Hyundai HY70100P User Manual

1

CONTENTS

PAGE NO.S

1

SAFETY 3 - 7

2

MACHINE SPECIFIC SAFETY

7 - 8

3

PREPERATION

9

4

STARTING PROCEDURE

10

5

STOPPING PROCEDURE

11

6

USING THE MACHINE

11

7

MAINTENANCE

11 - 14

8

SPECIFICATION

15

9

TROUBLESHOOTING

16

10

RECYCLING AND PRODUCT DISPOSAL

17

11

DECLARATION OF CONFORMITY

18

12

CONTACT DETAILS

19

13

WARRANTY 19

14

MANUAL UPDATES

19

INDEX

2

1. SAFETY

1.1 General Safety Notes.

1.2 The operator of the machine is responsible for, and has a duty of care in making sure

that the machine is operated safely and in accordance with the instructions in this user
manual. Keep the manual safe and pass it on if the machine is loaned or sold to another
user.

1.3 Please note the following safety points.

1.4 The machine should never be left it in a condition which would allow an untrained or

unauthorised person/s to operate this machine.

1.5 All due care and diligence should be taken by the operator for the safety of and with
regard to those around whilst using the machine.

1.6 Some or all of the following - warning signs, symbols and/or PPE pictograms may ap-

pear throughout this manual. You MUST adhere to their warnings. Failure to do so
may result in personal injury to yourself or those around you.

DANGER

Indicates a hazard, which, if not avoided, could result in serious injury or death.

WARNING

Indicates a hazard, which, if not avoided, could result in serious injury.

CAUTION

Indicates a hazard which, if not avoided, might result in minor or moderate injury.

NOTE

Indicates a situation that could easily result in equipment damage.

READ and keep the manual safe and pass it on if the machine is loaned or sold to another user.

You MUST fully understand all instructions to ensure you use and operate the machine safely.

Appropriate Personal Protective Equipment (PPE), MUST be worn at all times when operating or
repairing the machine.

3

1.10 Carbon Monoxide (where applicable).

1.11 Carbon monoxide is a colourless and odourless gas. Inhaling this gas can cause

death as well as serious long term health problems such as brain damage.

1.12 The symptoms of carbon monoxide poisoning can include but are not limited to the

following;
Headaches, dizziness, nausea, breathlessness, collapsing or loss of consciousness.

1.13 Carbon monoxide poisoning symptoms are similar to flue, food poisoning, viral

infections and simply tiredness. It is quite common for people to mistake this very
dangerous poisoning for something else.

1.14 To avoid carbon monoxide poisoning DO NOT use Petrol/Diesel powered equipment

inside any of the following; Home, garage, tent, camper van, mobile home, caravan
or boat. This is not exhaustive and if you are in any doubt contact your dealer.

1.15 If you think you have or someone around you has been affected by carbon monoxide

poisoning;

1.16 Get them fresh air immediately, by leaving the affected area or by opening doors and

windows. If safe and practical to do so make sure that the machine is turned off.
DO NOT enter a room you suspect of having carbon monoxide present – instead call
the emergency services.

1.17 Contact a Doctor immediately or go to Hospital – let them know that you suspect

carbon monoxide poisoning.

1.18 DO NOT use in an enclosed area or moving vehicle.

4

1.20 General Fuel Safety (where applicable).

CAUTION

ALL FUELS ARE FLAMABLE

1.21 Fire Hazard – keep fuel away from all sources of ignition for example heaters.

Lamps, sparks from grinding or welding.

1.22

1.23 ALWAYS keep the work area tidy.

1.24 ALWAYS clean up spills promptly using absorbent granules and a lidded bin.

1.25 ALWAYS dispose of waste fuels correctly.

1.30 Fueling/De-fueling (where applicable).

CAUTION

DO NOT carry out hot work on tanks that have contained fuel.

ALL FUELS ARE FLAMABLE

1.31 ALWAYS fuel and defuel in a well ventilated area outside of buildings.

1.32 ALWAYS wear correct, suitable and fit for purpose Personal Protective Equipment

(PPE), suggested items are but not limited to safety gloves, overalls.

1.33 When fueling/de-fueling ALWAYS avoid inhaling fumes.

1.34 When de-fueling ALWAYS use a proper fuel retriever.

1.35 ALWAYS carry fuel in the correct and clearly marked container.

1.40 Electrical Safety (where applicable).

1.41 Electricity can kill – NEVER work on LIVE/ENERGISED equipment.

1.42 Prior to carrying out any maintenance work you MUST identify electrical isolation

methods and isolate all electrical supplies.

1.43 Prior to use and with all electrical supplies isolated, you MUST check all electrical

cables, plugs and connectors for the following;

1.44 Are intact and have no signs of damage, to include but not limited to bare wires,

chaffing, cuts and loose wiring.

1.45 If there are any signs of damage, the damaged item MUST be taken out of service

until the damage has been repaired by an electrically competent person.

5

1.46 All trailing cables should be routed so as not to cause any kind of trip hazard.

1.47 NEVER work on or near electricity with wet hands, wet clothing and wet gloves.

1.50 Batteries (where present).

1.51 Batteries present a risk if they become damaged by the possible leaking of

electrolyte. This electrolyte is an acid and can cause serious burn injuries. Care
should be taken when working on or near them. NOTE the electrolyte may be in
a liquid or gel form.

1.52 Should you come in to contact with electrolyte you should;

1.53 Remove all clothing contaminated with electrolyte. If you cannot remove then

saturate them in water.

1.54 Get medical assistance as soon as possible. You must advise the medical staff of

the type of acid.

1.55 Lead/acid battery = dilute sulphuric acid.

1.56 Nickel/cadmium = potassium hydroxide alkali electrolyte.

1.57 Use fresh running water to wash off excess electrolyte, continue this until medical

assistance arrives. Make sure that you do not was the electrolyte to another part of
your body or face.

1.58 If electrolyte comes in to contact with Eyes the electrolyte needs to be immediately

washed away with large amounts of water. Make sure that you do not wash the
electrolyte to another part of your face or body.

1.59 Gasses from charging batteries are highly flammable and great care should be taken

to charge in well ventilated areas.

1.59.1 There is an explosion risk if the battery terminals are short circuited, when

connecting/disconnecting ALWAYS exercise great care so that the terminals or
battery leads are NOT allowed to touch and cause a spark. ALWAYS use suitable
insulated tools.

1.60 Vibrations (where applicable).

1.61 Prolonged use of hand held (operated) machines will cause the user to feel the

effects of/from vibrations. These vibrations can lead to white finger (Raynaud’s
phenomenon) or carpal tunnel syndrome. This condition reduces the ability of the
hand to feel and regulate temperature, causing numbness and heat sensations and
may cause never damage and circulatory tissue death.

1.62 Not all factors that lead to white finger disease are known, but cold weather, smoking

and other diseases that affect blood vessels and blood circulation as well as large
and long-lasting impact of shocks are considered factors in the formation of white
finger. Note the following to reduce the risk of white finger and carpal tunnel
syndrome;

1.63 Wear gloves and keep your hands warm.

1.64 Take regular breaks.

1.65 All of the above precautions may help reduce the risk of white finger disease but not

rule out the carpal tunnel syndrome. Long-term and regular users are therefore

6