Embedded System
www.ieiworld.com
FanlessFanless
♦
Socket P Intel® 45nm Mobile Core™2 Duo Processor
Supported
♦
Extended Temperature Fanless design support -20ºC~70ºC
♦
High Performance MPEG-2 Decoding, WMV9(VC-1) and
H.264(AVC) supported
♦
Built-in DDR2 SO-DIMM 2G memory
♦
Support 2xCOM, 4xUSB2.0, 2x Intel GbE LAN
♦
IEI One Key Recovery solution allows you to creat rapid OS
backup and recovery
+70°C
-20°C
Specications
Socket P Intel® Core™ Duo 2.4GHz, 3MB L2 Cache,
Processor
Chipset Intel® GM45 Chipset + ICH9M
System Memory Built in one 2GB SO-DIMM memory
Ethernet
Display
Serial Port
Watch Dog Timer
PS/2 One PS/2 KB/MS
USB Four x USB2.0
LED One dual stack LED, green for power, red for HDD
Storage One 2.5" SATA HDD capacity
Power Input
Power Consumption 45W
Chassis Construction Aluminum Alloy
Operating
Temperature
Operating Shock Half-Sine Shock Test 5G/11ms, 3 shocks per axis
Operating Vibration MIL-STD-810F 514.5 C-1
Weight (Net/Gross) 3.5Kg/4.2Kg
Dimension(WxHxD) 310 x 200 x 55mm
* Ambient air speed pre IEC-68-2-2 standard
Processor P8600
Socket P Intel® Celeron® M 2.0GHz, 1MB L2 Cache,
Processor 575
One Intel® 82574L GbE Controller
One Intel® WG82567LM GbE PHY
Intel® Gen 5.0 integrated Graphic engine
High Performance MPEG-2 Decoding, WMV9(VC-1) and
H.264(AVC) supported
CRT Interface integrated in Intel® GM45
Resolution: Analog monitor support XQGA up to
2048x1536MHz
One RS-232
One RS-422 (Optional RS-485 supoprt by internal jumper)
Isolated protection: up to 1200VDC
Software programmable support 1~255 sec. system reset
support by ITE 8718
12V DC in with 4pin mini-DIN
One AT/ATX switch
One 2pin Terminal block connector for remote control system
ON/OFF
-20ºC ~ 70ºC (SATA SSD) with air ow*
0ºC ~ 50ºC (SATA HDD) with air ow*
Dimensions
12V DC Input COM1 COM3
GPIO
(Remote Control)
Packing List
1x Power Cable (Terminal Block DC in Cable)
1 x Screw set
1 x QIG
1 x CD
T A N K - G M 4 5 A - V 1 0
(unit: mm)
2 x GbE 4 x USB VGA
ATX/AT
switch
Keyboard
Mouse
Power LED
Power
Switch
HDD
LED
Embedded System
The TANK-GM45A embedded system is a fan less system for wide range temperature environments. It is powered by the Intel® 45nm Core™2
Duo processor, uses the Intel® GM45 chipset and has 2.0 GB of DDR2 memory.
www.ieiworld.com
Extend-Temperature System
TANK-GM45A supports extended Temperature from -20ºC up to 70ºC with One Industrial 2.5” SATA Flash Disk. IEI IFD 2.5” SSD supporting
SATA SLC solutions features anti-vibration, low power consumption, high performance and perfect reliability. SSD not only performs much better
IOPS than HDD but also can be operated anytime because of no mobile components like the motor, bearing or and rotating head. In addition,
SSD can absolutely fulll specialized application performing in any harsh environment.
iFD 2.5" SATA 2510WT
Wide Temp. Grade
SATA SSD iFD-2510WT iFD-2500RW iFD-2000JW
Capacities 8GB~128GB 1GB~32GB 8GB~128GB
Data Transfer Rate (max.) Read-37MB/Sec; Write-37MB/Sec Read-60MB/Sec; Write-40MB/Sec Read-160MB/Sec; Write-140MB/Sec
Operation Temp. -40ºC ~ 85ºC -40ºC ~ 85ºC -40ºC ~ 85ºC
Storage Temp. -55ºC ~ 95ºC
Vibration 20G (7~2000Hz)
Shock 1500G/0.5ms
DC Input Voltage 5V single power supply operation
Enclosure Material Metal Mechanical Cover
Dimension 69.63mm x 99.88mm x 9.3mm (WxHxL)
iFD 2.5" SATA 2500RW
Wide Temp. Grade
iFD 2.5" SATA 2000JW
Wide Temp. Grade
High Performance Intel® GbE
High Performance Intel® GbE
• Intel® 82574L
The 82574 provides one PCIe l an e operating at 2 .5 G Hz with
sufficient bandwidth to support 1000 Mb/s transfer rate. Supports
9018-byte j um bo packets,40 K B of o n- chip buff er in g miti ga te s
instantaneous receive bandwidth demands and eliminates transmit
un d er– r uns by bu ff e rin g the en tir e o u tgo i ng packe t p r ior to
transmission.
• Intel® WG82567LM
IP Video
Surveillance
The 82567 is a single port GbE physical layer Transceiver (PHY) that
connects to its Media Access Controller (MAC) through a dedicated
interconnect and supports operation at data rate of 10/100/1000 Mb/s.
Supports up to 9 kB jumbo frames (full duplex)
Digital Security Surveillance
As the demands on Digital S ecurity Surve illance (DSS) systems become more complex, I EI
embedded Systems give equipment manufacturers and system integrators the opportunity to deliver
increasingly sophisticated video surveillance solutions.
TANK-GM45A is the Digital Security Surveillance system provides higher video resolution, high
Performance and lower power consumption solution.
Feature Benet
Low-power, fanless platform
Dual-core processing
Dual on-board Gigabit Ethernet
• Intel® Core™ Duo processor enable powerful dual-core computing at very low power
• Reduced design requirements (no fan required)
• Reduce environment (fan) noise, lower power and cooling requirements
• Increased performance for multi-threaded code
• High processing throughput for Streaming SIMD 3 (SSE3) instructionsaccelerates video processing
• 1066 MHz system bus for high system throughput
• Large 3 MB L2 cache keeps more data closer to the cores for faster execution
• Fast connectivity for data network
• High-speed IP camera connectivity option
T A N K - G M 4 5 A - V 1 0
Embedded System
www.ieiworld.com
Remote Control
DIO Signal
RC+ RC-
DIO GND
High: Turn off
Low: Turn on
The GPIO terminal block connects to a remote control device. Users
can control the system power on/off by inputting high or low voltage
into the terminal block.
Turn off the system: more than 1 V input
Turn on the system: less than 0.5 V input
AT/ATX Mode
Isolated Serial Port
COM1: Isolated RS232
COM3: Isolated RS422
(optional for RS485)
IEI TANK-GM45A provides
1. On board +15KV ESD protection
2. Isolated 1200VDC protection
An integrated circuit (IC) connected to external ports is susceptible
to damaging electrostatic discharge (ESD) pulses form the operating
environment and peripherals.
Additional protection can violate stringent signaling requirements,
leaving design engineers with the need to balance performance and
reliability.
AT/ATX Mode by external switch
Single 12V Power Input
The TANK-GM45A supp or ts 1 2V DC p ow er wit h
4 pin DC
ATX AT
The TANK-GM45A supports AT and ATX power
mo des. The s ettin g can be mad e thr ough
the AT/ATX switch on the external peripheral
interface panel
█ Optional 12VDC Adapter
Power Adapter 63000-FSP060DBAB1554-RS 63000-FSP096AHB-RS
Output Current 12V@5A, 60W 12V@8A, 96W
Output Voltage 11.4V~12.6V 11.4V~12.6V
Input Voltage 115V ~ 230V, 90V(Min) ~ 264V(Max) 110V ~ 240V, 90V(Min) ~ 264V(Max)
Operating Temp. 0 to 40ºC 0 to 40ºC
Storage Temp. -20 to 65ºC -20 to 80ºC
Energy Efciency 87% minimum 80% minimum
MTBF (25ºC) > 60000 hours >100000 hours
Dimension 110mm x 62mm x 31.5mm 167mm x 65mm x 37mm
Ordering Information
Part No. Description
TANK-GM45A-R10/P8600/2GB
TANK-GM45A-R10/CM575/2GB
63000-FSP060DBAB1554-RS POWER ADAPTER; FSP060-DBAB1554; VAC:90V~264V; 12V/ 60W with ERP and PSE certicates
63000-FSP096AHB-RS POWER ADAPTER; FSP096-AHB; VAC:90V~264V; 12V/ 96W with ERP and PSE certicates
32000-000002-RS 17.5cm European Standard Power Cord
32000-000025-RS 18.3cm American Standard Power Cord
32000-133200-RS PS2 KB/MS Y Cable
IFD-2510WT-XXXXX iFD 2.5" SATA 3.0 2510WT SLC SSD Wide Temp. Grade -40ºC~85ºC (8GB~128GB)
IFD-2500RW-XXXXX iFD 2.5" SATA 3.0 2500RW SLC SSD Wide Temp. Grade -40ºC~85ºC (1GB~32GB)
IFD-2000JW-XXXXX iFD 2.5" SATA 3.0 2000JW SLC SSD Wide Temp. Grade -40ºC~85ºC (8GB~128GB)
XXXXX=Capacity
Extend temperture fanless embedded system with Intel® Core™2 Duo P8600 2.4 GHz 3MB L2 cache and GM45 chipset, with 2GB DDR2 memory,
12VDC, -20ºC~70ºC,RoHS
Extend temperture fanless embedded system with Intel® Celeron® M 575 2.0 GHz 1MB L2 cache and GM45 chipset, with 2GB DDR2 memory,
12VDC, -20ºC~70ºC, RoHS
T A N K - G M 4 5 A - V 1 0
Loading...