Page 1
SERVICE
Whirlpool Europe
Customer Services
AWL 210
This documentation is only intended for qualified technicians who are aware of the respective safety regulations.
Date: 13.08.1996 Subject to modification
Document-No.: 4812 713 10839
Model AWL 210
Version 8540 210 01000 Page
Technical data 2 - 3
Spare part list 4
Exploded view 5
Wiring diagram 6
Circuit diagram 7
Program diagram 8
Service Manual
Tumble dryer
Air Vent
AWL 210
Page 2
SERVICE
13.08.1996 / Page 2 Whirlpool Europe
Doc. No: 4812 713 10839 Customer Service
Technical data
Dimensions
Height 85,0 cm
Width 59,5 cm
Depth 56,0 cm
Weight
Gross weight 33 kg
Net weight 31 kg
Surroundings temperature
Max.room temperature 35 ˚C
Min. room temperature 5 ˚C
Humidity
Max. relative humidity 95 %
Power connection
Voltage 230 V
Frequency 50 Hz
Connected load 2,8 kW
Fuse 16 A
Drum data
Volume 104 l
Drum speed (empty) 56 ± 3 rpm
Airflow 120 - 160 m
3
/h
Maximum loading capacity
Cotton 5 kg
Easy care 2,5 kg
Exhaust hose
Inner diameter 10 cm
Maximum allowable 4 m
(with 2 bows)
Electrical components
Heating
Type Aluminium mass
heating
Nominal voltage 230 V
Nominal power 2500 W ± 5%
Resistor R 20 19,5 - 23 Ω
Thermostats
Safety thermostat
(in heater) TL
Switching point
(off temp.) 270 ± 10 ˚C
Fluff thermostat
(in heater) TH 1.2
Switching point
(on temp.) 180 ± 7,5 ˚C
Switching point
(off temp.) 205 ± 7,5 ˚C
Exhausting thermostat
(in bottom) TH 1.1
Switching point
(on temp.) 45 ± 5 ˚C
Switching point
(off temp.) 60 ± 4 ˚C
Timer
Type electromechanical
Timer, Eaton
EC 4605
Nominal voltage 230 V
Frequency 50 Hz
Number of steps 60
Stop 01
Heating 02 - 53 (138 min)
Cool down 54 - 55 (6 min)
Anticreasing 56 - 59 (12 min)
Stop 60
Ambient temperature up to 70 ˚C
Storage temperature up to 85 ˚C
Main- and blower motor
Type 1-phase asynchronous
Nominal voltage 230 V
Frequency 50 Hz
Power consumption 295 W ± 7%
Resistances of coils
Main coil (2-3) 21,5 Ω± 7%
Auxiliary coil (2-1) 21,5 Ω± 7%
Rated speed with 5kg laundry
and 100 % rest humidity 2750 rpm
Capacitor 10 µF ± 10% / 400V
Page 3
SERVICE
Whirlpool Europe 13.08.1996 / Page 3
Customer Service Doc. No: 4812 713 10839
Technical data
Push buttons
Start / door switch
Start switch SST
Nominal voltage 230 V
Nominal current 16 A
Door switch SD
Nominal voltage 230 V
Nominal current 16 A
Radio interference filter
Type Eichhoff BV 16.250/109
Nominal voltage 230 V
Nominal capacity 0,1 µF + 2 x 0,015 µF X1Y
Buzzer
Nominal voltage 230 V
Resistance of coil 7 KΩ± 15 %
Page 4
SERVICE
13.08.1996 / Page 4 Whirlpool Europe
Doc. No: 4812 713 10839 Customer Service
Spare part list
Model AWL 210
Service No. 854021001000
Version 854021001000
Pos. No. 12NC Code Description from to
004 0 4812 530 48144 Bottom
011 0 4812 500 18054 Foot adjustable
012 0 4812 528 78033 Roll
012 1 4812 528 98003 Bearing Front
012 2 4812 520 28041 Shaft rear
021 0 4812 440 19387 Front,panel
022 0 4812 440 18926 Panel,side
024 0 4812 440 18928 Panel, rear
030 0 4812 440 19417 Table top
100 0 4812 417 38014 Door
131 0 4812 271 38362 Door lock
133 0 4812 417 28049 Pin Door
191 0 4812 466 68539 Gasket, door
220 0 4812 418 18177 Drum CPL.
223 0 4812 418 88017 Drum lifter
271 0 4812 358 18051 Belt
273 0 4812 358 18055 Pulley jokey
275 0 4812 492 68129 Spring
291 0 4812 466 68542 Gasket Drum
291 1 4812 466 68541 Gasket Fluff Filter
301 0 4812 452 19333 Control panel IGNIS
331 0 4812 413 48241 Knob
333 0 4812 276 18256 Button
344 0 4812 464 48093 Holder
351 0 4812 134 48202 Pilot lamp
355 0 4819 280 18015 Buzzer
401 0 4812 361 18247 Motor
401 1 4812 401 18226 Clamp Motor
420 0 4812 121 18144 Capacitor 10ÜF
421 0 4812 121 18121 Interf.filter
443 0 4812 361 18248 Blower Wheel
456 0 4812 259 38167 Heating element 2500 W
490 0 4812 321 18019 Cable,mains 5m (without plug)
490 0 4812 321 18026 Cable,mains 3m
503 0 4812 282 18457 Timer EC TRA
551 6 4812 271 28369 Thermostat
621 0 4812 276 18248 Switch Start
621 1 4812 276 18247 Switch Start reset
633 0 4812 271 38361 Switch, door
633 1 4812 276 18251 Pin Start reset
743 0 4812 530 48146 Conveyor
743 1 4812 530 48145 Air guide
743 2 4812 466 68538 Seal for blower
743 3 4812 464 48102 Cover Blower
761 0 4812 480 58077 Filter
787 0 4812 530 28836 Hose,deaeration
794 0 4812 466 28107 Gasket
902 1 4812 256 38002 Bracket Roller
902 3 4812 532 28915 Clamp
903 0 4812 532 28028 Clip,fix
903 1 4812 290 88053 Clip
903 2 4812 401 18195 Clip
910 0 4812 502 38057 Screw Torx 4,2 x 13
912 0 4812 502 48015 Screw
912 1 4812 502 38142 Screw M5 x 10
922 0 4812 532 58005 Ring,circlip Triring
922 1 4812 532 58007 Ring,circlip
962 0 4812 466 38012 Protection Motor
993 0 4812 263 78014 Adapter
Page 5
SERVICE
Whirlpool Europe 13.08.1996 / Page 5
Customer Service Doc. No: 4812 713 10839
Exploded view
Page 6
SERVICE
13.08.1996 / Page 6 Whirlpool Europe
Doc. No: 4812 713 10839 Customer Service
Wiring diagram
Page 7
SERVICE
Whirlpool Europe 13.08.1996 / Page 7
Customer Service Doc. No: 4812 713 10839
Circuit diagram
Page 8
SERVICE
13.08.1996 / Page 8 Whirlpool Europe
Doc. No: 4812 713 10839 Customer Service
Program diagram
Loading...