Impulse PCM-3343 User Manual

PCM-3343

DM&P Vortex86DX-1 GHz PC/104 SBC, LCD, Ethernet, CFC, Onboard Memory

TTLLVDSKB/MS

Power in

RS-422/485

RS-232 1/2

GPIO

PATA

RS-232 3/4

I2C

VxWorks

Speciﬁcations

CPU DM&P Vortex86DX 1.0 GHz, supports Floating Point Unit (FPU)

Processor System

Memory

Display

Ethernet

Watchdog Timer

Storage

Internal I/O

Expansion PC/104 Slot 1

Power

Environment

Physical Characteristics

Frequency 1.0 GHz L2 Cache 256 KB System Chipset DM&P Vortex86DX- 1.0 GHz BIOS Award integrated 16 Mbit ROM in SOC Technology DDR2 333 MHz SDRAM on board Max. Capacity 512 MB Onboard Memory Onboard 256 MB (512 MB supported by request) Chipset SMI SM712 VRAM 4 MB internal memory

Graphics Engine

LVDS Single channel 24-bit LVDS up to 1024 x 768 VGA Supports up to 1024 x 768 at 85 Hz TTL LCD Supports up to 1024 x 768 at 24 bit single channel TFT LCD Panel Dual Display VGA+TTL, VGA+LVDS Speed 10/100 Mbps

Controller

Connector Pin Header

CompactFlash CompactFlash socket (Type I/II),shared with primary master PATA PATA 1 Channel SPI Flash Optional onboard 4 MB SPI Flash Disk (Supported by request for boot device or storage on DOS OS) USB 4 x USB 2.0

Serial

Keyboard/Mouse 1 GPIO 16-bit general purpose input/output I2C 1

Power Type AT Power Supply Voltage 5V ± 5% only to boot up (12 V is optional for LCD inverter and add-on card) Power Consumption

(Typical: Idle in WinXPe) Power Consumption (Max, test

in passmark burn-in program) Battery 3 V/210 mAH Power Management APM 1.2 Operational 0 ~ 60° C (32 ~ 140° F) (Operational humidity: 40° C @ 85% RH non-condensing) Non-Operational -40° C ~ 85° C and 60° C @ 95% RH non-condensing Dimensions (L x W) 96 x 90 mm (3.8" x 3.5") Weight 0.508 kg (1.12 lb) Height Top Side: 8.6 mm; Bottom Side: 10.6 mm

Features

 Ultra low power, fanless DM&P Vortex86DX- 1 GHz and 256 MB onboard

DDR2 memory

 VGA+LCD dual display outputs, 24-bit LVDS/TTL supported

 Integrated Floating Point Unit

 Supports 2 Fast Ethernet ports in standard PC/104 96 x 90 mm dimensions

Fast Ethernet

USB 1/2

62.5 MHz single clock/cycle engine (EM+) 86 MHz single clock/cycle engine (EM4+) Designed to accelerate DirectDraw

Fast Ethernet1: Vortex86DX SOC integrated Fast Ethernet2: Realtek RTL8100C-LF

System reset Software programmable counter from 30.5μ sec. to 512 sec. x 2 sets

3 RS-232 from COM1/3/4, 1 RS-232/422/485 from COM2 with RS-485 auto ﬂow control (ESD protection for RS-232: Air gap ±15kV, Contact ±8kV), COM1/2 supports console mode

0.74 @ +5 V, 3.7 Watt (Vortex86DX 1 GHz, DDR2 256 MB)

0.85 A @ +5 V, 4.25 Watt (Vortex86DX 1 GHz, DDR2 256 MB)

 Supports embedded software APIs and Utilities

Software APIs:

Watchdog

Utilities:

BIOS ﬂash

GPIOBrightnessI2C

Backlight On/Off

PC/104 CPU Modules

All product specifications are subject to change without notice Last updated : 11-Jun-2012

Block Diagram

PCM-3343

4 USB Ports

3 RS-232

1 RS-232/422/485

PS/2 KB/MS

I2C connector

VGA connector

24-bit TTL

connector

Ordering Information

Model CPU

DM&P

PCM-3343L-256A1E

Vortex86DX 1 GHz DM&P

PCM-3343F-256A1E

Vortex86DX 1 GHz DM&P

PCM-3343Z-256A1E

Vortex86DX 800 MHz DM&P

PCM-3343Z2-256A1E

Vortex86DX 800 MHz

Note: Passive = fanless; Active = with fan

L2 Cache

256 KB

Primary Master PATA

Slave

PATA connector

USB 2.0

VGA

TTL

24-bit TTL-LVDS

Transmitter

Memory VGA LVDS TTL

Onboard 256 MB

- - - 1 2 1 1 1 Yes Passive PC/104 0 ~ 60° C

Yes Yes 1 2 4 3 1 1 Yes Passive PC/104 0 ~ 60° C

Yes Yes 1 2 4 3 1 1 Yes Passive PC/104 -20 ~ 80° C

Yes Yes 1 2 4 3 1 1 Yes Passive PC/104 -40 ~ 85° C

DM&P

Vortex86DX

(1 GHz )

(256KB L2)

SPI 16M-bit

PCI Bus

SMI SM712

Fast Ethernet

BIOS

USB

2.0

Single Channel

RS-232

MAC + PHY

ISA

External SPI

Fast Ethernet 2:

Realtek

RTL8100C-LF

RS-232/ 422/485

Onboard DDR2

333 MHz, 256 MB

(optional to 512MB)

Fast Ethernet 1:

Pin header

PC/104 connector

4 MB flash (Optional)

16-bit GPIO

KB/MSThermal

PATA

solution

Expansion

Operational Temp

Packing List

Part No. Description Quantity

PCM-3343 SBC Startup Manual

Utility CD 1700060202 Cable 6P-6P-6P PS/2 KB & MOUSE 20 cm 1 1703060053 PS2 Cable 6P (MINI-DIN)-6P (Wafer 2.0 mm) 6 cm 1 1703100260 USB cable 2 port 2.0 mm pitch w/ bracket 26 cm 1 1701200220 RS-232 x 2 ports 2.0mm pitch 22 cm 2 1703040157 RS-422/485 W/D-SUB COM 4P 15 cm 1 1700000898 VGA cable D-SUB 15P(F)/12P-1.25 mm 15 cm 1 1700017863 LAN cable RJ45/2 x 5P-2.0 15 cm 1 9660104000 PC/104 screw and copper post package 1 1960047356N001 Heatsink for DMP Vortex86DX (27 x 27 x 6.3 mm) 1

Optional Accessories

Part No. Description

1701440350 PATA cable 44P/44P/44P 35 cm

Embedded OS/API

Embedded OS/API Part No. Description

WinCE

Win XPE

QNX 6.4.1 Linux Ubuntu 10.04.1 VxWorks 5.5

Software API 205E343000

Online Download

2070009763 CE 5.0 Pro PCM-3343 V1.3 ENG 2070009536 CE 6.0 Pro PCM-3343 V1.3 ENG 207001108 CE 7.0 Pro PCM-3343 V1.0 ENG 2070009528 XPE WES2009 Vortex86DX V4.0 ENG 2070009529 XPE WES2009 Vortex86DX V4.0 MUI24

www.advantech.com/products

SUSI 3.0 SW API for PCM-3343 B:20091209 XP