Hummer Oreion HX-T, HX-T Owner's Manual

OWNERS MANUAL

OREION™ HUMMER HX-T™ OWNERS MANUAL

Item

Page Number

Foreword

3

Notice

3

Safety Regulations

4

General Warnings

5

Controls Layout

7

Controls and Operation

10

Pre-operation Checklist

15

Driving Instructions

15

Towing

17

Storage

17

Maintenance

18

- Scheduled Maintenance

19

- Battery Pack Maintenance

21

Battery Care

22

Battery Charging

23

Charger

23

Cleaning

26

Cart Specifications

27

Warranty

28

CONTENTS

HUMMER, HX, HX-T, all related Emblems and the distinctive vehicle model body and grilled

designs are General Motors Trademarks used under license to MEV and Oreion Motors.

2

OREION™ HUMMER HX-T™ OWNERS MANUAL

Foreword:

Thank you for purchasing an OREION cart for your golf and community transportation
needs. Oreion Motors would like to welcome you to this revolution in transportation. Your
business is important to everyone within Oreion Motors and the Oreion Dealer network.

Your safety is important to us, so please make sure that prior to operating the cart you have
read the following instructions and warnings. If you rent or loan your cart to others, please
make sure they have studied this manual before operating the cart.

Please consider this manual to be a permanent part of this cart and if it is sold, please make
sure that the new owner receives the manual so that they can view all operating
information as well.

Insurance Notice: Your insurance may not provide coverage for accidents involving the use
of this cart. To determine if coverage is provided you should contact your insurance
company or agent.

Notice:

The Oreion Motors LLC. warranty for owners appears at the end of this manual. No other
warranties, expressed or implied, are contained herein. This cart was fully checked by
OREION and/or an OREION Dealer before it was delivered to you.

Throughout this manual the words “golf car” and “electric cart” are used interchangeably.
Please exercise caution when using the cart as it is capable of speeds in excess of 15mph.

Familiarizing yourself with the Owner’s Manual and warnings will help avoid possible
personal injury and property loss.

The information contained in this document is subject to change without notice.

Oreion Motors reserves the right to make design changes to the cart without obligation to
make these changes on units previously sold.

3

OREION™ HUMMER HX-T™ OWNERS MANUAL

DANGER

WARNING

CAUTION

WARNING

Safety Regulations:

It is required to read the Owner’s manual completely before operating the cart or
attempting any repair/maintenance work. Any violations of instructions in the manual may
lead to property loss, serious injury, or even death.

Pay special attention to important statements with the words such as “Danger”, “Warning”,
“Caution”, “Attention” etc.

If any of the operation/warning decals are damaged, defaced, destroyed, or illegible it is
important that they be replaced with new decals. Please contact the manufacturer or your
dealer to obtain new decals.

DANGER indicates an immediate hazard that if ignored, could result in severe personal
injury or death.

WARNING indicates an immediate hazard that if ignored, could result in severe personal
injury or death.

CAUTION indicates a hazard or unsafe practice that if ignored, could result in minor personal
injury or product or property damage.

This cart is not designed to be used in conjunction with child safety seats
Do not use or install child safety seat in any seat or position in the cart
Always obey and follow laws and regulations regarding the transportation of

children

Children that require the use of a child safety seat in a regular type automobile

should not be transported in this cart

4

OREION™ HUMMER HX-T™ OWNERS MANUAL

DANGER

WARNING

General Warnings:

The following safety procedures should be followed during cart operation, maintenance or
repair. Other special warning signs are described in this manual.

The cart contains batteries which can emit quantities of explosive gases. Keep the cart in a
well-ventilated area and away from sparks and open flames.

Do not cover the cart while charging as an accumulation of hydrogen gas could result in
explosion.

When charging the cart be sure that the ignition is switched to the OFF position. If the key is
left in the ON position damage may be caused to the charger or the car.

The cart is equipped with an on board UL listed charger. When charging your car please be
sure to use a proper grounded charging cable to provide power to the charger. Ventilate
when charging or operating the cart in enclosed areas.

Do not perform service or maintenance on batteries while cart is charging.

The cart does not offer protection from lightning, flying debris, or other storm hazards.
Upon indication of severe weather condition, seek appropriate shelter immediately.

Always obey all traffic and course regulations when operating the cart.

Inspect battery terminals, cables and batteries before each use.

Always wear a full face shield, rubber gloves and rubber apron when working with or in
close proximity to batteries.

Turn the ignition switch to the OFF position, remove the key, place the drive into park, set
the park brake and unplug the charger before inspecting or performing any type of service
on the cart.

Connections should be tight and free of corrosion.

Use insulated tools only when working with electrical connections.

The tightness of the battery terminal nut should be between 95-105 inch pounds of torque.
Do not over tighten. Loose and/or over tightened connections can cause battery failure,
explosion and or fire.

5

OREION™ HUMMER HX-T™ OWNERS MANUAL

Do not overfill the batteries and keep batteries clean and free of moisture.

If any high heat condition or burning smell is noticed immediately park the cart in a safe
location, place the ignition in the OFF position, move yourself and passengers away quickly
to a safe distance from the cart and contact your dealer for assistance and repair. If fire or
smoke is detected contact your local fire department immediately.

Do not store your cart inside if any of the above noted conditions exist.

Only use recommended batteries of the correct size.

Only authorized technicians should perform maintenance or repair on the cart. It is required
to abide by all regulations and safety decals on the cart while performing any type of
maintenance or repairs.

Remove all jewellery and loosen items before performing maintenance procedures.

Improper application or maintenance will lead to deterioration of cart performance and
reduce the overall life of the cart.

Do not attempt to alter the cart in any manner which would affect stability, control, or top
speed. Such alterations may lead to serious injury or death, violate state and local laws, and
will void the manufacturer’s warranty.

6

OREION™ HUMMER HX-T™ OWNERS MANUAL

Controls Layout:

7

OREION™ HUMMER HX-T™ OWNERS MANUAL

WARNING

1. Lights & Indicator Signal Stalk

2. Steering Wheel

3. Key Switch

4. Windshield Wiper Control

5. LCD Instrument Display

6. Charge Indicator

7. Steering Column Lock

8. Heater Vent Driver

9. Heater Vent Passenger

10. Drivers Heated Seat Switch

11. Passengers Heated Seat Switch

12. Hazard Warning Lights

13. Pioneer™ CD/Radio/MP3 Aux (reference stereo manual)

14. Brake Pedal

15. Accelerator Pedal

16. Dual Retractable Cup Holder

17. Lockable Glove Box (12v 5 Amp Power Outlet Inside)

18. Excel Switch

19. Heater De-mister Switch

20. Horn

21. Interior Light

22. Rear View Mirror

23. Door Grab Handle (HX-T™ Models Only)

24. Door Release Handles (HX-T™ Models Only)

25. Storage Net (HX-T™ Models Only)

26. Forward & Reverse Stick

27. Park Break Handle

28. Seat Position Adjuster

29. Seat Upright Adjuster

Key Switch

The key switch is located on the right side of steering wheel. The key can only be removed in
the OFF Position.

When you turn the key to this position, all the electrical power will be turned off.

Do not take out the key while driving your car as it will result in sudden power loss and
braking may occur.

8

OREION™ HUMMER HX-T™ OWNERS MANUAL

Do not leave the key in the cart or leave children in the cart unattended.

LCD Instrument Display

1. Left Indicator Signal

2. Right Indicator Signal

3. Side & Driving Lights Signal

4. High Beam Driving Light Signal

5. Forward & Reverse Position Signal

6. Outside Temperature

7. Clock (24hour)

8. Amperage Display

9. Speed (Kph or Mph)

10. Battery Power (Volts)

11. Distance (Total & Trip)

12. Clock – Set (Keep pressed to Edit)

13. Reset trip (One Touch to Reset) / Switch from Km/h to Mph (Keep Pressed to Switch)

14. Park Brake On Signal

9

OREION™ HUMMER HX-T™ OWNERS MANUAL

Controls & Operation:

• It is imperative that all operators of the OREION cart be familiar with the controls prior

• To avoid unintentional acceleration and cart damage, do not position the direction

• Always set the parking brake and remove the key when parking or leaving the cart

Direction Selector Stick

The direction selector stick is located in between the two front seats. It has three selections,
‘D’ for Drive (Forward), ‘P’ for Park and ‘R’ for Reverse.

IMPORTANT NOTE: For Safety, the cart must be placed in the ‘P’ position before the
ignition switch is turned on.

WARNING

to operation.

selector switch (forward/reverse) until the cart has come to a complete stop.

unattended.

10