Imperial Cal Products WHP1900PS1, WHP1900PS, WHP1900PS1-TW, WH1900PS1, WH1900PS Installation Instructions Manual

...
Imperial
Cal. Products, Inc.
Installation Instructions
&
Warranty Information
Brea, CA 92821
www.imperialhoods.com
(800) 851-4192
DO NOT THROW AWAY,
PROPERTY OF THE HOME OWNER!
Imperial Cal Products, Inc.
Read Before Starting Installation!
Inspect your range hood prior to installing!
Any cosmetic defects must be reported to us prior to installation.
Once this hood is installed, ICP will NOT accept any responsibility
for any cosmetic blemishes, scratches or dents in the Canopy.
Save all original packaging if you wish to return for any reason!
FIRST:
Check your local building and electrical codes.
WARNING:
To reduce the risk of fire or electrical shock, Do Not use any two speed motor units with a Solid State control devise.
CAUTION:
To reduce the risk of fire or personal injury and to properly exhaust air, be sure to duct air to the outside. DO NOT vent exhaust air into spaces within wall, attics, ceilings, crawl spaces or garages. When venting to the outside make duct run as short and straight as possible. Avoid using elbows if at all possible. If elbows are used, we recommend that the first elbow is 24” from vent opening on the hood (minimum of 6”) and at least 24” between it and the next elbow. We strongly recommend no more then two 90 degree elbows in any duct run. DO NOT use duct pipe smaller than the outlet duct opening on the hood, this will reduce performance and void the warranty. DO NOT use flex ducting. Also, use either a Roof Cap or Wall Cap to end run. Be sure that all joints are taped securely in place. It is essential to have the proper distance between the bottom of the range hood and the cooking surface below. In most cases the cooking appliance manufacturers specifications will establish the fire safe minimum distance required, although there are other factors to consider:
! Local Building Codes ! Cross directional air movements ie: open windows, air conditioning/heating outlets, cooling fans, etc. ! Overall size of the cooking appliance and surrounding countertop surfaces. ! Range hood model selected.
Minimum distance between cooking surface and the bottom of the hood is 30” and 36” is the maximum distance. Keep in mind, increasing the distance will decrease the performance.
TWIN UNITS ONLY - Transitioning two pipes into one is NOT recommended. CFMs are reduced by 25% and the Performance warranty will be void.
PROPERTY OF HOME OWNER, DO NOT THROW AWAY!
Imperial Cal Products, Inc.
Wall Mount Installation Detail:
MODELS:
MODELS: MODELS:
WHP1900PS1 WHP1900PS WHP1900PS1-TW WH1900PS1 WH1900PS WH1900PS1-TW WH1900PS1R WH1900PSR WH1900PS1TWR WH1900PSB*(Baffle Filters) WH1900PS1-TWB*(Baffle Filters)
CAUTION: Be sure that incoming power is turned off.
1. Position the Wall Canopy on it’s back and remove the filters.
2. Remove the Powered Liner (C2000) assembly from the canopy shell by unscrewing the Four (4) mounting nuts with washers located at each corner of the insert.
3. Install canopy shell to the wall by securing it to a minimum of two (2) structural wall studs. Caution; Pre-Punched installation key holes in the rear of the canopy to be used only if they line up with the
exiting wall studs. If needed, drill additional mounting holes and secure to existing wall studs or remove the dry wall and install proper backing to match pre-punched mounting holes. Note: In the case of the “Rear Vented” series use the two vertical support pieces on the back side to temporarily attach the canopy to the wall. Locate the wall studs and using the four small (4) metal mounting brackets secure the canopy to the wall.
4"
24"
3/4"
10-3/4"
6-1/2"
1/2"
11-3/4"
18"
3
0
"
,
3
6
"
&
4
2
"
=
4
-
1
/
2
"
4
8
"
,
5
4
"
o
r
6
0
"
=
7
-
1
/
2
"
9-1/8"
2-1/2"
30", 36", 42", 48", 54" or 60"
Note: Check series specifications for size availability.
All sizes not available in all model series.
Front
Back
3
0
"
=
1
4
-
1
1
/
1
6
"
3
6
"
=
2
0
-
11
/
1
6
"
4
2
"
&
4
8
"
=
2
6
-
1
1
/
1
6
"
5
4
"
=
3
2
-
11
/
1
6
"
6
0
"
=
3
8
-
1
1
/
1
6
"
1
-
1
/
2
"
9
-
1
/
8
"
1
-
3
/
4
"
T
o
p
B
o
t
t
o
m
7
/
8
"
9
-
1
/
2
"
1
0
-
7
/
8
"
1
0
-
7
/
8
"
2
1
-
3
/
4
"
Loading...
+ 5 hidden pages