Hussmann ARL-0400, ARL-0650, ARV-01050, ARV-0300, ARV-0400 Installation And Operation Manual

R

A

S

RV & ARL SERIE

Merchandisers

Medium Temperature
& Low Temperature
Merchandisers

PLEASE READ THIS MANUAL BEFORE USING THE PRODUCT

Installation &
Operation Manual
Shipped With Case Data Sheets

P/N 2400134E
ARV, ARL Series
DECEMBER,2000

HUSSMANN -CORPORATION

Hussmann Monterrey Mexico
Carretera Mexico-Laredo KM. 1009
Cienega de Flores, Nuevo Leon 65550
MEXICO
Phone: [phone]
Fax: [phone]

Table of Contents

SHIPPING DAMAGE
General 1-1
Apparent Loss or Damage 1-1
Concealed Loss or Damage 1-1
Location 1-1

PREPARATION OF CABINET FOR OPERATION
Removing Cabinet from Skid 2-1
Leveling Cabinet 2-1
Shelf Installation 2-1
Door seal 2-2
Fan Cycle Switch 2-2
Lamps 2-2
Sealing case to floor 2-2

EXTERIOR DIMENSION
Exterior Dimensions 3-1

Refrigeration system
Description 4-1
Defrost Cycle 4-1

Start up / Operation
Electrical Supply 5-1
Temperature Control 5-1
Lighting 5-1
Defrost Water Evaporation 5-1

Maintenance 6-1
Cabinet Surfaces 6-1
Condenser 6-1
Evaporator Housing 6-1
Merchandiser Electrical Data 6-1

Warranty

IMPORTANT
KEEP THIS MANUAL FOR FUTURE REFERENCE
Quality that sets industry standards

These merchandisers are conform to:
U.L. - Underwriters Laboratories Inc.®
C.U.L. - Canadian Underwriters Laboratories Inc.®
U.L. Sanitation (ANSI/NSF 7 - 1990)
NOM - Norma Oficial Mexicana
ANCE - Asociacion Nacional de Normalización y Certificación del Sector Eléctrico, A.C.

P/N 2400134E 1-#

SHIPPING DAMAGE

General

All equipment should be thoroughly examined for shipping damage before and during unloading.

This equipment has been carefully inspected at our factory and the carrier has assumed responsibility for
safe arrival. If damaged, either apparent or concealed, claim must be made to the carrier.

Apparent Loss Or Damage

If there is an obvious loss or damage, it must be noted on the freight bill or express receipt and signed by
the carrier's agent; otherwise, the carrier may refuse the claim. The carrier will supply necessary forms.

Concealed Loss Or Damage

When loss or damage is not apparent until after equipment is uncrated, a claim for concealed damage must
be made. Upon discovering damage, make the request in writing to carrier for inspection within 15 days
and retain all packing materials and paperwork. The carrier will supply an inspection report and required
claim forms.

Location

These merchandisers are designed for indoor operation with a recommended operating room ambient
temperature range of 65°F (18°C)/50% rh to 90° F (32° C)/65% rh. Their performance is affected by store
air currents when the doors are open. Do NOT allow air conditioning, electric fans, or open doors and
windows to create air currents around these merchandisers, nor should they be exposed to direct sunlight or
other heat sources.

NOTE: The condensing unit draws ambient air through the front of the unit and discharges hot air out the
rear of the unit. In order to maintain proper refrigerator performance and compressor life, a minimum space
of 4" (10 cm) must be maintained between the refrigerator and surrounding surfaces.