IDW G-7, SC-148 Instruction Manual

Instruction Manual

G7

990 N. Amelia Ave., San Dimas, CA 91773 | toll free: 877.307.2665 | ofce: 909.447.8254 | fax: [phone]

www.idw-usa.com

Instruction Manual

G7

G7

FOR YOUR FUTURE REFERENCE

• Thank you for using our product. This manual will guide you in getting the best use of your
cooler.

• Remember to record the model and serial number located on the back of the cooler.

• Staple your receipt to your manual. You will need it to obtain Warranty Service.

Model #:

Serial #:

Date of Purchase:

TABLE OF CONTENTS

Parts and Identification....................................2

Safety Instructions .............................................3

Installation ...............................................................4

Electrical Requirements ...................................4

Light Control ............................................................6

Light Replacement ..............................................7

Start .............................................................................8

Maintenance ..........................................................8

Cleaning ................................................................. 10

Troubleshooting ................................................10

Warranty ................................................................ 11

1

Instructional Manual

PARTS (Model SC-148/G-7)

1. Glass Door

2. Horizontal light cover for glass door

3. Glass door seal gasket

4. Upper Flat shelf

5. Shelf strip (short/long) (2/2)

6. Shelf clip (6)

7. Lower Flat shelf

8. Evaporator baffle brace (4)

9. Switch power board

10. Thermostat

11. Evaporator fan

12. Fan baffle

13. Bottom hinge

14. Evaporator

15. Evaporator baffle

16. Top hinge cover

17. Upper hinge

18. Cabinet

19. Compressor

20. Compartment grill

21. Condenser

22. Compressor base

23. Wire clip

24. Adjustable leg (4)

25. Power cord

26. Supporting board

27. LED board (6)

28. Cabinet light cover

29. Horizontal light cover for glass door (2)

30. Door stop (bottom)

2

SAFETY INSTRUCTIONS

When using this appliance, always follow the basic safety precautions:

Read the entire User’s Manual before operating this appliance.1.
Use this appliance only for its intended purpose as described in this User’s Manual.2.
This cooler must be properly installed in accordance with the installation instructions before being used. 3.
See grounding instructions on page 4.
IDW requires that a dedicated circuit be used for the unit. Failure to do so voids warranty.4.
Never unplug your cooler by pulling on the power cord. Always grasp the plug firmly and pull it straight out 5.
from the outlet.
Unplug your cooler before cleaning or making any repairs. 6. Note: If for any reason this product requires service,

we strongly recommend that a certified technician perform the service.

Immediately repair or replace all electrical cords that have become frayed or otherwise damaged. Do not 7.
use a cord that shows cracks or abrasion damage along its length, the plug or the connector end.
This cooler should not be recessed or built into an enclosed cabinet. It is designed for freestanding 8.
installation only.
Do not operate or store your cooler near or around explosive fumes, gasoline or other flammable vapors 9.
and liquids.
Do not use flammable liquids to clean unit.10.
Setting the temperature control to the 0 position does not remove power to the light circuit, perimeter 11.
heaters, or evaporator fans.

G7

Please save these instructions!

DANGER!

Proper Disposal of the Refrigerator

PRE-CAUTION, NON-OPERATING COOLERS SHOULD HAVE:

Door removed.1.
Shelves kept in place in order to prevent any small child from climbing inside cooler.2.

FOR PROPER DISPOSAL OF COOLER: Distributors / retailers need to contact a qualified service technician:

To recover all Freon/refrigerant from the cooler 1.
To remove the compressor or remove the oil from the compressor 2.

Then the distributor/ retailer can contact their local metal recycling center to pick up the remaining cabinet,
shelves, etc. By law, disposal of hazardous wastes may be subject to fines and imprisonment under the
provisions of the environmental regulations. For more information please visit: http://www.epa.gov/osw/hazard/

index.htm

3