NOTE:
Please read all instructions
carefully before using this
product
Safety Notice
Hardware Identifier
Assembly Instruction
Parts List
Warranty
Ordering Parts
APEX
Tri-Level Dumbbell Rack
DBR 92
Model
DBR 92
Retain This
Manual for
Reference
07-4-06
OWNER'S
MANUAL
IMPEX® INC.
14777 DON JULIAN RD., CITY OF INDUSTRY, CA 91746
Tel: (800) 999-8899 Fax: (626) 961-9966
www.impex-fitness.com
info@impex-fitness.com
TABLE OF CONTENTS
BEFORE YOU BEGIN...................................................................................... 1
IMPORTANT SAFETY NOTICES..................................................................... 2
HARDWARE PACK……….....…....................................................................... 4
ASSEMBLY INSTRUCTIONS........................................................................... 5
EXPLODED DIAGRAM.........................................................................………. 8
PARTS LIST...................................................................................................... 9
WARRANTY.................................................................................................…. 10
ORDERING PARTS.......................................................................................… 10
BEFORE YOU BEGIN
Thank you for selecting the APEX Dumbbell Rack DBR-92 by IMPEX
your safety and benefit, read this manual carefully before using the machine. As a
manufacturer, we are committed to provide you complete customer satisfaction. If
you have any questions, or find there are missing or damaged parts, we guarantee
you complete satisfaction through direct assistance from our factory. To avoid
unnecessary delays, please call our TOLL-FREE customer service number. Our
Customer Service Agents will provide immediate assistance to you.
®
INC. For
Toll-Free Customer Service Number
1-800-999-8899
Mon. - Fri. 9 a.m. - 5 p.m. PST
www.impex-fitness.com
info@impex-fitness.com
1
IMPORTANT SAFETY NOTICE
PRECAUTIONS
This exercise machine is built for optimum safety. However, certain precautions apply whenever
you operate a piece of exercise equipment. Be sure to read the entire manual before you
assemble or operate your machine. In particular, note the following safety precautions:
1. Keep children and pets away from the machine at all times. DO NOT
leave children unattended in the same room with the machine.
2. Only one person at a time should be using the machine.
3. If the user experiences dizziness, nausea, chest pain, or any other abnormal
symptoms, STOP the workout at once. CONSULT A PHYSICIAN IMMEDIATELY.
4. Position the machine on a clear, leveled surface. DO NOT use the machine
near water or outdoors.
5. Keep hands away from all moving parts.
6. Always wear appropriate workout clothing when exercising. DO NOT wear
robes or other clothing that could become caught in the machine. Running
or aerobic shoes are also required when using the machine.
7. Use the machine only for its intended use as described in this manual. DO
NOT use attachments not recommended by the manufacturer.
8. Do not place any sharp object around the machine.
9. Disabled person should not use the machine without a qualified person or
physician in attendance.
10. Before using the machine to exercise, always do stretching exercises to
properly warm up.
11. Never operate the machine if the machine is not functioning properly.
12. Maximum weight capacity for the rack: 500 lbs.
WARNING: BEFORE BEGINNING ANY EXERCISE PROGRAM, CONSULT YOUR
PHYSICIAN. THIS IS ESPECIALLY IMPORTANT FOR INDIVIDUALS OVER THE AGE OF 35
OR PERSONS WITH PRE-EXISTING HEALTH PROBLEMS. READ ALL INSTRUCTIONS
BEFORE USING ANY FITNESS EQUIPMENT. IMPEX INC. ASSUMES NO RESPONSIBILITY
FOR PERSONAL INJURY OR PROPERTY DAMAGE SUSTAINED BY OR THROUGH THE
USE OF THIS PRODUCT.
SAVE THESE INSTRUCTIONS.
2
WARNING LABEL REPLACEMENT
The Warning Label shown here has been placed on the Stabilizer. If the label is missing or
illegible, please call customer service at 1-800-999-8899 for replacement. Apply the label in
location shown.
3
HARDWARE PACK
4
ASSEMBLY INSTRUCTION
Tools Required Assembling the Machine: One Adjustable Wrench and Allen Wrench
NOTE: It is strongly recommended this machine be assembled by two or more people to
avoid possible injury.
STEP 1 (See Diagram 1)
A.) Connect the Left Stabilizer (#3) to the Left Upright Beam (#1). Secure the side with two M10 x
3 ½” Allen Bolts (#13), four ∅ ¾” Washers (#9), and two M10 Aircraft Nuts (#14). Secure the
Bottom with one M10 x 5/8” Allen Bolt (#10) and Ø ¾” Washer (#9). Do NOT tighten all the
Nuts and Bolts yet.
B.) Repeat the above procedure A to Connect the Right Stabilizer (#4) to the Right Upright Beam
(#2).
DIAGRAM 1
5
STEP 2 (See Diagram 2)
A.) Connect the Left & Right Upright Beams (#1 & #2) with one Dumbbell Rack (#5) on the top
level. Align the holes then secure each end of the Rack with one M10 x 2 ¾” Allen Bolt (#12),
two ∅ ¾” Washers (#9), and one M10 Aircraft Nut (#14). Repeat the same step to install the
other Dumbbell Rack. Do not tighten the nuts and bolts yet.
B.) Repeat Procedure A above to install two Dumbbell Racks to the second level.
C.) Repeat Procedure A above to install two Dumbbell Racks to the third level. Tighten all Nuts
and Bolts previously installed.
DIAGRAM 2
6
STEP 3 (See Diagram 3)
A.) Insert a Weight Post (#6) into the hole on the side of the Left Upright Beam (#1). Secure it with
a M10 x 1 1/8” Allen Bolt (#11) and ∅ ¾” Washer (#9).
B.) Slide an Olympic Sleeve (#8) onto the Weight Post. Repeat the same step to install the other
three Posts
DIAGRAM 3
7
8
Parts list
KEY NO. DESCRIPTION Q’ty
1 Left Upright Beam 1
2 Right Upright Beam 1
3 Left Stabilizer 1
4 Right Stabilizer 1
5 Dumbbell Rack 6
6 Weight Post 4
7 1” End Cap 4
8 Olympic Sleeve 4
9 Ø ¾” Washer 38
10 M10 x 5/8” Allen Bolt 2
11 M10 x 1 1/8” Allen Bolt 4
12 M10 x 2 ¾” Allen Bolt 12
13 M10 x 3 ½” Allen Bolt 4
14 M10 Aircraft Nut 16
9
®
IMPEX
INC.
LIMITED WARRANTY
IMPEX Inc. ("IMPEX®") warrants this product to be free from defects in workmanship and
material, under normal use and s ervice conditions, for a period of two years on the Fram e from
the date of purchase. This warranty extends only to the original purchas er. IMPEX 's obligation
under this Warranty is limited to replacing or repairing, at IMPEX's option.
All returns must be pre-authorized by IMPEX. Pre-authorization may be obtained by calling
IMPEX Customer Service Department at 1-800-999-8899. All freights on products returned to
IMPEX must be prepaid by the customer. This warranty does not extend to any product or
damage to a product caused by or attributable to freight damage, abuse, misuse, improper or
abnormal usage or repairs not provided by an IMPEX authorized service center or for produc ts
used for commercial or rental purposes. No other warranty beyond that specifically set forth
above is authorized by IMPEX.
IMPEX is not responsible or liable for indirect, special or cons equential damages aris ing out of or
in connection with the use or performance of the pr oduct or other damages with respect to any
economic loss, loss of property, loss of revenues or profits, loss of enjoyments or use, cos ts of
removal, installation or other consequential damages or whatsoever natures. Some states do not
allow the exclusion or limitation of inc idental or consequential damages. Accordingly, the above
limitation may not apply to you.
The warranty extended hereunder is in lieu of any and all other warranties and any implied
warranties of merchantability or fitness for a particular purpose is lim ited in its sc ope and duration
to the terms set forth herein. Some states do not allow limitations on how long an implied
warranty lasts. Accordingly, the above limitation may not apply to you.
This warranty gives you specific legal right. You may also have other rights which vary from state
to state.
ORDERING REPLACEMENT PARTS
Replacement parts can be order ed by calling our Custom er Ser vice Department toll-free at 1-800-
999-8899 during our regular business hours: Monday through Friday, 9 am until 5 pm Pacific
standard time.
info@impex-fitness.com
When ordering replacement parts, always give the following information.
1. Model
2. Description of Parts
3. Part Number
4. Date of Purchase
Register on-line at ww w.impex-fitness.com
IMPEX
14777 Don Julian
City of Industry, CA 91746
®
INC.
10
Loading...