering or exiting the pool during this process.

4. Fill the pool with water up to just below the sleeve line (see drawing 4).

WATER LEVEL

Page 9

(118IO) ULTRA FRAME POOL ENGLISH 7.5” X 10.3” PANTONE 295U 07/20/2012

118A

SAVE THESE INSTRUCTIONS

Page 9

English

MAINTENANCE

Water maintenance

The maintenance of a proper water balance through appropriate use of sanitizers is the single most important factor in maximizing the life and appearance of the liner as well as ensuring clean, healthy and safe water. Proper technique is important for water testing and treating the pool water. See your pool professional for chemical, test kits and testing procedures. Be sure to read and follow the written instructions from the chemical manufacturer.

1. Never let chlorine come into contact with the liner if it is not completely dissolved. Dissolve

granular or tablet chlorine first in a bucket of water, then add it to the pool water. Likewise

with liquid chlorine; mix it immediately and thoroughly with the pool water.

2. Never mix chemicals together. Add chemicals to the pool water separately. Thoroughly

dissolve each chemical before adding another one to the water.

3. An Intex pool skimmer and an Intex pool vacuum are available to assist in maintaining

clean pool water. See your pool dealer for these pool accessories.

4. Do not use a pressure washer to clean the pool.

POOL MAINTENANCE & CHEMICALS

REMEMBER TO

• Protectallpooloccupantsfrompossiblewater-relatedillnessesbykeepingthe

pool water clean and sanitized. Do not swallow the pool water. Always practice good hygiene.

• Keepyourpoolcleanandclear.Thepoolfloormustbevisibleatalltimesfrom

the outside barrier of the pool.

• Keepchildrenawayfrompoolcoverstoavoidentanglement,drowning,orother

serious injury.

WARNING

TROUBLESHOOTING

PROBLEM

DESCRIPTION

CAUSE

SOLUTION

ALGAE

COLORED WATER

FLOATING MATTER IN WATER

CHRONIC LOW WATER LEVEL

SEDIMENT ON POOL BOTTOM

SURFACE DEBRIS

• Greenish water.

• Green or black spots

on pool liner.

• Pool liner is slippery

and/or has a bad odor.

• Water turns blue,

brown, or black when first treated with chlorine.

• Water is cloudy or

milky.

• Level is lower than

on previous day.

• Dirt or sand on pool

floor.

• Leaves, insects etc.

• Chlorine and pH level

need adjustment.

• Copper, iron or

manganese in water being oxidized by the added chlorine.

• "Hard water" caused by a

too high pH level.

• Chlorine content is low.

• Foreign matter in water.

• Rip or hole in pool liner

or hoses.

• Heavy use, getting in

and out of pool.

• Pool too close to trees.

• Super chlorinate with shock

treatment. Correct pH to your pool store's recommended level.

• Vacuum pool bottom.

• Maintain proper chlorine level.

• Adjust pH to recommended

level.

• Run filter until water is clear.

• Replace cartridge frequently.

• Correct the pH level. Check with

your pool dealer for advice.

• Check for proper chlorine level.

• Clean or replace your filter

cartridge.

• Repair with patch kit.

• Finger tighten all caps.

• Replace the hoses.

• Use Intex pool vacuum to

clean bottom of pool.

• Use Intex pool skimmer.

Page 10

(118IO) ULTRA FRAME POOL ENGLISH 7.5” X 10.3” PANTONE 295U 07/20/2012

118A

SAVE THESE INSTRUCTIONS

Page 10

English

STORAGE

POOL MAINTENANCE & DRAINAGE

Do not add chemicals if the pool is occupied. This can cause skin or eye irritation. Concentrated chlorine solutions can damage the pool liner. In no event is Intex Recreation

Corp., Intex Development Co. Ltd., their related companies, authorized agents and service

centers, retailers or employees liable to the buyer or any other party for the costs associated with the loss of pool water, chemicals or water damage. Keep spare filter cartridges on hand. Replace cartridges every two weeks. We recommend the use of a

Krystal Clear™ Intex Filter Pump with all of our above-ground-pools.

EXCESSIVE RAIN: To avoid damage to the pool and over filling, immediately drain rain water that causes the water level to be higher than the maximum.

How to Drain Your Pool and Long Term Storage

1. Check local regulations for specific directions regarding disposal of swimming pool water.

2. Check to make sure that the drain plug inside the pool is plugged in place.

3. Remove the cap from the drain valve on the outside pool wall.

4. Attach the female end of the garden hose to the drain connector (8).

5. Place the other end of the hose in an area where the water can be safely drained away

from the house and other nearby structures.

6. Attach the drain connector to the drain valve. NOTE: The drain connector will push the drain plug open inside the pool and water will start to drain immediately.

7. When the water stops draining, start lifting the pool from the side opposite the drain,

leading any remaining water to the drain and emptying the pool completely.

8. Disconnect hose and adapter when finished.

9. Re-insert drain plug in drain valve on inside of pool for storage.

10. Replace drain cap on outside of pool.

11. Reverse set up instructions to disassemble the pool, and remove all connecting parts.

12. Be sure that the pool and all parts are completely dry before storage. Air dry the liner in

the sun for an hour before folding (see drawing 5). Sprinkle some talcum powder to prevent the vinyl from sticking together and to absorb any residual moisture.

13. Create a square shape. Starting at one side, fold one-sixth of liner in on itself twice. Do the same on the opposite side (see drawings 6.1 & 6.2).

14. Once you have created two opposing folded sides, simply fold one over the other like closing a book (see drawings 7.1 & 7.2).

15. Fold the two long ends to the middle (see drawing 8).

16. Fold one over the other like closing a book and finally compact the liner (see drawing 9).

17. Store the liner and accessories in a dry, temperature controlled, between 32 degrees

Fahrenheit (0 degrees Celsius) and 104 degrees Fahrenheit (40 degrees Celsius),

storage location.

18. The original packing can be used for storage.

7.1

6.1 6.2

7.2 8 9

CAUTION

ALWAYS FOLLOW THE CHEMICAL MANUFACTURER'S DIRECTIONS, AND THE HEALTH AND HAZARD WARNINGS.

Page 11

(118IO) ULTRA FRAME POOL ENGLISH 7.5” X 10.3” PANTONE 295U 07/20/2012

118A

SAVE THESE INSTRUCTIONS

Page 11

English

STORAGE

WINTER PREPARATIONS

Winterizing your Above Ground Pool

After usage, you can easily empty and store away your pool in a safe place. You must drain, disassemble and properly store the pool when the temperature drops below 41 degrees Fahrenheit (5 degrees Celsius) to prevent ice damage to the pool and related components. Ice damage can result in sudden liner failure or pool collapse. Also see the section “How To Drain Your Pool’’.

Should temperatures in your area not drop below 41 degrees Fahrenheit (5 degrees Celsius), and you choose to leave your pool out, prepare it as follows:

1. Clean the pool water thoroughly. (If the type is an Easy Set Pool or an

Oval Frame Pool, make sure that the top ring is properly inflated).

2. Remove the skimmer (if applicable) or any accessories attached to the

threaded strainer connector. Replace strainer grid if necessary. Be sure all accessories parts are clean and completely dry before storage.

3. Close the Inlet and Outlet Plunger Valve.

4. Remove the ladder (if applicable) and store in a safe place. Be sure the

ladder is completely dry before storage.

5. Remove the hoses that connect the pump and filter to the pool.

6. Add the appropriate chemicals for the winter period. Consult your local

pool dealer as to which chemicals you should use and how to use them. This can vary greatly by region.

7. Cover pool with Intex Pool Cover. IMPORTANT NOTE: INTEX POOL COVER IS NOT A SAFETY COVER.

8. Clean and drain the pump, filter housing and hoses. Remove and discard

the old filter cartridge. Keep a spare cartridge for the next season).

9. Bring pump and filter parts indoors and store in a safe and dry area,

preferably between 32 degrees Fahrenheit (0 degrees Celsius) and 104 degrees Fahrenheit (40 degrees Celsius).

Page 12

(118IO) ULTRA FRAME POOL ENGLISH 7.5” X 10.3” PANTONE 295U 07/20/2012

118A

SAVE THESE INSTRUCTIONS

Page 12

English

SAFETY GUIDELINES

GENERAL AQUATIC SAFETY

Water recreation is both fun and therapeutic. However, it involves inherent risks of injury and death. To reduce your risk of injury, read and follow all product, package and package insert warnings and instructions. Remember, however, that product warnings, instructions and safety guidelines cover some common risks of water recreation, but do not cover all risks and dangers.

For additional safeguards, also familiarize yourself with the following general guidelines as well as guidelines provided by nationally recognized Safety Organizations:

• Demand constant supervision. A competent adult should be appointed as

a “lifeguard” or water watcher, especially when children are in and around the pool.

• Learn to swim.

• Take the time to learn CPR and first aid.

• Instruct anyone who is supervising pool users about potential pool

hazards and about the use of protective devices such as locked doors, barriers, etc.

• Instruct all pool users, including children what to do in case of an

emergency.

• Always use common sense and good judgement when enjoying any

water activity.

• Supervise, supervise, supervise.