Hyundai HY3050, HY30100, HY3150 User Manual
ELECTRIC AIR COMPRESSOR
Models HY3050, HY30100 & HY3150
User Manual
PAGE 2
Rev 2
CONTENTS
TITLE
PAGE No
1. SAFETY
3 –
4
2. UNPACKING – USGAE INSTRUCTIONS
5 –
8
3. PART LOCATIONS
8
4. SPECIFIC SAFETY
9 –
11
5. OPERATION, MAINTENANCE & TROUBLESHOOTING
12 -
19
6. SPECIFICATION
20
7. WIRING DIAGRAM
20
8. GENPOWER CONTACT DETAILS
21
9. DECLARATIONS OF CONFORMITY
21
10. RECYCLING
22
PAGE 3
Rev 2
1. SAFETY.
1.1. The operator of the machine;
1.1.1. Is responsible for and has a duty of care in making sure that the compressor is
operated safely and in accordance with the instructions in this user manual.
1.1.2. Should never leave it in a condition which would allow an untrained or unauthorised
person/s to operate this compressor.
1.1.2.1. Should take care and show due diligence for the safety of and with regard to
those around whilst using the machine, to include but not limited to;
1.1.2.1.1. Elderly, children, pets, livestock and property.
1.2. Some or all of the following PPE, Warning Signs and symbols may appear throughout this
manual and you must adhere to their warning/s. Failure to do so may result in personal
injury.
Personal Protective clothing (PPE)
Warning Signs and Symbols – FOLLOW safety messages to avoid or reduce risk of injury or death.
DANGER - indicates a
hazard which if not
avoided could result in
serious injury or death.
WARNING - indicates a
hazard which if not
avoided could result in
serious injury or death.
CAUTION - indicates a
hazard which if not
avoided might result
in minor or moderate
injury.
NOTE - indicates a
situation that could
easily result in
equipment damage.
READ MANUAL
GOGGLES
DO NOT OPEN
WHEN IN USE
RISK OF ACCIDENTAL
START-UP
PAGE 4
Rev 2
1.3. Electrical Safety.
1.3.1. Electricity can kill - never work on LIVE/ENERGISED equipment.
1.3.2. Identify electrical isolation method and always isolate all electrical supplies,
prior to carrying out any maintenance work.
1.3.3. Prior to use and with all electrical supplies isolated check all electrical cables,
plugs and connections for the following.
1.3.3.1.
Are intact and have no signs of damage, to include but not limited to
bare
wires, chaffing, cuts and loose wiring. If there are any signs of damage, the
damaged item should be taken out of service until the damage has been
repaired by an electrically competent person.
1.3.4. All trailing cables should be routed so as not to cause any kind of trip hazard.
1.3.5. Never work on or near electricity with w t hands, wet clothing, and wet gloves.
2. UNPACKING - USAGE INSTRUCTION.
PAGE 5
Rev 2
PAGE 6
Rev 2
�P�
AGE 7
��
Rev 2
3. PART LOCATIONS
1. DIRECT COMPRESSED AIR OUTLET.
2. TANK.
3. PRESSURE REDUCER.
4. BELT GUARD.
5. COMRESSOR UNIT.
6. ELECTRIC MOTOR.
7. PRESSURE SWITCH.
8. PRESSURE GUAGE.
9. PIVOT WHEEL.
10. CONDENSATE DRAIN.
11. WHEEL.
12. CHECK VALVE.
PAGE 8 Rev 2
5
6
4
7
8
3
2
1
9
12
10
11
Loading...